- DL manuals
- PS Engineering
- MP3 Player
- PMA8000B--MP3
- Installation And Operation Manual
PS Engineering PMA8000B--MP3 Installation And Operation Manual
9800 Martel Road
Lenoir City, TN 37772
www.ps-engineering.com
P
P
M
M
A
A
8
8
0
0
0
0
0
0
B
B
-
-
M
M
P
P
3
3
F
F
O
O
R
R
U
U
S
S
E
E
W
W
I
I
T
T
H
H
A
A
v
v
i
i
d
d
y
y
n
n
e
e
E
E
n
n
t
t
e
e
g
g
r
r
a
a
I
I
n
n
t
t
e
e
g
g
r
r
a
a
t
t
e
e
d
d
A
A
v
v
i
i
o
o
n
n
i
i
c
c
s
s
S
S
y
y
s
s
t
t
e
e
m
m
R
R
9
9
Document P/N 200-890-0403
Rev. 4, Jan. 2011
Audio Selector Panel with Marker Beacon Receiver
High-fidelity Stereo Intercom with Internal MP3 Player
System Installation and Operation Manual
FAA- TSO C50c, C35d
EASA ETSO C50c, 2C35d
Patented under one or more of the following;
No. 4,941,187; 5,903,227; 6,160,496 and 6,493, 450
PS Engineering, Inc. 2011 ©
Copyright Notice
Any reproduction or retransmittal of this publication, or any portion thereof, without the expressed written permission of PS Engi-
neering, Inc. is strictly prohibited. For further information contact the Publications Manager at PS Engineering, Inc., 9800 Martel
Road, Lenoir City, TN 37772. Phone (865) 988-9800, email contact@ps-engineering.com.
In certified aircraft, warranty is not valid unless this product is installed by an
Authorized PS Engineering dealer.
Summary of PMA8000B--MP3
Page 1
9800 martel road lenoir city, tn 37772 www.Ps-engineering.Com p p m m a a 8 8 0 0 0 0 0 0 b b - - m m p p 3 3 f f o o r r u u s s e e w w i i t t h h a a v v i i d d y y n n e e e e n n t t e e g g r r a a i i n n t t e e g g r r a a t t e e d d a a v v i i o o n n i i c c s s s s y y s s t t e e m ...
Page 2
Table of contents section i – general information........................................................................................................... 1-1 1.1 introduction .............................................................................................................................
Page 3
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page ii rev. 4, jan. 2011 section iii operation ...................................................................................................................
Page 4
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 1-1 rev. 4, jan. 2011 section i – general information 1.1 introduction the pma8000b-mp3 represents another evolutionary step in cockpit audio control and i...
Page 5
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 1-2 rev. 4, jan. 2011 there are five unswitched inputs, available for traffic or egpws, autopilot disconnect, and/or radar a l- timeter warning, with the f...
Page 6
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 1-3 rev. 4, jan. 2011 weight pma8000b-mp3 unit rack with connectors 1.34 lb. (0.61 kg) 0.51 lb. (0.24 kg) power requirements (including internal lighting):...
Page 7
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 1-4 rev. 4, jan. 2011 1.6 equipment supplied 1 ea. Of the following units: model description part number pma8000b-mp3 pma8000b-mp3 audio panel with marker ...
Page 8
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-1 rev. 4, jan. 2011 section ii - installation 2.1 general information 2.1.1 scope this section provides detailed installation and interconnection instruc...
Page 9
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-2 rev. 4, jan. 2011 2.3.3 audio panel mounting rack installation remove the unit from the mounting tray by unscrewing the 3/32" hex-head screw that is in...
Page 10
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-3 rev. 4, jan. 2011 the shields can be daisy-chained together, and then connected to the ground lugs mounted on the back plate shown in appendix b. Radia...
Page 11
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-4 rev. 4, jan. 2011 2.4.5 audio panel interface the pma8000b-mp3 is designed to interface with standard aircraft avionics, and presents a 510 re- ceive...
Page 12
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-5 rev. 4, jan. 2011 2.4.8 backlighting the pma8000b-mp3 has an automatic dimming of the pushbutton annunciation leds and marker lamps controlled by a pho...
Page 13
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-6 rev. 4, jan. 2011 connect the split com selected (j1 pin 24) to the #1 and #1 ifd p1122 and 2122, pin 38. Connect the com 2 select (j1 pin 25) to the #...
Page 14
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-7 rev. 4, jan. 2011 figure 2-3 jumper location 4. Place the lid back on the unit, aligning holes. 5. Install and tighten qty. 4 long thread screws into t...
Page 15
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-8 rev. 4, jan. 2011 use t h e l ow l evel ou t p u t of a n y a d d i t i on a l en t er t a i n m en t d evi ce t o con n ect t o t h e a u - d i o p a ...
Page 16
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-9 rev. 4, jan. 2011 2.6 marker beacon installation 2.6.1 marker antenna installation a marker beacon antenna, appropriate to the type and speed of the ai...
Page 17
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-10 rev. 4, jan. 2011 tel volume, turn adjustment clockwise to increase the incoming telephone audio. Ann vol function mode annunciation volume – controls...
Page 18
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-11 rev. 4, jan. 2011 2.9 pma8000b-mp3 pin assignments j1 function j2 function 1 mkr ant 1 pilot phones low 2 mkr ant low 2 copilot phones low 3 telephone...
Page 19
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-12 rev. 4, jan. 2011 2.10 post installation checkout after wiring is complete, verify power is only on pins 8 and 9 of the j2 and airframe ground on conn...
Page 20
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-13 rev. 4, jan. 2011 13. Push the spr button. Verify that all selected audio is heard in the cockpit speaker . Verify that the audio mutes when the mic i...
Page 21
Ps engineering pma8000b-mp3avidyne version (-0403) audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 2-14 rev. 4, jan. 2011 2.13 final inspection verify that the wiring is bundled away from all controls and no part of the installation inte rferes with air-...
Page 22
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-1 rev. 4, jan. 2011 section iii operation 3.1 scope this section provides detailed operating instructions for the ps engineering pma8000b-mp3, audio selector panel/marker beaco...
Page 23
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-2 rev. 4, jan. 2011 1 to c om 2, if c om 2 audio was previously selected, c om 1 audio will continue to be heard. This elimi- nates the pilot having to switch com 1 audio back ...
Page 24
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-3 rev. 4, jan. 2011 portable cellular phones with earpiece jacks. Pressing the tel button activates the telephone mode. This connects the telephone to the users as follows: in ...
Page 25
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-4 rev. 4, jan. 2011 the audio from the marker beacon receiver can be heard by selecting the "mkr" push-button switch. To adjust the volume level, there is a service adjustment ...
Page 26
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-5 rev. 4, jan. 2011 the outer volume control knob controls intercom volume or the passengers. It has no effect on radio or music levels. Adjust the radios and intercom volume f...
Page 27
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-6 rev. 4, jan. 2011 mode 4 - radio will not mute music, intercom will mute music - mute led is off. Annunciation is "intercom mute." ♫ music intercom radio annunciation led mod...
Page 28
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-7 rev. 4, jan. 2011 crew note because the cell phone uses an intercom circuit, all stations on that circuit will lose intercom capabi lity when the cell phone is in use, unless...
Page 29
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-8 rev. 4, jan. 2011 sfk annunciations are heard by the pilot and copilot positions only. Sfk annunciations will be heard by the copilot, even when the audio panel is in pilot i...
Page 30
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-9 rev. 4, jan. 2011 3.10.5 function “a” function “a” controls the distribution of aircraft radio within the intercom, as well as passenger intercom muting. In the “standard int...
Page 31
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-10 rev. 4, jan. 2011 music distri- bution mode standard music distribu- tion alternate music distribu- tion music 1 all headsets music source ics mode all crew iso all crew iso...
Page 32
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-11 rev. 4, jan. 2011 to skip (c) to the next song, press shift key (mon 2) and mkr. To pause (d) mp3 play, press shift key (mon 1) and tel. 3.13 music 1 & mp3 volume (h & i) th...
Page 33
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-12 rev. 4, jan. 2011 3.14.2 transfer using usb drive for best results, the following procedure should be used for a usb device when used with the pma8000b mp3. The usb drive sh...
Page 34
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 3-13 rev. 4, jan. 2011 3.15 internal recorder the pma8000b-mp3 comes equipped with an internal recorder. This digital system stores the last incom- ing audio from the radio you h...
Page 35
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 page 4-1 rev. 4, jan. 2011 section iv – warranty and service 4.1 warranty in order for the factory warranty to be valid, the installations in a certified aircraft must be accomplished...
Page 36
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 appendix a rev. 4, jan. 2011 appendix a – external ptt hook up part of the installation includes the installation of ptt (push to talk) switches that allow the use of your aircraft ra...
Page 37
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 rev. 4, jan. 2011 appendix b – pma 8000b mp3 installation drawings j2 j1 viewed from back 15 30 44 1 16 31 15 30 44 1 16 31 ground lug ground lug 475-440-0001 (x2) back plate assy 475...
Page 38
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 appendix d rev. 4, jan. 2011 appendix c – j1 connector interconnect (-0403 only) refer to avidyne installation manual for full systems interconnect.
Page 39
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 appendix d rev. 4, jan. 2011 appendix d – j2 connector interconnect (-0403 only) refer to avidyne installation manual for full systems interconnect..
Page 40
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 appendix e rev. 4, jan. 2011 appendix e – instructions for faa form 337 and continuing airworthiness 9.1 instructions for faa form 337, audio panels one method of airworthiness approv...
Page 41
Ps engineering pma8000b-mp3 audio selector panel and intercom system installation and operator’s manual 200-890-0403 appendix f rev. 4, jan. 2011 appendix f – rtca do160d environmental qualification form audio selector panel/intercom/marker beacon receiver part number: 050-890-( ) faa tso number: c5...