1. DL manuals
  2. PS Engineering
  3. Intercom System
  4. PM1000II
  5. Operator And Installation Manual

PS Engineering PM1000II Operator And Installation Manual

Other manuals for PM1000II: Operator And Installation Manual
Manual is about: 4-Place, Panel Mounted Intercom

Summary of PM1000II

  • Page 1

    Revision 7, may 2015 page 1 200-123-0003 pm1000ii faa-approved 4-place, panel mounted intercom operator's and installation manual part number 11920 (with crew) and 11922 (without crew) faa-tso c50c ps e ngineering , i ncorporated 9800 martel road lenoir city, tn 37772 phone (865) 988-9800 fax (865) ...

  • Page 2

    Pm1000ii operation/installation manual page 2 revision 7, may 2015 section i general information 1.1 introduction the pm1000ii, is an faa-tso approved, panel mounted, 4-place intercom system (ics). Please read this manual completely before installation to minimize the risk of damage to the unit and ...

  • Page 3

    Revision 7, may 2015 page 3 200-123-0003 1.7 license requirements none section 2 installation 2.1 general information the pm1000ii comes with all necessary hardware for installation. Installation of the pm1000ii, using the available wir- ing and hardware supplied, does not require special tools or k...

  • Page 4

    Pm1000ii operation/installation manual page 4 revision 7, may 2015 2.4.1 electrical noise issues warning: you must use separate shielded cables for the microphone and headphone jacks. Combining these two wires will cause loud oscillations and de- grade the intercom function. The oscillation is cause...

  • Page 5

    Revision 7, may 2015 page 5 200-123-0003 failure to do so will cause internal damage and void ps engineering's warranty. 1.Apply power to the aircraft and avionics. 2.Plug headsets into the pilot, copilot and passen- ger positions. 3.Verify that the pilot position can transmit and receive with the p...

  • Page 6

    Pm1000ii operation/installation manual page 6 revision 7, may 2015 not apply to you. 4.2 factory service the pm1000ii is covered by a one-year limited war- ranty. See warranty information. The unit is covered by a one-year limited warranty. See warranty information. Call ps engineering, inc. At (865...

  • Page 7

    Revision 7, may 2015 page 7 200-123-0003 appendix c instructions for continuing air- worthiness the pm1000ii is considered an “on-condition” main- tenance item. It is checked prior to each flight during normal operation. There are no additional considera- tions for continuing airworthiness other tha...

  • Page 8

    Pm1000ii operation/installation manual page 8 revision 7, may 2015 11920 connector layout, viewed from rear 1a 11-33 vdc 14 1 11920 sub-d db-25 female (sockets) on unit to aircraft radio phone hi 17 4 power in ground a/c radio phone audio hi a/c radio phone audio lo 18 5 pilot phone audio hi pilot p...

  • Page 9

    Revision 7, may 2015 page 9 200-123-0003 monaural headset jack details 1a 11-33 vdc 14 1 11922 sub-d db-25-- unit has female (socket) to aircraft radio phone hi 17 4 power in ground a/c radio phone audio hi a/c radio phone audio lo 18 5 pilot phone audio hi pilot phone audio lo copilot phones passen...