1. DL manuals
  2. National Products
  3. Toy
  4. 591
  5. Owner's Manual

National Products 591 Owner's Manual

Other manuals for 591: Owner's Manual

Summary of 591

  • Page 1

    Please read entire manual before starting assembly. Keep this manual along with your purchase receipt for future reference. Owner's manual to reduce the risk of injury, adult supervision is required. Never use on road ways, near motor vehicles, on or near steep inclines or steps, swimming pools or o...

  • Page 2: Important

    Remember to ... Charge the battery at least once a month during storage, even if the vehicle has not been used. Charge the battery immediately after each use. The battery will be permanently damaged and void your warranty if you fail to follow the instructions. Please refer to the battery care secti...

  • Page 3: Important Information

    Important information table of contents limited warranty important information warning battery warning battery charging battery care and disposal parts list assembly radio installation operating your vehicle trouble shooting label decoration parts diagram 2 3 4 5 6 7 8 9- 15 16 17 18-20 21 22 .........

  • Page 4: Warning

    Warning to prevent serious injuries this product is for use by children 3 and up, and is not intended for children under 3 years due to lack of ability to operate safely. Maximum weight 130 ibs. ( kg). Maximum 2 riders at a time. Do not leave children unattended. Adult supervision required. This pac...

  • Page 5: Battery Warning

    Battery warning warning about thermal fuses important notes battery can fall out and injure a child prevent fire electrical hazard your 12 volt battery is equipped with a built-in thermal fuse. The thermal fuse is a self-resetting safety device which automatically trips and shuts down operation of t...

  • Page 6: Battery

    Disconnect the battery and vehicle . Plugs connect the charger and vehicle . Plugs after it is fully charged, the battery must be reconnected into the from the main body. Plug plug battery connector charger connector non-rechargeable batteries are not to be recharged. Make sure the charger connector...

  • Page 7: Battery

    Your battery is a sealed lead-acid battery. It must be recycled or disposed of it in an environmentally sound manner. Never dispose your battery in the regular, household trash. The incineration, landfilling or mixing of sealed lead-acid batteries with household trash is prohibited by law in most ar...

  • Page 8: Parts

    Screwdriver (not included) please identify all parts before assembly and save all packaging material until assembly is completed to ensure that no parts are discarded. Metal parts have been coated with lubricant to protect them during shipment. Wipe all metal parts with a paper towel to remove any e...

  • Page 9: Assembly

    Assembly warning children can be harmed by small parts, sharp edges and sharp points in the vehicles unassembled state, or by electrical items. Care should be taken in unpacking and assembling the vehicle. Children should not handle parts, including the battery, or help in the assembly of the vehicl...

  • Page 10: Assembly

    Assembly 10 5 anti-roll bars installed. 5 anti-roll bar anti-roll bar 6 fit the ends of side step bar into the slots until you hear a "click" sound. Repeat process for other side. Side step 7 insert 6 screws into the tabs and tighten them. Repeat process for other side. 8 cut both ties and pull out ...

  • Page 11: Assembly

    Hat nut x2 assembly 11 9 linkage 10 wheel cover bushing wheel bushing iron washer 12 hat nut 11 install linkage and tighten with screws and nuts on both sides. Insert front end assembly into slots. Assemble all the parts in sequence as picture shown. Repeat process for other side. Place hat nut over...

  • Page 12: Assembly

    Assembly 12 align the rib in a hubcap with the slot in the wheel cover. "snap" a hubcap into the center of each wheel cover. 13 hubcaps hubcaps 16 insert side mirror and fasten with screw. Repeat process for other side. Screw x2 (st4 x 15) 14 plastic washer plastic hat nut 15 turn the vehicle downri...

  • Page 13: Assembly

    Assembly 13 18 nut screw insert the screw through the hole of turning shaft and fasten it with nut. Screw x1 (m5 x 20) nut x2 (m5) 19 put the dashboard through the turning shaft and locate on the body, then fasten it with screws. Dashboard screw x4 (st4 x 15) screw fixed bushing 20 put the bushing i...

  • Page 14: Assembly

    Assembly 14 22 screw window screw screw place the left window on body and fasten with screws. Repeat process for other side. Screw x6 (st4 x 15) 23 place the rear window at the rear between the two side windows and fasten screws. It with screw screw rear window discard screw x2 (st4 x 15) 24 backres...

  • Page 15: Assembly

    Assembly 15 26 25 put the spare tire cover into the slot on rear. Spare tire cover 27 open the hood and connect the plug. Put the hood cover on. Meijer.Com.

  • Page 16: Radio Installation

    16 radio installation 1 2 insert 4 x 1.5v "aa" (lr6) batteries into the compartment. 4 x 1.5v "aa" (lr6) batteries (not included) remove screws to take out the radio. 3 install the radio back into the vehicle. 3 sound buttons tune mp3 plug reset indicator light power on/off & volume control tip for ...

  • Page 17: Operating

    17 operating your vehicle maintenance important tip make sure the vehicle has come to a completely stop before switching between “forward” and “reverse”. Stop vehicle will automatically stop after the accelerator is released. Safety devices auto power off. If the motor is overloaded for any reason, ...

  • Page 18: Trouble

    18 trouble shooting important! If you experience a problem with your vehicle, first check the problems and solutions guide below. If you still experience a problem, please contact service center , toll-free at 1-877-743-3899 from 9 am to 5 pm ( ) monday through friday. Or ® npl (the warranty and cus...

  • Page 19: Trouble

    Problem possible cause solution short operating time (less than 1 hour per charge) undercharged battery a new battery should have been charged for at least 18 hours before using the vehicle for the first time. After that, it must be recharge the battery for at least 12 hours after each use .Never ch...

  • Page 20: Trouble

    Intermittent vehicle operation loose wire or connector check all wires around the motors and all connectors to make sure they are tight. Motor or electrical switch damage ® contact your npl service center for diagnosis and repair at 1-877-743-3899. When the go foot pedal is pressed, the vehicle won'...

  • Page 21: Label

    21 proper label application will help to keep the labels looking their best! When applying labels, keep the following guidelines in mind: wash your hands before applying the labels. Before applying the labels, wipe the surface of the vehicle with a clean, dry cloth to remove any dust or oils. Place ...

  • Page 22: Parts

    22 note: some parts shown are assembled to both sides of the vehicle. No. No. No. Part part part quantity quantity quantity parts diagram 1 2 3 4 10 11 12 1 2 3 4 5 6 7 8 9 10 11 12 1 1 4 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 2 4 1 1 1 2 2 4 4 4 8 4 2 2 1 1 2 2 5 6 7 8 9 13 14 15 16 17 18 19 19 20 21 22 23 ...

  • Page 23: Stop!

    National products limited do not return to store this product cannot be returned for a refund after it has been unpacked and used. Call our toll- free 1-877-743-3899 or fax us 1-909-869-5945 or email us customers erv ice@funcre ation.Net or visit us www.Funcre ation.Net for assistance and informatio...