Northline Express BK100E Owner's Manual

Manual is about: STANDARD BARREL stove KIT

Page of 14

Download

Print this page

Bookmark us

VGZ-023 / 041409

BK100E /

Page 1

READ ALL INSTRUCTIONS CARE-

FULLY BEFORE STARTING THE

INSTALLATION OR OPERATING

THE STOVE. FAILURE TO FOLLOw

INSTRUCTIONS mAY RESULT IN

P R O P E R T Y DA m AG E , B O D I LY

INjURY, OR EVEN DEATH.

SAFETY INSTRUCTIONS

SAFETY NOTICE: IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE/BUILDING FIRE mAY

RESULT. FOR YOUR SAFETY, CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT PERmITS,

RESTRICTIONS, AND INSTALLATION REqUIREmENTS FOR YOUR AREA.

READ ALL INSTRUCTIONS CAREFULLY.

1. The installation of this barrel stove must

comply with your local building code

rulings. Please observe the clearances to com-

bustibles (see reference figures 3–5).

Do not install this barrel stove

in a mobile home, manufactureD

home, tent or trailer -no eXcePtions!

(huD federal standard: 24 cfr ch.XX)

3. Always connect this barrel stove to a chimney

and vent to the outside. Never vent to another

room or inside a building.

4. Do NoT coNNecT a wood burning stove to

an aluminum Type B gas vent. This is not safe.

Use approved masonry or a UL 103 HT Listed

Residential Type and Building Heating Appli-

ance Chimney. Use a 6” diameter chimney or

larger, that is high enough to give a good draft

(see specifics in installation instructions.).

5. B e s u r e t h a t y o u r c h i m n ey i s s a f e l y

constructed and in good repair. Have the

chimney inspected by the fire department

or a qualified inspector. Your insurance

company may be able to recommend a

qualified inspector.

6. Creosote or soot may build up in the chimney

connector and chimney and cause a house/

building fire. Inspect the chimney connec-

tor and chimney twice monthly during the

heating season and clean if necessary (see Main-

tenance & Service Hints, page 11.)

7. To prevent injury, do not allow anyone to use this

stove who is unfamiliar with the correct operation

of the stove.

8. D o n o t o p e r a t e s t ove w h i l e u n d e r t h e

influence of drugs or alcohol.

9. Ashes should not be allowed to accumulate higher

than the spin damper. Dispose of ashes in a metal

container with a tight fitting lid. Keep the closed

container on a non-combustible floor or on the

ground, well away from all combustible materials.

Keep the ashes in the closed container until all

cinders have thoroughly cooled. The ashes may

be buried in the ground or picked up by a refuse

collector.

10. While constructing and assembling this barrel

stove, always wear ANSI approved safety goggles

and gloves.

Vogelzang International Corporation

400 West 17th Street

Holland, Michigan 49423

www.vogelzang.com

Phone: 1-616-396-1911

Fax: 1-616-396-1971

continued on next page

STANDARD BARREL STovE KIT

model BK100E

Owners manual

(save this manual for future reference)

NoT

USE THIS STOVE IN A

mOBILE HOmE, mANUFACTURED HOmE,

TENT, OR TRAILER – NO EXCEPTIONS!

NOTE: THIS STOVE IS

NoT

A UL LISTED STOVE.

NorthlineExpress.com

http://www.northlineexpress.com

Toll-Free 1-866-667-8454

1 2 3 4 5 6 7 Next › »

Summary of BK100E

Page 1
Vgz-023 / 041409 bk100e / page 1 read all instructions care- fully before starting the installation or operating the stove. Failure to follow instructions may result in p r o p e r t y da m ag e , b o d i ly injury, or even death. Safety instructions safety notice: if this stove is not properly inst...
Page 2
Page 2 / bk100e vgz-023 / 041409 20. Caution: hot surfaces. Keep children away. While stove is in operation, all persons, especially young children should be alerted to the hazards of high surface temperatures. Keep away from a hot stove to avoid burns or clothing ignition. 21. If small children wil...
Page 3: Assembly Instructions
Vgz-023 / 041409 bk100e / page 3 assembly instructions tools required caution: stove is heavy. Make sure you have adequate help and use proper lifting techniques when assembling kit and whenever moving stove. Refer to diagram and parts lists at back of this manual. 1. Remove parts from inside of car...
Page 4: Locating Stove
Page 4 / bk100e vgz-023 / 041409 caution: keep furnishings and other combustible materials away from the stove. Minimum clearances to combustible surfaces unit to sidewall ........................ 36 inches unit to back wall ....................... 36 inches unit corner to wall .................... ...
Page 5
Vgz-023 / 041409 bk100e / page 5 connector pipe installation fig. 6 – stovepipe/flue connections correct wrong wrong 1. The smooth end of the connector pipe fits over the cast iron damper collar. 2. Horizontal pipe runs must slope upwards towards the chimney at least 1/4” per foot of horizontal run....
Page 6: Chimney Connections
Page 6 / bk100e vgz-023 / 041409 chimney connections draft chimneys perform two functions. 1). As a means of exhausting smoke and flue gases which are the result of fuel combustion. 2). The chimney provides “draft” which allows oxygen to be continuously introduced into the appliance, so proper combu...
Page 7
Vgz-023 / 041409 bk100e / page 7 fig. 9 - chimney construction through roof fig. 10 - chimney connection to firebox through noncombustible (masonry) wall chimney connections continued … venting to existing fireplace in some instances, people desire to convert an existing fireplace for stove use. Usu...
Page 8
Page 8 / bk100e vgz-023 / 041409 chimney connections continued … many look identical to masonry fireplaces and should be checked carefully before connecting a stove to them. Venting a stove directly into a fireplace does not meet code and should not be attempted. (this constitutes connection to anot...
Page 9: Operating Instructions
Vgz-023 / 041409 bk100e / page 9 operating instructions warning: explosion hazard n e v e r u s e c h e m i c a l s , g a s o l i n e , g a s o l i n e - t y p e l a n t e r n f u e l , kerosene, charcoal lighter fluid, or similar flammable liquids to start or “freshen-up” a fire in the stove. Keep ...
Page 10
Page 10 / bk100e vgz-023 / 041409 operating instructions continued … 10. Never over fire this barrel stove by building excessively hot fires as a house/build- ing fire may result. 11. Inspect stove pipe and barrel every 60 days. Replace immediately if there is rusting or smoke leaking into the room....
Page 11
Vgz-023 / 041409 bk100e / page 11 maintenance & service hints ash disposal – do not allow ashes to accumulate higher than the grate. Dispose of properly. (see safety instructions #10, page 2.) chimney draft – draft is a function of the chimney, not the stove — do not expect the stove to draw. Smoke ...
Page 12
Page 12 / bk100e vgz-023 / 041409 ordering parts - bk100e barrel stove kit when ordering missing or replacement parts, always give the model number of the stove, part number, and part description. Use the illustration and parts list provided to identify parts. Ref. Part no. No. Description qty. 1 dc...
Page 13
Vgz-023 / 041409 bk100e / page 13 northlineexpress.Com http://www.Northlineexpress.Com toll-free 1-866-667-8454.
Page 14: Made In China
Page 14 / bk100e vgz-023 / 041409 this vogelzang heating appliance is safe when installed properly and will provide you with years of service. However, always exercise good judgement when you are using this stove. You are dealing with fire! Fire is inherently dangerous and must be treated with respe...