1. DL manuals
  2. Oasis
  3. Heat Pump
  4. C13b
  5. Installation Instructions Manual

Oasis C13b Installation Instructions Manual

Manual is about: SWIMMING POOL HEAT PUMP UNIT

Summary of C13b

  • Page 1

    Swimming pool heat pump unit installation & instruction manual.

  • Page 3

    Contents 1. Preface 2. Specifications 2.1 performance data of swimming pool heat pump unit 2.2 dimensions for swimming pool heat pump unit 3. Installation and connection 3.1 installation of system 3.2 3.3 how close to your pool? 3.4 3.5 3.6 initial start-up of the unit 4. Usage and operation 4.1 4.2...

  • Page 4

    1. Preface the unit can only be repaired by qualified installer center personnel or an authorised dealer. Maintenance and operation must be carried out according to the recommended time and frequency, as stated in this manual. Use genuine standard spare parts only. Failure to comply with these recom...

  • Page 5

    2 2.Specification 2.1 performance data of swimming pool heat pump unit refrigerant :r407c unit heating capacity heating power input running current power supply compressor quantity compressor fan quantity fan power input fan rotate speed fan direction noise water connection water flow volume water p...

  • Page 6

    3 2.Specification 2.1 performance data of swimming pool heat pump unit refrigerant :r407c unit heating capacity heating power input running current power supply compressor quantity compressor fan quantity fan power input fan rotate speed fan direction noise water connection water flow volume water p...

  • Page 7

    4 2.2 the dimensions for swimming pool heat pump unit 2.Specification models: oasis c8b/oasis c13b/oasis h13b/oasis c17b/oasis h17b models: oasis c21b/oasis c25b/oasis c25tb water inlet water outlet a e d c b type b a c d size e unit mm oasis c8b/c13b/h13b 650 1000 700 420 400 255 101 horizontal vis...

  • Page 8

    5 2.Specification models: oasis c35t-vb/oasis c50t-vb models: eh9b 1002 658 430 455 630 water inlet water outlet horizontal vision vertical vision 11 3 0 1490 1464 480 735 water inlet water outlet drainage horizontal vision vertical vision 255 102.5 88 120

  • Page 9

    6 installation items: the factory only provides the heat pump unit; the other items in the illustration are necessary spare parts for the water system ,provided by users or the installer. 3.1 installation illustration 3.Installation and connection chlorinator cell water outlet pool valve water suppl...

  • Page 10

    7 the unit will perform well in any outdoor location provided that the following three factors are present . 1. Fresh air - 2. Electricity - 3. Filter piping do not place the unit in an enclosed area with a limited air volume, where the units discharge air will be re-circulated. Do not place the uni...

  • Page 11

    3.4 spa heat pumps plumbing location: connect the unit in the pool pump discharge (return) line downstream of all filter and pool pumps, and upstream of any chlorinators, ozonators or chemical pumps. Standard model have slip glue fittings which accept 40mm nb pvc pipe for connection to the pool or s...

  • Page 12

    9 3.5 spa heat pumps electrical wiring note: although the unit heat exchanger is electrically isolated from the rest of the unit, it simply prevents the flow of electricity to or from the pool water. Grounding the unit is still required to protect you against short circuits inside the unit. Bonding ...

  • Page 13

    Disconnect 10 4. Usage and operation 4.1function of wire controller main display area aux. Display area 1 2 3 4 1 4 5 3 temp in set c f a min on off temp out vol mode set 2 mode set clock 1 button function no symbol name function on/off mode up press this button can start up or shut down the unit, c...

  • Page 14

    11 4. Usage and operation 2 display function a electric- heating on off timer on timer off it is showed when the unit sets the timer on it is showed when the unit sets the timer off in out temp temperature vol f min fahrenheit c set symbol meaning function cooling heating automatic it is showed when...

  • Page 15

    12 4. Usage and operation 4.2 the controller usage 1 starting up and shutting down press for 0.5 second can switch between unit on and unit off water outlet temperature actual mode display off unit 2 modes switching if it is cold/ heat unit, in the main interface, you can switch different modes of c...

  • Page 16

    13 4. Usage and operation 3 t emperature setting press or press or to change the value press to save value setting cooling target temperature mode set temp in c temp out mode set set temp c temp out mode set set temp c temp out mode set temp in c temp out mode set mode set 4 clock setting in the mai...

  • Page 17

    14 4. Usage and operation temp in c temp out mode set temp in c temp out mode set press hour minute flashing temp in c temp out mode set flashing press temp in c temp out mode set press or temp in c temp out mode set press to save hour value setting temp in c temp out mode set press or temp in c tem...

  • Page 18

    15 5 timer setting in the main interface press hold on 2 seconds and "on" is flashing, at this time, you can set the timer on means the unit timer is on then press again and hold on 2 seconds and "off" is flashes you can set the timer off means the unit timer is off . If you want cancel the timer of...

  • Page 19

    16 temp in c temp out mode set on flashing off temp in c temp out mode set press on press or off temp in c temp out mode set on off temp in c temp out mode set on off press press or temp in c temp out mode set on off temp in c temp out mode set press on off the timer on and off has been set flashing...

  • Page 20

    17 6 cancel the timer setting press for 2s and "on" is flashing at this time, press to cancel the setting of timer on; it is the same way to cancel the setting of timer off . For example temp in c temp out mode set on off the timer on/off has been set press for 2s temp in c temp out mode set on off ...

  • Page 21

    18 7 keyboard lock to avoid mis-operation, please lock the controller after parameter setting. At the main interface, press for 5 seconds, the keyboard will be locked. When the keyboard is locked, press for 5 seconds, the keyboard will be unlocked. Notes: when the unit is in alarming state, the key ...

  • Page 22

    19 28 28 27 meaning heating inlet target temp. Adjustable adjustable adjustable 4.3. Parameter table cooling inlet target temp. Auto inlet target temp. Remark default 4. Usage and operation.

  • Page 23

    Check the water supply device and the release often. You should avoid the condition of no water or air entering into system, as this will influence unit's performance and reliability. You should clear the pool/spa filter regularly to avoid damage to the unit as a result of the dirty of clogged filte...

  • Page 24

    21 5.2 malfunction table power on recovery temp. Sensor failure coil 1 temp. Sensor failure 2 on 1 off 8 on 1 off flashing off p01 p02 p033 p15 p25 p04 suction 1 temp. Sensor failure p17 p27 p181 p182 p19 p29 e11 e21 e12 e22 e031 e032 e035 e04 e101 e201 e06 e171 e172 e271 e272 e19 e29 p182 p282 e05 ...

  • Page 25

    22 6. Appendix 6.1 connection of pcb illustration 6.2 connections explanation pc4001 12v gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd gnd net di 01 5v ai 01 ai 02 ai 03 ai 04 ai 05 ai 06 ai 07 a i 0 8 ai 09 ai 1 1(50k) ai 12(50k) di ...

  • Page 26

    23 6. Appendix 1. The unit can only be repaired by qualified installer centre personnel or an authorised dealer. For europe market 2. This appliance is not intended for use by persons (including children) with reduced physical sensory or mental capabilities, or lack of experience and knowledge, unle...

  • Page 27

    24 6. Appendix 6.4 cable specification 13~25a 25~30a 30~40a 40~55a 55~70a phase line 2 2 1.5mm 2 2 4mm 2 2 6mm 2 2 10mm 2 2 16mm 2 2 25mm 2 1.5mm 2 1.5mm 2 4mm 2 6mm 2 10mm 2 16mm mcb 20a 40a 40a 63a 80a 100a creepage protector 30ma less than 0.1 sec signal line 2 n 0.5mm nameplate maximum current e...

  • Page 28

    25 6. Appendix 6.5 explosive view of the unit 1) model oasis c8b no. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 number 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 note code 2001-2225 3406-1204 20000-360005 3508-1218 32012-210143 2003-1379 2001-1359 2000-2249 2002-1444 2000-2250 20000-...

  • Page 29

    26 6. Appendix 2 model eh9b no. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 number 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 note code 3406-1204 2000-3619 32008-120007 32012-210078 32008-210109 2000-3909 2000-3501 2000-3115 3404-2126 2001-3605 2001-1418 20000-140150 2000-3603 32008-210103 95005-...

  • Page 30

    27 6. Appendix 3) model oasis c13b no. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 number 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 note code 2001-2225 3407-1202 20000-360005 3512-1218 32012-210143 2003-1379 2001-1359 2000-2249 2002-1444 2000-2250 20000-220068 95005-310156 2000-28...

  • Page 31

    28 6. Appendix 4 model oasis h13b no. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 number 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 note code 20000-140003 2001-2225 3407-1202 20000-360005 3512-1218 32012-210191 2003-1379 2001-1359 2000-2249 2000-2250 20000-220068 95005-310156 32008-210032 2...

  • Page 32

    29 6. Appendix 5) model oasis c17b no. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 number 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 note code 3509-2158 35012-120001 20000-360005 3509-1210 2000-3933 2000-1440 20001-220001 32009-210133 32009-210033 2000-2249 2000-1196 2000-225...

  • Page 33

    30 6. Appendix 6 model oasis h17b no. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 number 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 note code 95005-310114 3509-2158 35012-120001 20000-360005 3509-1210 2000-3933 2000-1440 20001-220001 32009-210158 32009-210033 2000-2249 2000-1196 2000-...

  • Page 34

    31 6. Appendix 7) model oasis c21b no. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 no. 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 code 35018-120003 2001-1359 3518-2107 3518-1202 2000-3920 2000-2802 20000-360005 2001-2225 32018-210058 2003-1379 2000-2249 2000-22...

  • Page 35

    32 6. Appendix 8 model oasis c25b no. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 no. 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 code 20000-360007 35018-120003 3518-2107 2001-1359 3400-2203 3518-1202 20000-360005 2000-2802 2001-2225 32019-210003 2000-2249 2000-2250 2000-14...

  • Page 36

    33 6. Appendix 5) model oasis c25tb no. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 no. 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 code 3518-2107 2001-1359 3400-2203 3518-1202 20000-360005 2000-2802 2001-2225 32019-210003 2000-2249 2000-2250 2000-1406 2001-1491 2000-3603 2000-1404 200...

  • Page 37

    34 6. Appendix 6 model oasis c35t-vb part note 2001-1355 2002-1342 2002-1348 2002-1383 2004-1303 2002-1337 2002-1339 32006-210044 32006-210010 35005-210003 32006-210012 32006-120006 32006-210009 32006-210014 35006-210026 35005-210013 2000-2802 35005-210016 20000-330005 32004-120001 35005-210009 3505...

  • Page 38

    35 6. Appendix 5) model oasis c50t-vb note 2001-1355 2002-1342 2002-1348 2002-1383 2004-1303 2002-1337 2002-1339 32006-210044 32006-210010 35005-210003 32006-210012 32006-120006 32006-210009 32006-210014 35006-210026 35005-210013 2000-2802 35005-210016 20000-330005 35006-120009 35005-210009 3505-140...

  • Page 40

    Code 20120807-0001 code 20120807-0001.