1. DL manuals
  2. RAIS
  3. Wood stove
  4. PALO C
  5. User Manual

RAIS PALO C User Manual

Manual is about: Q­-BIC; Q-BIC insert

Summary of PALO C

  • Page 1

    English rais - manual for palo, palo c and pilar 1 u s e r m a n u a l rais palo & pilar.

  • Page 2

    W e cannot be held r esponsible for any misprints.

  • Page 3

    English rais - manual for palo, palo c and pilar 3 rais palo & palo c rais pilar dato : december 2009 modified : 4 introduction .................................................................................................................................. 4 warranty .................................

  • Page 4

    4 english rais - manual for palo, palo c and pilar introduction thank you for purchasing a rais wood burning stove. These appliances have been ap- proved by hetas ltd as intermittent operating appliances for burning wood logs only. A rais wood burning stove is more than just a heat source: it also s...

  • Page 5

    English rais - manual for palo, palo c and pilar 5 specifications p alo p alo c pilar 152 pilar 172 nominal outputt (kw): 5 5 5 5 min./max. Output (kw): 2-6 2-6 2-6 2-6 heating ar ea (m 2 ): ca. 80 ca. 80 ca. 80 ca. 80 stove’ s width/depth/height (mm): 435-428-1240 435-428-1240 Ø440-1520 Ø440-1720 c...

  • Page 6

    6 english rais - manual for palo, palo c and pilar convection rais stoves are convection stoves. This means that the stove’s back and side panels are not over-heated. Convection means that there is a circulation of air, which ensures that the heat is distributed more evenly throughout the entire roo...

  • Page 7

    English rais - manual for palo, palo c and pilar 7 installation instructions the following pages give instructions for the safe and proper installation of this heating ap- pliance in the uk. These instructions cover the basic principles of installation, although detail may need slight modification t...

  • Page 8

    8 english rais - manual for palo, palo c and pilar chimney the chimney is the driving force which makes the stove function. In order for the stove to perform satisfactorily the chimney height must be sufficient to ensure the correct draught of 14 to 18 pa so as to clear the products of combustion an...

  • Page 9

    English rais - manual for palo, palo c and pilar 9 if it is found that there is excessive draught in the chimney then either an adjustable flue damper or alternatively a draught stabiliser should be fitted. The adjustable flue damper should not close off the flue entirely but should in its closed po...

  • Page 10: Palo / Palo C

    10 english rais - manual for palo, palo c and pilar palo & palo c manufacturer’s plate pilar manufacturer’s plate en 13240:2001+a2:2004 ec.Nr. 606 anordning til intervalfyring produktdokumentation sintef producent afstand til brændbart, bagvæg afstand til brændbart, sidevæg afstand til brændbart, dr...

  • Page 11

    English rais - manual for palo, palo c and pilar 11 installation it is prohibited to carry out unauthorised alterations to the stove. There must be plenty of fresh air in the room where the stove is being installed, in order to ensure proper combustion. Note that any mechanical exhaust ventilation -...

  • Page 12

    12 english rais - manual for palo, palo c and pilar operation of swivel base swivel base (palo) if the distriutor has already installed a swivelbase on the stove, you should do the follo- wing: swivel base (pilar) pos. 1: swivelbase locked pos.2: swivel angle 70° pos. 3: swivel angle 160° note!!! On...

  • Page 13

    English rais - manual for palo, palo c and pilar 13.

  • Page 14

    14 english rais - manual for palo, palo c and pilar normal set-up - only palo and palo c corner set-up (right-angled) secure base secure base a. Distance to furniture 750 mm 750 mm distance to flammable materials: b. - in front (floor) 300 mm 300 mm c. - to the side (floor) 150 mm 150 mm d. - rear (...

  • Page 15

    English rais - manual for palo, palo c and pilar 15 right-angled corner set-up 70° swivel base 70° swivel base a. Distance to furniture 750 mm 750 mm distance to flammable materials: b. - in front (floor) 300 mm 300 mm c. - to the side (floor) 150 mm 150 mm d. - rear (wall) 150 mm 150 mm e. -to the ...

  • Page 16

    16 english rais - manual for palo, palo c and pilar right-angled corner set-up 160°/360° swivel base 360° swivel base a. Distance to furniture 950 mm 950 mm distance to flammable materials: b. - in front (floor) 300 mm 300 mm installation distance in case of non-combustible wall we recommend a minim...

  • Page 17

    English rais - manual for palo, palo c and pilar 17 for the installer finally before firing the stove for the first time a check should be made to ensure that the as- sembly and stove installation has been satisfactory and that there are no leaks in any seals in the appliance and appliance connectio...

  • Page 18

    18 english rais - manual for palo, palo c and pilar the following table shows the calorific value of different types of wood, which have been stored for 2 years, and which have a residual moisture of 15-17%. Wood kg dry wood pr. M 3 compared to beech/oak hornbeam 640 110% beech and oak 580 100% ash ...

  • Page 19

    English rais - manual for palo, palo c and pilar 19 drying and storage drying wood takes time: proper air drying takes approx. 2 years. Here are some tips: store the wood sawn, split and stacked in an airy, sunny place, which is protected against rain (the south side of the house is particularly sui...

  • Page 20

    20 english rais - manual for palo, palo c and pilar control if the ash is white and the walls in the combustion chamber sott-free after the stove has been used, the air regulation was set correctly and the wood was sufficiently dry. Using the wood burning stove adjustment of the air damper. The damp...

  • Page 21

    English rais - manual for palo, palo c and pilar 21 first usage a careful start pays off. Start with a small fire, so that the wood burning stove can get accus- tomed to the high temperature. This gives the best start and any damage is avoided. Be aware that a strange but harmless odour and smoke co...

  • Page 22

    22 english rais - manual for palo, palo c and pilar light the fire and shut the door, leaving the door ajar approx. 10-15 mm. Lighting and fuelling tips before firing up: open a door or window close to the wood burn- ing stove. If there is a “storm” in the stove coming from the chimney, it is advisa...

  • Page 23

    English rais - manual for palo, palo c and pilar 23 when the flames are clear - after approx. 5-10 min. - close the door. Damper - see adjustment of air damper. After approx. 10-20 min. - when you have a good bed of glowing embers - add 2-3 pieces of wood. Leave the door ajar until the fire has caug...

  • Page 24

    24 english rais - manual for palo, palo c and pilar cleaning and care the wood burning stove and the chimney must be serviced by a chimney sweep twice a year. During cleaning and care, the stove must be cold. If the glass is sooty: - moisten a piece of paper or newspaper, dip it in the ash, and rub ...

  • Page 25

    English rais - manual for palo, palo c and pilar 25 cleaning of the flue ways remove the baffle plate by pivoting it up at one end and tilting it slightly at an angle. Carefully pull out the plate. Remove the upper baf- fle plate by pushing it up towards the smoke leader, tilting it slightly at an a...

  • Page 26

    26 english rais - manual for palo, palo c and pilar interruption of operation smoke spillage around door: could be due to too low draught in the chimney - check whether the flue or chimney is blocked - check whether the extraction hood is switched on; if it is, switch it off and open a win- dow/door...

  • Page 27

    English rais - manual for palo, palo c and pilar 27 accessories and spare parts if spare parts other than those recommended by rais are used, the warranty is voided. All replaceable parts can be bought as spare parts from your rais distributor. See the following spare parts diagrams for the individu...

  • Page 28

    28 english rais - manual for palo, palo c and pilar spare parts diagram - pilar pos. Number item no./description 1 1 5040602sv stainless steel topplate with hole 504060590/95 steel topplate with hole 2 1 5040601sv stainless steet topplate without hole 504060490/95 steel topplate without hole 3 1 504...

  • Page 29

    English rais - manual for palo, palo c and pilar 29.

  • Page 30

    30 english rais - manual for palo, palo c and pilar spare parts diagram - palo pos. Number item no./description 1 1 6040604sv stainless steel topplate without hole 604060190/95 steel topplate without hole 2 1 6040605sv stainless steet topplate with hole 604060290/95 steel topplate with hole 3 1 6041...

  • Page 31

    English rais - manual for palo, palo c and pilar 31.

  • Page 32

    32 english rais - manual for palo, palo c and pilar spare parts diagram - palo c pos. Number item no./description 1 1 6040604sv stainless steel topplate without hole 604060190/95 steel topplate without hole 2 1 6040605sv stainless steet topplate with hole 604060290/95 steel topplate with hole 3 1 60...

  • Page 33

    English rais - manual for palo, palo c and pilar 33.

  • Page 34

    34 english rais - manual for palo, palo c and pilar.

  • Page 35

    English rais - manual for palo, palo c and pilar 35.

  • Page 36

    Rais a/s industrivej 20 dk-9900 frederikshavn www.Rais.Dk.