RAIS Riva User Manual

Summary of Riva

  • Page 1

    1 english rais - manual for rais riva u s e r m a n u a l rais riva.

  • Page 2

    W e cannot be held r esponsible for any misprints..

  • Page 3

    3 english rais - manual for rais riva rais riva revision: 0 dato : december 2009 introduction .................................................................................................................................. 4 warranty ...................................................................

  • Page 4

    4 english rais - manual for rais riva introduction thank you for purchasing a rais wood burning stove. A rais wood burning stove is more than just a heat source: it also shows that you care about design and quality in your home. To make the most of your wood burning stove it is important that you re...

  • Page 5

    5 english rais - manual for rais riva rais riva nominal output (kw): 4,5 min./max. Output (kw): 2-7 heating area (m 2 ): ca. 80 stove’s width/depth/height (mm): 510-433-838 combustion chamber’s width/depth/height (mm): 360-240-380 recommended amount of wood when fuelling (kg): (distributed on 2-3 lo...

  • Page 6

    6 english rais - manual for rais riva convection rais stoves are convection stoves. This means that the stove’s back and side panels are not over-heated. Convection means that there is a circulation of air, which ensures that the heat is distributed more evenly throughout the entire room. The cold a...

  • Page 7

    7 english rais - manual for rais riva installation instructions the following pages give instructions for the safe and proper installation of this heating appliance in the uk. These instructions cover the basic principles of installation, although detail may need slight modification to suit particul...

  • Page 8

    8 english rais - manual for rais riva chimney the chimney is the driving force which makes the stove function. In order for the stove to perform satisfactorily the chimney height must be sufficient to ensure the correct draught of 14 to 18 pa so as to clear the products of combustion and prevent pro...

  • Page 9

    9 english rais - manual for rais riva if it is found that there is excessive draught in the chimney then either an adjustable flue damper or alternatively a draught stabiliser should be fitted. The adjustable flue damper should not close off the flue entirely but should in its closed position leave ...

  • Page 10: Riva

    10 english rais - manual for rais riva installation when installing the wood burning stove, there are some rules which must be followed: the stove must be set up and installed in accordance with all current national and local rules and regulations. Local authorities and a chimney specialist should b...

  • Page 11

    11 english rais - manual for rais riva change of chimney connection the stove is delivered ready for top outlet, but may be changed to back outlet in the fol- lowing way: remove smoke converter plate and smoke conduc- tor (see cleaning and care). Loosen the 3 pcs. M6 nuts by a wrench. Mount the smok...

  • Page 12

    12 english rais - manual for rais riva installation description the stove is only to be placed on non-combus- tible walls without cracks or other weaknesses. Ovnen må kun ophænges på ikke brændbare vægge uden revner. Local authorities and a chimney specialist should be contacted concern- ing the sui...

  • Page 13

    13 english rais - manual for rais riva check if the topplate of the burning chamber is horizontal. If necesssary washers are placed between the brackets as shown on the pictures to align the burning chamber relative to the wall. The burning chamber (without door or panels) are lifted on to the brack...

  • Page 14

    14 english rais - manual for rais riva sidepanels are lifted on to the guides in the bottom. The distance between the side panels and the fron panel to be equal in both sides. The front cover are mounted and fastened by two nuts. Sidepanels are fastened in the top by two bolts..

  • Page 15

    15 english rais - manual for rais riva the bottom plate is mounted with two bolts. The top plate in put on and the door is carefully installed again. For top connected stoves the flue pipe in in- stalled. The stove is finished. Check the full functional- ity of the door and air control. The sweeper ...

  • Page 16

    16 english rais - manual for rais riva installation distance in case of combustible wall to find out whether the wall next to where the stove is going to be installed is flammable, you should contact your building contractor or the local building authorities. The hearth should be able to accommodate...

  • Page 17

    17 english rais - manual for rais riva normal set-up - non combustible wall rais riva a. Distance to furniture 1000 mm distance to flammable materials: b. - in front (floor) 300 mm c. - to the side (floor) 150 mm d. - to the side of the wall 350 mm e. - to the floor 200 mm f. - to the ceiling 1000 m...

  • Page 18

    18 english rais - manual for rais riva for the installer finally before firing the stove for the first time a check should be made to ensure that the assembly and stove installation has been satisfactory and that there are no leaks in any seals in the appliance and appliance connections to the chimn...

  • Page 19

    19 english rais - manual for rais riva operating instructions fuel the stove is designed and approved in accordance with en 13240 and ns 3058 for stok- ing split, dried firewood. The firewood must have a water content of 15-22% and its max. Length should be the length of the combustion chamber minus...

  • Page 20

    20 english rais - manual for rais riva the following table shows the calorific value of different types of wood, which have been stored for 2 years, and which have a residual moisture of 15-17%. Wood kg dry wood pr. M 3 compared to beech/oak hornbeam 640 110% beech and oak 580 100% ash 570 98% maple...

  • Page 21

    21 english rais - manual for rais riva regulating the combustion air all rais stoves are equipped with a one-handed operating lever for regulating the damp- er. The stove-specific regulating mechanisms can be seen on the diagrams. Primary air is the combustion air added to the primary combustion zon...

  • Page 22

    22 english rais - manual for rais riva control if the ash is white and the walls in the combustion chamber sott-free after the stove has been used, the air regulation was set correctly and the wood was sufficiently dry. Using the wood burning stove adjustment of the air damper. The damper has 3 sett...

  • Page 23

    23 english rais - manual for rais riva first usage a careful start pays off. Start with a small fire, so that the wood burning stove can get accus- tomed to the high temperature. This gives the best start and any damage is avoided. Be aware that a strange but harmless odour and smoke concoction may ...

  • Page 24

    24 english rais - manual for rais riva light the fire and shut the door, leaving the door ajar approx. 10-15 mm. Lighting and fuelling tips before firing up: open a door or window close to the wood burn- ing stove. If there is a “storm” in the stove coming from the chimney, it is advisable to place ...

  • Page 25

    25 english rais - manual for rais riva when the flames are clear - after approx. 5-10 min. - close the door. Damper - see adjustment of air damper. After approx. 10-20 min. - when you have a good bed of glowing embers - add 2-3 pieces of wood. Leave the door ajar until the fire has caught on properl...

  • Page 26

    26 english rais - manual for rais riva cleaning and care the wood burning stove and the chimney must be serviced by a chimney sweep twice a year. During cleaning and care, the stove must be cold. If the glass is sooty: - moisten a piece of paper or newspaper, dip it in the ash, and rub the sooty gla...

  • Page 27

    27 english rais - manual for rais riva cleaning of flue way remove the smoke converter plate by tilting it to one side and turning it a little slantwise. Pull out the plate carefully. Then remove the smoke conductor by lifting it up and moving it forward. Carefully lift out the smoke conduc- tor. Re...

  • Page 28

    28 english rais - manual for rais riva interruption of operation smoke spillage around door: could be due to too low draught in the chimney - check whether the flue or chimney is blocked - check whether the extraction hood is switched on; if it is, switch it off and open a win- dow/door in the proxi...

  • Page 29

    29 english rais - manual for rais riva accessories and spare parts if spare parts other than those recommended by rais are used, the warranty is voided. All replaceable parts can be bought as spare parts from your rais distributor. See the following spare parts diagrams for the individual products..

  • Page 30

    30 english rais - manual for rais riva spare part drawing - rais riva pos./ref. Quantity part no./description 1 1 410060190/95 top plate without hole 2 1 410060290/95 top plate with hole 3 1 2101090/95 door 4 1 2100990 air-system 5 1 2102200 firebrick set 6 - 2105500 seal set.

  • Page 31

    31 english rais - manual for rais riva 2 1 5 3 4 6.

  • Page 32

    Rais a/s industrivej 20 dk-9900 frederikshavn www.Rais.Dk.