1. DL manuals
  2. Northern Lights
  3. Portable Generator
  4. M944T
  5. Parts Manual

Northern Lights M944T Parts Manual

Other manuals for M944T: Operator's Manual

Summary of M944T

  • Page 2

    Diesel engine exhaust and some of its constitu- ents are known to the state of california to cause cancer, birth defects, and other reproductive harm. — california — proposition 65 warning: northern lights 4420 14th avenue n.W. Seattle, wa 98107 tel: (206) 789-3880 fax: (206) 782-5455 copyright ©201...

  • Page 3: Parts Catalog

    P944 8/13 group 4 - fuel system fuel system assembly ............................. 0 - 7 injection pump ......................................... 8 - 9 double wall fuel lines ................................ 10 fuel filter ................................................... 11 fuel lines ..............

  • Page 4

    P944 8/13 model designation ii l, m, nl c w t l - northern lights propulsion engine m - northern lights marine generator set nl - northern lights industrial generator set c - commercial set northern lights marine diesel generator set with a 944 engine and a px-332k2 generator end. M944w northern lig...

  • Page 5

    P944 8/13 references: 1. Grouping section title. 7. Quantity of parts used. 2. Model designation of equipment that uses parts 8. Description of each component part. Listed on this page. 9. Serial number of unit the part fi ts. 3. Title and description of assembly. 10. Assembly or kit designated by k...

  • Page 6

    P944 8/13 group 1 – engine cylinder block key part number qty description serial number •• 32a0721010 1 cylinder block assembly (includes keys 1- 16) - 1 0482623500 10 expansion plug - 2 4 bearing cap* - 3 1 bearing cap, rear* - 4 32a0702600 10 bolt, bearing cap - 5 0482621800 6 expansion plug - 6 3...

  • Page 7

    P944 8/13 group 1 – engine cylinder block key part number qty description serial number •• 32a0744010 1 cylinder block assembly (includes keys 1- 16) - 1 0482623500 10 expansion plug - 2 4 bearing cap* - 3 1 bearing cap, rear* - 4 32a0702600 10 bolt, bearing cap - 5 0482621800 5 expansion plug - 6 3...

  • Page 8

    P944 8/13 group 1 – engine flywheel housing sae #4 key part number qty description serial number 1 32a1200100 1 flywheel housing sae #4 - 2 32a0714201 1 rear gasket - 3 f180510025 10 bolt with washer - 4 f180510030 2 bolt with washer - 5 3440711090 1 rear main seal (repair type) - 3440703700 1 rear ...

  • Page 9

    P944 8/13 group 1 – engine flywheel housing sae #3 key part number qty description serial number 1 32b1200301 1 flywheel housing sae #3 - 2 32a0714201 1 gasket - 3 mf241282 10 bolt with washer - 4 mf241284 2 bolt with washer - 5 3440711090 1 rear main seal - 6 13-05001 2 stud, m10 x 1.5 x 25 mm (37 ...

  • Page 10

    P944 8/13 1 - 4 group 1 – engine crankshaft, pulley, and flywheel key part number qty description serial number 1 32a2000014 1 crankshaft assembly (includes keys 2-5) - 2 f284610000 2 dowel pin - 3 f287007022 2 woodruff key - 4 32a2300101 1 gear - 5 32a2002901 1 nut - 6 32a2002101 1 pulley - 7 32a21...

  • Page 11

    P944 8/13 1 - 5 group 1 – engine crankshaft, pulley, and flywheel key part number qty description serial number 1 32a2000052 1 crankshaft assembly (includes keys 2-5) - 2 f284610000 2 dowel pin - 3 f287007022 2 woodruff key - 4 32a2300301 1 gear - 5 32a2002901 1 nut - 6 32a2002203 1 pulley - 7 32a21...

  • Page 12

    P944 8/13 1 - 6 group 1 – engine main bearing key part number qty description serial number 1 32a09-00010 1 main bearing set, standard - 32a09-00020 1 main bearing set, undersize 0.25 mm - 32a09-00030 1 main bearing set, undersize 0.50 mm - 32a09-00040 1 main bearing set, undersize 0.75 mm - 2 32b09...

  • Page 13

    P944 8/13 group 1 – engine notes 1 - 7.

  • Page 14

    P944 8/13 1 - 8 dwgs. 32b1905 & 32b1718 group 1 – engine piston & connecting rod.

  • Page 15

    P944 8/13 key part number qty description serial number 1 32a1710100 4 piston, standard l-nl944d, m944, & m30cw - 32a1710200 4 piston, oversize 0.25 mm l-nl944d, m944, & m30cw - 32a1710300 4 piston, oversize 0.50 mm l-nl944d, m944, & m30cw - 32a1704500 4 piston, standard m-nl944t, m38cr2 - 32a170460...

  • Page 16

    P944 8/13 1 - 10 key part number qty description serial number 1 32a1103100 1 front plate - 2 32a1100105 1 timing gear cover - 3 32a0704100 1 gasket - 4 f180508016 5 bolt with washer - 5 32a1100200 1 gasket - 6 f180508055 13 bolt with washer - 7 32a1101100 1 cover (m30cw & nl944d) - 8 0601613140 1 o...

  • Page 17

    P944 8/13 1 - 11 key part number qty description serial number 1 32a1113100 1 front plate - 2 32a1110100 1 timing gear cover - 3 32a0704100 1 gasket - 4 mf241251 5 bolt with washer - 5 32a1100200 1 gasket - 6 mf241264 13 bolt with washer - 7 32a1101100 1 cover (m38cr2 & nl944t) - 8 0601613140 1 o-ri...

  • Page 18

    P944 8/13 1 - 12 group 1 – engine timing gear key part number qty description serial number 1 32a2301100 1 camshaft gear - 2 32a2312301 1 injection pump gear - 3 32a2303010 1 idler gear assembly - 4 3432300801 1 thrust plate - 5 f180510020 1 bolt with washer - 6 32a3512101 1 oil pump gear - 7 32a230...

  • Page 19

    P944 8/13 1 - 13 group 1 – engine timing gear key part number qty description serial number 1 32a2301101 1 camshaft gear - 2 32a2305200 1 injection pump gear - 3 32a2303040 1 idler gear assembly - 4 3432300801 1 thrust plate - 5 mf241280 1 bolt with washer - 6 32a3512101 1 oil pump gear - 7 32a23003...

  • Page 20

    P944 8/13 1 - 14 key part number qty description serial number 1 32a0500101 1 camshaft l-m-nl944, m30cw - 32a0505101 1 camshaft m-nl944t, m38cr2 - 2 f287007022 1 woodruff key - 3 3040531403 1 thrust plate - 4 f180508016 2 bolt with washer l-m-nl944, m30cw - mf241251 2 bolt with washer l-m-nl944t, m3...

  • Page 21

    P944 8/13 1 - 15 group 1 – engine oil pump and pick-up key part number qty description serial number 1 32a3516101 1 oil pick-up - 2 f315002000 1 o-ring - 3 f180508016 2 bolt with washer - mf241251 2 bolt with washer (m944t) - 4 32a3510012 1 oil pump assembly - 5 32a3500600 1 o-ring - 6 f180508020 4 ...

  • Page 22

    P944 8/13 1 - 16 key part number qty description serial number 1 32a3901100 1 cover - 2 32a3911200 1 gasket - 3 f180508016 14 bolt with washer - 4 32a3605012 1 relief valve assembly - 5 3434000700 1 gasket - dwgs. # 32b3906 & 32b3606 group 1 – engine side cover and relief valve.

  • Page 23

    P944 8/13 1 - 17 key part number qty description serial number 1 32a3605012 1 relief valve assembly - 2 3434000700 1 gasket - 3 32a3610010 1 safety valve assembly - 4 f420218000 1 gasket - dwgs. # 32b3906a group 1 – engine relief valve m-nl944t, m38cr2.

  • Page 24

    P944 8/13 1 - 18 group 1 – engine oil filter key part number qty description serial number 1 24-01201 1 oil filter - 2 32a4001100 1 union l-m-nl944, m30cw - 32a4001101 1 union l-m-nl944t, m38cr2 - 32b4006.

  • Page 25

    P944 8/13 1 - 19 key part number qty description serial number 1 32a1300011 1 oil pan (includes keys 2 & 3) - 2 md050316 ** plug, m14 x 1.5 - 3 md050317 ** gasket - 4 f180508016 24 bolt with washer - mf240051 24 bolt with washer (m944t) - 5 32a4205100 1 dipstick - ** as required dwg. #: 32b1306 grou...

  • Page 26

    P944 8/13 1 - 20 key part number qty description serial number 1 21-54901 1 male elbow, 90 0 steel m14 x 1.5 x 3/8- 37t - 2 18-71201 1 hose assembly 1/2” i.D. X 19- 1/2” - 3 21-00003 1 cap, hex head brass 1/2 npt - 4 23-72003 1 bracket, oil drain hose support (without pto) - 23-75415 1 bracket, oil ...

  • Page 27

    P944 8/13 1 - 21 key part number qty description serial number 1 21-54901 1 male elbow, 90 0 steel m14 x 1.5 x 3/8- 37t - 2 18-71204 1 hose assembly 3/8” i.D. X 14” - 3 21-00606 1 male elbow 90 0 steel 3/8 npt x 3/8- 37t - 4 36-71201 1 shut-off ball valve, brass 3/8 npt - 5 21-31003 1 plug, hex head...

  • Page 28

    P944 8/13 group 1 – engine cylinder head key part number qty description serial number 1 32a0111020 1 cylinder head assembly (without turbocharger, includes keys 2-10) - 32a0126020 1 cylinder head assembly (with turbocharger, includes keys 2-10) - 2 0482622000 12 expansion plug - 3 0482622500 7 expa...

  • Page 29

    P944 8/13 1 - 23 group 1 – engine notes.

  • Page 30

    P944 8/13 1 - 24 32b0410 group 1 – engine valve train l-m944, m30cw.

  • Page 31

    P944 8/13 1 - 25 group 1 – engine valve train key part number qty description serial number 1 32a0400202 4 intake valve - 2 32a0401202 4 exhaust valve - 3 3060421402 8 valve spring - 4 3060431601 8 upper retainer - 5 3440402901 16 valve cotter - 6 3130411700 8 cap - 7 32a0402801 8 valve stem seal - ...

  • Page 32

    P944 8/13 1 - 26 32b0410 group 1 – engine valve train m-nl944t, m38cr2.

  • Page 33

    P944 8/13 1 - 27 group 1 – engine valve train key part number qty description serial number 1 32a0420100 4 intake valve - 2 32a0421100 4 exhaust valve - 3 3060421402 8 valve spring - 4 3060431601 8 retainer - 5 3440402901 16 keeper - 6 3130411700 8 cap - 7 32a0402801 8 valve guide seal - 8 mf241255 ...

  • Page 34

    P944 8/13 key part number qty description serial number 1 32a0413012 1 rocker cover - 2 md008784 1 cap, oil filler - 3 32a0413200 1 gasket - 4 f180508040 5 bolt with washer - mf241261 5 bolt with washer (m944t, nl944t2, m38cr2) - 5 00-01203 1 label “944” - 6 41-01020 9” hose 3/8” i.D., sold per inch...

  • Page 35

    P944 8/13 2 - 1 intake manifold group 2 – intake & exhaust system 32b3006 key part number qty description serial number 1 32a3016012 1 intake manifold (includes key 6) - 2 32a3000201 1 gasket - 3 01435-00840 12 capscrew, hex head flanged m8 x 1.25 x 40 mm - 4 01435-00890 2 capscrew, hex head flanged...

  • Page 36

    P944 8/13 2 - 2 intake manifold group 2 – intake & exhaust system 32b3006a key part number qty description serial number 1 32a3016012 1 intake manifold (includes key 6) - 2 32a3000201 1 gasket - 3 f180508040 14 bolt w/ washer - 4 f103508090 2 bolt - 5 f251508000 2 spring washer - 6 1 pipe (not avail...

  • Page 37

    P944 8/13 2 - 3 intake manifold group 2 – intake & exhaust system 32b3041d key part number qty description serial number 1 3673021304 1 inlet elbow - 2 3433004300 1 gasket - 3 32b6606100 1 air heater assembly - 4 3433004200 1 gasket - 5 mf241266 4 bolt with washer - 6 32a3000301 1 intake manifold - ...

  • Page 38

    P944 8/13 2 - 4 key part number qty description serial number 1 10-21201 1 housing, air filter - 2 3433004300 1 gasket - 3 12-09712 4 capscrew, hex head m8 x 1.25 x 25 mm s/s - 4 15-99707 4 wave washer m8 s/s - 5 23-21201 1 bracket - 6 12-00776 2 capscrew, hex head m8 x 1.25 x 20 mm s/s - 7 15-99707...

  • Page 39

    P944 8/13 2 - 5 key part number qty description serial number 1 10-21201 1 housing, air filter - 2 3433004300 1 gasket - 3 12-09712 4 capscrew, hex head m8 x 1.25 x 25 mm s/s - 4 15-99707 4 wave washer m8 s/s - 5 23-21201 1 bracket - 6 12-00776 2 capscrew, hex head m8 x 1.25 x 20 mm s/s - 7 15-99707...

  • Page 40

    P944 8/13 2 - 6 group 2 – intake & exhaust system 944airinlet key part number qty description serial number 1 24-20001 1 air filter - 2 19-00040 1 hose clamp #40 - 3 27-21201 1 connector, air inlet - 4 3433004300 1 gasket - 5 12-09712 1 capscrew, hex head m8 x 1.25 x 25 mm s/s - 6 15-00705 1 lock wa...

  • Page 41

    P944 8/13 2 - 7 group 2 – intake & exhaust system key part number qty description serial number 1 24-21003 1 air filter - 2 18-21203 1 hump hose, 4-1/8” id x 2” id x 4-3/4” loa 1/4” vent hole * - 18-21001 1 hump host 4-1/8” id x 2” id x 4-3/4 “ loa with 1/2” vent hole ** 3 19-00072 1 hose clamp #72 ...

  • Page 42

    P944 8/13 2 - 8 crankcase breather filter m944t revised 5-8-13 1 2 2 4 10 11 12 13 7 8 9 3 14 15 16 17 18 19 20 to cylinder block, forward of turbo oil supply from rocker arm cover 6 replaces relay board mounting screws 21 22 23 5.

  • Page 43

    P944 8/13 2 - 9 crankcase breather filter m944t revised 8-7-13 key part number qty description serial number 1 re552766 1 crankcase breather assembly - 2 23-21204 2 bracket, crankcase breather filter support - 3 19m7867 4 capscrew, hex head flanged m8 x 1.25 x 25 mm grade 10.9 - 4 14m7298 4 hex nut,...

  • Page 44

    P944 8/13 2 - 10 group 2 – intake & exhaust system air cleaner and mounting nl944d2 key part number qty description serial number 1 24-21206 1 air cleaner assembly (includes key #16) - 2 23-21203 1 air cleaner mounting bracket - 3 12-00712 2 capscrew, hex head m8 x 1.25 x 25 mm - 4 15-00701 4 flat w...

  • Page 45

    P944 8/13 updated 2-2-09 2 - 11 group 2 – intake & exhaust system air cleaner and mounting nl944t2 key part number qty description serial number 1 d030055 1 air cleaner assembly (includes keys #12-13) - 2 d030052 1 air cleaner mounting bracket w/ heat shield - 3 12-00712 2 capscrew, hex head m8 x 1....

  • Page 46

    P944 8/13 2 - 12 group 2 – intake & exhaust system a-11219/ b-8957 key part number qty description serial number 1 10-31203 1 exhaust manifold (formerly #10-31201 & 10-31202) - 2 32a3200200 1 gasket, exhaust manifold mounting - 3 12-09723 8 capscrew, hex head m8 x 1.25 x 115 mm s/s (formerly socket ...

  • Page 47

    P944 8/13 2 - 13 group 2 – intake & exhaust system 32b3205a key part number qty description serial number 1 32a3200600 1 exhaust manifold - 2 32a3200200 1 gasket, exhaust manifold mounting - 3 3423208300 4 stud - 4 f103508020 8 bolt - exhaust manifold nl944 non-turbo.

  • Page 48

    P944 8/13 2 - 14 group 2 – intake & exhaust system exhaust manifold 32c3214d key part number qty description serial number 1 32a3221100 1 exhaust manifold - 2 32a3200200 1 gasket - 3 3423208200 4 stud - 4 32b3200901 8 spacer - 5 3433231301 8 washer - 6 f251508000 8 spring washer - 7 f230008000 8 loc...

  • Page 49

    P944 8/13 2 - 15 group 2 – intake & exhaust system notes.

  • Page 50

    P944 8/13 m944t/ m38cr2, without air intake heater 2 - 16 group 2 – intake & exhaust system a-11948/ a-12198 turbocharger & mounting.

  • Page 51

    P944 8/13 m944t/ m38cr2, without air intake heater 2 - 17 group 2 – intake & exhaust system key part number qty description serial number 1 30-39400 1 turbocharger k26 (see parts detail, includes key #51) - 2 11-31401 1 gasket, turbo mtg. - 3 13-00814 4 stud, m10 x 1.5 x 30 mm (42 mm loa, grade 8.8)...

  • Page 52

    P944 8/13 2 - 18 group 2 – intake & exhaust system a-12500/ a-12528 turbocharger & mounting m944t/ m38cr2, with air intake heater revised 5-4-11.

  • Page 53

    P944 8/13 2 - 19 group 2 – intake & exhaust system key part number qty description serial number 1 30-39400 1 turbocharger k26 (see parts detail, includes key #51) - 2 11-31401 1 gasket, turbo mtg. - 3 13-00814 4 stud, m10 x 1.5 x 30 mm (42 mm loa, grade 8.8) - 4 31-31203 1 wet adapter - 5 14-00810 ...

  • Page 54

    P944 8/13 k26 turbocharger assembly 2 - 20 group 2 – intake & exhaust system.

  • Page 55

    P944 8/13 2 - 21 k26 turbocharger assembly key part number qty description serial number •• 30-39400 1 turbocharger assembly (id tag #5326 988 60 86 - includes all keys) - • 30-31430 1 repair kit (includes keys 4,5, 11-17, 19-22, 24, & 28) - 1 30-31662 1 spacer sleeve - 2 30-39401 1 turbine housing ...

  • Page 56

    P944 8/13 2 - 22 group 2 – intake & exhaust system a-11281/ b-8962 key part number qty description serial number 1 27-35400 1 elbow, wet exhaust 3” (cast iron) - 2 11-35401 1 gasket, exhaust elbow mtg. - 3 12-09753 4 capscrew, hex head m8 x 1.25 x 30 mm s/s - 4 15-00706 4 flat washer, m8 s/s - 5 21-...

  • Page 57

    P944 8/13 2 - 23 group 2 – intake & exhaust system a-12074/ a-12178 key part number qty description serial number 1 27-31237 1 wet exhaust elbow 3” - 2 19-31401 1 v-clamp - 3 21-12809 1 male elbow, 90 0 brass 3/4 npt x 3/4 hb - 4 18-15406 1 hose, 3/4” i.D. X 35”, wire reinforced - 5 19-00010 2 hose ...

  • Page 58

    P944 8/13 2 - 24 group 2 – intake & exhaust system a-4267/ b-3632a key part number qty description serial number 1 27-35405 1 dry exhaust elbow - 31-35401 1 dry exhaust adapter 2” npt female - 2 11-35401 1 exhaust elbow gasket - 3 15-00705 4 lock washer, helical m8 s/s - 4 12-00776 4 capscrew, hex h...

  • Page 59

    P944 8/13 2 - 25 group 2 – intake & exhaust system a-912/ b-9447 key part number qty description serial number 1 19-31401 1 v-clamp - 2 21-31002 1 plug, square head brass 3/8 npt (solid only) - 3 27-31243 1 elbow, dry exhaust 3” x 8.78” 27-31415 1 elbow, dry exhaust 3” x 4-7/8” (m38cr2 only) - 4 12-...

  • Page 60

    P944 8/13 updated 2-2-11 3 - 0 group 3 – cooling system a-11220/ b-8970 expansion tank and thermostat housing.

  • Page 61

    P944 8/13 updated 2-4-11 key part number qty description serial number 1 10-12205 1 expansion tank - 2 10-11202 1 thermostat housing (formerly #10-11201) - 3 12-09819 4 capscrew, hex head m10 x 1.5 x 75 mm s/s - 4 15-09805 4 flat washer m10 s/s - 5 35-11000 1 thermostat 180 0 f/ 82 0 c - 6 11-10015 ...

  • Page 62

    P944 8/13 3 - 2 group 3 – cooling system a-11221/ c-6124 key part number qty description serial number 1 20-11202 1 heat exchanger assembly (see parts detail) - 2 12-09212 4 capscrew, hex head 5/16- 18 x 1” s/s - 3 15-11000 4 flat washer 5/16” s/s - 4 18-11201 1 hose, heat exchanger outlet 1-1/2” i....

  • Page 63

    P944 8/13 3 - 3 group 3 – cooling system / c-5846 key part number qty description serial number •• 20-11202 1 heat exchanger assembly, cu-ni (includes all keys) - 1 20-11201 1 heat exchanger - 2 21-31624 1 plug, hex head brass 1/4 npt - 3 21-12010 1 zinc anode 11/32” o.D. X 1-3/4” - 4 21-12000 1 plu...

  • Page 64

    P944 8/13 3 - 4 group 3 – cooling system 32ab46080 key part number qty description serial number 1 mf140227 2 flange bolt - 2 32a4601101 1 thermostat cover - 3 32a4601400 1 gasket - 4 32a4602100 1 thermostat - 5 32a4610030 1 thermostat housing - 6 3444605300 1 gasket - 7 mf241268 1 bolt with washer ...

  • Page 65

    P944 8/13 3 - 5 group 3 – cooling system 32b4511z key part number qty description serial number 1 32a4500022 1 coolant pump assembly (includes keys 4-7) - 2 f180508045 5 bolt with washer - 3 32a4500500 1 gasket - 4 mf140227 2 flange bolt - 5 mf140231 1 flange bolt - 6 32a4500300 1 cover - 7 32a45004...

  • Page 66

    P944 8/13 3 - 6 group 3 – cooling system 32b4511a key part number qty description serial number 1 32b4510031 1 coolant pump assembly (includes keys 4-7) - 2 mf241261 5 bolt with washer - 3 32a4500500 1 gasket - 4 f180508025 2 bolt with washer - 5 f180508035 1 bolt with washer - 6 32a4500300 1 cover ...

  • Page 67

    P944 8/13 group 3 – cooling system 3 - 7 a-11222/ key part number qty description serial number 1 25-11202 1 raw water pump (see parts detail) - 2 31-11201 1 adapter, raw water pump mtg. - 3 25-19517 1 o-ring - 4 12-00776 3 capscrew, hex head m8 x 1.25 x 20 mm s/s - 5 15-00705 3 lock washer, helical...

  • Page 68

    P944 8/13 3 - 8 group 3 – cooling system a-11945 key part number qty description serial number 1 25-11202 1 raw water pump (see parts detail) - 2 31-11202 1 adapter, raw water pump mtg. - 3 25-19517 1 o-ring - 4 12-00776 3 capscrew, hex head m8 x 1.25 x 20 mm s/s - 5 15-00705 3 lock washer, helical ...

  • Page 69

    P944 8/13 3 - 9 group 3 – cooling system a-11209/ 50550-2001jabsco key part number qty description serial number •• 25-11202 1 raw water pump (includes all keys) - • 25-11216 1 repair kit (includes keys #1,3,4,6,7,8,9, & 18) - 1 25-15708 2 bearing - 2 25-11203 1 housing - 3 25-11204 1 cam - 4 25-112...

  • Page 70

    P944 8/13 32b3915 3 - 10 group 3 – cooling system oil cooler m944t, nl944t2, & m38cr2 added pages 2-26-09.

  • Page 71

    P944 8/13 3 - 11 group 3 – cooling system key part number qty description serial number 1 32a3904100 1 gasket, side cover - 2 f315002000 2 o-ring - 3 mf241254 16 bolt with washer - 4 32a3903101 1 case assembly - 5 0482772100 2 plug, tapered - 6 32a3903300 1 oil cooler element - 7 0550700090 4 o-ring...

  • Page 72

    P944 8/13 keel cooling outlet a-4400/ b-1700 key part number qty description serial number 1 31-15402 1 keel cooling adapter - 2 11-12203 1 gasket - 3 15-00222 2 lock washer, 5/16” s/s - 4 12-09212 2 capscrew, 5/16- 18 x 1” s/s - updated 2-8-11 3 - 12 group 3 – cooling system.

  • Page 73

    P944 8/13 3 - 13 group 3 - cooling system cooling fan 32b4816d key part number qty description serial number 1 32a4800400 1 fan - 2 3134512100 1 fan plate - 3 mf241254 4 bolt with washer - 4 0591020045 1 belt - nl944 all.

  • Page 74

    P944 8/13 group 4 – fuel system fuel system 4 - 0 32b6116 l - m944 non-turbo.

  • Page 75

    P944 8/13 key part number qty description serial number 1 mdo68353 4 nut - 2 mdo68355 4 gasket, fuel return - 3 mdo70717 4 gasket - 4 32b6102100 1 injection line no. 1 - 5 32b6102200 1 injection line no. 2 - 6 32b6102300 1 injection line no. 3 - 7 32b6102400 1 injection line no. 4 - 8 mm430703 3 cla...

  • Page 76

    P944 8/13 group 4 – fuel system fuel system 4 - 2 32b6116, nl944d3 nl944d2 updated page 5-26-11.

  • Page 77

    P944 8/13 group 4 – fuel system fuel system 4 - 3 nl944d2 updated page 5-26-11 key part number qty description serial number •• 3446200011 1 fuel filter head assembly (see assembly detail, includes keys 14-15) - 1 mdo68353 4 nut - 2 mdo68355 4 gasket, fuel return - 3 mdo70717 4 gasket - 4 32b6102100...

  • Page 78

    P944 8/13 group 4 – fuel system fuel system 4 - 4 32b6138&32b6116 updated 2-25-09 m944t & m38cr2 units without intake air heater.

  • Page 79

    P944 8/13 group 4 – fuel system fuel system 4 - 5 updated 2-25-09 key part number qty description serial number 1 18-51208 3 hose, 1/4” x i.D. X 4” - 2 19-50113 9 hose clamp #13 mini extended band s/s - 3 mm432045 4 gasket - 5 me016571 1 cap - 6 mf241257 4 bolt with washer - 7 mm43713701 4 nozzle su...

  • Page 80

    P944 8/13 group 4 – fuel system fuel system 4 - 6 32b6138&32b6116a m944t & m38cr2 (units with intake air heater) page added 3-21-11.

  • Page 81

    P944 8/13 key part number qty description serial number 1 18-51208 3 hose, 1/4” x i.D. X 4” - 2 19-50113 9 hose clamp #13 mini extended band s/s - 3 mm432045 4 gasket - 5 me016571 1 cap - 6 mf241257 4 bolt with washer - 7 mm43713701 4 nozzle support - 8 32a6115101 1 injection line no. 1 - 9 32a61152...

  • Page 82

    P944 8/13 group 4 – fuel system fuel system 4 - 8 32b6138dafuelsystem nl944t2 page updated 5-26-11.

  • Page 83

    P944 8/13 group 4 – fuel system fuel system 4 - 9 nl944t2 key part number qty description serial number 1 ms602011 3 hose - 2 ms660163 9 hose clamp - 3 mf241257 4 bolt with washer - 4 mm43713701 4 nozzle support - 5 mm432045 4 nozzle gasket - 6 ms660163 1 hose clamp - 7 me016571 1 cap - 8 32a6115101...

  • Page 84

    P944 8/13 4 - 10 group 4 – fuel system 32b6541 injection pump key part number qty description s/n •• 32a6501730 1 injection pump assembly, 1500/ 1800 rpm (m944, includes keys 12, 14-15) - •• 32a6501720 1 injection pump assembly, 1500/ 1800 rpm (nl944, includes keys 12, 14-15) - •• 26-51201 1 injecti...

  • Page 85

    P944 8/13 4 - 11 injection pump group 4 – fuel system 32b6561dmodifi ed key part number qty description s/n •• 32a6504320 1 injection pump assembly - 1 32a6101301 1 flange - 2 0601613140 1 o-ring - 3 0601613075 1 gasket - 4 f201510035 4 bolt with washer - 5 mf241253 1 bolt with washer - 6 f444006300...

  • Page 86

    P944 8/13 4 - 12 group 4 – fuel system a-11493/ st15033-1 key part number qty description serial number 1 27-51211 1 injection line #1 double wall - 2 27-51212 1 injection line #2 double wall - 3 27-51213 1 injection line #3 double wall - 4 27-51214 1 injection line #4 double wall - 5 10-58701 1 man...

  • Page 87

    P944 8/13 4 - 13 group 4 – fuel system 32b6205 key part number qty description serial number 1 3446200011 1 fuel filter assembly (includes keys 2- 6) - 2 3446200201 1 bracket - 3 24-51201 1 element - 4 mh037087 2 eye bolt - 5 0594601401 4 sealing washer - 6 mh037084 1 plug - 7 0594600801 1 sealing w...

  • Page 88

    P944 8/13 4 - 14 group 4 – fuel system fuel line connections key part number qty description serial number 1 21-52203 1 banjo fitting, steel 14 mm x 1/4 npt - 2 21-52245 1 male elbow, 90 0 brass 1/4 npt x 5/16- 45t - 3 21-71056 1 female swivel, brass 5/16 hb x 5/16- 45 t - 4 21-51201 1 male elbow, 4...

  • Page 89

    P944 8/13 4 - 15 group 4 – fuel system uscg fuel lines key part number qty description serial number 1 10-51099 1 manifold, fuel line connection - 2 12-01102 2 capscrew, hex head m6 x 1.0 x 16 mm s/s - 3 15-00610 2 lock washer, helical m6 s/s - 4 21-52245 2 male elbow, 90 0 brass 1/4 npt x 5/16- 45t...

  • Page 90

    P944 8/13 4 - 16 group 4 – fuel system uscg fuel lines key part number qty description serial number 1 10-51099 1 manifold, fuel line connection - 2 12-01102 2 capscrew, hex head m6 x 1.0 x 16 mm s/s - 3 15-00610 2 lock washer, helical m6 s/s - 4 21-74411 2 male elbow, 90 0 steel 1/4 npt x 5/16- 37t...

  • Page 91

    P944 8/13 group 4 – fuel system push-on fuel lines key part number qty description serial number 1 10-51099 1 manifold, fuel line connection - 2 12-01102 2 capscrew, hex head m6 x 1.0 x 16 mm s/s - 3 15-00610 2 lock washer, helical m6 s/s - 4 21-52245 2 male elbow, 90 0 brass 1/4 npt x 5/16- 45t - 5...

  • Page 92

    P944 8/13 group 4 – fuel system fuel lines, uscg a-1 sae j1527 iso 7840 key part number qty description serial number 1 21-52245 2 male elbow, 90 0 brass 1/4 npt x 5/16-45t - 2 18-51206 1 hose assembly, 5/16” i.D. X 13-1/2” - 3 18-51207 1 hose assembly, 5/16” i.D. X 19” - 4 19-01004 2 hose clamp, #4...

  • Page 93

    P944 8/13 4 - 19 group 4 – fuel system fuel lines, uscg a-1 sae j1942 abs m38cr2 key part number qty description serial number 1 10-51099 1 manifold, fuel line connection - 2 12-01102 2 capscrew, hex head m6 x 1.0 x 16 mm - 3 15-00610 2 lock washer, helical m6 s/s - 4 21-74411 2 male elbow, 90 0 ste...

  • Page 94

    P944 8/13 group 4 – fuel system key part number qty description serial number 1 10-51099 1 manifold, fuel line connection - 2 12-01102 2 capscrew, hex head m6 x 1.0 x 16 mm s/s - 3 15-00610 2 lock washer, helical m6 s/s - 4 21-52245 2 male elbow, 90 0 brass 1/4 npt x 5/16-45t - 5 21-71044 1 male elb...

  • Page 95

    P944 8/13 key part number qty description serial number 1 10-51099 1 manifold, fuel line connection - 2 12-00032 2 capscrew, hex head m6 x 1.0 x 30 mm - 3 15-00008 4 flat washer m6 - 4 14-04803 2 hex nut, nylock m6x1.0 - 5 21-52245 2 male elbow, 90 0 brass 1/4 npt x 5/16-45t - 6 18-58705 1 hose asse...

  • Page 96

    P944 8/13 4 - 22 group 4 – fuel system 32b6544 fuel feed pump key part number qty description serial number 1 3446109050 1 fuel feed pump assembly (includes all keys) - 2 0921200161 1 housing - 3 0921680150 1 push rod - 4 0921210011 2 check valve - 5 0921240010 2 valve check spring - 6 0921250010 2 ...

  • Page 97

    P944 8/13 4 - 23 group 4 – fuel system 32b6544a fuel feed pump key part number qty description serial number 1 3446109060 1 fuel feed pump assembly (includes all keys) - 2 0921200161 1 housing - 3 0921680150 1 push rod - 4 0921210011 2 check valve - 5 0921240010 2 valve check spring - 6 0921250010 2...

  • Page 98

    P944 8/13 4 - 24 group 4 – fuel system 32b6111 injector l-m944, m30cw.

  • Page 99

    P944 8/13 4 - 25 group 4 – fuel system injector key part number qty description serial number 1 32c6106000 4 injector assembly (includes all keys) - 2 32c6106010 4 injector holder - 3 0931105480 4 housing - 4 0931210380 4 pin - 5 0931270360 4 spring - 6 0931641351 4 nozzle retaining nut - 7 09317400...

  • Page 100

    P944 8/13 4 - 26 group 4 – fuel system 32b6140modifi ed injector m-nl944t, m38cr2.

  • Page 101

    P944 8/13 4 - 27 group 4 – fuel system injector key part number qty description serial number 1 32b6107020 4 injector assembly (includes all keys) - 2 32b6107600 4 injector holder - 3 0931107600 4 housing - 4 0931210480 4 pin - 5 0931270410 4 spring - 6 0931641020 4 nozzle retaining nut - 7 09322101...

  • Page 102

    P944 8/13 4 - 28 group 4 – fuel system a-11648/ b-9332 throttle assembly key part number qty description serial number •• 26-91200 1 throttle assembly (includes all keys) - 1 23-91201 1 bracket, throttle connection - 2 12-01152 2 capscrew, hex head m6 x 1.0 x 40 mm grade 8.8 - 3 15-01132 4 lock wash...

  • Page 103

    P944 8/13 4 - 29 group 4 – fuel system notes.

  • Page 104

    P944 8/13 5 - 0 group 5 – electrical system electrical system 12 volt standard ground a-11649/ c-4985propulsion l944.

  • Page 105

    P944 8/13 key part number qty description serial number 1 22-41203 1 wire harness assembly - 2 23-41204 1 bracket, circuit breaker & relay - 3 12-00812 2 capscrew, hex head m10 x 1.5 x 40 mm - 4 15-00804 2 wave washer, m10 - 5 12-01131 2 capscrew, hex head m6 x 1.0 x 20 mm - 6 15-00008 4 flat washer...

  • Page 106

    P944 8/13 5 - 2 group 5 – electrical system electrical system 24 volt standard ground a-119290/ c-4985propulsion l944.

  • Page 107

    P944 8/13 key part number qty description serial number 1 22-41203 1 wire harness assembly - 2 23-41204 1 bracket, circuit breaker & relay - 3 12-00812 2 capscrew, hex head m10 x 1.5 x 40 mm - 4 15-00804 2 wave washer, m10 - 5 12-01131 2 capscrew, hex head m6 x 1.0 x 20 mm - 6 15-00008 4 flat washer...

  • Page 108

    P944 8/13 5 - 4 group 5 – electrical system electrical system 12 volt standard ground a-11225/ c-4985 m944 & m30cw.

  • Page 109

    P944 8/13 key part number qty description serial number 1 22-40233 1 switch, oil pressure 15 psi - 2 22-41016 1 pressure sender 0- 80 psi, standard ground - 3 22-41025 1 switch, water temperature 210 0 f - 4 22-42055 1 temperature sender 250 0 f, standard ground - 5 22-40391 4 relay base without ret...

  • Page 110

    P944 8/13 5 - 6 group 5 – electrical system electrical system 12 volt isolated ground a-11330/ c-4985 m944 & m30cw.

  • Page 111

    P944 8/13 key part number qty description serial number 1 22-40236 1 switch, oil pressure 15 psi - 2 22-42803 1 pressure sender 0- 80 psi, isolated ground - 3 22-40938 1 switch, water temperature 210 0 f (formerly #22-40906) - 4 22-44810 1 temperature sender 250 0 f, isolated ground - 5 22-40391 5 r...

  • Page 112

    P944 8/13 a-11333/ c-4985 group 5 – electrical system electrical system 24 volt standard ground 5 - 8 m944 & m30cw.

  • Page 113

    P944 8/13 5 - 9 group 5 – electrical system electrical system 24 volt standard ground key part number qty description serial number 1 22-40233 1 switch, oil pressure 15 psi - 2 22-41016 1 pressure sender 0- 80 psi, standard ground - 3 22-41025 1 switch, water temperature 210 0 f - 4 22-42055 1 tempe...

  • Page 114

    P944 8/13 5 - 10 group 5 – electrical system electrical system 24 volt isolated ground a-11336/ c-4985 m944 & m30cw.

  • Page 115

    P944 8/13 key part number qty description serial number 1 22-40236 1 switch, oil pressure 15 psi - 2 22-42803 1 pressure sender 0- 80 psi, isolated ground - 3 22-40938 1 switch, water temperature 210 0 f (formerly #22-40906) - 4 22-44810 1 temperature sender 250 0 f, isolated ground - 5 22-40391 5 r...

  • Page 116

    P944 8/13 a-11474/ c-4985comm group 5 – electrical system electrical system 12 volt standard ground 5 - 12 m30cw with relay board.

  • Page 117

    P944 8/13 5 - 13 group 5 – electrical system electrical system 12 volt standard ground key part number qty description serial number 1 22-40233 1 switch, oil pressure 15 psi - 2 22-41016 1 pressure sender 0- 80 psi, standard ground - 3 22-41025 1 switch, water temperature 210 0 f - 4 22-42055 1 temp...

  • Page 118

    P944 8/13 a-12030/ c-4985tunits group 5 – electrical system electrical system 12 volt standard ground 5 - 14 m944t & m38cr2 without air intake heater updated 5-2-11.

  • Page 119

    P944 8/13 5 - 15 group 5 – electrical system electrical system 12 volt standard ground key part number qty description serial number 1 22-40233 1 switch, oil pressure 15 psi - 2 22-41016 1 pressure sender 0- 80 psi, standard ground - 3 22-41025 1 switch, water temperature 210 0 f 1/2 npt - 4 22-4205...

  • Page 120

    P944 8/13 a-12030/ c-4985tunits2 from turbocharger installation to starter positive group 5 – electrical system electrical system 12 volt standard ground 5 - 16 m944t & m38cr2 with air intake heater updated 5-4-11.

  • Page 121

    P944 8/13 5 - 17 group 5 – electrical system electrical system 12 volt standard ground key part number qty description serial number 1 22-40233 1 switch, oil pressure 15 psi - 2 22-41016 1 pressure sender 0- 80 psi, standard ground - 3 22-41025 1 switch, water temperature 210 0 f 1/2 npt - 4 22-4205...

  • Page 122

    P944 8/13 a-12108/ c-4985tunits group 5 – electrical system electrical system 12 volt isolated ground 5 - 18 m944t & m38cr2 without air intake heater updated 5-25-11.

  • Page 123

    P944 8/13 5 - 19 group 5 – electrical system electrical system 12 volt isolated ground key part number qty description serial number 1 22-40236 1 switch, oil pressure 15 psi - 2 22-42803 1 pressure sender 0- 80 psi, isolated ground - 3 22-40938 1 switch, water temperature 210 0 f 1/2 npt - 4 22-4481...

  • Page 124

    P944 8/13 a-12030/ c-4985tunits2 from turbocharger installation to starter positive group 5 – electrical system electrical system 12 volt isolated ground 5 - 20 m944t & m38cr2 with air intake heater added 5-25-11.

  • Page 125

    P944 8/13 5 - 21 group 5 – electrical system electrical system 12 volt isolated ground key part number qty description serial number 1 22-40236 1 switch, oil pressure 15 psi - 2 22-42803 1 pressure sender 0- 80 psi, isolated ground - 3 22-40938 1 switch, water temperature 210 0 f 1/2 npt - 4 22-4481...

  • Page 126

    P944 8/13 a-12131/ c-4985tunits group 5 – electrical system electrical system 24 volt standard ground 5 - 22 m944t & m38cr2 without air intake heater updated 5-25-11.

  • Page 127

    P944 8/13 5 -23 group 5 – electrical system electrical system 24 volt standard ground key part number qty description serial number 1 22-40233 1 switch, oil pressure 15 psi - 2 22-41016 1 pressure sender 0- 80 psi, standard ground - 3 22-41025 1 switch, water temperature 210 0 f 1/2 npt - 4 22-42055...

  • Page 128

    P944 8/13 a-12030/ c-4985tunits2 from turbocharger installation to starter positive group 5 – electrical system electrical system 24 volt standard ground 5 - 24 m944t & m38cr2 with air intake heater added 5-25-11.

  • Page 129

    P944 8/13 5 - 25 group 5 – electrical system electrical system 24 volt standard ground key part number qty description serial number 1 22-40233 1 switch, oil pressure 15 psi - 2 22-41016 1 pressure sender 0- 80 psi, standard ground - 3 22-41025 1 switch, water temperature 210 0 f 1/2 npt - 4 22-4205...

  • Page 130

    P944 8/13 a-12132/ c-4985tunits group 5 – electrical system electrical system 24 volt isolated ground 5 - 26 m944t & m38cr2 without air intake heater updated 5-25-11.

  • Page 131

    P944 8/13 5 - 27 group 5 – electrical system electrical system 24 volt isolated ground key part number qty description serial number 1 22-40236 1 switch, oil pressure 15 psi - 2 22-42803 1 pressure sender 0- 80 psi, isolated ground - 3 22-40938 1 switch, water temperature 210 0 f 1/2 npt - 4 22-4481...

  • Page 132

    P944 8/13 a-12030/ c-4985tunits2 from turbocharger installation to starter positive group 5 – electrical system electrical system 24 volt isolated ground 5 - 28 m944t & m38cr2 with air intake heater added 5-26-11.

  • Page 133

    P944 8/13 5 - 29 group 5 – electrical system electrical system 24 volt isolated ground key part number qty description serial number 1 22-40236 1 switch, oil pressure 15 psi - 2 22-42803 1 pressure sender 0- 80 psi, isolated ground - 3 22-40938 1 switch, water temperature 210 0 f 1/2 npt - 4 22-4481...

  • Page 134

    P944 8/13 5 - 30 group 5 – electrical system electrical system 12 volt standard ground a-12466/ b-9679 nl944d2 added 5-26-11.

  • Page 135

    P944 8/13 key part number qty description serial number 1 22-40233 1 oil pressure switch 15 psi - 2 22-41016 1 pressure sender 0-80 psi, standard ground - 3 mc880900 1 temperature switch, 100 0 c/ 212 0 f - 4 22-45201 1 temperature sender 250 0 f, standard ground - 15-01001 1 sealing washer, m16 - 5...

  • Page 136

    P944 8/13 5 -32 group 5 – electrical system electrical system 12 volt standard ground a-12446/ b-9681a nl944t2 added 5-26-11.

  • Page 137

    P944 8/13 key part number qty description serial number 1 22-40233 1 oil pressure switch - 2 22-41016 1 pressure sender, 0-80 psi, standard ground - 3 mc880900 1 temperature switch 100 0 c/ 212 0 f - 4 22-45201 1 temperature sender, 250 0 f standard ground - 15-01001 1 sealing washer, copper m16 - 5...

  • Page 138

    P944 8/13 5 -34 group 5 – electrical system electrical system air intake heater sub-assembly m944t added 5-26-11 3 2 2 4 4 1 d-4510

  • Page 139

    P944 8/13 electrical system air intake heater sub-assembly group 5 – electrical system 5 - 35 m944t updated 7-12-12 key part number qty description serial number 1 22-21207 1 intake air heater 1200 watt 24 volt 55 amp standard ground - 22-21206 1 intake air heater 1200 watt 24 volt 55 amp isolated g...

  • Page 140

    P944 8/13 5 -36 group 5 – electrical system starter 12 volt standard ground 32b6614.

  • Page 141

    P944 8/13 key part number qty description serial number 1 32a6611100 1 starter assembly (includes all keys) - 2 m414x07472 1 screw set (includes a & b) - 3 m578x31971 1 packing - 4 m641xd8571 1 front bracket assembly (includes key 5) - 5 m690x00574 1 bearing set - 6 m863x08675 1 lever assembly - 7 m...

  • Page 142

    P944 8/13 5 - 38 group 5 – electrical system starter 12 volt standard ground 32b6630dchanged m944t & nl944t.

  • Page 143

    P944 8/13 key part number qty description serial number 1 32a6610101 1 starter assembly (includes all keys) - 2 m414x04875 1 screw set - 3 m578x29171 1 packing - 4 m641xb1571 1 front bracket assembly (includes key 5) - 5 m690x00572 1 bearing set - 6 m863x08673 1 lever assembly - 7 m385x03771 1 bolt ...

  • Page 144

    P944 8/13 5 - 40 group 5 – electrical system small frame alternator and mounting 32b6826 key part number qty description serial number 1 32a6800302 1 alternator 12 volt/ 50 amp (see parts detail) - 2 32a6801201 1 bracket - 3 f180508020 1 bolt with washer - 4 f103510040 1 bolt - 5 f251510000 1 spring...

  • Page 145

    P944 8/13 5 -41 group 5 – electrical system small frame alternator and mounting 32b6813 key part number qty description serial number 1 32a6800401 1 alternator 12 volt/ 50 amp (nl944d2, see parts detail) - 32a6806600 1 alternator 12 volt/ 75 amp (nl944t2, see parts detail) - 2 32a6801103 1 bracket -...

  • Page 146

    P944 8/13 5 - 42 group 5 – electrical system small frame alternator and mounting a-12257 key part number qty description serial number 1 32a6806600 1 alternator 12 volt/ 75 amp (see parts detail) - 2 23-41205 1 bracket - 3 12-00718 2 capscrew, hex head m8 x 1.25 x 65 mm - 4 12-00753 1 capscrew, hex ...

  • Page 147

    P944 8/13 5 - 43 group 5 – electrical system medium frame alternator and mounting 32b6826withadditions key part number qty description serial number 1 22-40332 1 alternator 12 volt/ 90 amp isolated ground - 22-71052 1 alternator 24 volt/ 35 amp isolated ground - 22-40278 1 alternator 24 volt/ 40 amp...

  • Page 148

    P944 8/13 5 - 44 group 5 – electrical system medium frame alternator and mounting 32b6826withadditions key part number qty description serial number 1 22-40332 1 alternator 12 volt/ 90 amp isolated ground - 22-71052 1 alternator 24 volt/ 35 amp isolated ground - 22-40278 1 alternator 24 volt/ 40 amp...

  • Page 149

    P944 8/13 l944d- m944 - m30cw key part number qty description serial number 1 32a6800302 1 alternator assembly (includes all keys) - 2 a981x20771 1 nut set - 3 a628t63370 1 pulley assembly - 4 a414x19271 1 bolt set - 5 a640x67070 1 front bracket assembly - 6 a414x21271 1 screw set - 7 a930x94570 1 f...

  • Page 150

    P944 8/13 key part number qty description serial number 1 32a6800401 1 alternator assembly (includes all keys) - 2 a981x20771 1 nut set - 3 a628x65070 1 pulley assembly - 4 a414x19271 1 bolt set - 5 a640x69170 1 front bracket assembly - 6 a414x21271 1 screw set - 7 a930x94570 1 front bearing - 8 a88...

  • Page 151

    P944 8/13 5 - 47 key part number qty description serial number 1 32a6806600 1 alternator assembly (includes all keys) - 2 mm502565 1 nut set - 3 47x1102360 1 pulley assembly - 4 mm502566 1 bolt set - 5 47x1102348 1 front bracket assembly (includes keys 7 & 8) - 6 47x1102355 1 rotor assembly (include...

  • Page 152

    P944 8/13 stop solenoid group 5 – electrical system 32b8705 key part number qty description serial number 1 3428702602 2 rod - 3428702603 2 rod - 2 f250006000 2 washer - 3 f251506000 4 spring washer - 4 f230006000 5 lock nut - 5 32a8705300 1 bracket - 6 32a8705400 1 support rod - 7 32a8705900 1 sole...

  • Page 153

    P944 8/13 5 - 49 group 5 - electrical systems harness assembly with circuit breaker & relay panel key part number qty description serial number •• 22-41203 1 wire harness assembly with relay bases (w/o relays) - 1 23-40019 1 bracket - 2 22-41070 1 40 amp circuit breaker - 3 22-40391 2 relay base - 4...

  • Page 154

    P944 8/13 group 5 - electrical systems 12 & 24 volt relay logic board key part number qty description serial number •• 22-70083 1 12v relay logic board, manual start (includes all keys) - •• 22-70084 1 24v relay logic board, manual start (includes all keys) - •• 22-70086 1 12v relay logic board, aut...

  • Page 155

    P944 8/13 5 - 51 group 5 – electrical system drive belt applications 32b4812 part number qty description l944d - m944 - m30cw 40-05404 1 drive belt standard small or optional medium frame size alternators 12 v/ 50 amp, 12 v/ 90 amp, 24 v/ 35 amp, 24 v/ 40 amp m944t - m38cr2 40-45401 1 drive belt sta...

  • Page 156

    P944 8/13 key part number qty description serial number 1 00-01207 1 belt guard, small frame 12v/ 50 amp alternator - 00-01204 1 belt guard, medium frame alternators - 2 23-01201 1 bracket - 3 13-01201 1 stud, belt guard mtg. Upper right - 4 13-01202 1 stud, belt guard mtg. Lower right - 5 12-00719 ...

  • Page 157

    P944 8/13 key part number qty description serial number 1 00-01212 1 belt guard, small frame 12v/ 75 amp alternator - 00-01217 1 belt guard, medium frame alternators - 2 23-01201 1 bracket - 3 13-01203 1 stud, belt guard mtg. Upper right - 4 13-01204 1 stud, belt guard mtg. Lower right - 5 12-00719 ...

  • Page 158

    P944 8/13 key part number qty description serial number 1 00-01201 1 belt guard, small frame 12v/ 50 amp alternator - 00-01202 1 belt guard, medium frame alternators - 2 23-01201 1 bracket - 3 13-01201 1 stud, belt guard mtg. Upper right - 4 13-01202 1 stud, belt guard mtg. Lower right - 5 12-00719 ...

  • Page 159

    P944 8/13 5 - 55 key part number qty description serial number 1 00-01213 1 belt guard, small frame 12v/ 75 amp alternator - 00-01218 1 belt guard, medium frame alternators - 2 23-01201 1 bracket - 3 13-01203 1 stud, belt guard mtg. Upper right - 4 13-01204 1 stud, belt guard mtg. Lower right - 5 12...

  • Page 160

    P944 8/13 key part number qty description serial number 1 00-01211 1 belt guard, small frame 12v/ 50 amp alternator - 00-01208 1 belt guard, medium frame alternators - 2 23-01201 1 bracket - 3 13-01201 1 stud, belt guard mtg. Upper right - 4 13-01202 1 stud, belt guard mtg. Lower right - 5 12-00719 ...

  • Page 161

    P944 8/13 key part number qty description serial number 1 00-01214 1 belt guard, small frame 12v/ 75 amp alternator - 00-01219 1 belt guard, medium frame alternators - 2 23-01201 1 bracket - 3 13-01203 1 stud, belt guard mtg. Upper right - 4 13-01204 1 stud, belt guard mtg. Lower right - 5 12-00719 ...

  • Page 162

    P944 8/13 5 - 58 group 5 – electrical system key part number qty description serial number 1 00-01209 1 belt guard, small frame 12v/ 50 amp alternator - 00-01206 1 belt guard, medium frame alternators - 2 23-01201 1 bracket - 3 13-01201 1 stud, belt guard mtg. Upper right - 4 13-01202 1 stud, belt g...

  • Page 163

    P944 8/13 5 - 59 group 5 – electrical system key part number qty description serial number 1 00-01216 1 belt guard, small frame 12v/ 75 amp alternator - 00-01221 1 belt guard, medium frame alternators - 2 23-01201 1 bracket - 3 13-01203 1 stud, belt guard mtg. Upper right - 4 13-01204 1 stud, belt g...

  • Page 164

    P944 8/13 a-11651, a-11521 / b-4734-2changed main instrument panel 12 volt l944 key part number qty description serial number •• 22-91200 1 main instrument panel, 12 volt (includes all keys) - 1 28-90031 1 plate, main instrument panel - 2 37-90069 1 tachometer 0 -3500 rpm 12/24 volt - 3 37-90072-1 1...

  • Page 165

    P944 8/13 5 - 61 group 5 – electrical system a-119300, a-11522 / b-4734-2changed main instrument panel 24 volt l944 key part number qty description serial number •• 22-91205 1 main instrument panel, 24 volt (includes all keys) - 1 28-90031 1 plate, main instrument panel - 2 37-90069 1 tachometer 0 -...

  • Page 166

    P944 8/13 key part number qty description serial number •• 22-92110 1 s-1 start/stop control panel, 12 volt (includes all keys) - •• 22-92115 1 s-1 start/stop control panel, 24 volt (includes all keys) - 1 00-40013 1 plate, s-1 control panel - 2 22-90167 1 rocker switch - 3 22-90168 1 rocker switch ...

  • Page 167

    P944 8/13 5 - 63 group 5 – electrical system a-8553/ b-5971 series 1-b start-stop control panel key part number qty description serial number •• 22-92120 1 s 1-b start/stop control panel - 12 volt (includes all keys) - •• 22-92125 1 s 1-b start/stop control panel - 24 volt (includes all keys) - 1 28...

  • Page 168

    P944 8/13 key part number qty description serial number •• 22-91211 1 s-3c control panel, 12 volt (includes all keys) - •• 22-91212 1 s-3c control panel, 24 volt (includes all keys) - 1 28-90010 1 panel plate - 2 37-90081-1 1 oil pressure gauge, 0-80 psi 12 volt - 37-90082-1 1 oil pressure gauge, 0-...

  • Page 169

    P944 8/13 5 - 65 group 5 – electrical system key part number qty description serial number •• 22-91201 1 s-3c control panel, 12 volt (includes all keys) - •• 22-91202 1 s-3c control panel, 24 volt (includes all keys) - 1 39-40008 1 enclosure - 2 37-90081-1 1 oil pressure gauge, 0-80 psi 12 volt - 37...

  • Page 170

    P944 8/13 key part number qty description serial number 1 22-40438 1 speed switch, 2 pt. Electric ss40 - 22-40274 1 speed switch, 1 pt. Electric ss18 - 2 22-40440 ** magnetic pick-up - 3 23-41203 1 bracket, magnetic pick-up mtg. - 4 19m7788 2 capscrew, hex head flanged m12 x 1.75 x 25 mm - 5 19m7784...

  • Page 171

    P944 8/13 5 - 67 group 5 – electrical system notes.

  • Page 172

    P944 8/13 6 - 0 group 6 – gasket sets gaskets l-m944 & m30cw key part number qty description serial number •• 29-01200 1 gasket set, engine overhaul (includes all keys) - 1 f315002000 3 o-ring - 2 3066151300 1 gasket - 3 f315602500 2 o-ring - 32b9421modifi ed updated 6-7-10

  • Page 173

    P944 8/13 6 - 1 gaskets l-m944 & m30cw group 6 – gasket sets key part number qty description serial number 4 f420208000 4 gasket - 5 f420210000 2 gasket - 6 f420214000 1 gasket - 7 f420218000 2 gasket - 8 3434000700 1 gasket - 9 mm432045 4 gasket, nozzle holder - 10 md068355 4 gasket, fuel return - ...

  • Page 174

    P944 8/13 6 - 2 group 6 – gasket sets gaskets m944t & m38cr2 key part number qty description serial number •• 29-01201 1 gasket set, engine overhaul (includes all keys) - 1 f315002000 3 o-ring - 2 3066151300 1 gasket - 3 f315602500 2 o-ring - 4 f420208000 4 gasket - 5 f420210000 2 gasket - 6 f420214...

  • Page 175

    P944 8/13 6 - 3 gaskets m944t & m38cr2 group 6 – gasket sets key part number qty description serial number 12 0594600801 1 sealing washer - 13 0594601401 10 sealing washer - 14 32a3500600 1 o-ring - 15 0601613075 1 o-ring - 16 0601613140 2 o-ring - 17 3063625901 2 gasket - 18 32a0112300 1 gasket, cy...

  • Page 176

    P944 8/13 6 - 4 group 6 – gasket sets gaskets nl944d2 32b9421modifi ed key part number qty description serial number •• 29-01202 1 gasket set, engine overhaul (includes all keys) - 1 f315002000 3 o-ring - 2 3066151300 1 gasket - 3 f315602500 2 o-ring - 4 f420208000 4 gasket - 5 f420210000 2 gasket -...

  • Page 177

    P944 8/13 6 - 5 gaskets nl944d2 group 6 – gasket sets key part number qty description serial number 5 f420210000 2 gasket - 6 f420214000 1 gasket - 7 f420218000 2 gasket - 8 3434000700 1 gasket - 9 mm432045 4 gasket, nozzle holder - 10 md068355 4 gasket, fuel return - 11 md070717 4 gasket - 12 05946...

  • Page 178

    P944 8/13 6 - 6 group 6 – gasket sets gaskets nl944t2 32b9421modifi ed key part number qty description serial number •• 29-01203 1 gasket set, engine overhaul (includes all keys) - 1 f315002000 3 o-ring - 2 3066151300 1 gasket - 3 f315602500 2 o-ring - 4 f420208000 4 gasket - 5 f420210000 2 gasket -...

  • Page 179

    P944 8/13 6 - 7 gaskets nl944t2 group 6 – gasket sets key part number qty description serial number 5 f420210000 2 gasket - 6 f420214000 1 gasket - 7 f420218000 2 gasket - 8 3434000700 1 gasket - 9 mm432045 4 gasket, nozzle holder - 10 md068355 4 gasket, fuel return - 11 md070717 4 gasket - 12 05946...

  • Page 180

    P944 8/13 7 - 0 group 7 - gear and adapter parts a-11937/ b-9345 zf63iv gear attaching parts l944d.

  • Page 181

    P944 8/13 7 - 1 group 7 - gear and adapter parts key part number qty description serial number 1 3312116002 1 adapter assembly sae #4 - 2 34-60068 1 drive dampertype “r” sae #10 - 3 12-00832 12 capscrew, hex head m10 x 1.5 x 30 mm - 4 15-00802 12 lock washer, helical m10 - 5 12-00831 8 capscrew, hex...

  • Page 182

    P944 8/13 8 - 0 group 8 - base frames 32b0107 key part number qty description serial number 1 00-71201 1 front lifting eye (m944 - m30cw - m944t - m38cr2) - 32a0102700 1 front lifting eye (nl944d2 - nl944t) - 2 12-89751 2 capscrew, hex head flanged m8 x 1.25 x 16 mm - 3 32a0102800 1 rear lifting eye...

  • Page 183

    P944 8/13 8 - 1 group 8 - base frames a-11650/ b-9291 key part number qty description serial number 1 23-81206 2 engine mounting bracket - 2 19m7789 8 capscrew, hex head flanged m12 x 1.75 x 30 mm - front engine mounting l944.

  • Page 184

    P944 8/13 8 - 2 group 8 - base frames key part number qty description serial number 1 23-81201 1 engine mounting bracket, rear right hand - 2 23-81204 1 engine mounting bracket, rear left hand - 3 19m7789 4 capscrew, hex head flanged m12 x 1.75 x 30 mm - rear engine mounting l944.

  • Page 185

    P944 8/13 8 - 3 group 8 - base frames a-11228, a-11437/ b-9075 key part number qty description serial number 1 39-81201 1 base frame, steel, plateform mounts - 39-81202 1 base frame, aluminum, plateform mounts - 2 23-81202 1 mounting bracket - 3 12-09912 8 capscrew, hex head m12 x 1.75 x 25 mm - 4 1...

  • Page 186

    P944 8/13 a-11208/ b-9078 key part number qty description serial number 1 39-81203 1 base frame, steel, centerbonded mounts - 2 23-81202 2 front engine mounting bracket - 3 12-09912 8 capscrew, hex head m12 x 1.75 x 25 mm - 4 15-09012 8 lock washer, helical m12 s/s - 5 14-95501 2 capscrew, hex head ...

  • Page 187

    P944 8/13 8 - 5 group 8 - base frames a-11475/ b-9076 key part number qty description serial number 1 39-81206 1 aluminum base frame, centerbonded mounts - 39-81204 1 steel base frame, centerbonded mounts - 2 23-81202 2 front engine mounting bracket - 3 12-09912 8 capscrew, hex head m12 x 1.75 x 25 ...

  • Page 188

    P944 8/13 8 - 6 group 8 - base frames a-11475/ b-9782 base frame m38cr2 uci224e 16 generator updated 6/7/10 key part number qty description serial number 1 39-81206 1 aluminum base frame, centerbonded mounts - 39-81204 1 steel base frame, centerbonded mounts - 2 23-81202 2 front engine mounting brac...

  • Page 189

    P944 8/13 a-11949/ b-9488 key part number qty description serial number 1 39-81208 1 steel base pan, plateform mounts - 2 23-81208 1 mounting bracket - 3 12-09912 8 capscrew, hex head m12 x 1.75 x 25 mm - 4 15-09012 8 lock washer, helical m12 - 5 14-09830 4 hex nut, nylock m12 x 1.75 s/s - 6 15-0900...

  • Page 190

    P944 8/13 a-12086, a-12312/ b-9078fornl944d-t key part number qty description serial number 1 39-81207 1 base frame, steel, centerbonded mounts - 2 23-81202 2 front engine mounting bracket - 3 12-00912 8 capscrew, hex head m12 x 1.75 x 25 mm - 4 15-00912 8 lock washer, helical m12 - 5 12-00964 2 cap...

  • Page 191

    P944 8/13 8 - 9 group 8 - base frames notes.

  • Page 192

    P944 8/13 9 - 0 group 9 - accessories & optional equipment a-11327/ b-8938 key part number qty description serial number 1 10-65401 1 housing, pto clutch h-28 b-pad - 2 23-61202 1 bracket, engine/pto support, right hand - 3 12-00037 3 capscrew, hex head m12 x 1.75 x 45 mm - 4 12-00955 1 capscrew, he...

  • Page 193

    P944 8/13 9 - 1 group 9 - accessories & optional equipment a-11327/ b-8938 key part number qty description serial number 1 10-65401 1 housing, pto clutch h-28 b-pad - 2 23-61209 1 bracket, engine/pto support, right hand - 3 12-00037 3 capscrew, hex head m12 x 1.75 x 45 mm - 4 12-00955 1 capscrew, he...

  • Page 194

    P944 8/13 9 - 2 group 9 - accessories & optional equipment a-11931/ b-9337 key part number qty description serial number 1 10-65401 1 housing, pto clutch h-28 b-pad - 2 23-61204 1 bracket, engine/pto support, right hand - 3 12-00037 3 capscrew, hex head m12 x 1.75 x 45 mm - 4 12-00955 1 capscrew, he...

  • Page 195

    P944 8/13 key part number qty description serial number key part number qty description serial number 1 34-60031 1 electric clutch assembly (12 volt) - 34-60032 1 electric clutch assembly (24 volt) - 2 12-00513 4 capscrew, hex head 1/2-13 x 1-1/4 - 3 15-00007 4 flat washer m12 - 4 00-61003 1 grommet...

  • Page 196

    P944 8/13 9 - 4 group 9 - accessories & optional equipment a-11391/ b-9098 key part number qty description serial number 1 22-10003 1 coolant level switch/ gauge, isolated ground - 2 21-71044 1 male elbow 90 0 brass 1/4 npt x 1/4- 45t - 3 21-71045 2 female swivel brass 1/4 hb x 1/4- 45t - 4 18-51007...

  • Page 197

    P944 8/13 a-11491/ b-9099 key part number qty description serial number 1 37-15401 1 flow switch, bronze 8 gpm - 2 23-11202 1 bracket - 3 23-18703 1 clamp - 4 12-00712 4 capscrew, hex head m8 x 1.25 x 25 mm - 5 15-00701 4 flat washer m8 - 6 14-04802 4 hex nut, nylock m8 x 1.25 - 7 12-00953 4 capscre...

  • Page 198

    P944 8/13 9 - 6 group 9 - accessories & optional equipment a-11392/ b-9160 key part number qty description serial number 1 22-10004 1 oil level switch/ gauge - 2 23-71202 1 bracket - 3 12-00111 4 capscrew, hex head 1/2- 20 x 3/4” - 4 15-00102 4 lock washer helical 1/4” - 5 15-00111 4 flat washer 1/4...

  • Page 199

    P944 8/13 9 - 7 group 9 - accessories & optional equipment a-11392/ b-9160turbo key part number qty description serial number 1 22-10004 1 oil level switch/ gauge - 2 23-71203 1 bracket - 3 12-00111 4 capscrew, hex head 1/2- 20 x 3/4” - 4 15-00102 4 lock washer helical 1/4” - 5 15-00111 4 flat washe...

  • Page 200

    P944 8/13 9 - 8 group 9 - accessories & optional equipment a-12427/ b-9604 key part number qty description serial number 1 22-10004 1 oil level switch/ gauge - 2 23-71204 1 bracket - 3 12-00111 4 capscrew, hex head 1/2- 20 x 3/4” - 4 15-00102 4 lock washer helical 1/4” - 5 15-00111 4 flat washer 1/4...

  • Page 201

    Www.Northern-lights.Com 4420 14th ave. Nw., seattle wa 98107 tel: (206) 789-3880 • 1-800-762-0165 • fax: (206) 782-5455 northern lights and lugger are registered trademarks of northern lights, inc. © 2013 all rights reserved. Litho usa..