1. DL manuals
  2. PACIFIC CYCLE
  3. Bicycle
  4. SCHWINN STINGRAY ELECTRIC
  5. Manual

PACIFIC CYCLE SCHWINN STINGRAY ELECTRIC Manual

Summary of SCHWINN STINGRAY ELECTRIC

  • Page 1

    Schwinn stingray electric manufactured for pacific cycle, inc. (a division of dorel industries) pacific cycle, inc. 4902 hammersley road madison, wi 53711 800-666-8813 www.Schwinnstingray.Com customer service/warranty • 877-741-6154 • service@pacific-cycle.Com © 2005 pacific cycle, inc. Made in chin...

  • Page 2: Table Of Contents

    Introduction .................................................................. 03-04 service and repairs ..........................................................05 charge the battery ...................................................... 06-07 safety rules ...........................................

  • Page 3: Warning

    Warning for the safety of your child, read all warnings and assembly/use instructions. Keep this guide for future reference. • severe injury or death can result if you do not follow the instructions in this manual. • adult assembly required. The product contains small parts, which are for adult asse...

  • Page 4: Keep This Manual

    Keep this manual this manual should be considered a permanent part of the vehicle and should remain with the vehicle when resold or otherwise transferred to a new owner or operator. The manual contains important safety information and instructions which should be read carefully before operating the ...

  • Page 5: Service And Repairs

    Write the serial number of your stingray electric here for future reference. When speaking to customer service, you will need to provide the model number (xxxx) and the serial number, found on the front of the frame. Model number _______________________________ serial number ________________________...

  • Page 6: Warning

    Warning • only adults may charge battery. Never allow a child to charge battery. Serious injury could occur. • do not charge battery if you see wear or damage to the battery, connections and wires, charger and its supply cord. • do not allow battery to drain completely. Permanent damage to battery c...

  • Page 7: Warning

    Warning • only adults may charge battery. Never allow a child to charge battery. Serious injury could occur. • do not charge battery if you see wear or damage to the battery, connections and wires, charger and its supply cord. • do not allow battery to drain completely. Permanent damage to battery c...

  • Page 8: Warning

    Warning severe injury or death can result if you do not follow the instructions in this manual. • age range for use:10 to 16 years of age. Do not allow children younger than 10 years of age to operate the stingray electric. • maximum loading: 200 lbs. Never exceed maximum load capacity for the sting...

  • Page 9

    • never attempt wheelies, jumps or other stunts. • always inspect the stingray electric each time it is used to make sure it is in safe operating condition. Refer to "before every ride" and "care and maintenance" sections in this manual. • always keep both hands on handlebars and both feel on footre...

  • Page 10

    • always use caution going down hills. Always use caution when braking while going down hills. Check terrain carefully before you start down any hill. Always shift weight backward. Never go down a hill at the fast speed. Do not go down a hill at an angle that would cause the vehicle to lean sharply ...

  • Page 11

    Get to know your stingray electric 11 throttle brake levers fuse holder battery box motor.

  • Page 12

    Throttle the throttle is on the right handlebar. Turn throttle forward to make the stingray electric go forward. Brakes the brakes are attached to the handlebars. Squeeze the brake levers to slow or stop the stingray electric as necessary. Squeeze front and rear brake levers evenly. Battery light th...

  • Page 13: Before Every Ride

    • an adult should always perform the following checklist before every ride, for the safety of your child and to keep the stingray electric in good working order. • if you find any damaged or worn parts, do not use the stingray electric. Refer to "service and repairs" on page 5 to order new parts or ...

  • Page 14: Cleaning

    Your stingray electric will provide years of fun, if properly cared for and maintained. If you find damaged or worn parts, do not use the stingray electric. Refer to "service and repairs" on page 5 to order new parts or find an authorized repair center. Cleaning keep your stingray electric clean so ...

  • Page 15: Tire Maintenance

    Tire maintenance • to inflate a tire, remove cap from the valve stem and set aside. Attach bicycle pump and inflate to 30 psi. Do not over-inflate tire. Replace valve stem cap. • check nuts on each wheel, and make sure they are tight. • inspect rims. If they are cracked or bent, they must be replace...

  • Page 16: Brake Lever

    Brake lever warning • never allow the stingray electric to be used if the brake lever is not functioning properly. • the brake lever may become loose over time. Tighten screw nut connecting brake cable to brake lever. • squeeze brake lever and make sure the stingray electric cannot be pushed forward...

  • Page 17: Batteries

    Batteries read all warnings about battery safety. Only adults may recharge or handle batteries. • the stingray electric uses two 12-volt batteries to supply power to a 250-watt motor. • recharge batteries after each use. When batteries are fully charged, three lights on the stingray electric throttl...

  • Page 18: Replacing The Batteries

    Replacing the batteries only adults may replace the batteries • replace the batteries with genuine schwinn parts. Do not use another brand, as this may void your warranty. Refer to "service and repairs" on page 5 to order parts or to find an authorized repair center. •turn off, and unplug battery ca...

  • Page 19: Troubleshooting

    Problem the stingray electric does not run. Probable cause • batteries are low • batteries are dead • fuse has blown • wires are loose • electrical system has been damaged by water. Dirt or sand has jammed the switch. • motor is damaged. What to do • recharge the batteries • replace the batteries. S...

  • Page 20

    Problem batteries will not recharge the stingray electric does not run very long. The brake is too tight or too loose. When applying the throttle, it's either too sluggish or too sensitive. Probable cause • charging plug is not plugged in all the way into the charging outlet of the stingray electric...

  • Page 21

    Problem stingray electric runs sluggishly. Probable cause • batteries need recharging. • batteries are old. • stingray electric is overloaded. What to do • recharge batteries. See page 7. • replace batteries. See page 18. • maximum weight: 200 lbs. Reduce weight on stingray electric. Do not tow anyt...

  • Page 22: 90 Day Warranty

    Limited warranty - please save your original sales receipt the express limited warranty as contained herein is exclusive and in lieu of all other warranties, express or implied, including implied warranties of merchant ability and fitness for a particular purpose. There are no warranties that extend...