1. DL manuals
  2. Radio Systems
  3. Transmitter
  4. TR-6000
  5. Operating Instructions Manual

Radio Systems TR-6000 Operating Instructions Manual - Table of Contents

Manual is about: AM Broadcast Transmitter

Summary of TR-6000

  • Page 1

    Radio systems tr-6000 10 watt am broadcast transmitter operating instructions 601 heron drive • logan township, nj 08085 phone: 856-467-8000 • fax: 856-467-3044 www.Radiosystems.Com.

  • Page 2

    Radio systems tr-6000 am broadcast transmitter radio systems tr-6000 am broadcast transmitter page 2 radio systems tr-6000 am broadcast transmitter operation manual radio systems tr-6000 am broadcast trasnmitter — part # man-tr6000 manual revision 04-04-2012 to reflect new packaging with thin front ...

  • Page 3: Table of Contents

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 3 table of contents specifications ...................................................................................................................... 4 operating instructions ........................................................

  • Page 4: Specifications

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 4 specifications r.F. Power output adjustable to 10 watts type of emission amplitude modulation (a3) frequency range 500 khz to 1.71 mhz (500 to 1710 khz in the am broadcast band) frequency stability ± 20 hz (-20° to +50° c) carrier...

  • Page 5

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 5 tr-6000 am broadcast transmitter operating instructions overview the tr-6000 is a solid-state, class d am transmitter specially designed for traveler’s information, carrier current, roadside radio, and other low-power broadcast ba...

  • Page 6

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 6 tr-6000 jumper settings j3 power control relay configuration - relay power supplied by main + input (not fused) - relay power supplied by n.C. Contact - relay power supplied by n.O. Contact - relay power supplied by common contact...

  • Page 7

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 7 j8 clock source j10 reference i/o j11 standard oscillator no i/o tcxo no i/o standard oscillator standard oscillator out tcxo tcxo out external reference in external reference in note: * indicates factory setting * * *.

  • Page 8

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 8 1 2 3 4 5 + dc (not fused) to relay coil + dc to n.C. Relay contact + dc to n.O. Relay contact + dc to common relay contact + dc (fused) to relay coil note: factory jumper defaults (jumpers 1 & 3) energize relay common contact wit...

  • Page 9

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 9 tr-6000 frequency change procedure 1. Set dip switches s1, s2 and s3 for the desired output frequency. 2. Set the output filter jumpers for low or high band. 3. Adjust the power control vr1 to its minimum position. 4. Turn vr10 an...

  • Page 10

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 0 tr-6000 test procedure 1. Check the circuit board for solder shorts and bad solder joints. 2. Check the alignment of the terminal strips, headphone jack and potentiometers. 3. Check for proper installation of diodes, transistors...

  • Page 11

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 1 31. Increase the audio generator level to 0 dbm and adjust vr3 to the point just below clipping of the rf envelope. 32. Adjust vr6 for 90% to 95% modulation. 33. Decrease the audio generator level in 10 db steps and check for at...

  • Page 12

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 2.

  • Page 13

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 3.

  • Page 14

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 4.

  • Page 15

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 5 b.

  • Page 16

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 6.

  • Page 17

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 7.

  • Page 18

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 8.

  • Page 19

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 1 9 bill of materials level 1 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 seq. 10 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 20 30 40 50 60 70 80 90 100 110 120 130 140 150 160 170 180 component - item 11...

  • Page 20

    R a d i o s y s t e m s , i n c . T r - 6 0 0 0 m a n u a l p a g e 2 0 warranty radio systems, inc. Warrants this equipment to be free from defects in materials and workmanship for a period of one (1) year. This warranty extends to first users of the product and future owners who purchase this prod...

  • Page 21

    For assy: part #11234 04/12 601 heron drive logan township, nj 08085 phone: 856-467-8000 fax: 856-467-3044 http://www.Radiosystems.Com.