1. DL manuals
  2. Quadra-Fire
  3. Wood stove
  4. 57ST-ACC
  5. Owner's manual

Quadra-Fire 57ST-ACC Owner's manual

Other manuals for 57ST-ACC: Owner's Manual, Installation Manual, Owner's Manual
Manual is about: 5700 STEP TOP WOOD STOVE SERIES

Summary of 57ST-ACC

  • Page 1

    R www.Quadrafi re.Com 7038-159d november 28, 2011 o - t l tested and listed by portland oregon usa omni-test laboratories, inc. C us do not discard this manual caution • important operating a n d m a i n t e n a n c e instructions included. • leave this manual with party responsible for use and oper...

  • Page 2: Caution

    Page 2 7038-159d november 28, 2011 r 5700 step top wood stove series acc hearth & home technologies welcomes you to our tradition of excellence! In choosing a quadra-fire appliance, you have our assurance of commitment to quality, durability, and performance. This commitment begins with our research...

  • Page 3

    November 28, 2011 7038-159d page 3 r 5700 step top wood stove series acc congratulations ...............................................................2 sample of safety/serial number label ...........................2 warranty policy ...............................................................4...

  • Page 4

    Page 4 7038-159d november 28, 2011 r 5700 step top wood stove series acc warranty policy.

  • Page 5

    November 28, 2011 7038-159d page 5 r 5700 step top wood stove series acc.

  • Page 6

    Page 6 7038-159d november 28, 2011 r 5700 step top wood stove series acc 1 listing and code approvals the quadra-fire 5700 wood stove (acc) meets the u.S. Environmental protection agency’s 1990 particulate emis- sion standards. A. Appliance certifi cation c. Glass specifi cations d. Btu & effi cienc...

  • Page 7: User Guide

    November 28, 2011 7038-159d page 7 r 5700 step top wood stove series acc 2 operating instructions warning! Do not operate appliance before reading and understanding operating instructions. Failure to operate appliance according to operating instructions could cause fi re or injury. User guide a. You...

  • Page 8

    Page 8 7038-159d november 28, 2011 r 5700 step top wood stove series acc b. Fire safety to provide reasonable fi re safety, the following should be given serious consideration: 1. Install at least one smoke detector on each fl oor of your home to ensure your safety. They should be located away from ...

  • Page 9

    November 28, 2011 7038-159d page 9 r 5700 step top wood stove series acc g. Burning process in recent years there has been an increasing concern about air quality. Much of the blame for poor air quality has been placed on the burning of wood for home heating. In order to improve the situation, we at...

  • Page 10

    Page 10 7038-159d november 28, 2011 r 5700 step top wood stove series acc i. Air controls 1. Start-up air control the start-up air control has two primary functions. The fi rst function is to activate the automatic combustion control system (acc). • slide the start-up air control all the way back un...

  • Page 11

    November 28, 2011 7038-159d page 11 r 5700 step top wood stove series acc j. Burn rates and operating effi ciency for maximum operating effi ciency 1. This appliance has a timer system (acc) that operates the appliance at its maximum effi ciency removing any guess work for the homeowner. Follow the ...

  • Page 12: Correct Position

    Page 12 7038-159d november 28, 2011 r 5700 step top wood stove series acc correct position incorrect positions k. Correct baffl e & blanket placement ceramic blanket and baffl e board are not in contact with the back of the fi rebox. Ceramic blanket is not in contact with the back of the fi rebox an...

  • Page 13

    November 28, 2011 7038-159d page 13 r 5700 step top wood stove series acc l. Building a fire before lighting your fi rst fi re in the appliance: 1. Confi rm the baffl e and ceramic blanket are correctly posi- tioned. See page 12 for detailed diagrams. They should be even with the front tube and rest...

  • Page 14

    Page 14 7038-159d november 28, 2011 r 5700 step top wood stove series acc m. Wood fuel moisture seasoned wood • cut logs to size • split to 6 inches (152 mm) or less in diameter. • air dry to a moisture content of around 20% - *soft wood - about nine months to dry - *hard wood - about eighteen month...

  • Page 15

    November 28, 2011 7038-159d page 15 r 5700 step top wood stove series acc 7. Snap disc location if you fi nd the blower coming on and off at undesirable temperatures, relocate the snap disc to another location in the designated zone on the back of the appliance. Figure 15.2. There is a manual over-r...

  • Page 16

    Page 16 7038-159d november 28, 2011 r 5700 step top wood stove series acc p. Opacity (smoke) opacity is the measure of how cleanly your appliance is burning. Opacity is measured in percent: • 100% opacity is when an object is totally obscured by the smoke column from a chimney, and • 0% opacity mean...

  • Page 17

    November 28, 2011 7038-159d page 17 r 5700 step top wood stove series acc 3 maintenance and service • frequency: when ash is within 1-3/4 inch (44mm) of firebox lip. Leave 1/4 to 1/2 inch (6-13mm) of ash in the bottom of the firebox. • by: homeowner b. Disposal of ashes a. Ash removal system operati...

  • Page 18

    Page 18 7038-159d november 28, 2011 r 5700 step top wood stove series acc d. Appliance inspection - routine • frequency: every 2 months at the same time the chim- ney and chimney connector are inspected. • by: homeowner check for: • cracks in glass • door handle - smooth cam operation • baffl e and ...

  • Page 19

    November 28, 2011 7038-159d page 19 r 5700 step top wood stove series acc • frequency: as desired • by: homeowner • clean glass with a non-abrasive glass cleaner. Abrasive cleaners may scratch and cause glass to crack. • if the deposits on the glass are not very heavy, normal glass cleaners work wel...

  • Page 20

    Page 20 7038-159d november 28, 2011 r 5700 step top wood stove series acc i. Quick reference maintenance guide 2 2 baffl e and blanket placement is critical to heat out- put, effi ciency and overall life of the unit. Make sure the baffl e is pushed all of the way to the back of the fi rebox and the ...

  • Page 21

    November 28, 2011 7038-159d page 21 r 5700 step top wood stove series acc 4 troubleshooting guide with proper installation, operation, and maintenance your woodstove will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist you or a qualifi ed...

  • Page 22

    Page 22 7038-159d november 28, 2011 r 5700 step top wood stove series acc 5 service parts replacement a. Glass replacement 1. Ensure that the fi re is out and the appliance is cool to the touch. 2. Protect a table or counter top with padding or towels. Protect your hands and wear gloves to prevent i...

  • Page 23

    November 28, 2011 7038-159d page 23 r 5700 step top wood stove series acc figure 23.2 baffle board & blanket even with front tube & resting on all tubes burn rate air control start-up air control 2 pc baffle board ceramic blanket on top tube channels c. Baffl e removal figure 23.1 - baffl e 1. Remov...

  • Page 24

    Page 24 7038-159d november 28, 2011 r 5700 step top wood stove series acc d. Door handle assembly 1. Install washer on door handle shaft. 2. Slide door handle through door. 3. Install second washer(s) as shown in figure 24.1. 4. Install key in groove. 5. Align groove in latch cam with key; slide lat...

  • Page 25

    November 28, 2011 7038-159d page 25 r 5700 step top wood stove series acc e. Tube channel assembly replacement removing tube channel assembly 1. Remove the right side bricks (5 pieces) and right hand rear brick. 2. Remove the 2 brick retainers by sliding back and then up. 3. Remove the baffl e prote...

  • Page 26: Installer’S Guide

    Page 26 7038-159d november 28, 2011 r 5700 step top wood stove series acc 6 getting started installer’s guide a. Design and installation considerations before installing, determine the following: • type of chimney connector to be used - single wall, vertical or horizontal - double wall, vertical or ...

  • Page 27

    November 28, 2011 7038-159d page 27 r 5700 step top wood stove series acc marginal location: • below peak location not recommended: • not the highest point of the roof • wind loading possible multi-level roofs windward leeward recommended: outside air intake on windward side not recommended: outside...

  • Page 28

    Page 28 7038-159d november 28, 2011 r 5700 step top wood stove series acc these are safety requirements and are not meant to assure proper fl ue draft. Figure 28.1 f. 2-10-3 rule figure 28.2 3 ft. (91cm) minimum less than 10 ft. (305cm) 2 ft. (61cm) 3 ft. (91cm) minimum 10 ft. (305cm) to nearest roo...

  • Page 29

    November 28, 2011 7038-159d page 29 r 5700 step top wood stove series acc g. Tools and supplies needed h. Fire safety to provide reasonable fi re safety, the following should be given serious consideration: 1. Install at least one smoke detector on each fl oor of your home to ensure your safety. The...

  • Page 30

    Page 30 7038-159d november 28, 2011 r 5700 step top wood stove series acc 7 dimensions and clearances a. Appliance dimensions figure 30.1 - front view figure 30.2 - side view note: flue collar size is 6 inch (152mm) diameter (id) 5700 pedestal model 5700 leg model 33-7/8 in. (861mm) 14-15/16 in. (38...

  • Page 31

    November 28, 2011 7038-159d page 31 r 5700 step top wood stove series acc b. Clearances to combustibles (ul and ulc) note: clearances may only be reduced by means approved by the regulatory authority having jurisdiction g a b alcove side view a b c d backwall / sidewall c d alcove top view e f e f c...

  • Page 32

    Page 32 7038-159d november 28, 2011 r 5700 step top wood stove series acc c. Hearth protection requirements floor protection: • must be non-combustible material. • extend beneath heater and to the front, sides and rear as indicated. • the floor must be non-combustible or otherwise adequately protect...

  • Page 33

    November 28, 2011 7038-159d page 33 r 5700 step top wood stove series acc d. Calculating alternate floor protection material thermal conductivity: k value the k value indicates the amount of heat (in btu’s) that will fl ow in 1 hour throught 1 square foot of a uniform material 1 inch thick for each ...

  • Page 34

    Page 34 7038-159d november 28, 2011 r 5700 step top wood stove series acc 8 venting and chimney systems a. Venting systems the venting system consists of: • a chimney connector (also known as fl ue or stove pipe) • a chimney • thimble these get extremely hot during use. Temperatures inside the chimn...

  • Page 35

    November 28, 2011 7038-159d page 35 r 5700 step top wood stove series acc • must be a 6 inch (152mm) diameter (id) high temperature chimney listed to ul 103 ht (2100 o f) or ulc s629m. • must use components required by the manufacturer for installation. • must maintain clearances required by the man...

  • Page 36

    Page 36 7038-159d november 28, 2011 r 5700 step top wood stove series acc figure 36.1 masonry chimney floor protector thimble, 12 in. (305mm) of brick ceiling joist combustible wall airtight cleanout door fireclay flue liner with air space sheathing eave 1 in. (25mm) clearance with firestop rafter f...

  • Page 37

    November 28, 2011 7038-159d page 37 r 5700 step top wood stove series acc f. Masonry chimney liner thimble assembly: 12 in. (305mm) of brick separation between clay liner and combustibles. Fireclay liner 5/8 in. (16mm) minimum or equivalent. Sill support header wood stud 2 in. (51mm) clearance from ...

  • Page 38

    Page 38 7038-159d november 28, 2011 r 5700 step top wood stove series acc figure 38.1 - thimble construction trim collar chimney section with 2 inch (51mm) clearance to combustibles chimney connector fire clay flue liner with airspace masonry chimney wall band to secure chimney section wood studs us...

  • Page 39

    November 28, 2011 7038-159d page 39 r 5700 step top wood stove series acc chimney flue liner fireclay liner or equivalent masonry chimney constructed to nfpa 211 wall spacer wall band trim collar chimney connector 1 inch (25mm) air space to chimney section min. Clearance 2 inch (51mm) min. Chimney c...

  • Page 40

    Page 40 7038-159d november 28, 2011 r 5700 step top wood stove series acc a. Outside air kit installation 1. Remove all materials from packing box. 2. Using a #2 phillips screwdriver attach the fl ex adapter to the appliance using 4 screws. Figure 40.1 3. For fl oor installation remove circular “kno...

  • Page 41

    November 28, 2011 7038-159d page 41 r 5700 step top wood stove series acc figure 41.3 note: the ash removal system, must be installed fi rst before installing the pedestal. B. Pedestal assembly and ash removal system (ars) installation included in kit: door assembly, door handle & magnet, ash drawer...

  • Page 42

    Page 42 7038-159d november 28, 2011 r 5700 step top wood stove series acc installing pedestal assembly 1. Slide pedestal over adapter on bottom of stove and secure with screws supplied with the kit. Figure 42.1. 2. Line up holes in sides of pedestal with holes in adapter. 3. Securely tighten pedesta...

  • Page 43

    November 28, 2011 7038-159d page 43 r 5700 step top wood stove series acc c. Leg kit and ash removal system (ars) installation begin installing the ars system. 1. Follow steps 1 through 6 on page 41. Installing leg kit 1. Remove leg mounting brackets packaged inside fi re- box. 2. There are 4 screws...

  • Page 44

    Page 44 7038-159d november 28, 2011 r 5700 step top wood stove series acc 10. Burn wood only. Other types of fuels may generate poisonous gases (e.G., carbon monoxide). 11. If unit burns poorly while an exhaust blower is on in home, (i.E., range hood), increase combustion air. 12. Installation shall...

  • Page 45

    November 28, 2011 7038-159d page 45 r 5700 step top wood stove series acc e. Blower installation (optional) 1. Align holes in mounting fl ange of blower with bolt holes in appliance. Blower should be positioned at bottom of rear outer skin as shown in figure 45.1. 2. Insert and tighten bolts supplie...

  • Page 46

    Page 46 7038-159d november 28, 2011 r 5700 step top wood stove series acc 10 reference materials beginning mfg date: 4-10-09 ending mfg date: a. Exploded view 04/11 part number list on following page. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 17 18 19 20 21 22 23 24 25 26 27 28 16.

  • Page 47

    November 28, 2011 7038-159d page 47 r 5700 step top wood stove series acc ending manufacturing date: active important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be orde...

  • Page 48

    Page 48 7038-159d november 28, 2011 r 5700 step top wood stove series acc important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. Sto...

  • Page 49

    November 28, 2011 7038-159d page 49 r 5700 step top wood stove series acc important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. Sto...

  • Page 50: Side View

    Page 50 7038-159d november 28, 2011 r 5700 step top wood stove series acc 04/11 important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized deale...

  • Page 51

    November 28, 2011 7038-159d page 51 r 5700 step top wood stove series acc date of service performed by description of service c. Service and maintenance log.

  • Page 52

    7038-159d november 28, 2011 page 52 r hearth & home technologies 1445 north highway colville, wa 99114 division of hni industries contact information: please contact your quadra-fire dealer with any questions or concerns. For the number of your nearest quadra-fire dealer, log onto www.Quadrafi re.Co...