1. DL manuals
  2. RAIS
  3. Indoor Fireplace
  4. 700 
  5. Instructions For The Use

RAIS 700  Instructions For The Use

Manual is about: Rais 700

Summary of 700 

  • Page 1

    English rais ­ manual for rais 700 1 instructions for installation, use and maintenance rais 700 important information on first lighting the stove you must be careful not to touch the painted surfaces and it is most important that the door is kept slightly ‘ajar’ in order for the door seal and seala...

  • Page 2

    English rais ­ manual for rais 700 2.

  • Page 3: Rais 700

    English rais ­ manual for rais 700 3 revision date : 2011 introduction ………………………………………………………….. 4 warranty …………………………………………………….………….. 4 specifications ………………………………………………………….. 5 installation instructions ………………………………….……… 6 convection ……………………………………..……….………... 7 chimney ……………………..…………………………….…………....

  • Page 4: Warranty

    English rais ­ manual for rais 700 4 a rais wood burning stove is more than just a heat source: it also shows that you care about design and quality in your home. To make the most of your wood burning stove it is important that you read the manual thoroughly before installing and using it. In the ca...

  • Page 5: Specifications

    English rais ­ manual for rais 700 5 nominal output (kw): min. / max. Output (kw): efficiency (%): particles after ns3058/3059 (g/kg): dust measured according to din+ (mg/nm 3 ): smoke gas mass flow (g/s): smoke gas temperature (°c): intermittent operation: heating area (m 2 ): size, width/depth/hei...

  • Page 6: Installation Instructions

    English rais ­ manual for rais 700 6 installation instructions the following pages give instructions for the safe and proper installation of this heating appliance in the uk. These instructions cover the basic principles of installation, although some details may need slight modification to suit par...

  • Page 7

    English rais ­ manual for rais 700 7 the stoves are equipped with cool door handles ­ a rais special feature ­ which means you could almost do away with gloves. Be aware, however, that all exterior surfaces become hot during use ­ so take extreme care. Convection rais stoves are convection stoves. T...

  • Page 8

    English rais ­ manual for rais 700 8 any bend in the chimney or connecting fluepipe should not exceed 45°. 90° bends should not be used. Combustible material should not be located where the heat dissipating through the walls of fireplaces or flues could ignite it. Therefore when installing the stove...

  • Page 9

    English rais ­ manual for rais 700 9 flue outlet positions.

  • Page 10

    English rais ­ manual for rais 700 10 hearth the hearth should be able to accommodate the weight of the stove and its chimney if the chimney is not independently supported. The weight of the stove is indicated in the brochure. The stove should preferably be installed on a non­combustible hearth of a...

  • Page 11

    English rais ­ manual for rais 700 11.

  • Page 12

    English rais ­ manual for rais 700 12.

  • Page 13

    English rais ­ manual for rais 700 13 ventilation ­ make the best possible use of the inserts. The stove is equipped with four convection air outlets, which can be connected with suitable air ducts to other rooms. Note, this is not a working drawing..

  • Page 14

    English rais ­ manual for rais 700 14 combustion air supply in order for the stove to perform efficiently and safely there must be an adequate air supply into the room in which the stove is installed to provide combustion air. The provision of air supply to the stove must be in accordance with curre...

  • Page 15

    English rais ­ manual for rais 700 15 it is possible to order ‘made to measure’ frames. Contact your rais dealer. A a lift the stove from the pallet to the place of installation on to a suitably protected floor. The stove can be mounted on the optional adjustable stand ( see page 29 ). These are ava...

  • Page 16

    English rais ­ manual for rais 700 16 insulation ability such as aqua panel ( coefficient of thermal conductivity 0.36 w/mk ) or better. Please use metal stud. Insulate ceiling if necessary.

  • Page 17

    English rais ­ manual for rais 700 17 insulate ceiling if necessary.

  • Page 18

    English rais ­ manual for rais 700 18 distance to non combustible material 50mm min distance to non combustible material 50mm min insulate ceiling if necessary.

  • Page 19

    English rais ­ manual for rais 700 19.

  • Page 20

    English rais ­ manual for rais 700 20

  • Page 21

    English rais ­ manual for rais 700 21 installation distance in case of combustible wall to find out whether the wall next to where the stove is going to be installed is flammable, you should contact your building contractor or the local building authorities. The hearth should be able to accommodate ...

  • Page 22: Operating Instructions

    English rais ­ manual for rais 700 22 only use recommended fuels the following table shows the calorific value of different types of wood, which have been stored for 2 years and which have a residual moisture of 15 ­ 17%. Wood kg dry wood pr m 3 compared to beech/oak hornbeam 640 110% beech and oak ...

  • Page 23

    English rais ­ manual for rais 700 23 drying and storage drying wood takes time: proper air drying takes approximately 2 years. Here are some tips: store the wood sawn, split and stacked in an airy, sunny place, which is protected against rain (the south side of the house is particularly suitable). ...

  • Page 24

    English rais ­ manual for rais 700 24 using the wood burning stove adjustment of the air damper ­ the damper has 3 settings position 1 the damper is almost closed meaning that there is a minimal air intake. Position 2 pull the lever until the first click. This position gives full secondary air. Duri...

  • Page 25

    English rais ­ manual for rais 700 25 before lighting the stove check with the installer that the installation work and commissioning checks described above have been carried out correctly and that the chimney has been swept clean, is sound and free from any obstructions. As part of the stoves’ comm...

  • Page 26

    English rais ­ manual for rais 700 26 to light the stove, use alcohol briquettes or similar, as well as approximately 2kg of firewood, split into kindling sticks. Set the air damper to the fully open position. Tips before firing up: open a door or window close to the wood burning stove. If there is ...

  • Page 27

    English rais ­ manual for rais 700 27 when the flames are clear, after approximately 5­10 minutes, close the door. Damper ­ see adjustment of the damper. After approximately 10­20 minutes, when you have a good bed of glowing embers, add 2­3 pieces of wood. Leave the door ajar until the fire has caug...

  • Page 28: Maintenance

    English rais ­ manual for rais 700 28 maintenance cleaning and care the wood burning stove and the chimney must be serviced by a chimney sweep twice a year. During cleaning and care, the stove must be cold. If the glass is sooty: ­ moisten a piece of paper or newspaper, dip it in the ash, and rub th...

  • Page 29

    English rais ­ manual for rais 700 29 the flue ways consist of a baffle plate and a smoke conductor above. These parts are screwed together. Both parts are made of vermiculite. Handle these parts carefully. Lift the baffle plate a little and push towards one of the sides. Remove the baffle plate by ...

  • Page 30

    English rais ­ manual for rais 700 30 problem solving smoke spillage around door: ­ could be due to too low draught in the chimney ­ check if the flue or chimney is blocked soot on glass: ­ could be because the firewood is too wet. ­ make sure that the stove is heated properly when firing up, prior ...

  • Page 31

    English rais ­ manual for rais 700 31 do’s and don’ts do’s · sweep the chimney / flue twice a year. · service the appliance at least once a year · dry, burn dry wood only. Use a moisture meter if unsure. · spares, only use genuine rais spare parts · contact your dealer if you are unsure about the op...

  • Page 32

    English rais ­ manual for rais 700 32 7090501mon stand 70914spec special frame 7091790 air system manifold kit 7090506 telescopic support 7091301sv special adaptor spare parts are available to order from your rais dealer / stockist. 7091401sort complete cover 7092090 steel door 7091090 glass door 70...

  • Page 33

    English rais ­ manual for rais 700 33.

  • Page 34

    English rais ­ manual for rais 700 34 u k distributor. Robeys ltd. Riverside, goods road, belper, derbyshire, england. De56 1uu tel: 01773 820940 fax: 01773 820477 e mail: info@robeys.Co.Uk www.Robeys.Co.Uk june 2011.