OfiTE 120-60 Instruction Manual - Operation
OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com
8
Operation
The blending assembly has two speeds, “HI” and “LO”. The Constant Speed
Blender will not operate unless the blending assembly is set to “HI”. Before
operation, press the “HI” button on the blending assembly.
The unit has three operating modes: Manual, Variable, and Auto. The
MAN/
AUTO - Variable switch (13) and the MAN/AUTO switch (15) set the mode.
1. To set the unit to Manual Mode, set the
MAN/AUTO - Variable switch (13)
to
MAN/AUTO and the MAN - AUTO switch (15) to MAN.
2. To set the unit to Auto Mode, set the
MAN/AUTO - Variable switch (13) to
MAN/AUTO and the MAN - AUTO switch (15) to AUTO.
3. To set the unit to Variable Mode, set the
MAN/AUTO - Variable switch
(13) to
Variable.
Before turning the unit on, be sure to set the MAN/AUTO switch (15)
and the ST PT 1 / ST PT 2 switch (14) to the center position and turn
the Potentiometer (16) fully counter-clockwise.
1. Place the mix water into the mixing cup and place the lid on top of the
container.
2. The
MAN/AUTO - Variable switch (13) should be in the MAN/AUTO
position. The
MAN/AUTO switch (15) should be in the MAN position.
3. Place the
ST PT 1 / ST PT 2 switch (14) to the ST PT 1 position to start
the unit.
When you initially start the unit, the rotational speed may exceed the
setpoint, but will stabilize within a few seconds.
4. After stabilization, you have 15 seconds to add the cement to the mix
water and cover the container with the lid. Reset the timer to zero by
pressing the Reset Button (8).
5. After 15 seconds, increase the rotational speed by setting the
ST PT 1 /
ST PT 2 switch (14) to ST PT 2.
6. After mixing the cement an additional 35 seconds, stop the blender by
setting the
ST PT 1 / ST PT 2 switch (14) to the center position.
7. Return the
MAN/AUTO switch (15) to the center position.
8. After mixing is complete, clean the blending cup and lid as soon as
possible to prevent any cement from building up on the container.
Operation
Manual Mode