- DL manuals
- PS Engineering
- Intercom System
- PMA8000-SR
- Owner's Manual
PS Engineering PMA8000-SR Owner's Manual
9800 Martel Road
Lenoir City, TN 37772
www.ps-engineering.com
P
P
M
M
A
A
8
8
0
0
0
0
0
0
-
-
S
S
R
R
Audio Selector Panel with Marker Beacon Receiver
High-fidelity Stereo Intercom with integrated SIRIUS Satellite Radio
System Installation and Operation Manual
FAA-Approved TSO C50c, C35d
Patented under one or more of the following;
No. 5,903,227; 6,160,496 and 6,493,450
Document P/N 200-880-0000
Revision 15, June 2009
PS Engineering, Inc. 2009 ©
Copyright Notice
Any reproduction or retransmittal of this publication, or any portion thereof, without the expressed written permission of PS
Engineering, Inc. is strictly prohibited. For further information contact the Publications Manager at PS Engineering, Inc., 9800
Martel Road, Lenoir City, TN 37772. Phone (865) 988-9800, email contact@ps-engineering.com.
In certified aircraft, warranty is not valid unless this product is installed by an
Authorized PS Engineering dealer.
Summary of PMA8000-SR
Page 1
9800 martel road lenoir city, tn 37772 www.Ps-engineering.Com p p m m a a 8 8 0 0 0 0 0 0 - - s s r r audio selector panel with marker beacon receiver high-fidelity stereo intercom with integrated sirius satellite radio system installation and operation manual faa-approved tso c50c, c35d patented un...
Page 2
Table of contents section i general information ........................................................................................ 1-1 1.1 introduction ........................................................................................................................... 1-1 1.2 scope........
Page 3
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page ii rev. 14, oct. 2008 2.11 tel c heckout ........................................................................................................................... 2-14 2.1...
Page 4
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 1-1 rev. 14, oct. 2008 section i general information 1.1 introduction the pma8000-sr represents another evolutionary step in cockpit audio control and intercommunications ut...
Page 5
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 1-2 rev. 14, oct. 2008 controls the intercom level for the pilot and copilot, while the large knob controls the passenger intercom volume. Intercom squelch is automatic. The...
Page 6
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 1-3 rev. 14, oct. 2008 audio selector specifications audio selector panel input impedance: 510 Ω input isolation: -60 db (min.) speaker muting: -60 db (min.) speaker output ...
Page 7
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 1-4 rev. 14, oct. 2008 1.6 equipment supplied 1 ea. Of the following units: model description part number pma8000-sr pma8000-sr audio panel with marker beacon and stereo int...
Page 8
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 1-5 rev. 14, oct. 2008 when you activate online you pay only $5.00 at www.Sirius.Com . If you choose to activate by phone the charge is $15. You can either call 1.888.539.Si...
Page 9
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-1 rev. 14, oct. 2008 section ii - installation 2.1 general information 2.1.1 scope this section provides detailed installation and interconnection instructions for the ps ...
Page 10
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-2 rev. 14, oct. 2008 2.3.3 audio panel mounting rack installation remove the unit from the mounting tray by unscrewing the 3/32" hex-head screw that is in the center of th...
Page 11
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-3 rev. 14, oct. 2008 radiated signals can be a factor when low level microphone signals are "bundled" with current carrying power wires. Keep these cables physically separ...
Page 12
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-4 rev. 14, oct. 2008 connect the speaker output from the unit to the com 2 speaker load input on the pma8000-sr (j1 27 wrt 28). The speaker load is 16 Ω, 3w. 2.4.6 tel (du...
Page 13
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-5 rev. 14, oct. 2008 lighting system to work. The photocell mounted in the unit face will automatically adjust the intensity of the push-button annunciation leds. 2.4.10 u...
Page 14
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-6 rev. 14, oct. 2008 this pin can also be used to control passenger karaoke mode, by connecting to pin 13 of the j2, or as a pa cockpit/cabin speaker relay control, as lon...
Page 15
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-7 rev. 14, oct. 2008 to change the internal distribution: remove the top cover by removing 9 screws from the top cover. Lo- cate the jumper strip near the j2 connector. Re...
Page 16
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-8 rev. 14, oct. 2008 alternate music interconnect a 3-position (on-off-on) can be used to switch entertainment completely off, if desired. External #2 input 24 23 25 27 26...
Page 17
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-9 rev. 14, oct. 2008 . Alternate music interconnect using pav80 to control the satellite radio ent. #1 input (l) 24 23 25 27 26 28 30 29 10 sr output (r) sr output (l) ent...
Page 18
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-10 rev. 14, oct. 2008 2.4.19 playback button installation (j2, pin 22- option 1, only) to activate the recording system playback, a momentary push button switch is require...
Page 19
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-11 rev. 14, oct. 2008 mkr vol mkr sns figure 2-6 top cover adjustments • marker beacon volume, turn adjustment counterclockwise to increase marker beacon audio level. • ma...
Page 20
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-12 rev. 14, oct. 2008 2.8 pma8000-sr pin assignments j1 function j2 function 1 mkr ant 1 pilot phones lo 2 mkr ant lo 2 copilot phones lo 3 telephone audio in 3 copilot ph...
Page 21
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-13 rev. 14, oct. 2008 2.9 post installation checkout after wiring is complete, verify power is only on pins 8 and 9 of the j2 and airframe ground on connec- tor pins 10 an...
Page 22
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-14 rev. 14, oct. 2008 13. Push the spr button. Verify that all selected audio is heard in the cockpit speaker. Verify that the au- dio mutes when the mic is keyed. 14. Ver...
Page 23
Ps engineering pma8000-sr series audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 2-15 rev. 14, oct. 2008 2.12.2 sirius satellite radio id number the sirius satellite radio identification number can be played back through the annunciation. Have a pencil h...
Page 24
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 3-1 rev. 14, oct. 2008 section iii operation general information 3.1 scope this section provides detailed operating instructions for the ps engineering pma8000-sr, audio selector p...
Page 25
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 3-2 rev. 14, oct. 2008 figure 3-2 pma8000-sr operating controls note: placing the pma8000-sr in–tel– the intercom mode pushbutton determines who is on the phone, and who is still o...
Page 26
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 3-3 rev. 14, oct. 2008 hear a beep with each key press, followed by three acknowledgement beeps. This must be accomplished only once and the pma8000-sr will “remember” that pa is a...
Page 27
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 3-4 rev. 14, oct. 2008 for optimum microphone performance, ps engineering recommends installation of a microphone muff kit from oregon aero (1-800-888-6910). This will not only opt...
Page 28
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 3-5 rev. 14, oct. 2008 c rew : pilot and copilot are connected on one intercom channel and have exclusive access to the aircraft radios. They may also listen to entertainment 1. Pa...
Page 29
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 3-6 rev. 14, oct. 2008 figure 3-3 satellite ra- dio remote control 3.7 telephone mode (9) the tel mode serves as a full duplex interface for telephone systems such as aircell or po...
Page 30
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 3-7 rev. 14, oct. 2008 press the volume up and down (vol up, vol dn) buttons to change the satellite radio volume through the audio panel. This will only adjust the sirius radio an...
Page 31
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 3-8 rev. 14, oct. 2008 note: to turn off the satellite radio from the pma8000 panel without us- ing the remote, push the “tel” and “spr” buttons at the same time. If you believe th...
Page 32
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 page 4-1 rev. 14, oct. 2008 section iv- warranty and service 4.1 warranty in order for the factory warranty to be valid, the installations in a certified aircraft must be accomplished b...
Page 33
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 appendix a rev. 14, oct. 2008 appendix a external ptt hook up part of the installation includes the installation of ptt (push to talk) switches that allow the use of your aircraft radio...
Page 34
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 appendix b rev. 14, oct. 2008 appendix b – pma 8000 installation drawings 475-013-0001 lock nut (4 ea) 44-pin connector (2 ea) rack back plate 430-880-0050 475-440-0004 (4 ea) 475-440-0...
Page 35
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 appendix b rev. 14, oct. 2008 figure 6-1 pma8000-sr installation drawing caution: apply steady pressure to the bezel while screwing the unit into the tray to ensure even seating of the ...
Page 36
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 appendix c rev. 14, oct. 2008 appendix c, j1 interconnect com 1 audio hi com 1 mic key com 1 lo communications transceiver #1 communications transceiver #2 nav 1 audio hi nav 1 audio lo...
Page 37
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 appendix d rev. 14, oct. 2008 appendix d, j2 connector interconnect 22 20 35 36 24 23 25 copilot phones (r) copilot phones (l) copilot phones lo pass. 1 mic jack pass. Mic lo pass. Mic ...
Page 38
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 appendix e rev. 14, oct. 2008 appendix e- instructions for faa form 337 and continuing airworthiness 9.1 instructions for faa form 337, audio panels one method of airworthiness approval...
Page 39
Ps engineering pma8000-sr audio selector panel and intercom system installation and operator’s manual 200-880-0000 appendix g rev. 14, oct. 2008 appendix f rtca do160d environmental qualification form audio selector panel/intercom/marker beacon receiver part number: 050-880-( ) faa tso number: c50c,...