1. DL manuals
  2. Racers Edge
  3. Toy
  4. GLG20
  5. Instruction Manual

Racers Edge GLG20 Instruction Manual

Other manuals for GLG20: Instructions, User Manual
Manual is about: 1:10 Scale RAdio Controlled Electric Powered 2WD Racing Buggy

Summary of GLG20

  • Page 2

    Operating instructions: · place the model on a car stand or something that holds all 4 wheels off the ground. Turn on the esc. · right after powering up the esc will denote a series of beeps denoting the neutral setting of the transmitter. A second beeping sound denotes the success of neutral setup....

  • Page 3

    1 control panel 2 steering wheel 3 throttle trigger 4 battery compartment 5 charging jack 6 sterring servo reverse 7 power led 8 steering trim 9 bind button 10 throttle servo reverse 11 battery voltage 12 steering dual rate 13 power switch 14 throttle trim 14 9 8 7 6 10 11 12 13 glg20 2.4ghz battery...

  • Page 4

    1 l r 2 1 3 1 3 2 1 2 4 5 front suspension front suspension t02056 3x34.5 hinge pin front inner ………………………………4 ………………………………2 t02056 2.3 e-ring ……………4 t02083 m3x15 screw t02059 ball stud - long ……………………2 3 1 2 assemble in the specified order l r assemble left and right sides the same way t02104 t02008...

  • Page 5

    4.0mm 2 4 3 3 1 2 3 1 4 2 5 6 11 7 8 9 10 t02043 4.0 e-ring …………………………1 ………………………4 t02080 3x6x2.5 ball bearing t02044 4.5x5.4 block carrier t02044 m3x10 screw ……………………………2 ………………2 t02060 ball stud - short ………………………2 t02136 ball stud - silvery ………………………1 ……………………2 t02044 3x7x0.8 washer 3 1 2 assemble...

  • Page 6

    3 5 6 l r 3 1 2 3 1 2 1 2 4 3 5 6 7 8 ……………8 t02054 2.3 e-ring t02060 ball stud-short ……………………4 …………2 t02079 5x10x4 ball bearing …………………4 t02054 3x27.5 hinge pin front outer ………4 t02042 2x9.8 shaft …………2 3 1 2 assemble in the specified order front suspension front suspension l r assemble left and ri...

  • Page 7

    4 7 9 t02029 4.8mm ball end(long) t02091 3x54 turnbuckle …………8 ………4 ………4 t02082 m3x10 screw ……2 t02082 m3x22 screw t02117 upper shock bushing …………………2 front suspension front suspension t02082(m3x22) t02091 t02029 t02029 t02082(m3x22) t02082(m3x10) t02117 t02117 t02129 front upper(right) front upper ...

  • Page 8

    10 differential ……………1 t02078 10x15x4 ball bearing t02156 4.8x1.6 o-ring ……………………1 ………………………1 t02154 2x8.8 pin t02154 5.1x13x0.2 washer ………………1 t02078 10x15x4 t02154 28t gear t02154 14t gear t02157 diff gear shaft t02154 2x8.8 t02155 gear differential outdrives t02152 52t diff gear t02156 4.8x1.6 t0...

  • Page 9

    6 apply grease screw cement apply threadlocker(screw cement) t02036 13 12 transmission motor mounts t02079 5x10x4 t02051 t02041 t02052 20t t02150 gear differential case-l t02150 gear differential case-r t02079 5x10x4 t02079 5x10x4 ts2031 28t t02079 5x10x4 ball bearing ………………4 t02051 5x16.8 idler gea...

  • Page 10

    Approx.18mm 7 15 14 t02084 m4 flanged nylon nut …………1 t02082 m3x10 screw ………………4 ……2 t02117 upper shock bushing ………………………2 main gear rear damper tower t02082(m3x22) t02117 t02082 m3x22 screw t02084 t02040 t02134 t02134 t02038 t02038 t02119 t02082(m3x10) t02082(m3x22) t02117 t02130 t02108.

  • Page 11

    8 17 16 t02059 ball stud - long ……………2 …………4 t02082 m3x10 screw …………2 t02083 m3x8 screw rear bulkhead rear chassis t02014 t02059 t02082 t02082 t02018 t02151 t02083.

  • Page 12

    9 l r …………4 t02083 m3x10 screw l r assemble left and right sides the same way t02014 t02105 19 18 …………………2 t02083 m3x8 screw t02055 3x48 hinge pin rear inner ……2 rear suspension rear suspension t02055 t02083 t02083.

  • Page 13

    Rear transmission 10 20 21 3 1 2 1 3 2 4 5 ……………2 t02082 m3x10 screw ……………2 t02082 m3x8 screw …………2 t02082 m3x10 screw …………4 rear shock tower & rear fender 3 1 2 assemble in the specified order screws which were semi tightened in p9 18 t02083 m3x8 screw 18 t02083(3x8) t02082 t02083 t02082(3x10) t020...

  • Page 14

    L r 22 23 11 l r t02060 ball stud - short ………………2 t02034 2x9.8 shaft t02079 5x10x4 b all bearing ……………4 t02057 3x30.5 hinge pin rear outer …………………………4 …………2 t02057 2.3 e-ring t02013 3.1x6x1 plastic washer ………………………2 rear suspension l r assemble left and right sides the same way apply grease rear sus...

  • Page 15

    24 26 12 t02029 4.8mm ball end(long) t02091 3x54 turnbuckle …………………………4 …………………………2 …………2 t02083 m3x8 screw …………2 t02083 m3x10 screw rear suspension main chassis t02083(3x10) t02108 t02083(3x8) t02083(3x10) t02108 t02108 t02108 1:1 x2 25 rear suspension x2 assemble as many times as specified 1:1 tur...

  • Page 16

    27 front 28 13 x2 x2 f r x2 3 2 1 2 shock absorber shock absorber f r assemble front and rear sides the same way 3 1 2 assemble in the specified order x2 assemble as many times as specified rear ……………………4 …………………………8 t02138 / t02139 2.3 e-ring t02068 9.9x2.5 shock piston …………………4 t02069 2.8x1.9 o-ri...

  • Page 17

    29 30 14 x2 x2 3 2 1 1 2 3 l r t02084 m3 nylon nut …………2 ……2 t02082 m3x15 screw 3 1 2 assemble in the specified order x2 assemble as many times as specified l r assemble left and rear sides the same way shock absorber front suspension for adjusting the spring tension compress the spring and install ...

  • Page 18

    31 32 15 l r t02084 m3 nylon nut …………2 ……2 t02082 m3x15 screw t02081 3x7x0.8 washer t02083 m3x8 screw t02082 m3x5 screw t02141 m3x3 screw ……………2 …………2 …………1 ………2 l r assemble left and rear sides the same way rear suspension 3 2 1 3 1 2 assemble in the specified order motor long t02082 t02084 1 2 3 4...

  • Page 19

    33 34 16 steering servo 3 2 1 1 2 3 4 3 1 2 assemble in the specified order radio electronic speed controller t02087 receiver t02030 t02027(25t) t02028 t02136 t02081 t02082 t02082 t02081 double-sided tape sanwa t02035 steering servo-h(24t) steering servo-s(23t) select for your servo sanwa servo t020...

  • Page 20

    35 36 17 after fitting wheels to tyres,apply instant glue as shown front x2 x2 …………2 battery battery wheels x2 assemble as many times as specified 3 2 1 1 2 3 4 3 1 2 assemble in the specified order t02086 small clip rear t02131 t02131 t02086 t02086 t02075(sponge) t02074(sponge) t02074 t02075 t02132...

  • Page 21

    37 38 18 t02086 small clip ……………5 t02084 m4 flanged nylon nut ……………4 x2 assemble as many times as specified body mounting body mounting 6mm drill holes with the specified diameter cut off shaded portion 6mm 6mm 3° 3° +3 deg -3 deg t02086 t02086 t02076 t02084 t02108 t02103 x3 t02118.

  • Page 22

    Exploded view t02056 t02056 t02056 t02104 t02059 t02083 t02026 t02037 t02014 t02080 t02080 t02043 t02023 t02043 t02136 t02080 t02015 t02024 t02044 t02060 t02044 t02082 t02082 t02082 t02082 t02054 t02054 t02054 t02060 t02056 t02042 t02060 t02034 t02079 t02012 t02079 t02029 t02091 t02029 t02082 t02082...

  • Page 23

    T02119 1pcs 80t spur gear t02103 t02005 gear cover ts2031 t02010 1pcs main chassis plate t02011 1pcs c-type holder l t02012 1pcs steering block-r t02013 rear hub carriers-l 1pcs gear cover button 1pcs 1pcs steering block-l 1pcs rear hub carriers-r 3.1x6x1 plastic washer 4pcs 1pcs 28t idler gear alum...

  • Page 24

    T02108 2pcs t02026 1pcs motor guard t02029 4.8 ball end-long t02030 t02114 t02027 1pcs steering t02028 2pcs servo plate t02132 2pcs t02133 t02034 4pcs hexagonal t02035 2pcs 1.0 servo spacer t02036 1pcs motor plate t02037 1pcs front hinge pin brace t02038 2pcs slipper pad 6pcs 2pcs 4.8 ball end-short...

  • Page 25

    T02054 t02055 t02051 1pcs idler gear shaft t02052 1pcs gear 20t t02056 t02057 t02135 2pcs rear drive shaft assembly t02059 t02060 t02136 t02137 4pcs shock end eyelet 5.8x6 t02117 t02138 2pcs 3x42.5 front shock shaft t02139 2pcs 3x51 rear shock shaft t02066 t02067 2pcs 2pcs 2pcs 3x30.5 hinge pin rear...

  • Page 26

    T02074 t02075 2pcs t02081 t02082 t02084 t02085 t02086 2pcs rear buggy tires with foams 2pcs 2pcs front ribbed buggy tires with foams 3x7x0.8 washer 10pcs 3x15 screw 3x8 screw 3x10 screw 3x8 screw 8pcs 8pcs 8pcs 8pcs m4 flanged nylon m3 nylon nut 6pcs 2.3 e-ring 4 e-ring small clip 8pcs t02083 6pcs n...

  • Page 27

    Tu0222 servo mount 2pcs tu0224 op op tu0223 rear arm mount -ball 8pcs op front arm mount 1set m3x3 buggy parts list tu0219 c-type-holder 25 degree op tu0218 servo saver-aluminium hex mount 5.1x8x0.2 washer m2x5 screw tu0225 4pcs 4pcs 4pcs op tu0220 tu0221 c-type-holder 30 degree rear arm mount f/r 1...

  • Page 28

    Buggy parts list ..................... ....................................$ $ ........$ ...... $ ................$ ................. $ .............................. $ $ ............................$ ....$ ...............$ ........... $ ...........$ .....$ ....$ ....$ ......................$ .........

  • Page 29

    Date driver track / city / comments front suspension ride height rear suspension / batteries shock mounting&camber link servo esc batteries motor conditions smooth bumpy low traction med traction high traction sandy soft dirt grass hard soil clay notes motor pinion/spur other / wing wing angle 4° 10...