- DL manuals
- PS Engineering
- Receiver
- 6000
- Installation And Operation Manual
PS Engineering 6000 Installation And Operation Manual
9800 Martel Road
Lenoir City, TN 37772
www.ps-engineering.com
PMA6000
PMA6000M
PMA6000C
PMA6000M-C
Audio Selector Panel with Intercom System
and
Marker Beacon Receiver
Installation and Operation Manual
Flying never sounded so good™
FAA-Approved
TSO C35d
TSO C50c
Document P/N 200-066-0100
Revision 1, March 2005
PS Engineering, Inc. 2005 ©
Copyright Notice
Any reproduction or retransmittal of this publication, or any portion thereof, without the expressed written
permission of PS Engineering, Inc. is strictly prohibited. For further information contact the Publications
Manager at PS Engineering, Inc., 9800 Martel Road, Lenoir City, TN 37772. Phone (865) 988-9800
Summary of 6000
Page 1
9800 martel road lenoir city, tn 37772 www.Ps-engineering.Com pma6000 pma6000m pma6000c pma6000m-c audio selector panel with intercom system and marker beacon receiver installation and operation manual flying never sounded so good™ faa-approved tso c35d tso c50c document p/n 200-066-0100 revision 1,...
Page 2
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page ii rev. 1, march 2005 table of contents section i general information................................................................................................ 1-1 1.1 introduction........
Page 3
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page iii rev. 1, march 2005 3.5 split mode (6000c, 6000mc) ................................................................................................. 3-2 3.6 intercom .........................
Page 4
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 1-1 rev. 1, march 2005 section i general information 1.1 introduction the pma6000 family of audio selector panels are revolutionary products. Never before has there been so much capability an...
Page 5
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 1-2 rev. 1, march 2005 figure 1-1 pma6000m figure 1-2 pma6000m-c 1.4 approval basis - faa tso approval. The pma6000, pma6000c and audio selector panels are faa approved under tso c50c (audio ...
Page 6
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 1-3 rev. 1, march 2005 unswitched inputs: 2 (tel ringer, altimeter dh) transmitter selections: 5 (com 1, com 2, com1/2, com2/1, tel/com1) on pma6000, , pma6000m (com 1, com 2, com1/2, com2/1,...
Page 7
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 1-4 rev. 1, march 2005 1.7 equipment required but not supplied a. Speaker, 4 Ω b. Headphones, mono, up to 6 as required c. Microphones, up to 6 as required d. Marker antenna (75 mhz, vswr e. ...
Page 8
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 2-1 rev. 1, march 2005 section ii -installation 2.1 general information 2.1.1 scope this section provides detailed installation and interconnect instructions for the ps engineering pma6000- s...
Page 9
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 2-2 rev. 1, march 2005 2.3.2 mounting requirements the pma6000 must be rigidly mounted to the instrument panel of the aircraft structure and within view and reach of the pilot position(s). In...
Page 10
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 2-3 rev. 1, march 2005 radiated signals can be a factor when low level microphone signals are "bundled" with current carrying power wires. Keep these cables physically separated. It is very i...
Page 11
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 2-4 rev. 1, march 2005 case i: ptt is built into both pilot and copilot yokes. Case ii: ptt is in pilot yoke only. This configuration requires a modified external ptt switch plugged into the ...
Page 12
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 2-5 rev. 1, march 2005 2.4.9 speaker loads certain vhf nav/comms, such as king kx170-series have internal speaker amplifiers. These are not used with a pma6000, but must be loaded to prevent ...
Page 13
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 2-6 rev. 1, march 2005 a radio signal of more than 1 vrms is needed to trigger the irs. Therefore, if the irs does not seem to be recording, increase the aircraft radio volume slightly. 2.5 a...
Page 14
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 2-7 rev. 1, march 2005 w a r n i n g : d o n o t o v e r - t i g h t e n t h e l o c k d o w n s c r e w w h i l e i n s t a l l i n g t h e u n i t i n t r a y . Internal damage will result....
Page 15
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 2-8 rev. 1, march 2005 2.9.4 operational checkout, 3 rd com version (6000c and 6000m-c) 1. Complete steps 1 to 10, above. 2. Rotate the mic selector switch to the c om 3 position. Verify that...
Page 16
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 3-1 rev. 1, march 2005 section iii operation general information 3.1 scope this section provides detailed operating instructions for the ps engineering pma6000, pma6000m, pma6000c, and pma600...
Page 17
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 3-2 rev. 1, march 2005 the person who presses their push to talk (ptt), will be heard over the aircraft radio. Turning the rotary switch to the c om 2 position will place pilot and copilot on...
Page 18
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 3-3 rev. 1, march 2005 3.6 intercom 3.6.1 volume control (6000, 6000m, 6000c, 6000mc) the pilot volume control knob adjusts the loudness of intercom and music in the pilot’s headphones only. ...
Page 19
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 3-4 rev. 1, march 2005 3.6.3.2 entertainment input the audio selector panel has provisions for up to two separate entertainment input devices. Which device is heard is determined by the posit...
Page 20
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 3-5 rev. 1, march 2005 the recorder function is automatic. Pressing the momentary switch will cause the last message to play (in- coming radio and transmit sidetone). This will be heard in th...
Page 21
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 3-6 rev. 1, march 2005 the need for the avionics shop to reduce the sensitivity in the field so as to prevent early detection of the marker beacons. If your particular installation requires m...
Page 22
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 page 4-1 rev. 1, march 2005 section iv- warranty and service 4.1 warranty in order for the factory warranty to be valid, the installations in a certified aircraft must be accomplished by an faa- c...
Page 23
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0004 appendix a rev. 4, april 2002 appendix a external ptt hook up part of the installation includes the installation of ptt (push to talk) switches that allow the use of your aircraft radio for commun...
Page 24
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 appendix b rev. 1, march 2005 appendix b- installation drawing 1.31 in in (33.27 mm) 0.60 in in (15.25 mm) 0.35 in in (8.9 mm) 5.25 in in (133.4 mm) 0.8 in in (20.3 mm) 6.31in (160.3 mm) cutout si...
Page 25
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 appendix c rev. 1, march 2005 appendix c bottom connector wiring, (see note 9) com 1 audio hi com 1 mic key com 1 lo communications transceiver #1 communications transceiver #2 nav 1 audio hi nav ...
Page 26
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 appendix d rev. 1, march 2005 appendix d top connector wiring (mono), pma6000, pma6000c, pma6000m, pma6000m-c 11 5 e 4 d notes: 1 a 6 f 7 h 8 j 2 b n 12 top connector pma6000 (monaural) swap switc...
Page 27
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 appendix e rev. 1, march 2005 appendix f -instructions for continuing airworthiness and faa form 337 sample ica checklist for ps engineering audio panels: section item information 1 introduction i...
Page 28
Ps engineering pma6000 series audio selector panel and intercom system installation manual 200-066-0100 appendix f rev. 1, march 2005 appendix g rtca do160b environmental qualification form audio selector panel/intercom/marker beacon receiver part number: 6000, 6000m, 6000mc faa tso number: c50c, c3...