1. DL manuals
  2. Radiant
  3. Water Heater
  4. 135RAD3L
  5. Owner's Manual

Radiant 135RAD3L Owner's Manual

Manual is about: 3 and 4 Star Gas Storage Water Heaters

Summary of 135RAD3L

  • Page 1

    Specifications and materials may change without notice. Effective for all prodigy water heaters manufactured and sold after 1 october 2012. Owner’s manual models: 3 star 135rad3n 135rad3l 170rad3n 170rad3l 4 star 135rad4n 135rad4l 170rad4n 170rad4l 3 and 4 star gas storage water heaters h3958 026271...

  • Page 2

    Owner’s manual – gas storage h3958 026271 rev. A welcome 1 installation details 2 gas connections 5 specifications 6 commissioning adjustments 7 owner’s information 10 system maintenance 12 troubleshooting 14 warranty 16 other information 19 notes 20 contents radiant ® is a registered trademark of d...

  • Page 3

    Owner’s manual – gas storage 1 h3958 026271 rev. A your decision to purchase a radiant hot water system will reward you for many years to come. Since 1915, the dux range has seen continuous research and development, resulting in many breakthroughs in the efficiency, reliability and longevity of hot ...

  • Page 4: Pool Heating

    Owner’s manual – gas storage 2 h3958 026271 rev. A pool heating this water heater must not be used for pool heating. Installation requirements this water heater must be installed by a licensed tradesperson, and in accordance with: • as/nzs3500.4 “national plumbing and drainage code hot water supply ...

  • Page 5: Water Supply Pressure

    Owner’s manual – gas storage 3 h3958 026271 rev. A the water heater for clearance above to replace the anode. A properly drained overflow tray must be used where property damage could occur from water spillage. (see as/nzs3500.4.2 for further details). Warranty does not cover consequential damage du...

  • Page 6: Cold Water Connection

    Owner’s manual – gas storage 4 h3958 026271 rev. A cold water connection it is mandatory to fit the following items between the supply main and the rp¾"/20mm socket in the water heater. • an isolating valve • a non return valve • a line strainer • a union all fittings must be approved by the relevan...

  • Page 7: Warning

    Owner’s manual – gas storage 5 h3958 026271 rev. A refer to the data label for correct gas type. Gas piping should be connected through the side of the case (see figure below). The plastic grommet must be installed around the pipe and clipped into the case. The gas control is fitted with a rc½"/15mm...

  • Page 8

    Owner’s manual – gas storage 6 h3958 026271 rev. A tank specifications 3 star 4 star model numbers 135rad3n 135rad3l 170rad3n 170rad3l 135rad4n 135rad4l 170rad4n 170rad4l capacity (l) 135 170 135 170 net weight empty (kg) 72 86 72 86 relief valve pressure (kpa) 1400 1400 1400 1400 gas consumption (m...

  • Page 9: Tradesperson.

    Owner’s manual – gas storage 7 h3958 026271 rev. A n ote: commissioning adjustments must be done only by a licensed tradesperson. Lighting the water heater the water heater must be filled with water before lighting. Instructions for lighting procedure are on the inside of the access cover and shown ...

  • Page 10: Warning:

    Owner’s manual – gas storage 8 h3958 026271 rev. A may already be at the selected temperature. Warning: do not attempt to light if the pilot is out and the knob is in the “on” position (one of the number settings). Follow steps above. Shutting down the water heater 1. Turn the knob to “•” (off) posi...

  • Page 11: Note:

    Owner’s manual – gas storage 9 h3958 026271 rev. A note: pressure adjustments at gas cylinder regulator should be conducted as required to ensure correct supply pressure to water heater as per as5601/ag601. Ignition system (spark gap) if there is no spark or the spark looks weak, adjust as follows: ...

  • Page 12: Safety

    Owner’s manual – gas storage 10 h3958 026271 rev. A safety this appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the a...

  • Page 13: How Long Will The Heater Run

    Owner’s manual – gas storage 11 h3958 026271 rev. A how long will the heater run each day? The length of time that the heater will run each day will vary dependent upon the amount of hot water being used by the household. Caution: all water heaters have the ability to produce hot water in a surprisi...

  • Page 14: How Does My System Work?

    Owner’s manual – gas storage 12 h3958 026271 rev. A how does my system work? The dux water storage tank is used to store the heated water ready for household use. It has a high temperature vitreous enamel lining to provide long life, and a high density polyurethane insulation to ensure minimal heat ...

  • Page 15

    Owner’s manual – gas storage 13 h3958 026271 rev. A v. Gently operate the pressure & temperature relief valve to let air into the heater and allow water to escape through the hose. Vi. Flush the heater until clear water appears then reconnect all fittings, fill the heater and restore the gas supply....

  • Page 16: What Should I Check Before

    Owner’s manual – gas storage 14 h3958 026271 rev. A what should i check before making a service call? If there is not enough hot water, it is recommended that the following points be considered before making a service call. If after checking the following points the problem has not been identified, ...

  • Page 17

    Owner’s manual – gas storage 15 h3958 026271 rev. A • replace faulty tap washers and have your plumber rectify any leaking pipe work. Troubleshooting.

  • Page 18: Radiant Hot Water Unit

    Owner’s manual – gas storage 16 h3958 026271 rev. A radiant hot water unit manufactured by dux manufacturing limited (“dux”) terms of warranty and replacement guarantee all radiant water heaters manufactured and sold after 1 january 2012 are backed by a comprehensive one (1) year full parts and labo...

  • Page 19

    Owner’s manual – gas storage 17 h3958 026271 rev. A which may have arisen as a result of, without limitation, the following: accidental damage, abuse, misuse, maltreatment, abnormal stress or strain, harsh or adverse water conditions including excessive water pressure or temperature, neglect of any ...

  • Page 20: Contact Details

    Owner’s manual – gas storage 18 h3958 026271 rev. A • proof of purchase; • date of installation; • contact details; • product serial number. Contact details dux’s contact details are as follows: business address: dux manufacturing limited lackey road moss vale, nsw, 2577 australia telephone: 1300 36...

  • Page 21

    Owner’s manual – gas storage 19 h3958 026271 rev. A product warranty is applicable only in australia and new zealand. See page 16 for terms of warranty. Privacy act amendment (2000): if and whenever warranty service is required, your personal details will be given to an authorised dux service agent ...

  • Page 22

    Owner’s manual – gas storage 20 h3958 026271 rev. A notes.

  • Page 23

    Owner’s manual – gas storage 21 h3958 026271 rev. A notes.

  • Page 24

    Owner’s manual – gas storage h3958 026271 rev. A 3 and 4 star gas storage water heaters serial number for advice, repairs and service, call: 1300 365 115 (australia) 0800 729 389 (new zealand) www.Dux.Com.Au/warranty please register your water heater please take a moment to fill out your details for...