Summary of VIVA L USA
Page 1
U s e r m a n u a l viva l usa.
Page 2
U s e r m a n u a l viva l usa viva 100/120/160 l usa sparepart drawing 1 2 3 4 5 6 7 8 9 10 11 12 14 13 15 16 17 18 19.
Page 3
1 2 3 4 5 6 7 8 9 10 11 12 13 22 14 15 16 17 20 18 21 19 24 23 25 viva 100/120/160 l g usa sparepart drawing.
Page 4
W e cannot be held responsible for any misprints recycling: the oven is wrapped in packaging that is recyclable. This must be disposed of according to national rules regarding the disposal of waste. The glass can not be reused. The glass should be discarded along with the residual waste from ceramic...
Page 5
5 us english user manual viva l usa list of content - viva l usa omni report no. : # 0138ws017e revision : 0 date (dmy) : 22-02-2017 spare part drawings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3 introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...
Page 6: Introduction
Us english 6 user manual viva l usa introduction congratulations on the purchase of your new rais woodburning stove. A rais woodburning stove is more than just a source of heat, it is a symbol of the emphasis you put on decorating your home with superiorly designed high-quality products. Please read...
Page 7
7 us english user manual viva l usa u.S. Environmental protection agency certified to comply with 2020 particulate emission standards using crib wood. 1.1 g/hr, method 28r this wood heater needs periodic inspection and repair for proper operation. It is against federal regulations to operate this wo...
Page 8
Us english 8 user manual viva l usa viv a 100 l usa viv a 120 l usa viv a 160 l usa w eight of stove app. 198 lbs (90 kg) app. 220 lbs (100 kg) app. 251 lbs (1 14 kg) stove exterior: width/depth/height Ø18,5” / 39,4 “ Ø470mm / 1000 mm Ø18,5” / 47,25” Ø470mm / 1200mm Ø18,5” / 63” Ø470mm / 1600mm fire...
Page 9: Convection
9 us english user manual viva l usa convection all rais stoves are convection stoves, which means that the sides of the stove never get too hot. Convection works by pulling cold air into the system at the base of the stove and up through the convection duct that is located along the combustion chamb...
Page 10: Chimney
Us english 10 user manual viva l usa chimney rais stoves must be installed using a class a ul 103 ht approved factory-built chimney system or a code-approved masonry chimney with a flue liner. In canada, the appliance must be connected to a factory-built chimney conforming to can/ulc- s629. The chim...
Page 11: Important Note:
11 us english user manual viva l usa chimney flue masonry insulated chimney connector pipe 18” (46cm) below ceiling min. 2” (5cm) min. 2” (5cm) for rear venting or other unlisted configu- rations, consult the local building codes and follow the nfpa 211 guidelines. If the stovepipe is fitted with a ...
Page 12: Installation
Us english 12 user manual viva l usa installation precautions and specifications before installation, remember to consult your local building inspector or fire marshal to determine the need to obtain a permit. Also enquire about restrictions and installa- tion inspection requirements in your area. I...
Page 13
Us english 13 user manual viva l usa adja cen t w allad jac en t w all c c ba ck w all side wa ll cl ea ra nc es to co mb us tib le su rfa ce s **r ea r/t op ve nt op tio n ce ilin g ** fl oo r pr ot ec to r se e f ur th er fl oo r p ro te ct io n re qu ire m en ts at b ot to m o f t hi s l ab el. F...
Page 14
14 us english user manual viva l usa to prevent house fires contact local 8uilding or fire officials about restrictions and installation ins pe cti on in your area. Lnstall and us e only in accordance with manufacturer's installation and operating instructions an d local codes. In absence of any loc...
Page 15
Us english 15 user manual viva l usa ad jac en t w all adjacent wall c c back wall si de w all clearances to combustible surfaces **rear/top vent option ceiling ** floor protector see further floor protection requirements at bottom of this label. Floor protection for canada: 30" (76 cm) from unit to...
Page 16
16 us english user manual viva l usa **: please refer to nfpa guidelines in usa and can/csa b365-m91 in canada. Ad jac en t w all adjacent wall c c back wall si de w all clearances to combustible surfaces **rear/top vent option ceiling ** floor protector see further floor protection requirements at ...
Page 17: Floor Protection
Us english 17 user manual viva l usa clearance to non-combustible wall we recommend a minimum clearance to non-combustible material of at least 2” (50 mm) so that cleaning is easy. The cleaning door of the chimney should be acces- sible at all times. Clearances may only be reduced by means approved ...
Page 18: Firewood
18 us english user manual viva l usa firewood only burn wood that has been seasoned for at least one full year (two years is bet- ter). If the wood has not been seasoned or dried, energy will be lost in evaporating the water held in the wood. Furthermore, condensation or creosote might occur in the ...
Page 19: Ventilation
Us english 19 user manual viva l usa ventilation extractor fans may not be fitted in the same room as the stove, as this can cause the stove to emit smoke and fumes into the room. The stove requires a permanent and adequate air supply to operate safely and ef- fectively. The installer may have fitte...
Page 20
20 us english user manual viva l usa installing a 360° swivel base. Remove the stop screw. The stove can now rotate freely. The swivel base lock (spring) can be tightened by loosening the screw to adjust the bracket. Move the bracket toward the plus symbol and tighten the screw again. A a 45 ° 90 ° ...
Page 21: Adjusting The Combustion Air
Us english 21 user manual viva l usa adjusting the combustion air all rais stoves are equipped with an easy-to-use handle for adjusting the air con- trol. Alternatively, the stove can be equipped with a self-regulating, automatic cleverair ™ air damper. For the various positions of the control pleas...
Page 22: Using The Stove
22 us english user manual viva l usa using the stove only use wood as fuel as described in the firewood section of this manual. Adjusting the air control with a manual air damper there are three different positions for air control: material: remarks: bend tool: established: designer: project manager...
Page 23: First Fire
Us english 23 user manual viva l usa first fire your new rais should be broken into gently for top performance and to prevent paint damage, cracks in the firebrick, and excessive wear and tear. Start with a small fire (never overload the firebox) to allow the materials to get accustomed to the highe...
Page 24: Lighting and Fuelling
24 us english user manual viva l usa lighting and fuelling please note! If the air system is connected, the valve must remain open ".Top-down" lighting • start by placing 3-4 pieces of chopped wood - approx. 1 ½-2 kg in the bottom of the combustion chamber. Place approx. 1kg of dry wood, chopped to ...
Page 25
Us english 25 user manual viva l usa 4 1 2 3 5 6 7.
Page 26: Fuel Caution
26 us english user manual viva l usa fuel caution do not burn garbage or flammable fluids such as gasoline, naptha, or engine oil(plastic and other artificial materials emit harmful gases), driftwood, treated wood, artificial logs, or non-seasoned wood. Do not use chemicals or fluids to start the fi...
Page 27: Warning!!
Us english 27 user manual viva l usa advarsel hvis brændet kun ulmer eller ryger, og der tilføres for lidt luft, udvikles der uforbrændte røggasser. Røggas kan antændes og eksplodere. Det kan give skader på materiel og i værste fald på personer. Luk aldrig helt for lufttilførslen, når der tændes op ...
Page 28
28 us english user manual viva l usa change of chimney connection the stove is delivered ready for top outlet, but may be changed to back outlet in the following way: strike out the knock out plate at the rear of stove. Remove any top plate, baffle plate and smoke chikane. Remove the blanking plate ...
Page 29
Us english 29 user manual viva l usa maintaining the installation. Establish a routine for the fuel, wood burner and firing tecnique. Check daily for creosote build-up until experience shows how often you need to clean to be safe. Be aware that the hotter the fire the less creosote is deposited, and...
Page 30
30 us english user manual viva l usa remove the upper baffle plate, by lowering the left side. Now there is a clear path to the smoke outlet. Then lower the left side, and take it out. Remove the back left skamol corner, by carefully lifting it up and out. Remove the steel skamol bracket, holding th...
Page 31: Disposal Of Ashes
Us english 31 user manual viva l usa disposal of ashes ashes should be placed in a metal container with a tightfitting lid. The closed container of ashes should be placed on a noncombustible floor or on the ground, well away from all combustible materials, pending final disposal. If the ashes are di...
Page 32: Trouble Shooting
32 us english user manual viva l usa trouble shooting smoke seeping through the door: • not enough draft in the chimney ( • check if there are any obstructions in the chimney or the wind pipe • check whether the kitchen exhaust fan is in use and if so, turn it off and open the window for a short per...
Page 33: Accessories
Us english 33 user manual viva l usa accessories 000651705xx / 3 - air kit back (xx: optional color code) 000651735xx - air kit floor - viva l (xx: optional color code) 2711590 - swivel base - viva 8142390 - flue collar for swivel base 6kg heat accumulating stones for 2796521 - viva 120 l 4-pcs. Set...
Page 34
Us english 34 user manual viva l usa spare parts viva 100/120/160 l usa only use the specified original rais components! If spare parts other than those recommended by rais are used, the warranty is voided. All replaceable parts can be bought as spare parts from your rais distributor. For reference ...
Page 35
35 us english user manual viva l usa spare parts viva 100/120/160 l g usa (model with sideglasses) only use the specified original rais components! If spare parts other than those recommended by rais are used, the warranty is voided. All replaceable parts can be bought as spare parts from your rais ...
Page 36
Rais a/s industrivej 20 dk-9900 frederikshavn www.Rais.Com.