- DL manuals
- Ohio Medical
- Medical Equipment
- Moblvac III-cs
- Operator Maintenance
Ohio Medical Moblvac III-cs Operator Maintenance
Summary of Moblvac III-cs
Page 1
Constant suction unit operator/maintenance m a n u a l ohio medical corporation 1111 lakeside drive gurnee, illinois 60031-4099 1-800-662-5822/847-855-0800 fax: 847/855-6218 www.Ohiomedical.Com.
Page 2
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 2 the purpose of the moblvac ® iii-cs is to perform all routine constant suctioning procedures. These may include tracheal and oral aspiration, wound a...
Page 3
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 3 1. Instructions for use prior to initial use upon receiving your new moblvac ® iii-cs, perform the following initial tests to ensure that your unit i...
Page 4
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 4 the moblvac ® iii-cs will use any collection device. However, if you are not using an ohio medical 1200cc disposable collection canister, make sure t...
Page 5
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 5 or chest drainage units with built in flow adjustment valves. Place the chest drainage unit in the “optional” ohio medical chest drainage unit bracke...
Page 6
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 6 overflow - aspirant has contaminated the overflow trap assembly. Replace and/or clean parts according to procedures described in overflow cleaning pr...
Page 7
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 7 to access the internal components of the moblvac ® iii-cs, remove the two (2) phillips head screws lo- cated in the rear of the unit near the back as...
Page 8
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 8 2. Discard all tubing 3. Open the regulator by removing the two screws on the cap, using a phillips screwdriver. 4. Disassemble black cartridge from ...
Page 9
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 9 procedure should be performed. 1. Remove the pump assembly from the moblvac iii-cs as described above in the pump replacement section. 2. .Remove the...
Page 10
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 10 iv. Troubleshooting problem cause correction low or no vacuum on running unit. 1. Regulator is turned all the way off. 1. Turn regulator knob clockw...
Page 11
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 11 5. Device specifications pump rotary carbon vane type. Performance vacuum range: up to 580mm hg free air flow: 38 lpm minimum controls vacuum regula...
Page 12
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 12 figure 1.
Page 13
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 13 figure 2.
Page 14
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 14 figure 3.
Page 15
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 15.
Page 16
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 16 figure 4.
Page 17
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 17 fiogure 5.
Page 18
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 18 figure 6.
Page 19
Ohio medical corporation, 1111 lakeside drive, gurnee, il 60031-4099 (800)662-5822—fax: (847) 855-6218 www.Ohiomedical.Com —– 550107 (rev.5) 08/2005 19.
Page 20
Ohio medical corporation (800)662-5822—fax: (847) 855-6218 www.Aerosinstruments.Com —– 550107 (rev.5) 08/2005 1111 lakeside drive gurnee, il 60031-4099 phone: 800-662-5822/(847-855-0800) fax: 847-855-6218 email: info@ohiomedical.Com http://www.Ohiomedical.Com.