1. DL manuals
  2. PS Engineering
  3. Extender
  4. PMA8000
  5. Installation And Operaion Manual

PS Engineering PMA8000 Installation And Operaion Manual

Summary of PMA8000

  • Page 1

    9800 martel road lenoir city, tn 37772 www.Ps-engineering.Com p p m m a a 8 8 0 0 0 0 0 0 document p/n 200-890-0000 revision 9, june 2005 audio selector panel with marker beacon receiver high-fidelity stereo intercom system installation and operation manual faa-approved tso c50c, c35d patented under...

  • Page 2

    Table of contents section i general information..................................................................... 1-1 1.1 introduction ......................................................................................................................... 1-1 1.2 scope..............................

  • Page 3

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page ii revision 9, june 2005 2.11.4 tel c heckout ......................................................................................................... 2-11 2.11.5 i nternal r ...

  • Page 4

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 1-1 revision 9, june 2005 section i general information 1.1 introduction the pma8000 represents another evolutionary step in cockpit audio control and intercommunications util-...

  • Page 5

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 1-2 revision 9, june 2005 controls the intercom level for the pilot and copilot, while the large knob controls the passenger intercom volume. Intercom squelch is automatic. A 3...

  • Page 6

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 1-3 revision 9, june 2005 audio selector specifications audio selector panel input impedance: 510 Ω input isolation: -60 db (min.) speaker muting: -60 db (min.) speaker output ...

  • Page 7

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 1-4 revision 9, june 2005 1.6 equipment supplied 1 ea. Of the following units: model description part number pma8000 pma8000 audio panel with marker beacon and stereo intercom....

  • Page 8

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-1 revision 9, june 2005 section ii - installation 2.1 general information 2.1.1 scope this section provides detailed installation and interconnection instructions for the ps ...

  • Page 9

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-2 revision 9, june 2005 fhp 6-32 x ½" screws (475-632-0012). The audio selector panel must be supported at front and rear of the mounting tray. 2.3.4 audio panel tray and con...

  • Page 10

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-3 revision 9, june 2005 note: adding a high-performance audio control system, particularly in conjunction with high-performance active noise canceling headsets, cannot improv...

  • Page 11

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-4 revision 9, june 2005 3/32" cellular jack com 3 mic input com 3 audio audio lo cellular plug (typical) tip= microphone out ring= speaker audio base=ground this is a typical...

  • Page 12

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-5 revision 9, june 2005 2.4.11 public address mode by pressing the mute and spr pushbuttons at the same time, the pma8000 will be placed into public ad- dress (pa) mode. In t...

  • Page 13

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-6 revision 9, june 2005 music interconnect for music 1 to drive both inputs 23 24 25 ent. #1 input 26 28 27 alternate music interconnect ent. #2 input music interconnect for ...

  • Page 14

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-7 revision 9, june 2005 2.4.14.1.2 entertainment 2 mute (j2 pin 13 & 14) connecting j2 pin 13 to pin 14 (or ground) through a spst switch places the entertainment #2 music so...

  • Page 15

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-8 revision 9, june 2005 tel vol spr vol mkr vol figure 2-2- pma8000 adjustments • speaker volume- turn adjustment clockwise to increase cabin speaker output. • marker beacon ...

  • Page 16

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-9 revision 9, june 2005 2.8 pma8000 pin assignments j1 function j2 function 1 mkr ant 1 pilot phones lo 2 mkr ant lo 2 copilot phones lo 3 telephone audio in 3 copilot phones...

  • Page 17

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-10 revision 9, june 2005 2.9 post installation checkout after wiring is complete, verify power is only on pins 8 and 9 of the j2 and airframe ground on connec- tor pins 10 an...

  • Page 18

    Ps engineering pma8000 series audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 2-11 revision 9, june 2005 12. Verify proper operation of all receiver sources by selecting them using the appropriate button. The button illuminates to show which source is in...

  • Page 19

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 3-1 revision 9, june 2005 section iii operation general information 3.1 scope this section provides detailed operating instructions for the ps engineering pma8000, audio selector pane...

  • Page 20

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 3-2 revision 9, june 2005 figure 2 pma8000 operating controls note: placing the pma8000 in–tel– the intercom mode pushbutton determines who is on the phone, and who is still on the in...

  • Page 21

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 3-3 revision 9, june 2005 3.4.1.1 public address function to access pa function, press the mute (6) and spr (5) buttons simultaneously. The com1 and com2 receive leds will blink to in...

  • Page 22

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 3-4 revision 9, june 2005 table 3-1 mic muff ™ part numbers manufacturer model mic muff™ part number bose dynamic electret m87 dynamic 90010 90015 90020 david clark h10-30 h10-20, h10...

  • Page 23

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 3-5 revision 9, june 2005 3.6.3.1 entertainment input the audio selector panel has provisions for two separate entertainment input devices. Music 1 feeds the pilot and copilot positio...

  • Page 24

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 3-6 revision 9, june 2005 pma8000 can serve as a audio control and distribution center. When tel is active, the button will illuminate. In all intercom mode, all crew and passengers w...

  • Page 25

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 3-7 revision 9, june 2005.

  • Page 26

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 page 4-1 revision 9, june 2005 section iv- warranty and service 4.1 warranty in order for the factory warranty to be valid, the installations in a certified aircraft must be accomplished b...

  • Page 27

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 appendix a revision 9, june 2005 appendix a external ptt hook up part of the installation includes the installation of ptt (push to talk) switches that allow the use of your aircraft radio...

  • Page 28

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 appendix b revision 9, june 2005 appendix b – pma 8000 installation drawings 475-013-0001 lock nut (4 ea) 44-pin connector (2 ea) rack back plate 430-890-0050 475-440-0004 (4 ea) 475-440-0...

  • Page 29

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 appendix b revision 9, june 2005 appendix c, j1 interco nnect com 1 audio hi com 1 mic key com 1 lo communications transceiver #1 communications transceiver #2 nav 1 audio hi nav 1 audio l...

  • Page 30

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 appendix d revision 9, june 2005 appendix d, j2 connector interconnect 35 36 24 23 25 pass. Mic lo pass. Mic hi 37 38 pass. Mic lo pass. Mic hi 39 40 pass. Mic lo pass. Mic hi 41 42 pass. ...

  • Page 31

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 appendix e revision 9, june 2005 appendix e- instructions for faa form 337 and continuing airworthiness 9.1 instructions for faa form 337, audio panels one method of airworthiness approval...

  • Page 32

    Ps engineering pma8000 audio selector panel and intercom system installation and operator’s manual 200-890-0000 appendix g revision 9, june 2005 appendix f rtca do160d environmental qualification form audio selector panel/intercom/marker beacon receiver part number: 050-890-( ) faa tso number: c50c,...