P r o v e n p e r f o r m a n c e model 6500 dpg, item # 165930 diesel portable generator m165930a owner’s manual 00308 6500 dpg shown with optional wheel kit (item # 165916) any questions, comments, or problems? Call customer service at 1-800-270-0810 hours: m onday - friday 7:00 am to 5:30 pm cst ...
1 thank you thank you for purchasing a northstar diesel series generator. Your machine is designed for long life, dependability, and the top performance you demand. Please take time now to read through this manual so you can better understand the machine’s operation, maintenance and safety precautio...
2 specifications item number 165930 maximum output 6500 watts (w) continuous output 6120 watts (w) voltage 120 / 240 volt (v) phase single phase (4-wire) frequency 58.0-63.0 hertz (hz) power factor 1.0 p.F. Engine 10 hp yanmar l100ae-deg engine speed 3480-3720 rpm fuel type diesel fuel capacity 6.5 ...
3 machine component identification figure 1 (ref. 1-11) 00309 ref. Description ref. Description 1 gas cap with gauge 9 air cleaner housing 2 6.5 gallon fuel tank 10 muffler 3 operation instructions 11 decompression lever 4 control panel 12 warning decals 5 oil filter access cover 13 ignition fuse 6 ...
4 generator features reference 1 - gas cap w ith gauge. The gas cap is extra large, creating a large hole for refilling and a comfortable grip. You can always monitor the fuel level without removing the cap by using the fuel level indicator built into the gas cap. Reference 2 - 6.5 gallon fuel tank....
5 the reset button must be pushed to reset the receptacle. Reference 20 - 120 volt-30 amp tw istlock receptacle. The control panel is equipped with one nema l5-30r receptacle. This receptacle accepts only nema l5-30p plugs, one of which is shipped with the generator. Reference 21 - 120/240 volt-30 a...
6 warning this generator is equipped with a grounding screw located on the rear of the generator for your protection. Always complete the grounding path from the generator to a copper pipe/rod that is driven into moist earth, to prevent electrical shock. Always use electrical cords that are in good ...
7 contaminants. Over time the effectiveness of the insulation is eliminated and a dead short can result. Always compare the generator nameplate data with that of the equipment to be used to ensure that watts, volts, amperage, and frequency requirements are suitable for operating equipment. The watta...
8 40 9600 30’ 15’ 10’ * 50 12000 15’ * * * *not recommended caution: equipment damage can result from the low voltage caused by using an extension cord with a small wire size. Use this chart to estimate the total load on your generator. For determining generator load requirements dev ice running wat...
9 so could result in damage to equipment plugged into the unit and possible injury to the individual. All engines have a tendency to slow down when a load is applied. When the electrical load is connected to the generator, the engine is more heavily loaded, and as a result the speed drops slightly. ...
10 generator base. Use a deflector (piece of cardboard or paper) to direct the oil down the hole. Generator care the generator is a two pole, 3600 rpm, 60 hz, brushless, revolving field and synchronous type with one sealed radial roller bearing. The generator rotor is directly connected to the engin...
11 troubleshooting problem possible causes possible remedies engine will not start. A) low oil level. B) air in the line. C) out of fuel. D) battery is defective. E) fuel filter clogged. F) fuel shut off valve is in the off position. A) fill crankcase to proper oil level. B) bleed the air from the f...
