1. DL manuals
  2. PS Engineering
  3. Intercom System
  4. PMA7000M-S
  5. Installation And Operation Manual

PS Engineering PMA7000M-S Installation And Operation Manual

Manual is about: High-fidelity Stereo Audio Selector Panel

Summary of PMA7000M-S

  • Page 1

    9800 martel road lenoir city, tn 37772 pma7000s pma7000m-s with options document p/n 200-070-0006 revision 6, nov 1998 faa-approved tso c50c, c35d high-fidelity stereo audio selector panel intercom system installation and operation manual ps engineering, inc. 1998 © copyright notice any reproduction...

  • Page 2

    Table of contents 1 section i general information ..................................................................... 1-1 1.1 introduction ..................................................................................................... 1-1 1.2 scope ..............................................

  • Page 3

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page ii rev 5, nov 98 2.10 p ost i nstallation c heckout ........................................................................... 2-12 2.11 u nit i nstallation ..................

  • Page 4

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 1-1 rev. 6, nov 98 1 section i general information 1.1 introduction the pma7000m-s represents the next step in cockpit audio control and intercommunica- tions. Using proprie...

  • Page 5

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 1-2 rev. 6, nov 98 allows the user to listen to the receiver(s) selected on the cabin speaker. Except for the unswitched inputs, all speaker audio is muted during transmit. ...

  • Page 6

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 1-3 rev. 6, nov 98 operation is subject to the following conditions: this device may not cause harmful interference. This device must accept any interference received, inclu...

  • Page 7

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 1-4 rev. 6, nov 98 intercom specifications intercom positions: 6 places (with individual intellivox circuits) music inputs: 2 (stereo) music muting: >-50 db "soft mute" when...

  • Page 8

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-1 rev. 6, nov 98 2 section ii - installation 2.1 general information 2.1.1 scope this section provides detailed installation and interconnect instructions for the ps engi-...

  • Page 9

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-2 rev. 6, nov 98 2.3 equipment installation procedures 2.3.1 cooling requirements forced air cooling of the pma7000m-s is not required. However the unit should be kept awa...

  • Page 10

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-3 rev. 6, nov 98 2.4.1 noise due to the variety and the high power of radio equipment often found in today's general aviation aircraft, there is a potential for both radia...

  • Page 11

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-4 rev. 6, nov 98 2.4.3.1 stereo pma7000m-s installations into monaural pma6000, pma6000m. Installations replacing pma6000 or pma6000m require re-wiring of the top connecto...

  • Page 12

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-5 rev. 6, nov 98 craft avionics dimmer. Connect the dimmer control line to j1 pin d for 14 volt systems, and to j1 pin f for 28 volt systems. Pin e is light ground. If an ...

  • Page 13

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-6 rev. 6, nov 98 system incorporates a "soft mute" system. This will mute the entertainment devices dur- ing ics or radio conversation. Any signal appearing in the unswitc...

  • Page 14

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-7 rev. 6, nov 98 2.4.14 irs installation (option 1, and 2) to install the irs, a momentary push button switch is required. This switch can be located any where in cockpit ...

  • Page 15

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-8 rev. 6, nov 98 2.5.2 external marker lights (7000ms) for installations that require external marker beacon lights, there are three outputs that can drive 12-volt lamps o...

  • Page 16

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-9 rev. 6, nov 98 ac 43.13-2a, aircraft manufacturers’ recommendations and faa-approved technical data. Warning: it is probable that radio interference will occur in the sp...

  • Page 17

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-10 rev. 6, nov 98 pma7000m-s j2, pin m is the passenger hook switch. Install a spst switch in a location adjacent to each passenger headset where cellphone use is desired....

  • Page 18

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-11 rev. 6, nov 98 2.9 pma7000m-s pin assignments pilot phone audio hi (left) copilot phone audio (lt) copilot phone audio lo copilot phone audio (rt) pass 1 mic audio hi p...

  • Page 19

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-12 rev. 6, nov 98 2.10 post installation checkout after wiring is complete, verify power is only on pin 20 of the j1 (bottom connector), and airframe ground on bottom conn...

  • Page 20

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-13 rev. 6, nov 98 15. Verify that the audio selector panel system does not adversely affect any other aircraft system by systematically switching the unit on and off, whil...

  • Page 21

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 2-14 rev. 6, nov 98 2.14 digital annunciation checkout if interfaced with an annunciation system, verify that all alert messages play at the appro- priate time, and that the...

  • Page 22

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0004 page 3-1 rev. 4, oct.200-070-0006 page 3-1 3 section iii operation general information 3.1 scope this section provides detailed operating instructions for the ps engineering pma7...

  • Page 23

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0004 page 3-2 rev. 4, oct.200-070-0006 page 3-2 tons is pressed, it will stay in the "in" position. Press the switch again and it be in the "out" position and remove that receiver fro...

  • Page 24

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0004 page 3-3 rev. 4, oct.200-070-0006 page 3-3 system, such as the trimble 3100 d. Placing the mic selector in tel placed the pilot mi- crophone and headphones on the cellphone. The ...

  • Page 25

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0004 page 3-4 rev. 4, oct.200-070-0006 page 3-4 3.6 intercom 3.6.1 intellivox™ vox-squelch no adjustment of the intellivox™ squelch control is necessary. Through three individual sign...

  • Page 26

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0004 page 3-5 rev. 4, oct.200-070-0006 page 3-5 can be adjusted at the headset. If desired, passenger volume level can be adjusted by a screwdriver adjustment at the top of the tray (...

  • Page 27

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0004 page 3-6 rev. 4, oct.200-070-0006 page 3-6 when in the a ll mode, pilot and copilot will hear entertainment 1 input while all passen- gers will hear the entertainment 2 source. W...

  • Page 28

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0004 page 3-7 rev. 4, oct.200-070-0006 page 3-7 on the phone. All will hear selected audio. Com 1 audio is automatically heard in the head- sets. The pilot will have transmit capabili...

  • Page 29

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0004 page 3-8 rev. 4, oct.200-070-0006 page 3-8 operating as a continuous loop recorder, (first message received will be the last heard), the recorder has one minute of recording time...

  • Page 30

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 page 4-1 rev. 6, nov 98 4 section iv- warranty and service 4.1 warranty in order for the factory warranty to be valid, the installations in a certified aircraft must be accomplis...

  • Page 31

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 appendix a rev. 6, nov 98 5 appendix a external ptt hook up part of the installation includes the installation of ptt (push to talk) switches that allow the use of your aircraft ...

  • Page 32

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 appendix b rev. 6, nov 98 6 appendix b – installation drawing 1.31 in (33.27 mm) 0.60 in (15.25 mm) 0.35 in (8.9 mm) 5.25 in (133.4 mm) 0.8 in (20.3 mm) 6.31in (160.3 mm) cutout ...

  • Page 33

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0001 appendix c rev. 1, july 98 7 appendix c bottom connector interconnect com 1 audio hi com 1 mic key com 1 lo communications transceiver #1 communications transceiver #2 nav 1 audi...

  • Page 34

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 appendix e rev. 6, nov 98 8 appendix d top connector interconnect u 19 10 w 20 x 21 y 22 z 1 4 d 16 15 t a rev date: sheet of title: document number: size pma7000 top connector w...

  • Page 35

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0003 appendix f rev. 3, sept. 98 9 appendix e- instructions for faa form 337 and continuing airworthiness 9.1 instructions for faa form 337, audio panels one method of airworthiness a...

  • Page 36

    Ps engineering pma7000m-s series audio selector panel and intercom system installation and operator’s manual 200-070-0006 appendix f rev. 6, nov 98 10 appendix f rtca do160c environmental qualification form audio selector panel/intercom/marker beacon receiver part number: 7000s; 7000m-s faa tso numb...