1. DL manuals
  2. Quadra-Fire
  3. Stove
  4. CASTILE-CSB-B
  5. Installation Manual

Quadra-Fire CASTILE-CSB-B Installation Manual

Manual is about: castile-b

Summary of CASTILE-CSB-B

  • Page 1

    1 7021-154j may 12, 2017 castile-b pellet appliance model(s): castile-mbk-b castile-cwl-b castile-csb-b castile-pmh-b installation and service of this appliance should be performed by qualified personnel. Hearth & home technologies recommends hht factory trained or nfi certified professionals. Insta...

  • Page 2

    2 7021-154j may 12, 2017 castile freestanding table of contents safety alert key: • danger! Indicates a hazardous situation which, if not avoided will result in death or serious injury. • warning! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • cautio...

  • Page 3

    May 12, 2017 7021-154j 3 castile freestanding model castile pellet appliance laboratory omni test laboratories, inc. Report no. 061-s-77d-6.2 type solid fuel room appliance/pellet fuel burning type standard astm e1509-04, ulc s627-00 and ulc/ord-c1482-m1990 room appli - ance pellet fuel burning type...

  • Page 4: Install Guide

    4 7021-154j may 12, 2017 castile freestanding install guide 2 getting started marginal location: • below peak location not recommended: • not the highest point of the roof • wind loading possible multi-level roofs windward leeward recommended: outside air intake on windward side not recommended: out...

  • Page 5

    May 12, 2017 7021-154j 5 castile freestanding • installation and use of any damaged appliance. • modification of the appliance. • installation other than as instructed by hearth & home technologies. • installation and/or use of any component part not approved by hearth & home technologies. • operati...

  • Page 6

    6 7021-154j may 12, 2017 castile freestanding e. Install checklist appliance install appliance is leveled and connector is secured to appliance. Hearth extension size/height decided. Outside air kit installed. Floor protection requirements have been met. If appliance is connected to a masonry chimne...

  • Page 7

    May 12, 2017 7021-154j 7 castile freestanding figure 7.2- front view figure 7.1 - top view figure 7.3 -side view figure 7.4 - side view with top vent adapter 24 in. (609mm) 24-5/8 in. (626mm) 12 in. (305mm) 24 in. (609mm) 28-9/16 in. (725mm) 15-15/16 in. (405mm) 22-7/8 in. (582mm) 17 in. (431mm) 16-...

  • Page 8

    8 7021-154j may 12, 2017 castile freestanding straight back against wall inches millimeters a back wall to appliance 2 51 b side wall to appliance 6 152 corner installation inches millimeters c walls to appliance 2 51 vertical installation inches millimeters d back wall to flue pipe 3 76 e side wall...

  • Page 9

    May 12, 2017 7021-154j 9 castile freestanding a c b d note: • illustrations reflect typical installations and are for design purposes only. • i llustrations/diagrams are not drawn to scale. • actual installation may vary due to individual design preference. D. Alcove figure 9.1 *all minimums listed ...

  • Page 10

    10 7021-154j may 12, 2017 castile freestanding 4 vent information a. Venting termination minimum requirements j or k x v m i h a v g b v v a b v f v c b b e l v d v electrical service v n v n v n n v inside corner fixed closed open open fixed closed v x g g termination cap air supply inlet gas meter...

  • Page 11

    May 12, 2017 7021-154j 11 castile freestanding b. Avoiding smoke and odors negative pressure, shut-down and electrical power failure to reduce the probability of back-drafting or burn-back in the pellet appliance during power failure or shut down con - ditions, it must be able to draft naturally wit...

  • Page 12

    12 7021-154j may 12, 2017 castile freestanding to minimize the effects of negative air pressure: • install the outside air kit with the intake facing prevailing winds during the heating season • ensure adequate outdoor air for all combustion appliances and exhaust equipment • ensure furnace and air ...

  • Page 13

    May 12, 2017 7021-154j 13 castile freestanding g. E quivalent feet of pipe the table below can help you calculate the equivalent feet of pipe which is a method used to determine pellet vent size. Figure 13.1. 2 ft. 2 ft. 3 ft. 2 ft. Example of 3 elbow-rear vent termination calculation pellet venting...

  • Page 14

    14 7021-154j may 12, 2017 castile freestanding i. P ellet venting charts figure 14.1 fire risk. • only listed venting components may be used. • no other vent components may be used. Substitute or damaged vent components may impair safe operation. Warning the maximum horizontal venting allowed with n...

  • Page 15

    May 12, 2017 7021-154j 15 castile freestanding straight out figure 15.1 figure 15.2 45 degree wall thimble illustration shows venting going in both directions. Choose which one is best for your installation. 2 in. (51mm) minimum 2 in. (51mm) minimum 6 in. (152mm) minimum 6 in. (152mm) minimum 6 in. ...

  • Page 16

    16 7021-154j may 12, 2017 castile freestanding c. Through the wall & vertical - exterior figure 16.1 figure 16.2 d. Vertical - interior - typical installation figure 16.3 non-combustible hearth pad airtight clean-out door clean-out cover sheathing 3 in. (76mm) minimum 1 in. (25mm) clearance flashing...

  • Page 17

    May 12, 2017 7021-154j 17 castile freestanding e. Masonry f. Alternate masonry figure 17.1 figure 17.2 non-combustible hearth pad airtight clean-out door clean-out cover sheathing 3 in. (76mm) minimum 1 in. (25mm) clearance flashing fireclay flue liner with airspace concrete cap 1 in. (25mm) clearan...

  • Page 18

    18 7021-154j may 12, 2017 castile freestanding 6 appliance set-up a. Outside air kit instructions parts included in kit: 1 piece of 2 inch x 3 foot flex hose, 2 hose clamps, 1 collar assembly,1 termination cap assembly, 1 trim ring, 12 screws. Tools needed: phillips head screwdriver; wire cutters; h...

  • Page 19

    May 12, 2017 7021-154j 19 castile freestanding figure 19.2 figure 19.1 top vent adapter 3 to 3 inch rear exhaust outlet use hole on each side as drilling guide offset collar 3 to 6 inch mount with 4 screws clean-out cover b. Top vent adapter installation 3 to 3 inch top vent adapter 3 to 6 inch top ...

  • Page 20

    20 7021-154j may 12, 2017 castile freestanding e. Optional log set placement instructions 2 piece log set installation 1. Open door to expose the firebox. 2. Install the left log first and then the right log. Figure 20.1 3. Lean the logs against the cast iron brick in the back of the firebox. 4. Pus...

  • Page 21

    May 12, 2017 7021-154j 21 castile freestanding figure 21.1 terminal block center 2 screws for thermostat wires power outlet fuse fuse w r figure 21.2 press and pull to remove press and pull to remove figure 21.3 thermostat operation digital display digital display back light heat (on) or off button ...

  • Page 22

    22 7021-154j may 12, 2017 castile freestanding 7 mobile home installation you must use a quadra-fire outside air kit for installation in a mobile home. 1. An outside air inlet must be provided for the combustion air and must remain clear of leaves, debris, ice and/or snow. It must be unrestricted wh...

  • Page 23: Castile-Fs-B

    May 12, 2017 7021-154j 23 castile freestanding 8 accessory list service parts r castile-fs-b beginning manufacturing date: oct. 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell...

  • Page 24

    24 7021-154j may 12, 2017 contact information hearth & home technologies 352 mountain house road halifax, pa 17032 division of hni industries please contact your quadra-fire dealer with any questions or concerns. For the number of your nearest quadra-fire dealer log onto www.Quadrafire.Com do not di...