- DL manuals
- Oki
- Fax Machine
- OF5300
- Service Manual
Oki OF5300 Service Manual
Service Manual for OF5300/5600
Chapter 0 Introduction
Front Cover
OKIFAX 5050 / 5300 / 5600
FACSIMILE PRODUCTS
Adobe Acrobat printable reference copy
of the OKIDATA Service Training Manual.
05/07/98
Note: This Adobe Acrobat version of the Okidata Service Training Manual was built with
the pictures rendered at 300 dpi, which is ideal for printing, but does not display well
on most displays.
OKIDATA has taken care to insure that the information is complete, accurate and up-to-date. However, OKIDATA assumes no
responsibility for errors or omissions which may occur. All the information provided is subject to change from time to time at the
sole discretion of OKIDATA.
Summary of OF5300
Page 1
Service manual for of5300/5600 chapter 0 introduction front cover okifax 5050 / 5300 / 5600 facsimile products adobe acrobat printable reference copy of the okidata service training manual. 05/07/98 note: this adobe acrobat version of the okidata service training manual was built with the pictures r...
Page 2
Table of contents page service manual for of5300/5600 0 about this manual read me first 1 copyright 2 okifax 5050 service authorization 3 okifax 5050 addendum to okifax 5300/5600 service manual 4 1 general information 1.1 general performance 6 1.2 general user's function 7 1.3 general maintenance fu...
Page 3
Table of contents page ....2.9.3 technical functions example 40 ........Technical functions 01 to 11 (table 2.9.2) 41 ........Technical functions 12 to 16 (table 2.9.2) 42 ........Technical functions 17 to 23 (table 2.9.2) 43 ........Technical functions 24 to 27 (table 2.9.2) 44 ........Technical fu...
Page 4
Table of contents page ....4.2.3.3 control panel assembly, paper guide (u) assembly 81 ....4.2.3.4 sub-roller, adf roller assembly, pinch roller, contact image sensor, document detectors (pc1 and pc2) 82 ....4.2.3.5 motors (resist, drum), assemblies (release guide, manual guide) stacker cover, fusin...
Page 5
Table of contents page ....7.1.3 alarm led on 117 ....7.1.4 printing test failure 118 ....7.1.5 no local copy 119 ....7.1.6 auto dial failure 120 ....7.1.7 transmission problem 121 ....7.1.8 auto reception failure 122 ....7.1.9 reception problem 123 ....7.1.10 sensor calibration test 124 ....7.1.11 ...
Page 6
Table of contents page a1.1 unit configuration and block diagram (figure a.1.12) 159 ....Block diagram (figure a1.2.2) 160 ....Block diagram abbreviations 161 a1.2 function of each unit 162 a2.1 signal flow explanation 163 ....(1) copy mode 164 ....Copy picture signal (figure a2.2.1) 165 ....(2) g3 ...
Page 7
Table of contents page ....A3.2.10 m17 circuit diagram 200 ........Related signals of send motor (figure a3.2.13) 201 ....A3.2.11 m17 circuit diagram 202 ........Related signals of drum/resist motor (figure a3.2.14) 203 ....A3.2.12 m17 circuit diagram 204 ........Related signals of fan motor (figure...
Page 8
Table of contents page ........5-6-3 tr1 and tr2 241 ........5-6-4 ch 242 ........5-7 photosensors 243 a3.7 unc5 (ncu) circuit diagram 244 ....Block diagram of unc (figure a3.7.1) 245 a3.8 telu circuit diagram (option) 246 ....Block diagram of tel-u (option) (figure a3.8.1) 247 a3.11 memo (memory) c...
Page 9
Table of contents page ............Operation 283 ............Operation during toner full state 284 ............Operation during toner low state 285 ............Low toner alarm 286 ........B2.3.2.3 paper feed monitoring 287 c circuit diagrams c.1 general information 288 d illustrated parts list assem...
Page 10
Table of contents page 4. Troubleshooting 323 ....4.1 precautions prior to the troubleshooting 324 ....4.2 preparations for the troubleshooting 325 ....4.3 troubleshooting method 326 ........4.3.1 lcd status message list 327 5. Connection diagram 328 ....5.1 interconnection diagram 329 ....5.2 pcb l...
Page 11
Table of contents page h.1 general information 365 ....Okidata's web site 366 ....Faxable facts 367 ....Okilink ii 368 i recommended spare parts list (rspl) i. General information 369 ....Okidata's web site 370 ....Faxable facts 371 ....Okilink ii 372.
Page 12
Page: 1 service manual for of5300/5600 chapter 0 introduction kit contents this read me first sheet quick start guide certification manual hardware handbook service manual pc interface kit missing items if any items are missing, please contact okidata order processing at the appropriate number liste...
Page 13
Page: 2 service manual for of5300/5600 chapter 0 introduction disclaimer this document may not be reproduced without the written permission of okidata training and publications. Every effort has been made to ensure the accuracy of the information contained in this training course. Okidata is not res...
Page 14
Zip code is a registered trademark of the united states postal service. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 15
Page: 3 service manual for of5300/5600 chapter 0 introduction may, 1998 re: okifax 5050 service authorization dear okidata facsimile dealer: okidata is proud to announce the addition of the okifax 5050 to our facsimile product line. Enclosed is the okifax 5050 service information addendum, which wil...
Page 16
Page: 4 service manual for of5300/5600 chapter 0 introduction functionality the okifax 5050 is technically similar to the okifax 5300. The physical appearance is identical to the okifax 5300; however, the okifax 5050 is strictly a stand-alone facsimile product. Although there is a pc interface conne...
Page 17
Packaging box, w/ graphics p/n 53593002 foam endcap: left p/n 53591101 foam endcap: right p/n 53591102 level: first production release: version: fc11 firmware: flash rom 1 location: e17-3 pcb serial number effectivity: of 5050: all serial numbers size: 4 mb okidata p/n: n/a (not socketed firmware) o...
Page 18
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 19
Page: 6 service manual for of5300/5600 chapter 1 general information (01) type of appearance desktop type (02) applicable lines public switched telephone network (pstn) private branch exchange (pbx) (03) compatibility itu-t group 3 facsimile transceiver (04) document width max. 216 mm (8.5 inches [n...
Page 20
Letter: legal: iso a4: 273.4 mm (10.76 inches) / 266.7 mm (10.49 inches) for assured quality 349.6 mm (13.76 inches) / 342.9 mm (13.49 inches) for assured quality 291 mm (11.46 inches) / 284.3 mm (11.19 inches) for assured quality (11) copy stacker max. 100 sheets (20-lb bond, oki data recommended p...
Page 21
(20) (20) modem itu-t rec. V.29: 9600/7200 bps itu-t rec. V.27 ter: 4800/2400 bps itu-t rec. V.21 channel 2: 300 bps itu-t rec. V.17: 14400/12000 bps itu-t rec. V.33: 14400/12000 bps itu-t rec. V.34: 28800 bps (okifax 5600 only) note: 33600 bps (v.34) is available (okifax 5600) when tech func 32 is ...
Page 22
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 23
Page: 7 service manual for of5300/5600 chapter 1 general information (01) transmit mode automatic transmit mode manual transmit mode (02) receive mode automatic receive mode manual receive mode tel/fax automatic switchover mode tad mode pc mode (03) dual access (04) voice request (05) automatic redi...
Page 24
(24) page retransmission only in memory tx mode retransmits in page units (25) reduction printing reduction rate is from 100% to 75% (legal to letter) (26) smoothing printing in case of 3.85 l/mm to 7.7 l/mm (27) programmed key operation "f" key + "ot" key (28) auto dialing one-touch dialing okifax ...
Page 25
Activity report protocol report (service man setting) message confirmation report (single address or multiple addresses) broad cast entry report (broadcast) transmission error report confidential reception report configuration report telephone directory power outage report copyright 1997, okidata, d...
Page 26
Page: 8 service manual for of5300/5600 chapter 1 general information (01) self-diagnosis cpu rom/ram check flash (/mask) memory check (program, language, default) ram check ram check (memory board: option) pc-if board (parallel) check print test (02) sensor calibration (adjustment of scanning level)...
Page 27
Page: 9 service manual for of5300/5600 chapter 1 general information figure 1.4.2 shows the general appearance of the okifax 5300/5600 general appearance of okifax 5300/5600 (figure 1.4.2) copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner ex...
Page 28
Page: 10 service manual for of5300/5600 chapter 1 general information table 1.5.1 shows basic performance specifications. Note: tf: technical function setting fp: function program setting ot: one-touch key pressed f: select function key pressed.
Page 43
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 44
Page: 11 service manual for of5300/5600 chapter 1 general information table 1.6.1 shows reports and lists specifications. Note: f +ot: press function and one-touch key fp: function program setting tf: technical function setting no. Item specifications 01 call-back message the transmitter sends a cal...
Page 45
Page: 12 service manual for of5300/5600 chapter 1 general information (1) date and time (2) sender id (3) csi/personal id (4) letters "please call back" (5) sender id (6) sender's call back telephone number copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata b...
Page 46
Page: 13 service manual for of5300/5600 chapter 1 general information copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 47
Page: 14 service manual for of5300/5600 chapter 1 general information local date and time printing (example) note: tsi printing (tf+05) local date and time printing (tf+04) copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for...
Page 48
Page: 15 service manual for of5300/5600 chapter 1 general information note: memory reception only is printed on the mode in the report as called. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this materi...
Page 49
Page: 16 service manual for of5300/5600 chapter 1 general information explanation of example (1) title of the report (2) date and time when the report was printed (3) sender id (4) total calling and called time (5) date of transmission or reception (6) time when the communication started (7) time sp...
Page 50
Called (reception ng or memory rx) b. C. (broadcast) box=xx (confidential reception) fwd-r (fax forwarding rx) fwd-t (fax forwarding tx) (10) number of transmitted pages or received pages (11) result code ok (note1)/no/stop (note 2)/busy/paper (out of recording paper)/s_jam (document jam)/r_jam (rec...
Page 51
Page: 17 service manual for of5300/5600 chapter 1 general information message confirmation report example 1 of 2 example 2 of 2.
Page 52
Explanation of example (1) title of the report (2) date and time when the report was printed (3) sender id (4) date of transmission or reception (5) length of time for which the fax was connected to the line (6) identification of the remote station personal id/location id/tsi/csi/dial number (7) com...
Page 53
Page: 18 service manual for of5300/5600 chapter 1 general information copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 54
Page: 19 service manual for of5300/5600 chapter 1 general information copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 55
Page: 20 service manual for of5300/5600 chapter 1 general information copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 56
Page: 21 service manual for of5300/5600 chapter 1 general information copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 57
Page: 22 service manual for of5300/5600 chapter 1 general information example 1 of 4 example 2 of 4.
Page 58
Example 3 of 4.
Page 60
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 61
Page: 23 service manual for of5300/5600 chapter 1 general information example 1 of 6 example 2 of 6.
Page 62
Example 3 of 6.
Page 63
Example 4 of 6.
Page 64
Example 5 of 6.
Page 65
Example 6 of 6.
Page 66
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 67
Page: 24 service manual for of5300/5600 chapter 1 general information copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 68
Page: 25 service manual for of5300/5600 chapter 1 general information copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 69
Page: 26 service manual for of5300/5600 chapter 2 installation procedures this sectionthe following flowchart outlines the installation procedure..
Page 71
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 72
Page: 27 service manual for of5300/5600 chapter 2 installation procedures precautions for installation (01) fluctuation in line voltage 120vac (102v to 127v) 230vac (198v to 264v) (02) room temperature 50 to 90°f (10 to 32°c) (03) humidity 20 to 80% rh (04) operating environment pressure: equivalent...
Page 73
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 74
Page: 28 service manual for of5300/5600 chapter 2 installation procedures 2.3.1 procedure (01) remove tape on the top of the carton box and open its cover. Unpacking procedure 1 (figure 2.3.1.1) (02) take out the accessory box from the carton box. (see figure 2.3.2.1) (03) take out the machine with ...
Page 75
Unpacking procedure 3 (figure 2.3.2.2).
Page 76
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 77
Page: 29 service manual for of5300/5600 chapter 2 installation procedures after having taken out the machine and accompanied accessories from the carton box, check the contents according to the following list: contents list (table 2.4.2) item no. Name q'ty remarks 1 okifax 5300 or okifax 5600 1 2 ac...
Page 78
Page: 30 service manual for of5300/5600 chapter 2 installation procedures (01) items image drum (id) unit (already installed) toner cartridge recording paper document stacker (02) procedure 1) toner cartridge peel off the fixed tape attached to the copy stacker. Open the document table and copy stac...
Page 79
Toner cartridge installation 3 (figure 2.5.2.3) take out the toner cartridge from the damp proof bag, shake it five or six times as shown in the illustration to eliminate the toner deflection, and peel off the seal gently. Ensure that the plastic tab on the right-hand side of the toner cartridge rec...
Page 80
Toner cartridge installation 5 (figure 2.5.2.5) clean the toner scattered in the vicinity of the toner cartridge using a cloth moistened with cold water. Do not use hot water since it makes the toner stick there. Close the copy stacker until the buttons have been locked completely. Recording paper c...
Page 81
Sheets must not exceed the paper full marker of the new paper limit indication. If excessive sheets are set, it will cause paper jams. After loading the new paper, push it forward into the slot at the front of the facsimile until it locks. Recording paper cassette installation 2 (figure 2.5.2.7) doc...
Page 82
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 83
Page: 31 service manual for of5300/5600 chapter 2 installation procedures the power supply is provided as follows. Nominal input voltage 120vac (voltage range 102 to 127vac) nominal input voltage 230vac (voltage range 198 to 250vac) check whether the ac voltage of your input is within the above-ment...
Page 84
Page: 32 service manual for of5300/5600 chapter 2 installation procedures (1) procedure connect the lines. Telephone and line connections (figure 2.7.1) copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this...
Page 85
Page: 33 service manual for of5300/5600 chapter 2 installation procedures caution: when packing the unit for shipment, remove the image drum and toner from the unit and ship separately! Failure to do so will result in damage to the machine. Copyright 1997, okidata, division of oki america, inc. All ...
Page 86
Page: 34 service manual for of5300/5600 chapter 2 installation procedures 2.9.1 key operation flowchart (figure 2.9.1) 2.9.2 technical functions 2.9.3 technical functions example 2.9.4 user's functions 2.9.5 user's functions examples 2.9.6 clock adjustment 2.9.7 dual access operation 2.9.8 system da...
Page 87
Page: 35 service manual for of5300/5600 chapter 2 installation procedures the key operation flowchart is shown on the following pages..
Page 91
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 92
Page: 36 service manual for of5300/5600 chapter 2 installation procedures this section explains setting items generally conducted by service personnel, not by users. Table 2.9.1 shows the initial setting items and their purposes. (the default settings differ by country.) each item can be accessed by...
Page 93
Page: 37 service manual for of5300/5600 chapter 2 installation procedures this table shows the initial setting items and their purposes. The default settings may differ by country. Each item can be accessed by entering the corresponding service number on technical function. Note: s-on: effective if ...
Page 94
05 tsi print switches the function of printing tsi data from remote fax onto the received pages. Tsi is printed at the leading edge of first reproduced copy. (set at receiver.) when tf04 is set to "all", tsi is printed for the all received pages. On : enable off : disable (reference) tsi; transmitti...
Page 95
10 mdy/dmy switches lcd display and report print from month/day/year to day/month/year or vice versa. Mdy/dmy selectable. Mdy 11 long document scan switches the function of transmitting long-size document (more than 380 mm). On : unlimited (1 hour) off : 380 mm. (14.96 inches) off 12 echo protection...
Page 96
18 dis bit 32 specifies whether to transmit a bit 32 in dis. On : transmits a bit 32 off: disable note: disable only if communication / compatibility problems occur with an older remote machine. On 19 error criterion registers the threshold value whether to transmit rtn or mcf signal when the error ...
Page 97
27 strobe for led head setting of led print head strobe signals (00000-11111). Selection of strobe width in led head. "00000" is darkest and "11111" is lightest. This setting should be verified upon initial install of machine, or replacement of main control board or led head. Note 1: when the rank m...
Page 98
31 symbol rate symbol rate (later) selects the v.34 modem symbol rate for okifax 5600. 2400, 2800, 3200, 3429 selectable. 2800 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Oki...
Page 99
Page: 38 service manual for of5300/5600 chapter 2 installation procedures tad: telephone answering device tad can be connected to external telephone terminal to record your messages. Tad records your speech and switches an automatic voice message response to the calling station. Note 1: a choice of ...
Page 100
*1 to enable the manual tx mode. Load document ---> press start button ---> manual transmission note: if remote rx function is set to a value other than off, that code can be used to force fax rx during tad mode operation. Tad mode flowchart (type 2) if the fax does not detect cng signal during work...
Page 101
Note: if remote rx function is set to a value other than off, that code can be used to force fax rx during tad mode operation. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Oki...
Page 102
Page: 39 service manual for of5300/5600 chapter 2 installation procedures this function is used for the purpose of tel/fax automatic switching as discussed below. It assumes that an optional handset is connected to the machine. (1) if the machine detects a call with a cng signal indicating an auto s...
Page 103
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 104
Page: 40 service manual for of5300/5600 chapter 2 installation procedures note: the fonts displayed on the lcd operation panel may differ from the fonts written this manual. Setting the service bit 1) purpose to enable or disable the following functions: drum and toner counter display (clear) servic...
Page 106
*1: 01-29 for okifax 5300 01-30 for okifax 5600 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 107
Page: 41 service manual for of5300/5600 chapter 2 installation procedures.
Page 109
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 110
Page: 42 service manual for of5300/5600 chapter 2 installation procedures copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 111
Page: 43 service manual for of5300/5600 chapter 2 installation procedures.
Page 112
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business.
Page 113
Partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 114
Page: 44 service manual for of5300/5600 chapter 2 installation procedures.
Page 115
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 116
Page: 45 service manual for of5300/5600 chapter 2 installation procedures.
Page 117
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 118
Page: 46 service manual for of5300/5600 chapter 2 installation procedures this section explains the items usually set up by general users. Table 2.9.3 shows the initial setting items and their purposes. Each function program setting (fp) can be accessed by entering the corresponding function number ...
Page 119
Page: 47 service manual for of5300/5600 chapter 2 installation procedures note: s-on: effective if the service bit has been set on. Fp: function program setting tf: technical function setting no. Item specifications 01 auto dial 1) one-touch dial 2) two-digit dial 3) keypad dial 4) chain dial 5) mix...
Page 120
03 receive mode 1) auto receive mode 2) manual receive mode 3) telephone/fax automatic switchover automatic redial selectable by key operation. Selectable by key operation. Selectable by key operation. The fax recognizes a fax call from a verbal call as follows: if the fax detects a call with a cng ...
Page 121
08 voice request a voice request from the transmitter is available only upon completion of the total message transmission. A voice request from the receiver is available at the end of each page being received. 09 local copy printing resolution: horizontal: 8 pel/mm horizontal: 300 dpi vertical: 7.7 ...
Page 122
17 no toner reception the fax can temporarily store received messages in memory when toner has run out. The messages are printed when toner has been newly supplied or an operator presses the select function key followed by the one-touch key no. 10 under the lcd message "msg. In memory/replace toner ...
Page 123
Page: 48 service manual for of5300/5600 chapter 2 installation procedures x: available n/a: not available \: available with limitation copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http:/...
Page 124
Page: 49 service manual for of5300/5600 chapter 2 installation procedures x: available n/a: not available \: available with limitation copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http:/...
Page 125
Page: 50 service manual for of5300/5600 chapter 2 installation procedures flowchart.
Page 126
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 127
Page: 51 service manual for of5300/5600 chapter 2 installation procedures f+ot item specifications no. 01 delayed transmission (tx) this function enters a message transmission time(s) and location(s) for execution at a specified time. 02 broadcast/memory transmission to make a one-time selection of ...
Page 128
06 report printing 1. Activity report 2. Broadcast message confirmation report (multi location) 3. Phone directory report 4. Configuration report (serviceman report if service bit sets to on.) 5. Protocol dump report * tf + 01 (sets to on service bit) log. Report * tf + 01 (sets to on service bit) 0...
Page 129
09 user's programs 1. Function program 2. Dial parameters 3. Clock adjustment 4. System data program function program 01: mcf (single-loc.) 02: mcf (multi-loc.) 03: err. Report (mcf.) 04: image in mcf. 05: sender id 06: monitor volume 07: buzzer volume 08: closed network 09: tx mode default 10: t/f ...
Page 130
10 print operation 1. Substitutive message print 2. Confidential reception message print 3. Printer cleaning used to print messages stored in memory during toner low condition. Also used to print messages received in memory when rx mode is set to mem rx. The messages are printed when toner has been ...
Page 131
Page: 52 service manual for of5300/5600 chapter 2 installation procedures user function program settings (table 2.9.4) part 1 of 4 p.F. No. Item specifications default 01 message confirmation report (single location) enables or disables the automatic message confirmation report printing after a sing...
Page 132
07 buzzer volume selects the sound volume of each buzzer (end of communication buzzer, voice request buzzer and off-hook alarm) and software ringer from high, low and middle levels. Low/mid/high selectable. Note: fixed a low level for key touch tone. Mid 08 closed network the fax compares lower four...
Page 133
14 2’nd cassette paper size (option) . The operator must select the preferable paper size as the machine cannot detect the paper size automatically. Letter 15 user language a choice of 2 languages for lcd and print message are available. Eng (english), spanish/french, portu-guese eng 16 incoming rin...
Page 134
22 pc/fax switch when the host side does not respond at the time of incoming call to pc, specifies whether to starts forcibly as fax reception or not. On: enables off: disables note: when the bi-centro board is installed on the fax, pc/fax switching mode appears in the lcd display. On 23 one-touch k...
Page 135
Page: 53 service manual for of5300/5600 chapter 2 installation procedures 1) accessing the user's functions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 136
Page: 54 service manual for of5300/5600 chapter 2 installation procedures.
Page 139
Note 1: resolution & original of tx mode default setting can be selected by using ---> key, while documents are loaded in the adf. 2) ring response time before specifying the ring response time, set the service bit on following the operations shown in 2.9.3 (1). (service bit setting). ¬.
Page 140
3) dial parameters (service bit "off") to get the "dial parameter" message on the display, perform the same operation as table 2.9.9. (dial parameters settings)..
Page 141
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 142
Page: 55 service manual for of5300/5600 chapter 2 installation procedures copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 143
Page: 56 service manual for of5300/5600 chapter 2 installation procedures.
Page 144
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 145
Page: 57 service manual for of5300/5600 chapter 2 installation procedures tsi/csi (default: blank) registration of sender id (default: blank) registration of telephone number for the call-back message (default: blank).
Page 146
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 147
Page: 58 service manual for of5300/5600 chapter 2 installation procedures (1) procedure (service bit "on") the display shows:.
Page 149
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 150
Page: 59 service manual for of5300/5600 chapter 2 installation procedures no. Item specifications default 01 redial tries switches on the re-dial times to meet the regulations of the installed country. 0 to 10 tries (in one-try steps) 1 to 5 tries for fre. 3 02 redial interval switches on the re-dia...
Page 151
12 auto start enables or disables the function of dialing without pressing the start key in one-touch dial and 2-digit auto dial modes. On: enable off: disable on 13 access digit prefix dialing digits with which pbx connects the fax to the public line. Off/max. 4digit(s) selectable. Digit: enable of...
Page 152
Page: 60 service manual for of5300/5600 chapter 2 installation procedures (1) purpose activate self-diagnosis which includes: print test cpu-rom version printing cpu-ram check prog version printing language version printing default version printing ram check ram check (memory board: optional) pc-i/f...
Page 153
Self-diagnosis print test (example) fig. 2.9.4.
Page 154
*1 marked item is shown for condition of all ram except exceed ram. *2 marked item is shown to sram for exceed. *3 marked items are option. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (h...
Page 155
Page: 61 service manual for of5300/5600 chapter 2 installation procedures 1. Transmission (1) load documents (2) make sure that the loaded documents are fed in automatically. The std and normal lamps light. The display shows select location. (3) dial the telephone number of the remote machine by the...
Page 156
Typical reception flow (fig. 2.9.6).
Page 157
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 158
Page: 62 service manual for of5300/5600 chapter 2 installation procedures (1) items memory board pc interface board telephone handset second paper cassette unit (2) procedure turn the facsimile power switch off and remove the ac power cord. Note: unplug the ac power cord from the wall outlet first a...
Page 159
Page: 63 service manual for of5300/5600 chapter 2 installation procedures mem, 1 or 2mb memory board, can be mounted on to the connector cn13 of m17 board. Remove rear cover. Remove the rear cover by removing the two screws s1 and s2 . Fig. C.1.3 install memory board: first, install the memory board...
Page 160
Fit the fixing hooks at anchor positions on the cassette guide, after that, lift the rear cover slightly and push it inward. Tighten the two screws s1 and s2. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates t...
Page 161
Page: 64 service manual for of5300/5600 chapter 2 installation procedures rear cover remove rear cover. Remove the rear cover by removing the two screws s1 and s2 . Fig. C.2.3 install ctr board. First, install ctr board on to the connector cn12, cn17 of m17 board, and then tighten the two screws to ...
Page 162
Fig. C.2.4 a) insert the tip of a cutter or nipper between the mold of rear cover and detach the cut-out from the larger cover piece. Note: be careful not to scratch the rear cover. B) work the cut-out free and remove it. Copyright 1997, okidata, division of oki america, inc. All rights reserved. Se...
Page 163
Page: 65 service manual for of5300/5600 chapter 2 installation procedures (1) after having taken out the telephone set, telephone handset and curled cord from the carton box, connect them as show in fig. C.3.2 below. (2) after installing the connection cable to the telephone set, extend the connecti...
Page 164
Fig. C.3.4 (4) install the telephone assembly on the facsimile transceiver unit. In this case, cram the telephone assembly into the position of fig. C.3.5 by lifting the facsimile transceiver unit slightly. When 2'nd tray is mounted on the facsimile transceiver unit, install the telephone assembly i...
Page 165
Fig. C.3.6 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 166
Page: 66 service manual for of5300/5600 chapter 2 installation procedures this item explains how to install the second paper cassette unit option. This second paper cassette unit comes with a second front and facsimile connector cable. Installation 1. Turn the facsimile power switch off and remove t...
Page 167
3. Gently lower the facsimile on the second paper cassette unit. Note: make sure that the positioning boss of the second paper cassette unit fits into the 2 holes at the bottom of the facsimile transceiver main unit. 4. Peel off the tape attached on the second paper cassette unit. Figure c.2.4 5. In...
Page 168
6. Reconnect the power cord to the wall and the facsimile, and turn the facsimile power on. Figure c.2.5 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 169
Page: 67 service manual for of5300/5600 chapter 3 brief technical description the electro-photographic process involves six sub-processes: (1) charging (2) exposure (3) development (4) transfer (5) fusing (6) cleaning the outline of each process is explained below..
Page 171
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 172
Page: 68 service manual for of5300/5600 chapter 3 brief technical description copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 173
Page: 69 service manual for of5300/5600 chapter 3 brief technical description the electro-photographic process consists of six essential processes. The following figure 3.2.1 provides a general description. * process: 1 : charging 2 : exposure 3 : developing 4 : transfer 5 : fusing 6 : cleaning figu...
Page 174
Page: 70 service manual for of5300/5600 chapter 3 brief technical description the following three boards, memory board (option), telephone interface board (option), pc interface board (option) and three units constitute the okifax 5300/5600 units. Main control board mcnt: (m17; okifax 5000 series) m...
Page 175
Page: 71 service manual for of5300/5600 chapter 3 brief technical description copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 176
Page: 72 service manual for of5300/5600 chapter 3 brief technical description.
Page 177
Figure 3.5.1 overall dimension and mechanical structure copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 178
Page: 73 service manual for of5300/5600 chapter 4 disassembly this chapter explains the procedures for replacement of assemblies and units in the field. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this...
Page 179
Page: 74 service manual for of5300/5600 chapter 4 disassembly (1) before starting disassembly and reassembly, always turn the ac power switch off, and pull out the ac plug. Note: unplug the ac power cord from the wall outlet first and then from the facsimile. (2) do not try to disassemble as long as...
Page 180
Page: 75 service manual for of5300/5600 chapter 4 disassembly table 4.2.1 shows the tools required for the replacement of parts such as circuit boards and mechanical units. Table 4.2.1 tools copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner ...
Page 181
Page: 76 service manual for of5300/5600 chapter 4 disassembly this section explains how to disassemble and reassemble the fax. Figure 4.2 shows the disassembly procedure flow as generalization. The detailed disassembly procedure is explained from sub-section 4.2.3.1 to 4.2.3.8. Copyright 1997, okida...
Page 182
Page: 77 service manual for of5300/5600 chapter 4 disassembly copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 183
Page: 78 service manual for of5300/5600 chapter 4 disassembly copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 184
Page: 79 service manual for of5300/5600 chapter 4 disassembly copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 185
Page: 80 service manual for of5300/5600 chapter 4 disassembly.
Page 186
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 187
Page: 81 service manual for of5300/5600 chapter 4 disassembly.
Page 188
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 189
Page: 82 service manual for of5300/5600 chapter 4 disassembly.
Page 190
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 191
Page: 83 service manual for of5300/5600 chapter 4 disassembly.
Page 192
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 193
Page: 84 service manual for of5300/5600 chapter 4 disassembly.
Page 194
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 195
Page: 85 service manual for of5300/5600 chapter 4 disassembly.
Page 196
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 197
Page: 86 service manual for of5300/5600 chapter 4 disassembly copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 198
Page: 87 service manual for of5300/5600 chapter 5 adjustments adjustment point: technical function no. 27. * to bring the lcd up to technical function, press select function key once, copy key twice and "2" key (in case of no message in memory). Note: when the rank marking of the replaced led print ...
Page 199
Partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 200
Page: 88 service manual for of5300/5600 chapter 5 adjustments the clock frequency and power voltage of the machine are not possible to adjust in the field. However, their measurement procedures are described here for confirmation of clock frequency and each voltage. 1) clock frequency measurement po...
Page 201
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 202
Page: 89 service manual for of5300/5600 chapter 5 adjustments 1) turn ac power off. 2) carry out the disassembly procedure up to main cover and scanner unit removal. (refer to the mechanical disassembly and reassembly in chapter 4-2.) 3) connect extension cables to the m17 board. 4) connect the freq...
Page 203
Page: 90 service manual for of5300/5600 chapter 5 adjustments copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 204
Page: 91 service manual for of5300/5600 chapter 6 cleaning and maintenance the user (or service personnel) is required to replace the following items as consumable parts. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for a...
Page 205
Page: 92 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 206
Page: 93 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 207
Page: 94 service manual for of5300/5600 chapter 6 cleaning and maintenance the recommended preventative maintenance of the following items should be performed twice a year (once a year is the absolute minimum) after the machine is installed. Table 6.2.2 describes the preventative maintenance procedu...
Page 208
Page: 95 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 209
Page: 96 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 210
Page: 97 service manual for of5300/5600 chapter 6 cleaning and maintenance 1. Purpose a user can clear the image drum counter and also check some of the other counters (such as the print counter, scan counter) by using the key. 2. Procedure the following example shows the menu flow when the service ...
Page 211
Page: 98 service manual for of5300/5600 chapter 6 cleaning and maintenance 1. Purpose the service personnel can clear and check the following counters. Image drum toner image drum (total) print scan note: drum (t) count is used to display the total in-use life of the machine. This counter cannot be ...
Page 212
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 213
Page: 99 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 214
Page: 100 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 215
Page: 101 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 216
Page: 102 service manual for of5300/5600 chapter 6 cleaning and maintenance.
Page 217
Note: after performing the adjustment, make copies of test charts or known good documents. Compare the copies to the originals to evaluate the copy print quality. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updat...
Page 218
Page: 103 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 219
Page: 104 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 220
Page: 105 service manual for of5300/5600 chapter 6 cleaning and maintenance note: this procedure requires coordination with technical staff at the remote location. In addition, both locations must have a telephone handset connected to each machine. 1. Purpose to check the telephone line quality in c...
Page 221
Page: 106 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 222
Page: 107 service manual for of5300/5600 chapter 6 cleaning and maintenance note: this procedure requires coordination with technical staff at the remote location. In addition, both locations must have a telephone handset connected to each machine. 1. Purpose to check the telephone line quality in c...
Page 223
Page: 108 service manual for of5300/5600 chapter 6 cleaning and maintenance 1. Purpose to send the multi-frequencies of tone dialing to the line. 2. Procedure copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates t...
Page 224
Page: 109 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 225
Page: 110 service manual for of5300/5600 chapter 6 cleaning and maintenance copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 226
Page: 111 service manual for of5300/5600 chapter 6 cleaning and maintenance sample is from the transmitter side..
Page 228
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 229
Page: 112 service manual for of5300/5600 chapter 6 cleaning and maintenance the printed out data permits to analyze g3 facsimile communication protocol signals between two facsimile machines. Figure 6.13.2 shows the result of an analysis on the printed data referring to figure 6.13.1 (protocol data ...
Page 230
Page: 113 service manual for of5300/5600 chapter 6 cleaning and maintenance table 6.14.1 shows all facsimile control field (fcf) signals which are needed to analyze the printed out protocol dump data. Some signals have two different hexadecimal codes in accordance with the calling party or called pa...
Page 231
Page: 114 service manual for of5300/5600 chapter 7 troubleshooting this chapter contains: (a) troubleshooting flow charts related to general operations (b) troubleshooting flow charts by test operations (c) troubleshooting flow charts placing an emphasis on mechanical portions section no. Name of fl...
Page 232
Page: 115 service manual for of5300/5600 chapter 7 troubleshooting.
Page 233
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business.
Page 234
Partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 235
Page: 116 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 236
Page: 117 service manual for of5300/5600 chapter 7 troubleshooting note*: "printer alarm i" will be shown as follows: printer alarm 1 to printer alarm 4. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to thi...
Page 237
Page: 118 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 238
Page: 119 service manual for of5300/5600 chapter 7 troubleshooting.
Page 240
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 241
Page: 120 service manual for of5300/5600 chapter 7 troubleshooting.
Page 243
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 244
Page: 121 service manual for of5300/5600 chapter 7 troubleshooting this section explains how to localize the cause of problems occurred after completion of connection with a remote station..
Page 245
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 246
Page: 122 service manual for of5300/5600 chapter 7 troubleshooting.
Page 247
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business.
Page 248
Partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 249
Page: 123 service manual for of5300/5600 chapter 7 troubleshooting this section explains how to localize the cause of problems occurred after completion of connection with a remote station..
Page 250
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 251
Page: 124 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 252
Page: 125 service manual for of5300/5600 chapter 7 troubleshooting.
Page 253
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 254
Page: 126 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 255
Page: 127 service manual for of5300/5600 chapter 7 troubleshooting.
Page 256
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 257
Page: 128 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 258
Page: 129 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 259
Page: 130 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 260
Page: 131 service manual for of5300/5600 chapter 7 troubleshooting.
Page 265
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 266
Page: 132 service manual for of5300/5600 chapter 7 troubleshooting note: this section places an emphasis on troubleshooting of mechanical portions. Therefore, it is recommended to replace the mcnt board first and, then if not solved, follow this flow chart. Copyright 1997, okidata, division of oki a...
Page 267
Page: 133 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 268
Page: 134 service manual for of5300/5600 chapter 7 troubleshooting.
Page 269
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 270
Page: 135 service manual for of5300/5600 chapter 7 troubleshooting.
Page 271
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business.
Page 272
Partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 273
Page: 136 service manual for of5300/5600 chapter 7 troubleshooting 7.1.22.1 precautions 7.1.22.2 troubleshooting flow charts of printer unit 7.1.22.3 image problems table copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for a...
Page 274
Page: 137 service manual for of5300/5600 chapter 7 troubleshooting 1. Points to check before correcting image troubles (1) is the printer being run in proper ambient conditions? (2) have the supplies (toner) and the routine replacement part (ep unit) been replaced properly? (3) is the recording pape...
Page 275
Page: 138 service manual for of5300/5600 chapter 7 troubleshooting overall troubleshooting flowchart 1: top cover is open 2: replace image drum message 3: engine controller error 4: fan motor rotation error 5: fuser unit thermal error 6: paper jams 7: no paper tray or no paper action items (printer ...
Page 276
Page: 139 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 277
Page: 140 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 278
Page: 141 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 279
Page: 142 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 280
Page: 143 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 281
Page: 144 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 282
Page: 145 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 283
Page: 146 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 284
Page: 147 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 285
Page: 148 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 286
Page: 149 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 287
Page: 150 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 288
Page: 151 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 289
Page: 152 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 290
Page: 153 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 291
Page: 154 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 292
Page: 155 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 293
Page: 156 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 294
Page: 157 service manual for of5300/5600 chapter 7 troubleshooting copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 295
Page: 158 service manual for of5300/5600 chapter 8 dipswitch settings the okifax 5300 and okifax 5600 do not have any dipswitches. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx...
Page 296
Page: 159 service manual for of5300/5600 chapter a board descriptions 1. The unit configuration is shown below. Figure a.1.1.2 unit configuration diagram (1) main control board okifax 5300: m17 pcb; okifax 5600: m17 (2) modem board (modem): okifax 5600 only (3) network control unit (unc-5) (4) pc in...
Page 297
Telephone interface board (tel) hook board (hook) note: item 7 will be removed from the product in later revisions. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 298
Page: 160 service manual for of5300/5600 chapter a board descriptions.
Page 300
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 301
Page: 161 service manual for of5300/5600 chapter a board descriptions a/d analog-to-digital converter amp amplifier batt battery cni connector number i cpu central processing unit d-motor drum motor drv motor drive dram dynamic random-access memory exseed image processing gate array fan fan motor fl...
Page 302
Page: 162 service manual for of5300/5600 chapter a board descriptions the section describes the principal functions of the individual units of the fax machines electrical sections. The block diagram is shown in figure a1.2.2. (1) okifax 5300: m17 pcb okifax 5600: m17 pcb cpu basic processor scanning...
Page 303
Drum motor control resist motor control modem chip/modem board (for okifax 5600) modulation and demodulation for v.34 (for okifax 5600) modulation and demodulation for v.33 and v.17 modulation and demodulation for v.29 and v.27 ter modulation and demodulation for v.21 generation of single-frequency ...
Page 304
Hook switch circuit 10) telu board (option): note: this board is contained within the optional handset. Speech network circuit basic speech functions included. (11) tqsb board (option) second paper cassette unit for okifax 5300/5600 mos-cpu motor control copyright 1997, okidata, division of oki amer...
Page 305
Page: 163 service manual for of5300/5600 chapter a board descriptions note: the okioffice 44 and okifax 5300/5600 machines have very similar signal flows. The differences are: the one-line scanning processing speed of okifax 5300/5600 is faster. The exseed (image processing lsi) and sram (dark/light...
Page 306
Page: 164 service manual for of5300/5600 chapter a board descriptions figure a2.2.1 shows the picture signal route in local copy mode. One-line picture data is transferred to a/d converter (analog/digital) via operational amplifier from the scanning unit (cis: contact image sensor) as an analog data...
Page 307
Page: 165 service manual for of5300/5600 chapter a board descriptions.
Page 308
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 309
Page: 166 service manual for of5300/5600 chapter a board descriptions figure a2.2.2 shows the g3 send picture signal route in the g3 mode, the data transfer route from the scan unit up to the dram is the same as in the copy mode described in (1). The picture data for one-line is transferred from dra...
Page 310
Page: 167 service manual for of5300/5600 chapter a board descriptions.
Page 311
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 312
Page: 168 service manual for of5300/5600 chapter a board descriptions figure a2.2.3 shows the g3 receive picture signal route in the g3 mode, the high-speed picture signal arriving from the telephone line at l1 and l2 of ncu passes through the transformer t1 and the amplifier and is input to the mod...
Page 313
Page: 169 service manual for of5300/5600 chapter a board descriptions.
Page 314
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 315
Page: 170 service manual for of5300/5600 chapter a board descriptions figure a2.2.4 shows the 300bps send protocol signal route in g3 communication, this is the route of the procedural control signals (pre-message, post-message phases etc.) at 300bps. The protocol send data is read into dram in the ...
Page 316
Page: 171 service manual for of5300/5600 chapter a board descriptions.
Page 317
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 318
Page: 172 service manual for of5300/5600 chapter a board descriptions figure a2.2.5 shows the 300bps receive protocol signal route. In g3 communication, this is the route of the procedural control signals (pre-message, post-message phases etc.) at 300bps. The 300bps modulated signals received via th...
Page 319
Page: 173 service manual for of5300/5600 chapter a board descriptions.
Page 321
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 322
Page: 174 service manual for of5300/5600 chapter a board descriptions figure a2.2.6 shows the report print signal route. This signal route describes the printing route of character data used to print activity report, message confirmation report, etc. The report data is read into dram in the sequence...
Page 323
Page: 175 service manual for of5300/5600 chapter a board descriptions.
Page 324
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 325
Page: 176 service manual for of5300/5600 chapter a board descriptions this signal route describes the memory transmission used in broadcast mode, delayed broadcast mode, etc. The stored encoded data undergoes buffering, passes through cpu, modem and ncu and then sent out to the telephone line. Copyr...
Page 326
Page: 177 service manual for of5300/5600 chapter a board descriptions this signal route describes the memory reception used in no-paper mode, no-toner reception, confidential mode, etc. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner excha...
Page 327
Page: 178 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 328
Page: 179 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 329
Page: 180 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of a cpu, crystal oscillator circuit and reset signal generator. Figure a3.2.1 shows the block diagram of cpu and the peripheral circuits. 2. Function 1) crystal oscillator circuit x1 ...
Page 330
Page: 181 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 331
Page: 182 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of an input/output gate array ic2 (ioga3). Figure a3.2.2 shows the related signals of ioga3. 2. Functions ioga3 is newly developed lsi for scanning and printing control of okifax 5000 ...
Page 332
Page: 183 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 333
Page: 184 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of flash memory, mask rom, ic3 (real time clock ic) and back up battery circuit. Fig. A3.2.3 shows the block diagram of flash memory, mask rom and real time clock. 2. Function 1) flash...
Page 334
Page: 185 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 335
Page: 186 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the audio monitor circuit consists of ic11 (analog switch ic) and ic5 (amplifier) generates the following audio monitor. Line monitoring buzzer signals figure a3.2.4 shows the block diagram of audio monitor circui...
Page 336
Page: 187 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 337
Page: 188 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of the following function: ic6 (a/d converter) and amplifier 30 v/24 v conversion circuit connector cn10 that provides an interface between m17 board and cis (contact image sensor). Fi...
Page 338
Page: 189 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 339
Page: 190 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of the iexseed (image processing lsi) of ic20 and sram. Figure a3.2.6 shows the related signals of iexseed. 2. Functions iexseed is newly developed lsi for the image processing of okif...
Page 340
Page: 191 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 341
Page: 192 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of connector cn15 that provides an interface between m17 board and the modem board (28.8 kbps). The circuit diagram consists of modem (14.4kbps). The circuit diagram consists of modem ...
Page 342
Page: 193 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 343
Page: 194 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram shown consists of the following connectors: connector cn6 that provides an interface between m17 board and ncu board. Connector cn7 that provides an interface between m17 board and external ele...
Page 344
Oh2 : detection of off-hook of terminal connected to tel-1 or tel-2 oh1 : output upon circuit current detection after fax line seizure rp : receiving sensitivity determination terminal ri : ringing detection signal s : send signal (picture data/protocol/tonal signals/pb tone etc.) r : received signa...
Page 345
Page: 195 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 346
Page: 196 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 347
Page: 197 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 348
Page: 198 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of connector cn2 that provides an interface between m17 board and led print head. Figure a3.2.12 shows the related signals and block diagram of led print head. 2. Function data of 1664...
Page 349
Page: 199 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 350
Page: 200 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of the following functions and connectors: ic21 (send motor drive) connector cn5 that provides an interface between m17 board and the send motor. Figure a3.2.13 shows the related signa...
Page 351
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 352
Page: 201 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 353
Page: 202 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of the following functions and connectors: ic9 (drum motor driver) ic22 (resist motor driver) connector cn3 that provides an interface between m17 board and the resist motor. Connector...
Page 354
Page: 203 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 355
Page: 204 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of the following connectors: connector cn11 that provides an interface between m17 board and the fan motor. Connector cn14 that provides an interface between m17 board and the second t...
Page 356
Control method: when second tray is installed on the facsimile transceiver unit, the tray is connected to the facsimile transceiver unit by a connector. The tray controls by the command from cpu of pu (printer unit) section. Copyright 1997, okidata, division of oki america, inc. All rights reserved....
Page 357
Page: 205 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 358
Page: 206 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 359
Page: 207 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of the following connector: connector cn1 provides an interface between m17 board and main power supply unit. 2. Function 1) sensors and switch control six types of sensors are used in...
Page 360
Page: 208 service manual for of5300/5600 chapter a board descriptions sensor type sensor name function psin-n psin2-n inlet sensor inlet sensor 2 this photosensor is positioned before the resist roller to detect whether the paper has entered into the printer section. Wrsns-n write sensor detects the...
Page 361
Page: 209 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 362
Page: 210 service manual for of5300/5600 chapter a board descriptions 2) fuser unit temperature control the heater in the fuser unit is controlled by the thermister, ioga3 and cpu to keep the heater roller surface within a prescribed temperature range. The cpu supervises the status of the port pc0 p...
Page 363
Page: 211 service manual for of5300/5600 chapter a board descriptions 3) high-voltage and medium-voltage control high voltages are activated by ioga3 and generated by the high-voltage circuit inside the power supply unit. The ch (charge) voltage of about -1.35 kv is used for the charge roller. The t...
Page 364
Page: 212 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of the following connector: connector cn13 that provides an interface between m17 board and optional memory board. Connector cn12 and cn17 that provides an interface between m17 board ...
Page 365
Page: 213 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 366
Page: 214 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 367
Page: 215 service manual for of5300/5600 chapter a board descriptions 1. Block diagram the circuit diagram consists of the following functions and connectors: ram3 to ram5 figure a3.2.22 shows the block diagram of dram. 2. Function 1) psram 2 mbyte dram x 1 (ram3) for oda version 512 kbyte dram x 2 ...
Page 368
Page: 216 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 369
Page: 217 service manual for of5300/5600 chapter a board descriptions 1. Block diagram figure a3.4.1 shows a block diagram of ope (05w). The o5wh (operation unit) circuit consists of the following blocks: 1) ic1 (one chip mos-cpu) output ports setting leds on and off: 8 ports specifies the row durin...
Page 370
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 371
Page: 218 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 372
Page: 219 service manual for of5300/5600 chapter a board descriptions a3.6.1 1vp (for 120 v)/2vp (for 230 v) circuit diagram (1/2) a3.6.2 1vp (for 120 v)/2vp (for 230 v) circuit diagram (2/2) copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner...
Page 373
Page: 220 service manual for of5300/5600 chapter a board descriptions important: oki data corporation recommends that maintenance of the power supply unit (1vp/2vp board) be performed by replacement of the whole power supply unit, not by replacement of components. Therefore, 1) circuit descriptions ...
Page 374
Page: 221 service manual for of5300/5600 chapter a board descriptions this circuit generates the following voltages. Output voltage output voltage +5 v logic circuit supply voltage (ic lsi), and high-voltage source voltage, etc. +8 v cis (contact image sensor) -8 v cis (contact image sensor) +30 v s...
Page 375
Page: 222 service manual for of5300/5600 chapter a board descriptions voltage: ac 120 v +6%, -15% (ac 102 v to 127 v ac 230 v +15%,-14% (ac 198 v to 264 v) frequency: 50/hz/60hz +/-2% copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchang...
Page 376
Page: 223 service manual for of5300/5600 chapter a board descriptions transformer type b pin no. Rated voltage rated current current range voltage range output ripple output noise cn3-b11-b1 3 a13 +5v 1.8 a 0.2 to 4.5 a 5 v +/-4% 100 mvp-p 250 mvp-p cn3-a15, b15 +30 v 1.20 a 0 to 1.20 a - 4.0 vp-p -...
Page 377
Page: 224 service manual for of5300/5600 chapter a board descriptions symbol 1vp board 2vp board remarks inlet ass'y 4ys4011-2894p001 4ys4011-2894p002 f1 51ms063l 19181-5a f2 51ms016l not mounted f3 ggs 3.15 21702.5 t1 (transformer 10 4yb4049-7082p1 4yb4049-7083p1 c1, c2, c56 and c242 not mounted mo...
Page 378
Page: 225 service manual for of5300/5600 chapter a board descriptions figure a3.6.1 shows a block diagram of 1vp (120v)/2vp (230v). Note: the differences between 1vp (ac120v) and 2vp (ac230v) board are shown in the following table. Symbol 1vp board 2vp board remarks inlet ass'y 4ys4011-2894p001 4ys4...
Page 379
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 380
Page: 226 service manual for of5300/5600 chapter a board descriptions 5-1 general 5-2 circuit description 5-3 low-voltage section 5-4 protection circuits 5-5 cover open circuit copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx)...
Page 381
Page: 227 service manual for of5300/5600 chapter a board descriptions the power supply unit consists mainly of ac transformer and a power pcb (1vp board for ac120v/2vp board for ac230v). A block diagram of the power supply unit is shown in figure a3.6.1 the power pcb is composed of five main circuit...
Page 382
Page: 228 service manual for of5300/5600 chapter a board descriptions 5-2-1 ac input section 5-2-2 heater control circuit copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata....
Page 383
Page: 229 service manual for of5300/5600 chapter a board descriptions 1) ac commercial power is supplied to line filter circuit through the ac inlet, power switch (sw1) and the fuse (f1). Fuse f1 is used for protecting the heater circuit. 2) the filter circuit consists of l101, r1, c1, c2, c3 and l1...
Page 384
Page: 230 service manual for of5300/5600 chapter a board descriptions 1) the ac power divided from the ac input section passes through l2 for noise elimination and is fed to the heater via d1 (operating as a switch) from the power pcb. 2) the on/off operation of d1 is controlled by the operation of ...
Page 385
Page: 231 service manual for of5300/5600 chapter a board descriptions 5-3-1 +30 v circuit 5-3-2 +/- 8 v circuit 5-3-3 +5 v circuit copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx...
Page 386
Page: 232 service manual for of5300/5600 chapter a board descriptions 1) the +30 v circuit provides +30 v output by rectifying the corresponding output of transformer t1 by a rectifier diode ds1 and smoothing the rectified signal by capacitor c7. 2) resistor r53 is used to discharge the electric cha...
Page 387
Page: 233 service manual for of5300/5600 chapter a board descriptions 1) the +/- 8 v circuit provides +8 v and -8 v outputs by rectifying the corresponding output of transformer t1 by rectifier diodes d10 and d11 and smoothing the rectified signals by capacitors c13 and c14. 2) resistors r22 and r23...
Page 388
Page: 234 service manual for of5300/5600 chapter a board descriptions 1) +5 v circuit provides +5 v output by lowering +30 v output by means of dc-dc converter circuit. 2) ic1 is a control ic of frequency fixed type (operating at about 30 khz in present power supply unit) 3) q1 is a power transistor...
Page 389
Page: 235 service manual for of5300/5600 chapter a board descriptions 1) the protection circuit includes fuse f3 for +30 v and +5 v overcurrent protection circuit. 2) if an overvoltage is applied to the +5 v circuit, d8, r9 and d6 operate to short-circuit the +30 v circuit for half-wave cycle and fu...
Page 390
Page: 236 service manual for of5300/5600 chapter a board descriptions 1) the cover open circuit consists of sw2. When the stacker cover is opened, the cover open microswitch (sw2) on the 1vp/2vp board is turned off to cut the supply of h5v to the high-voltage power supply circuit. As a result all hi...
Page 391
Page: 237 service manual for of5300/5600 chapter a board descriptions this circuit consists of photo-sensors and high voltage generation unit. Note: if the high-voltage unit inside the 1vp/2vp circuit board is replaced, the output voltage and current output from the terminals must be checked and adj...
Page 392
Page: 238 service manual for of5300/5600 chapter a board descriptions 5-6-1 functional overview 5-6-2 sb2, db1, db2 and cb 5-6-3 tr1 and tr2 5-6-4 ch copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this ma...
Page 393
Page: 239 service manual for of5300/5600 chapter a board descriptions the high-voltage outputs consist of tr1 (3.5 kv), tr2 (-0.75 kv), db1 (+300 v), db2 (-300 v), sb2 (-450v), cb (+400 v) and ch (-1.35 kv) and are obtained as follows. The control signal obtained from ioga of m17 board is applied to...
Page 394
Page: 240 service manual for of5300/5600 chapter a board descriptions 1) these four high-voltage outputs are obtained from the flyback voltage of q10. 2) the positive and negative voltages of db1 and db2 are obtained by switching the charging direction under the triac and thyristor. 3) feedback is n...
Page 395
Page: 241 service manual for of5300/5600 chapter a board descriptions 1) the tr1 high-voltage is obtained by rectifying the secondary output of q17 switching circuit by a voltage-doubler rectifier. 2) tr1 output circuit has both constant current (hereinafter called cc) and constant voltage (hereinaf...
Page 396
Page: 242 service manual for of5300/5600 chapter a board descriptions 1) the ch output voltage is stabilized by keeping the primary flyback voltage obtained by switching operation of q16 at a constant voltage by d76 and d82. Copyright 1997, okidata, division of oki america, inc. All rights reserved....
Page 397
Page: 243 service manual for of5300/5600 chapter a board descriptions the photosensors mounted on this circuit board/sensor board supervise the paper running state during printing. These six photosensors are used in this printer as listed below. All of their outputs enter ioga for referring to and p...
Page 398
Page: 244 service manual for of5300/5600 chapter a board descriptions 1. Block diagram figure a3.7.1 shows a block diagram of unc5 (ncu) circuit. 2. General functions of this circuit are as follows: 1) generates and detects signals to be exchanged with a telephone exchange or network in phases a and...
Page 399
These circuits provide dc characteristics according to the line requirements using the primary dc resistor in the line transformer t1 and the r10 and r11 resistors. The capacitor c4 bypasses ac signals. 5 impedance matching network (r523, r536, c503) this circuit matches the impedance between the li...
Page 400
Page: 245 service manual for of5300/5600 chapter a board descriptions.
Page 401
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 402
Page: 246 service manual for of5300/5600 chapter a board descriptions the telu board is the control board of the telephone set when the optional telephone assembly is installed on the facsimile transceiver. 1. Block diagram figure a3.8.1 shows a block diagram of telu circuit. 2. General functions of...
Page 403
Transmitter signal route signal from the microphone of the handset is input to pin 15 and 16 of speech ic. This signal is determined by the amplification factor and output to the telephone line via unc, hook switch and db2 (rectifier). Receive signal route receive signal from the telephone line ente...
Page 404
Page: 247 service manual for of5300/5600 chapter a board descriptions.
Page 405
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 406
Page: 248 service manual for of5300/5600 chapter a board descriptions by mounting this optional memory board (mem/mem-2), it can be used for the expansion memory. 1. Block diagram figure a3.11.1 shows a related signal of memory board. Memory board circuit consists of the following block. 1) 512 kbyt...
Page 407
2.0 mbyte - 200 note: no. Of sheets are counted provided that itu-t no.1 sample document is used. No. Of sheets are typical value. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx...
Page 408
Page: 249 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 409
Page: 250 service manual for of5300/5600 chapter a board descriptions ctr board is used as an interface board of pc and fax when pc is connected to facsimile machine. 1. Block diagram ctr board circuit is formed by receiver, driver, and 1284-i/f. Figure a3.12.1 shows related signals of ctr board. 2....
Page 410
Oki-scl 1 command. 3) faxmodem (tia/eia class 1) send/receive a class 1 command between host pc and fax machine. 4) memory (mfpl: multi-function peripheral language) by using mfpl command, it is possible to display on screen of host pc for condition of fax machine and performs the initial registrati...
Page 411
Page: 251 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 412
Page: 252 service manual for of5300/5600 chapter a board descriptions copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 413
Page: 253 service manual for of5300/5600 chapter a board descriptions 1. Block diagrm this board is installed as the optional board for the unit. Figure a3.13.1 shows a block diagram of the second tray (option). 2. Function second tray consists of the following functions: • paper capacity: 500 sheet...
Page 414
Page: 254 service manual for of5300/5600 chapter b print operation description this appendix describes the print operation processes and assemblies of the unit. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates...
Page 415
Page: 255 service manual for of5300/5600 chapter b print operation description 1) image drum cartridge 2) resist motor 3) drum motor 4) led head 5) fuser copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to thi...
Page 416
Page: 256 service manual for of5300/5600 chapter b print operation description the image drum cartridge (i/d or ep [electro-photographic) consists of an image drum, a charger, and a developer. The cartridge forms a toner image on the drum, using an electrostatic latent image formed by the led print ...
Page 417
Page: 257 service manual for of5300/5600 chapter b print operation description this resist motor is a pulse motor of 48 steps/rotation that is two-phase excited by the signal from the m17 board. It drives the hopping roller and the resist roller via two one-way clutches according to the direction of...
Page 418
Page: 258 service manual for of5300/5600 chapter b print operation description this drum motor is a pulse motor of 48 steps/rotation that is two-phase excited by the signal from the m17 board and is the main motor of this mechanism. Copyright 1997, okidata, division of oki america, inc. All rights r...
Page 419
Page: 259 service manual for of5300/5600 chapter b print operation description image data for each dot on a line from the m17 board is received by the shift registers and latch registers. The letter size led head are driven to radiate the image data on to the ep (image) drum. Copyright 1997, okidata...
Page 420
Page: 260 service manual for of5300/5600 chapter b print operation description the fuser consists of a heater, a heat roller, a thermister and a thermostat. An ac voltage from the power supply board (1vp/2vp) is applied to the heater under the control of the heat-n signal from the m17 board. This ac...
Page 421
Page: 261 service manual for of5300/5600 chapter b print operation description copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 422
Page: 262 service manual for of5300/5600 chapter b print operation description b2.2.1 process operations copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 423
Page: 263 service manual for of5300/5600 chapter b print operation description 1) hopping and feeding 2) charging 3) exposure 4) developing 5) transfer 6) fusing 7) cleaning 8) cleaning of rollers copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business pa...
Page 424
Page: 264 service manual for of5300/5600 chapter b print operation description hopping and feeding are affected by a single resist motor in the mechanism shown below. Turning the resist motor in the "a" direction drives the hopping roller. Turning the resist motor in the "b" direction drives the res...
Page 425
(b) feeding 1 after end of hopping, turning the resist motor in the "b" direction (in the counter-clockwise [ccw] direction) drives the resist roller to advance the paper. (in this case, the hopping gear also turns, but the hopping roller is prevented from turning by the one-way clutch gear.) 2 the ...
Page 426
Page: 265 service manual for of5300/5600 chapter b print operation description charging is affected by applying a dc voltage to the charge roller that is in contact with the image drum surface. The charge roller is composed of two layers consisting of a conductive layer and a surface protective laye...
Page 427
Page: 266 service manual for of5300/5600 chapter b print operation description 3) exposure light emitted from the led head irradiates the image drum surface with negative charges. The surface potential of the irradiated part of the image drum drops, thereby forming an electrostatic latent image asso...
Page 428
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 429
Page: 267 service manual for of5300/5600 chapter b print operation description toner is attracted to the electrostatic latent image on the image drum surface to convert it into a visible toner image. Developing takes place at the contact between the image drum and the developing roller. 1 as the ton...
Page 430
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 431
Page: 268 service manual for of5300/5600 chapter b print operation description the transfer roller is composed of conductive sponge material and is designed to make the image drum surface and the paper closely into contact. Paper is placed over the image drum surface, and a positive charge, opposite...
Page 432
Page: 269 service manual for of5300/5600 chapter b print operation description after the end of the transfer operation, the unfused toner image is fused on the paper under heat and pressure as it passes between the heater roller and the back-up roller. The heater roller with a teflon coating incorpo...
Page 433
Page: 270 service manual for of5300/5600 chapter b print operation description after the end of the transfer, residual toner on the image drum is attracted to the cleaning roller temporarily by static electricity to clean the image drum surface. Copyright 1997, okidata, division of oki america, inc....
Page 434
Page: 271 service manual for of5300/5600 chapter b print operation description the charge roller, transfer roller and cleaning roller are cleaned in the following cases: in warning up at power-on time in warning up after the cover is opened and closed when the number of accumulated sheets is 10 or m...
Page 435
Page: 272 service manual for of5300/5600 chapter b print operation description b2.3.1 errors list b2.3.2 major trouble errors b2.3.3 recoverable errors copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this ...
Page 436
Page: 273 service manual for of5300/5600 chapter b print operation description the errors are listed below. 1) major trouble errors fuser error (printer alarm 4) fan error (printer alarm 3) paper supply error paper transport system error paper exit jam paper size error 2'nd tray communication error ...
Page 437
Page: 274 service manual for of5300/5600 chapter b print operation description b2.3.2.1 fuser error (printer alarm 4) b2.3.2.2 fan error (printer alarm 3) b2.3.2.4 2'nd tray communication error (printer alarm 2) b2.3.2.5 cover open b2.3.2.3 paper feed monitoring copyright 1997, okidata, division of ...
Page 438
Page: 275 service manual for of5300/5600 chapter b print operation description the fuser error indicates an error in thermister on heater. In case the fuser error occurs at the time of printing, the heater is turned off soon but the printing continues of that page. However, if the error occurs befor...
Page 439
Page: 276 service manual for of5300/5600 chapter b print operation description the fan error is generated when the fansns signal lead goes "1" while the fan is running at full speed. Operation of the fansns signal when the fan is turned on is described below. Since the fan alarm is not monitored dur...
Page 440
Page: 277 service manual for of5300/5600 chapter b print operation description copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 441
Page: 278 service manual for of5300/5600 chapter b print operation description this error is generated if on sending a command to the 2'nd tray is returned no-status (40s) or an undefined status. However, in case there is no status when reset, it will be considered that the 2'nd tray is not mounted....
Page 442
Page: 279 service manual for of5300/5600 chapter b print operation description cover open sensor "0" indicates an open cover. When the cover is closed the cu (control unit) section sends the reset signal and processes in the same way as if the power has been turned on. Copyright 1997, okidata, divis...
Page 443
Page: 280 service manual for of5300/5600 chapter b print operation description the three recoverable errors are listed in the table below. Status description of supervising sensor 2'nd tray route open paper supply route from the option 2'nd tray to the main body is open, recording paper of the 1'st ...
Page 444
Page: 281 service manual for of5300/5600 chapter b print operation description composition operation operation during toner full state operation during toner low state low toner alarm copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchang...
Page 445
Page: 282 service manual for of5300/5600 chapter b print operation description the device consists of the stirring gear which rotates at a constant rate, the stirring bar and the magnet on the stirring bar. The stirring bar rotates through the link on the protrusion in the stirring gear. The configu...
Page 446
Page: 283 service manual for of5300/5600 chapter b print operation description toner low is detected by monitoring the time interval between the encounter of the magnet set on the sensor lever and the magnet on the stirring bar. Copyright 1997, okidata, division of oki america, inc. All rights reser...
Page 447
Page: 284 service manual for of5300/5600 chapter b print operation description operation during toner full state the stirring bar rotates due to interlocking with the stirring gear. Even when the magnet on the stirring bar reaches the maximum height, since the other side is being dipped in the toner...
Page 448
Page: 285 service manual for of5300/5600 chapter b print operation description operation during toner low state when the stirring bar reaches the maximum height, since there is no resistance provided by the toner on the other side, it falls to the minimum height due to its own weight. Because of thi...
Page 449
Page: 286 service manual for of5300/5600 chapter b print operation description a check for low toner is carried out at all times when the drum is rotating (rotation in opposite direction is excluded). The toner sensor is not monitored while the drum motor is in halt. When the toner low state is dete...
Page 450
Page: 287 service manual for of5300/5600 chapter b print operation description status description and supervising sensor distance paper supply error indicates monitoring error in hopping. Hopping is retried 3 times 118 mm (4.64") or less path length +36 (hopping) x 3 transport system jam 1 indicates...
Page 451
Page: 288 service manual for of5300/5600 chapter c circuit diagrams he okifax 5300 and okifax 5600 circuit diagrams contain component level repair information and are okidata proprietary. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exc...
Page 452
Page: 289 service manual for of5300/5600 chapter d illustrated parts list copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 453
Page: 290 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks.
Page 454
1a 1pa4120-1079g 1 hopper: document assy. 1 50607301 rspl 2a 2pp4120-1084p 1 tray: sub hopper 1 50220901 rspl 3a 2pp4120-1091p 1 cover: ncu 1 53075901 rspl 4a 1pp4120-1089p 1 cover: main 1 53075801 rspl 5a 2pa4083-6130g 1 guide: manual feed assy (gray) 1 51011001 rspl 6a 40044501 board-unc 1 4004450...
Page 455
Page: 291 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 1 40105301 unit: op panel (of5300) 1 40105301 rspl 1b 40079101 unit: op panel (of5600) 1 40079101 rspl 2 4pb4120-1074p1 film: one-touch cover 1 52203301 rspl.
Page 456
3 4pb4120-1073p10 1 sheet: one-touch (l) 1 52081310 rspl 4a 40047110 sheet-f-050v 1 n/a 4d 40076810 sheet-f-175v 1 n/a 5 4pb4014-4776p20 1 label: ten key (ok) 1 n/a 6a 40047001 sheet: one touch (of5300) 1 53077901 rspl 7a 1pp4120-1111p1 cover: one-touch cover-175 1 53076101 rspl 7b 1pp4120-1072p1 on...
Page 457
Page: 292 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 1 2pa4120-1214g1 cover: stacker assy 1 53077801 rspl 2 4pb3517-1567p1 wire: guide 1 51013801 rspl 3 4yb4120-1117p1 motor: (main) 1 56512701 rspl 4 4yb4120-1118p1 motor: regist...
Page 458
16 4pp4083-6081p1 gear: eject roller idle 1 51229201 rspl 17 3pb4083-6030p1 roller: registration 1 53342501 rspl 18 4pp4083-6042p1 gear: transfer roller 1 51229001 rspl 19 4yb5084-7640p1 roller: transfer 1 50409301 rspl 20 3pb4083-6064p2 roller: back-up 1 53343701 rspl 21 4pp4083-6052p1 bushing: pre...
Page 459
Page: 293 service manual for of5300/5600 chapter d illustrated parts list.
Page 460
Rev. No. Oki parts number description q'ty remarks 31 2pa4120-1085g1 guide: release assy. 1 51019201 rspl 32 4pp4120-1087p1 spring: release 1 50930001 rspl 33 4ya4116-1228g1 led head (1228g10 1 56112101 rspl 34 224a1286p0140 connector: led cable 1 56730201 rspl 35 4yx4120-1124g1 cable: led head assy...
Page 461
Page: 294 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 1a 4yb4049-7082p1 transformer: 120 v 1 56414201 rspl 1b 4yb4049-7083p1 transformer: 230 v 1 56414001 rspl 2 3pa4083-6090g1 assy: contact 1 56730001 rspl.
Page 462
3a 40035901 pwr unit-acdc drop (120v) 1 40035901 rspl 3b 40035902 pwr unit-acdc drop (230v) 1 40035902 rspl 4a 40050803 board: m17-3 1 40050803 rspl 5 2yx4076-7012g00 1 guide: cassette (r) assy 1 1024301 rspl 6 3pp4083-7653p1 lever: lock cassette 2 50808401 rspl 7 4pp4083-7655p1 spring: cassette loc...
Page 463
Page: 295 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 30b 4yb4049-1878p00 1 board-spsu (230v) 1 40123401 rspl.
Page 464
31 40123401 plate: assembly (pc interface) (of5600) 1 51024001 rspl 32 4pp4120-1187p1 plate: earth (pcfx) (of5600) 1 51023601 rspl 33 4pp4083-7665p00 1 fg plate d 1 51023601 rspl 34 4yc4061-5115p00 1 tape: teflon 2 52202601 rspl copyright 1997, okidata, division of oki america, inc. All rights reser...
Page 465
Page: 296 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 1 1pp4120-1015p00 1 frame: scanner 1 53350701 rspl 2 2pp4120-1034p1 base: scanner (l) 1 50221101 rspl 3 4pp4120-1023p1 plate: adf ground 1 51019901 rspl 4 4pp4120-1017p1 lever...
Page 466
5 4pp4120-1016p1 lever: pc1 1 50808701 rspl 6 3pp4120-1038p1 pocket plate 1 51020001 rspl 7 2pp4120-1037p1 base: scanner (r) 1 50221201 rspl 8 4pp4120-1032p1 spring: latch 2 50930101 rspl 9 4pp3529-5045p1 roller: pinch (feed) 1 50405201 rspl 10 4pp4120-1020p1 shaft: pinch roller 1 51113701 rspl 11 4...
Page 467
Page: 297 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 1 3pa4120-1045g1 roller: feed (1) assy. 1 53350701 rspl 2 4pp4120-1226p00 1 plate: earth (sr) 1 51023801 rspl.
Page 468
3 4pp4120-1227p00 1 plate: earth (sl) 1 51023901 rspl 4 4ys4011-1714p2 earth code 1 5 1pp4120-1040p00 1 guide: paper (u) 1 51024501 rspl 6 4pa4120-1041g1 plate: pinch assy. 1 51020501 rspl 7 4pb4120-1051p1 brush: ground 1 51305101 rspl 8 4pp3529-5035p1 gear: z28 1 51236401 rspl 9 4pa3529-5087g1 rubb...
Page 469
Page: 298 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 1 40040002 cord: op panel connection 1 40041002 rspl 2 4yb4120-1026p1 speaker 1 57001701 rspl.
Page 470
3 3ys4111-3527p2 cable: 2nd tray connector 1 56632801 rspl 4 4ys4111-3441p1 cord: connector (c1s) 1 56634501 rspl 5 4ys4111-3442p1 cord: connector (pc1/2) 1 56634601 rspl 6 105a1070c0001 core: ferrite d 2 55505201 rspl 7b 4ys3512-1485p1 cord: ac power 1 56618901 rspl 7c 236a6058p0001 cord: ac 220v 1...
Page 471
Page: 299 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 1 1pp4120-1095p01 1 cradle 1 n/a.
Page 472
2 4ya4129-1006g00 1 board-hook 1 n/a 6 4ya4129-1005g00 1 board-telu 1 n/a 7 1pp4120-1096p00 1 base-cradle 1 n/a 8 3pp4120-1097p00 1 cover-terminal 1 n/a 9 3pa4120-1140g00 1 attachment-assembly 1 n/a 10 4yb3512-2029g00 4 handset 1 n/a 12 4ys4111-5552p00 1 connection-cord 1 n/a 14 4ys4111-5551p00 1 mo...
Page 473
Page: 300 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 1 1pp4122-1401p00 1 plate: upper 1 51023301 2 3pa4122-1370g00 1 guide: sheet assembly 1 50222001 3 1pa4122-1369g00 1 cover: front assembly 1 53075301 4 3pa4122-1371g00 1 guide...
Page 474
6 4pp4120-1009g00 1 frame: separation (f) assembly 1 50222101 7 1pp4122-1323p00 1 cover: rear 1 53075201 8 4pb4122-1441p00 1 ground: stick finger 1 51023401 9 1pa4122-1366g00 1 frame: hopping assembly 1 50222401 10 4pp3522-3568p00 1 bearing 1 51608901 11 4pp4122-1207p00 1 gear (z70) 1 51239001 12 3p...
Page 475
32 4pp4122-1338g00 1 sheet link (r) 1 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 476
Page: 301 service manual for of5300/5600 chapter d illustrated parts list rev. No. Oki parts number description q'ty remarks 1 1pp4122-1401p00 1 plate: upper 1 51023301 2 3pa4122-1370g00 1 guide: sheet assembly 1 50222001 3 1pa4122-1369g00 1 cover: front assembly 1 53075301 4 3pa4122-1371g00 1 guide...
Page 477
5 1pa4122-1362g00 4 cassette assembly (2nd tray) 1 50107304 6 4pp4120-1009g00 1 frame: separation (f) assembly 1 50222101 7 1pp4122-1323p00 1 cover: rear 1 53075201 8 4pb4122-1441p00 1 ground: stick finger 1 51023401 9 1pa4122-1366g00 1 frame: hopping assembly 1 50222401 10 4pp3522-3568p00 1 bearing...
Page 478
31 4pp4122-1339g00 1 sheet link (l) 1 32 4pp4122-1338g00 1 sheet link (r) 1 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 479
Page: 302 service manual for of5300/5600 chapter d illustrated parts list whole unit consumables options packaging user's manuals service (technical) manuals copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to...
Page 480
Page: 303 service manual for of5300/5600 chapter d illustrated parts list okifax 5300 p/n 62209201 okifax 5600 p/n 62209301 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidat...
Page 481
Page: 304 service manual for of5300/5600 chapter d illustrated parts list kit: image drum p/n 56116901 cartridge: toner p/n 52106701 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://b...
Page 482
Page: 305 service manual for of5300/5600 chapter d illustrated parts list 1 mb fax memory expansion card p/n 70013501 2 mb fax memory expansion card p/n 70031601 okifax 5600 only 500 sheet letter/legal paper tray p/n 70029401 printer interface p/n 58241701 telephone handset p/n 70031801 copyright 19...
Page 483
Page: 306 service manual for of5300/5600 chapter d illustrated parts list box: spares kraft p/n 53552209 cap: end - left p/n 53591101 cap: end - right p/n 53591102 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any upda...
Page 484
Page: 307 service manual for of5300/5600 chapter d illustrated parts list guide: quick start guide (english only) p/n 59279001 handbook: hardware p/n 59279501 kit: pc interface p/n 58327601 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner e...
Page 485
Page: 308 service manual for of5300/5600 chapter d illustrated parts list kit: okifax 5300/5600 service training p/n 58241901 includes the items listed below: sheet: id/read me first p/n 58327301 manual: certification p/n 59278401 manual: service p/n 59278301 guide: quick start guide (english only) ...
Page 486
Page: 309 service manual for of5300/5600 chapter e board layout the boards used in the okifax 5300 and okifax 5600 are listed below. M17 (main control) board unc-5 (network control unit) power supply unit o5wh (operator panel) board s34 (modem) board modem (okifax 5600 only) ctr (pc interface) board...
Page 487
Rev. No. Oki parts number description q'ty remarks 1 40040002 cord: op panel connection 1 40041002 rspl 2 4yb4120-1026p1 speaker 1 57001701 rspl 3 3ys4111-3527p2 cable: 2nd tray connector 1 56632801 rspl 4 4ys4111-3441p1 cord: connector (c1s) 1 56634501 rspl 5 4ys4111-3442p1 cord: connector (pc1/2) ...
Page 488
9b 4yb3522-1297g1 core: ferrite 1 56634801 rspl 10 105a1051c1003 core: ferrite 1 55505303 rspl 11 40048201 connection cord-wire (psu) 1 n/a 12 40040101 connection cord-wire (spsu) 1 n/a 13 105a1062c0002 0443-167251 core 1 n/a 14 105a1068c1004 5fc-8 core 1 15 105a1070c0004 tfc-23-11-14 core 1 16 105a...
Page 489
Page: 310 service manual for of5300/5600 chapter f second paper feeder 1.1 functions 1.2 external view and component names (figure 1-1) copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http:...
Page 490
Page: 311 service manual for of5300/5600 chapter f second paper feeder when the second paper feeder is installed, the second paper feeder is connected to the facsimile by a connector. The second paper feeder supplies paper automatically through the operation of pulse motor (hopping), which is driven...
Page 491
Page: 312 service manual for of5300/5600 chapter f second paper feeder copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 492
Page: 313 service manual for of5300/5600 chapter f second paper feeder 2.1 general mechanism 2.2 hopper mechanism copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 493
Page: 314 service manual for of5300/5600 chapter f second paper feeder the second paper feeder feeds the paper into the facsimile by receiving the signal from the facsimile, which drives the pulse motor inside the second paper feeder, and this motion is transmitted to rotate the one-way clutch of th...
Page 494
Page: 315 service manual for of5300/5600 chapter f second paper feeder the hopper automatically feeds the facsimile with the paper being set, single sheet at a time. When the paper is loaded in the paper cassette, it is then transported by the pulse motor, carrying forward only a single sheet caught...
Page 495
Page: 316 service manual for of5300/5600 chapter f second paper feeder this section covers the procedures for the disassembly, reassembly and installations in the field. This section describes the disassembly procedures, and for reassembly procedures, basically proceed with the disassembly procedure...
Page 496
Page: 317 service manual for of5300/5600 chapter f second paper feeder (1) parts replacements must be carried out, by first turning the facsimile power switch off "o" and removing the facsimile from the second paper feeder. (2) do not disassemble the second paper feeder if it is operating normally. ...
Page 497
Page: 318 service manual for of5300/5600 chapter f second paper feeder this section describes the layout of the main components. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.O...
Page 498
Page: 319 service manual for of5300/5600 chapter f second paper feeder this section describes the parts replacement methods for the components listed in the disassembly order diagram below. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner e...
Page 499
Page: 320 service manual for of5300/5600 chapter f second paper feeder (1) turn the facsimile power switch off, pull out the ac cord from the outlet. Remove the facsimile from the second paper feeder. (2) take the paper cassette assy 1 out of second paper feeder. (3) remove six screws 2 and remove t...
Page 500
Assy 10. (7) remove the protect (m) 14, guide bracket 15, planet gears 16 and planet gear bracket 17. (8) remove the e-ring 18 which is keeping the sheet link 19 on the guide r (2nd) assy 10, and pull out the hinge stand 20. (9) remove three remaining screws 21 which are keeping the motor on the mot...
Page 501
Page: 321 service manual for of5300/5600 chapter f second paper feeder (1) remove the pulse motor (see 3.3.1). (2) remove the connector 25 from the tqsb-2pcb 26. (3) remove the screw 27 and remove the tqsb-2pcb 26. Note: refer to detail a in previous section (see 3.3.1). Copyright 1997, okidata, div...
Page 502
Page: 322 service manual for of5300/5600 chapter f second paper feeder (1) follow up to step (3) of 3.3.1 and remove the hopping frame assy. (2) remove the screw 1 and remove the earth plate 2. Remove the sensor lever 7 and remove the ground plate 6. Remove the gear 3 and remove the metal bush 5 and...
Page 503
Page: 323 service manual for of5300/5600 chapter f second paper feeder 4.1 precautions prior to the troubleshooting 4.2 preparations for the troubleshooting 4.3 troubleshooting method 4.3.1 lcd status message list copyright 1997, okidata, division of oki america, inc. All rights reserved. See the ok...
Page 504
Page: 324 service manual for of5300/5600 chapter f second paper feeder (1) go through the basic checking items provided in the facsimile handbook. (2) obtain detailed information concerning the problem from the user. (3) go through checking in the conditions similar to that in which the problem occu...
Page 505
Page: 325 service manual for of5300/5600 chapter f second paper feeder (1) display on the operator panel the status of the problem is displayed on the lcd (liquid crystal display) on the operator panel. Go through the appropriate troubleshooting procedures according to the messages displayed on the ...
Page 506
Page: 326 service manual for of5300/5600 chapter f second paper feeder when a problem occurs, go through the troubleshooting according to the following procedure. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updat...
Page 507
Page: 327 service manual for of5300/5600 chapter f second paper feeder table 4-1 lists the statuses and problems displayed as lcd (operator panel) messages. *1: indicates the same message on the display, when 1st or 2nd cassette becomes jam error (feeding). *2: however, if 1st cassette has recording...
Page 509
Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 510
Page: 328 service manual for of5300/5600 chapter f second paper feeder 5.1 interconnection diagram 5.2 pcb layout copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 511
Page: 329 service manual for of5300/5600 chapter f second paper feeder copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 512
Page: 330 service manual for of5300/5600 chapter f second paper feeder copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 513
Page: 331 service manual for of5300/5600 chapter f second paper feeder 1: cabinet and cassette assembly (figure 6-1) paper feeder (table 6-1) rev. No. Oki parts number description q'ty remarks 1 1pp4122-1401p00 1 plate: upper 1 51023301 2 3pa4122-1370g00 1 guide: sheet assembly 1 50222001 3 1pa4122-...
Page 514
4 3pa4122-1371g00 1 guide: inner assembly 1 50221501 5 1pa4122-1362g00 4 cassette assembly (2nd tray) 1 50107304 6 4pp4120-1009g00 1 frame: separation (f) assembly 1 50222101 7 1pp4122-1323p00 1 cover: rear 1 53075201 8 4pb4122-1441p00 1 ground: stick finger 1 51023401 9 1pa4122-1366g00 1 frame: hop...
Page 515
30 4pp4122-1398p00 2 sheet spring 1 31 4pp4122-1339g00 1 sheet link (l) 1 32 4pp4122-1338g00 1 sheet link (r) 1 2: mechanical assembly (figure 6-2) rev. No. Oki parts number description q'ty remarks 1 1pp4122-1401p00 1 plate: upper 1 51023301 2 3pa4122-1370g00 1 guide: sheet assembly 1 50222001 3 1p...
Page 516
6 4pp4120-1009g00 1 frame: separation (f) assembly 1 50222101 7 1pp4122-1323p00 1 cover: rear 1 53075201 8 4pb4122-1441p00 1 ground: stick finger 1 51023401 9 1pa4122-1366g00 1 frame: hopping assembly 1 50222401 10 4pp3522-3568p00 1 bearing 1 51608901 11 4pp4122-1207p00 1 gear (z70) 1 51239001 12 3p...
Page 517
32 4pp4122-1338g00 1 sheet link (r) 1 copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 518
Page: 332 service manual for of5300/5600 chapter g rmcs system all rmcs stands for the remote management center system. Rmcs refers to setting registration data and conducting the following types of maintenance operations from a remote location. (refer to figure 1) the purpose of this system is to s...
Page 519
Page: 333 service manual for of5300/5600 chapter g rmcs system 1.1 identifying the packaged contents 1.2 required devices 1.3 connectable peripheral equipment copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates t...
Page 520
Page: 334 service manual for of5300/5600 chapter g rmcs system before using this system, the packaged contents with the package list. Contact your dealer if any component from the package. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner ex...
Page 521
Page: 335 service manual for of5300/5600 chapter g rmcs system the following devices and software are required to operate this system. Personal computer ibm pc/at or compatible model internal memory 300kb or more extended memory 1mb or more fixed disk drive 20mb or more display cga/ega/vga type fx-0...
Page 522
Page: 336 service manual for of5300/5600 chapter g rmcs system printer mouse microsoft mouse or equivalent telephone to use a mouse, a mouse driver program is required. This program is automatically incorporated by the installation program. Copyright 1997, okidata, division of oki america, inc. All ...
Page 523
Page: 337 service manual for of5300/5600 chapter g rmcs system 2.1 mounting 2.1.1 mounting procedures 2.2 installation 2.2.1 registering the rmcs basic system 2.2.2 registering the facsimile model no. 2.2.3 deleting the facsimile model no. 2.2.4 updating the password 2.2.5 updating the dip switches ...
Page 524
Page: 338 service manual for of5300/5600 chapter g rmcs system conceptual connection diagram of rmcs with other devices this system (rmcs model 20) is used fx050 series facsimile with pc-i/f. Conceptual connection diagram of rmcs model 20 with other devices copyright 1997, okidata, division of oki a...
Page 525
Page: 339 service manual for of5300/5600 chapter g rmcs system 1) before operation, disconnect the power plug of the ibm pc/at from the system plug socket. 2) disconnect the power plug of fx050 series facsimile, too and set pc-i/f board to the facsimile. 3) connect rs232c cable between com. Port of ...
Page 526
Page: 340 service manual for of5300/5600 chapter g rmcs system when the pc/at is activated by using the hard disk, insert an rmcs system disk into drive a. When c>_ is displayed, enter commands as shown below to activate the installation program. C> a:[enter] a> inst[enter] select processing with th...
Page 527
Page: 341 service manual for of5300/5600 chapter g rmcs system the flow of new registration is different from that of updating. First, the flow of new registration is described below. 1) enter the drive no. Used to register the system. 2) enter the directory name with up to eight alphanumeric charac...
Page 528
Defined, password registration not required. 4) when you use rmcs model 10, set the dip switches on the rmcs card. Normally, you need only press [enter]. When an other extension slot and conflicting address space are being used, change the address space with the dip switches, then set the contents b...
Page 529
6) when updating, enter [y]. Then updating status. When not updating, enter [n]. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business partner exchange (bpx) for any updates to this material. (http://bpx.Okidata.Com).
Page 530
Page: 342 service manual for of5300/5600 chapter g rmcs system 1) search the directory in which the system is registered. When the system is found, register the model number. 2) insert a disk corresponding to the model into drive a, then press any key. The model number is displayed and the confirmat...
Page 531
Page: 343 service manual for of5300/5600 chapter g rmcs system 1) search the directory in which the system is registered. When the system is found, a list of registered models is displayed. 2) select the model number to be deleted. This number is then displayed in inverse video. The confirmation scr...
Page 532
Page: 344 service manual for of5300/5600 chapter g rmcs system 1) search the directory in which the system is registered. When the system is found, the old password is displayed on the screen requesting entry of a new password is displayed. 2) register a new password of up to 15 alphanumeric charact...
Page 533
Page: 345 service manual for of5300/5600 chapter g rmcs system this setting is available for only rmcs model 10. 1) search the directory in which the system is registered. When the system is found, the dip switch setting is displayed. For the detail of setting, refer to 2.2.1. After setting is compl...
Page 534
Page: 346 service manual for of5300/5600 chapter g rmcs system 1) when to delete, enter [y], then whole rmcs system is deleted. When not to delete, enter [n]. Then the installation menu appears. Copyright 1997, okidata, division of oki america, inc. All rights reserved. See the okidata business part...
Page 535
Page: 347 service manual for of5300/5600 chapter g rmcs system 3.1 activating and terminating the system 3.1.1 to activate 3.1.2 entering the id and password 3.2 tel directory 3.2.1 to terminate 3.2.2 selecting destination drive 3.3 main menu 3.4 environment setting copyright 1997, okidata, division...
Page 536
Page: 348 service manual for of5300/5600 chapter g rmcs system before activating the system if the facsimile terminal is equipped with a selector function to "enable" or "unable" remote maintenance, set to "enable" in advance. Copyright 1997, okidata, division of oki america, inc. All rights reserve...
Page 537
Page: 349 service manual for of5300/5600 chapter g rmcs system enter the following command in the pc-dos command input state. C>rmcs after completing the necessary preparations, the id and password entry screen is displayed. Copyright 1997, okidata, division of oki america, inc. All rights reserved....
Page 538
Page: 350 service manual for of5300/5600 chapter g rmcs system the id is recorded in the operation report as part of the system operator history. Enter up to 50 alphanumeric characters except ["], [\] for the id. Enter the password registered at installation. When the correct password is entered. Te...
Page 539
Page: 351 service manual for of5300/5600 chapter g rmcs system you can select such services (items) registration and deletion of information related to users. We describe the detail of each service later. There are two ways to specify an item: select by using the up arrow key and the down arrow key,...
Page 540
Page: 352 service manual for of5300/5600 chapter g rmcs system to terminate this system select "terminate" on tel directory menu screen or the main menu screen to return to pc-dos. Caution: after terminating remote management, restore the original facsimile terminal setting. (see to "unable" remote ...
Page 541
Page: 353 service manual for of5300/5600 chapter g rmcs system now, select the destination drive. Press [space] to change the drive name. Select "terminate" to stop processing and return to the tel directory menu screen. Select "execute" to copy user information between the drives and return to the ...
Page 542
Page: 354 service manual for of5300/5600 chapter g rmcs system the main menu screen varies according to fax models. For further operation, refer to each fax model manual. There are two ways to specify an item: select by using the [up arrow] and [down arrow] keys, then press [enter] or enter the numb...
Page 543
Page: 355 service manual for of5300/5600 chapter g rmcs system selecting "environment setting" on the main menu to display this screen. Communication port setting: select communication port to connect the ibm pc/at and pc-i/f. Frame size setting: select a frame size for each frame to transfer tel nu...
Page 544
Page: 356 service manual for of5300/5600 chapter g rmcs system 4.1 activating the program 4.2 modifying message 4.2.1 file selection 4.3 saving message 4.3.1 confirmation 4.4 loading message 4.4.1 confirmation 4.5 other message file copyright 1997, okidata, division of oki america, inc. All rights r...
Page 545
Page: 357 service manual for of5300/5600 chapter g rmcs system after activating the pc/at with a hard disk, insert the rmcs system disk into drive a. When c>_ is displayed, enter the following commands to activate the program. C>a:[enter] a> scrned [enter] then the screen for menu selection is displ...
Page 546
Page: 358 service manual for of5300/5600 chapter g rmcs system file selection: select "message modify" on the menu screen, then the following screen is displayed. Enter the key no. Indicated on the left of the model to modify. Then the screen for file selection is displayed. Press [page up] or [page...
Page 547
Page: 359 service manual for of5300/5600 chapter g rmcs system select the message title to modify. Select the position with [up arrow key], [down arrow key], [] keys, and press the [enter] key, then the position is selected. Press [page up] or [page down] to scroll the screen back to the previous pa...
Page 548
Page: 360 service manual for of5300/5600 chapter g rmcs system model selection: select "message save" on the menu screen. Then the following screen is displayed. Enter the key number indicated on the left side of the model with messages to store. Press [page up] or [page down] to scroll the screen b...
Page 549
Page: 361 service manual for of5300/5600 chapter g rmcs system select a drive with the [space] key. Since it is assumed that data is stored on a floppy disk, you can select drive a or drive b. When setup is ready, insert a formatted floppy into the drive and press the [enter] key, then saving is ini...
Page 550
Page: 362 service manual for of5300/5600 chapter g rmcs system model selection: select "message load" on the menu screen, the following screen is displayed. Enter the key number indicated on the left side of the model with a message reset. Press [page up] or [page down] to scroll the screen back to ...
Page 551
Page: 363 service manual for of5300/5600 chapter g rmcs system select a drive with the [space] key. It is assumed that a message is loaded on the machine from the floppy disk, you can select drive a or drive b. When setup is ready, insert a floppy disk which stores the message into the drive and pre...
Page 552
Page: 364 service manual for of5300/5600 chapter g rmcs system in addition to the "scrn oooo. Lx" file, the following message files are available. Rmcs system err_mess. Tx error message text rms_env. Tx operator id text sc oooo p. Tx printing screen text u_print. Tx printing text rms_env2. Tx new us...
Page 553
Page: 365 service manual for of5300/5600 chapter h product service bulletins okidata's product service bulletins contain technical information obtained after product release. Firmware updates, part number changes, and procedural changes are some of the subjects covered by these bulletins. The produc...
Page 554
Page: 366 service manual for of5300/5600 chapter h product service bulletins okidata's web site provides easy access to okidata's product and service information. The business partner exchange (bpx) provides dealer-only information to okidata's sales and service providers. The information covers all...
Page 555
Page: 367 service manual for of5300/5600 chapter h product service bulletins okidata's faxable facts is an automated fax document retrieval system. It is maintained by okidata's customer service and support group. A wide variety of information is available through faxable facts. It is frequently upd...
Page 556
Page: 368 service manual for of5300/5600 chapter h product service bulletins okilink ii is okidata's bulletin board service. This service is available to all okidata certified service technicians. Okilink ii provides additional troubleshooting and service information. Technicians can download files,...
Page 557
Page: 369 service manual for of5300/5600 chapter i recommended spare parts list (rspl) recommended spare parts lists (rspl's) contain the current part numbers, descriptions, pricing, and stocking information for okidata product spare parts. The recommended spare parts lists are distributed via okida...
Page 558
Page: 370 service manual for of5300/5600 chapter i recommended spare parts list (rspl) okidata's web site provides easy access to okidata's product and service information. The business partner exchange (bpx) provides dealer-only information to okidata's sales and service providers. The information ...
Page 559
Page: 371 service manual for of5300/5600 chapter i recommended spare parts list (rspl) okidata's faxable facts is an automated fax document retrieval system. It is maintained by okidata's customer service and support group. A wide variety of information is available through faxable facts. It is freq...
Page 560
Page: 372 service manual for of5300/5600 chapter i recommended spare parts list (rspl) okilink ii is okidata's bulletin board service. This service is available to all okidata certified service technicians. Okilink ii provides additional troubleshooting and service information. Technicians can downl...