Www.Quadrafi re.Com 7039-131m october 13, 2015 o-t l tested and listed by portland oregon usa omni-test laboratories, inc. C us do not discard this manual notice • important operating a n d m a i n t e n a n c e instructions included. • leave this manual with party responsible for use and operation....
Page 2 7039-131m october 13, 2015 2100 millennium wood stove (acc) hearth & home technologies welcomes you to our tradi- tion of excellence! In choosing a quadra-fire appliance, you have our assurance of commitment to quality, durabil- ity, and performance. This commitment begins with our research o...
October 13, 2015 7039-131m page 3 2100 millennium wood stove (acc) section 1: listing and code approvals a. Appliance certifi cations ......................4 b. Mobile home approved ......................4 c. Glass specifi cations ............................4 d. Btu & effi ciency specifi cations .....
Page 4 7039-131m october 13, 2015 2100 millennium wood stove (acc) 1 listing and code approvals a. Appliance certifi cation c. Glass specifi cations d. Btu & effi ciency specifi cations this stove is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass. Please contact your deal...
October 13, 2015 7039-131m page 5 2100 millennium wood stove (acc) 2 getting started a. Design, installation & location consider ations consideration must be given to: • safety • convenience • traffi c fl ow • chimney and chimney connector required it is a good idea to plan your installation on pape...
Page 6 7039-131m october 13, 2015 2100 millennium wood stove (acc) recommended location marginal location location not recommended recommended location location not recommended multi-level roofs windward leeward outside air kit termination cap figure 6.1 c. Negative pressure draft is the pressure di...
October 13, 2015 7039-131m page 7 2100 millennium wood stove (acc) exterior conditions such as roof line, surrounding trees, prevailing winds and nearby hills can influence stove performance. Your local dealer is the expert in your geographic area and can usually make suggestions or discover solutio...
Page 8 7039-131m october 13, 2015 2100 millennium wood stove (acc) floor protector chimney connector ceiling support listed chimney listed termination cap storm collar flashing figure 8.3 interior prefabricated chimney figure 8.2 exterior prefabricated chimney figure 8.1 masonry chimney h. Typical s...
October 13, 2015 7039-131m page 9 2100 millennium wood stove (acc) 3 dimensions and clearances cl 11-1/2 in. (292mm) 16 in. (406mm) c l 4-1/2 in. (108mm) outside air connection 20-3/4 in. (527mm) 26-7/16 in. (671mm) 24-5/16 in. (618mm) 6-11/16 in. (170mm) a. Appliance dimensions figure 9.1 front vie...
Page 10 7039-131m october 13, 2015 2100 millennium wood stove (acc) b. Clearances to combustibles (ul and ulc) backwall / sidewall a b c d e f f e corner installation c alcove top view g a alcove side view note: clearances may only be reduced by means approved by the regulatory authority having juri...
October 13, 2015 7039-131m page 11 2100 millennium wood stove (acc) a. Hearth protection requirements floor protection: floor protector must be non-com- bustible material, extending beneath heater and to the front, sides and rear as indicated. The fl oor must be non-com- bustible or otherwise adequa...
Page 12 7039-131m october 13, 2015 2100 millennium wood stove (acc) b. Outside air kit installation 1. Remove all materials from packing box. 2. Using a #2 phillips screw driver attach the fl ex adapter to the stove using 4 screws. Figure 12.1. 3. For fl oor installations, remove circular “knock-out...
October 13, 2015 7039-131m page 13 2100 millennium wood stove (acc) c. Blower (optional) 1. Remove the 3 bolts (1/4”-20 phillips head) on the outer skin at the bottom rear of appliance. 2. Align holes in mounting fl ange of blower with bolt holes in appliance. Blower should be positioned at bottom o...
Page 14 7039-131m october 13, 2015 2100 millennium wood stove (acc) note: in canada when using a factory-built chimney it must be safety listed, type ul103 ht (2100 o f) class “a” or conforming to can/ulc-s629m, standard for 650 o c factory-built chimneys. 5 chimney requirements floor protector chim...
October 13, 2015 7039-131m page 15 2100 millennium wood stove (acc) thimble site constructed for masonry chimney installation: components • a minimum length of 12 inches [305mm] (longer for thicker walls) of solid insulated factory-built chimney length constructed to ul 103 type ht 6 inch (152mm) in...
Page 16 7039-131m october 13, 2015 2100 millennium wood stove (acc) chimney height / rise and run this product was designed for and tested on a 6 inch (152mm) chimney, 14 to 16 feet (420-480cm) high, (includes stove height) measured from the base of the appliance. The further your stack height or di...
October 13, 2015 7039-131m page 17 2100 millennium wood stove (acc) d. Chimney termination requirements follow manufacturer’s instructions for clearance, securing fl ashing and terminating the chimney. • must have an approved and listed cap • must not be located where it will become plugged by snow ...
Page 18 7039-131m october 13, 2015 2100 millennium wood stove (acc) 6 mobile home installation 10. Burn wood only. Other types of fuels may generate poisonous gases (e.G., carbon monoxide). 11. If unit burns poorly while an exhaust blower is on in home, (i.E., range hood), increase combustion air. 1...
October 13, 2015 7039-131m page 19 2100 millennium wood stove (acc) note: when the speed control is turned clockwise, it will click on to high speed. Continue to turn the speed control clockwise to decrease the speed. At full clockwise, the blower should blow gently, but should not stop. 1. With the...
Page 20 7039-131m october 13, 2015 2100 millennium wood stove (acc) 8 operating instructions b. Wood selection & storage burn only dry seasoned wood. Store wood under cover, out of the rain and snow. Dry and well-seasoned wood will not only minimize the chance of creosote formation, but will give yo...
October 13, 2015 7039-131m page 21 2100 millennium wood stove (acc) 2. Second stage the next stage of burning, the secondary stage, is the period when the wood gives off fl ammable gases which burn above the fuel with bright fl ames. During this stage of burning it is very important that the fl ames...
Page 22 7039-131m october 13, 2015 2100 millennium wood stove (acc) f. Burn rates and operating effi ciency for maximum operating effi ciency 1. This appliance has a timer system (acc) that operates the stove at its maximum effi ciency removing any guess work for the homeowner. Follow the instructio...
October 13, 2015 7039-131m page 23 2100 millennium wood stove (acc) note: operate appliance on high burn 15 minutes a day to help keep fl ue/chimney clean. G. Building a fire before lighting your fi rst fi re in the stove: 1. Confi rm the baffl e is correctly positioned. It should be even with the f...
Page 24 7039-131m october 13, 2015 2100 millennium wood stove (acc) correct position incorrect positions firebox damage due to improper baffl e place- ment is not covered by warranty. Operate the wood burning appliance with the baffl e in the correct position only. Not doing so could result in: • re...
October 13, 2015 7039-131m page 25 2100 millennium wood stove (acc) j. Opacity (smoke) this is the measure of how cleanly your appliance is burn- ing. Opacity is measured in percent; 100% opacity is when an object is totally obscured by the smoke column from a chimney, and 0% opacity means that no s...
Page 26 7039-131m october 13, 2015 2100 millennium wood stove (acc) k. Frequently asked questions issues solutions odor from appliance when fi rst operated, this appliance may release an odor for the fi rst several hours. This is caused by the curing of the paint and the burning off of any oils rema...
October 13, 2015 7039-131m page 27 2100 millennium wood stove (acc) a. Quick reference maintenance guide ceramic blanket back of firebox baffle board baffle retainer bracket 2 2 locknut door cross section (example) latch cam spacing door handle spring handle baffl e and blanket placement is critical...
Page 28 7039-131m october 13, 2015 2100 millennium wood stove (acc) b. General maintenance inspection: inspect the system at the appliance connection and at the chimney top. Cooler surfaces tend to build creosote deposits quicker, so it is important to check the chimney from the top as well as from ...
October 13, 2015 7039-131m page 29 2100 millennium wood stove (acc) c. Glass replacement 1. Ensure that the fi re is out and the appliance is cool to the touch. 2. Protect a table or counter top with padding or towels. Protect your hands and wear gloves to prevent injury. 3. Remove the door with the...
Page 30 7039-131m october 13, 2015 2100 millennium wood stove (acc) replace the fi rebrick if they become crumbly and/or if there is a 1/4 inch (6.35mm) gap between the bricks. Inspect the fi rebrick after each ash removal. The fi rebox is lined with high quality fi rebrick, which has exceptional in...
October 13, 2015 7039-131m page 31 2100 millennium wood stove (acc) e. Baffl e removal 1. Remove all ash from the fi rebox, and extinguish all hot embers before disposal into a metal container. 2. The baffl e board has 2 pieces. With the ceramic blanket still in place, slide one baffl e piece over t...
Page 32 7039-131m october 13, 2015 2100 millennium wood stove (acc) g. Tube channel assembly replacement removing tube channel assembly 1. Remove the right side shield by removing 2 screws in the back using a phillips head screw driver. 2. Remove 4 screws from channel access cover and remove cover. ...
October 13, 2015 7039-131m page 33 2100 millennium wood stove (acc) 10 troubleshooting with proper installation, operation, and maintenance your wood stove will provide years of trouble-free service. If you do experience a prob- lem, this troubleshooting guide will assist a qualifi ed service person...
Page 34 7039-131m october 13, 2015 2100 millennium wood stove (acc) 11 reference materials a. Exploded drawings & service parts list figure 34.1 part number list on following pages. 1 2 3 4 5 6 7 8 9 10 11 12 14 16 15 13 09/15.
October 13, 2015 7039-131m page 35 2100 millennium wood stove (acc) service parts 21m-acc beginning manufacturing date: july 2007 ending manufacturing date: active r important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and ...
Page 36 7039-131m october 13, 2015 2100 millennium wood stove (acc) service parts 21m-acc beginning manufacturing date: july 2007 ending manufacturing date: active r important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and ...
October 13, 2015 7039-131m page 37 2100 millennium wood stove (acc) service parts 21m-acc beginning manufacturing date: july 2007 ending manufacturing date: active r important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and ...
Page 38 7039-131m october 13, 2015 2100 millennium wood stove (acc) hearth & home technologies inc. Limited lifetime warranty hearth & home technologies inc., on behalf of its hearth brands (”hht”), extends the following warranty for hht gas, wood, pellet, coal and electric hearth appliances that ar...
Hearth & home technologies 1445 north highway colville, wa 99114 division of hni industries 7039-131m october 13, 2015 page 40 contact information: please contact your quadra-fire dealer with any questions or concerns. For the number of your nearest quadra-fire dealer, visit our web site at www.Quad...
