1. DL manuals
  2. Ohlins
  3. Motorcycle Accessories
  4. FGK 202
  5. Mounting Instructions

Ohlins FGK 202 Mounting Instructions - Safety Precautions

Summary of FGK 202

  • Page 1

    Front fork kit for yamaha r6 fgk 202 mounting instructions part no. Pcs. Front fork kit fgk202 1 sticker set Öhlins 1 owners manual 07284-01 1 warning! This kit should only be installed by an authorized Öhlins dealer. The installation procedure requires certain tools. Before installing this product,...

  • Page 2: Safety Precautions

    Safety precautions © Öhlins racing ab. All rights reserved. Any reprinting or unauthorized use without the written permission of Öhlins racing ab is prohibited. Printed in sweden. Safety symbols in this manual, mounting instructions and other technical documents, important information concerning saf...

  • Page 3

    Install Öhlins front fork kit 6 tube. Torque 10 nm. 3.15 set the spring preload, rebound and compression adjusters according to adjustments and set-up data in this manual. 3.16 install the front fork legs into the triple clamps at the position recommended in set-up data (fork leg position). Tighteni...

  • Page 4

    3 - install Öhlins front fork kit 5 position and be careful not to damage it. 3.7 open the compression and the rebound adjuster fully. Install the top cap directly to the shaft extension (no spring or preload tube). Pull up the outer tube and tighten it to the top cap. Handtighten only. 3.8 pump out...

  • Page 5

    1 - remove original front fork 2 warning! It is advisable to have an Öhlins dealer install the front fork. When installing, consult your vehicle service manual. 1.1 put the motorcycle on a workstand so that the front wheel barely touches the ground. Warning! Make sure the vehicle is securely support...

  • Page 6

    3 2 - disassemble original front fork 2.1 loosen the top cap from the outer tube. 2.2 pull down the outer tube. 2.3 remove the top cap by loosening it from the shaft. Use appropriate tool according to your vehicle service manual. 2.4 remove the spring and surrounding parts from the fork leg, drain t...

  • Page 7

    4 3 - install Öhlins front fork kit caution! Work with only one fork leg at a time. Do not mix the parts. Caution! The front fork kit is divided into one compression cartridge and one rebound cartridge. Important: • install the cartridge marked “reb” (rebound) in the right side fork leg. • install t...

  • Page 8: Www.Ohlins.Com

    Öhlins racing ab box 722 s-194 27 upplands väsby, sweden phone +46 8 590 025 00 fax +46 8 590 025 80 © Öhlins racing ab. All rights reserved. Any reprinting or unauthorized use without the written permission of Öhlins racing ab is prohibited. Www.Ohlins.Com Öhlins products are subject to continuous ...