1. DL manuals
  2. National Products
  3. Toy
  4. 571
  5. Owner's Manual

National Products 571 Owner's Manual

Summary of 571

  • Page 1

    Please read entire manual before starting assembly. Keep this manual along with your purchase receipt for future reference. Owner's manual to reduce the risk of injury, adult supervision is required. Never use on road ways, near motor vehicles, on or near steep inclines or steps, swimming pools or o...

  • Page 2: Important

    Remember to ... Charge the battery at least a month during storage, even if the vehicle has not been used. Once charge the battery immediately after each use. He battery a void your warranty to follow the instructions. Please refer to the battery care section in this manual for more information. T w...

  • Page 3: Important Information

    Important information table of contents limited warranty important information warning battery warning battery charging battery care and disposal parts list assembly operating your vehicle trouble shooting label decoration parts diagram 2 3 4 5 6 7 8 9- 13 14 15- 17 18 19 ..............................

  • Page 4: Warning

    Warning 4 wa rn in g w a rn in g to prevent serious injuries this product is for use by children 3 and up, and is not intended for children under 3 years due to lack of ability to operate safely. Maximum weight 66 ibs.(30 kg). Only 1 rider at a time. Do not leave children unattended. Adult supervisi...

  • Page 5: Battery Warning

    5 ba tte ry w arn in g b a tt e ry w a rn in g battery warning warning about thermal fuses important notes battery can fall out and injure a child prevent fire electrical hazard your 6 volt battery is equipped with a built-in thermal fuse. The thermal fuse is a self-resetting safety device which aut...

  • Page 6: Battery

    Disconnect the battery and vehicle . Plugs connect the charger and . Battery plugs after it is fully charged. The battery must be reconnected into the from the plug plug the vehicle. 3 3 4 2 1 once the battery is charged, disconnect the battery connector from the charger connector. Unplug the charge...

  • Page 7: Battery

    Your battery is a sealed lead-acid battery. It must be recycled or disposed of it in an environmentally sound manner. Never dispose your battery in the regular, household trash. The incineration, landfilling or mixing of sealed lead-acid batteries with household trash is prohibited by law in most ar...

  • Page 8: Parts

    Scissors (not included) screwdriver (not included) please identify all parts before assembly and save all packaging material until assembly is completed to ensure that no parts are discarded. Metal parts have been coated with lubricant to protect them during shipment. Wipe all metal parts with a pap...

  • Page 9: Assembly

    Assembly warning children can be harmed by small parts, sharp edges and sharp points in the vehicles unassembled state, or by electrical items. Care should be taken in unpacking and assembling the vehicle. Children should not handle parts, including the battery, or help in the assembly of the vehicl...

  • Page 10: Assembly

    Assembly 10 as se mb ly ii a s s e m b ly ii insert the rear axle through the gearbox. L 8 f fit the axle sleeves into the both holes of rack on each side end. 7 cut and discard the shipping strap. 6 5 any improper installation of the hat nut may use the pliers to take off! Meijer.Com.

  • Page 11: Assembly

    Use an underlay pipe sleeve against the opposite end of rear axle while hammering the hat nut on. 11 underlay pipe sleeve (included) g k h e d i g l right install all the above parts to the rear wheel in order. Right 10 h k g d l left install all the above parts to the rear wheel in order. Left 9 as...

  • Page 12: Assembly

    Fit the hook of steering column into the hole of steering linkage. Insert the bolt through the hole of hook and tighten it with locknut. R p 15 fit the steering column through the hole. Q 14 insert the bolt into the steering wheel through the hole and tighten it with locknut. Q r n 13 assembly 12 as...

  • Page 13: Assembly

    Assembly 13 as se mb ly iii a s s e m b ly ii i open the hood and connect the plugs. 17 18 make sure it fits into the slot properly. Pull down and fasten the latch. Meijer.Com.

  • Page 14: Operating

    14 maintenance how to drive the vehicle there are forward/reverse switch and a power switch on the dashboard. If push the forward/reverse switch to "forward" or "reverse", vehicle will automatically move forward or backward when the power switch is on and the accelerator pedal is pressed. Important ...

  • Page 15: Trouble

    Pst important! If you experience a problem with your vehicle, first check the problems and solutions guide below. If you still experience a problem, please contact service center , toll-free at 1-877-743-3899 from 9 am to 5 pm ( ) monday through friday. Or ® npl pst email us customerservice@funcreat...

  • Page 16: Trouble

    Problem possible cause solution short operating time (less than 1 hours per charge) undercharged battery a new battery should have been charged for at least 18 hours before using the vehicle for the first time. After that, it must be recharge the battery for at least 12 hours after each use .Never c...

  • Page 17: Trouble

    17 intermittent vehicle operation loose wire or connector check all wires around the motors and all connectors to make sure they are tight. Motor or electrical switch damage contact your service center for diagnosis and repair. ® npl when the go foot pedal is pressed, the vehicle won't run without a...

  • Page 18: Label

    18 proper label application will help to keep the labels looking their best! When applying labels, keep the following guidelines in mind: wash your hands before applying the labels. Before applying the labels, wipe the surface of the vehicle with a clean, dry cloth to remove any dust or oils. Place ...

  • Page 19: Parts

    Note: some parts shown are assembled to both sides of the vehicle. 19 no. No. No. Part part part quantity quantity quantity 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 19 21 22 23 24 25 30 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 18 16 33 17 34 35 17...

  • Page 20: Stop!

    National products limited do not return to store this product cannot be returned for a refund after it has been unpacked and used. Call our toll- free 1-877-743-3899 or fax us 1-909-869-5945 or email us customers erv ice@funcre ation.Net or visit us www.Funcre ation.Net for assistance and informatio...