1. DL manuals
  2. Rangemaster
  3. Ventilation Hood
  4. 64000 series
  5. Installation Instructions Manual

Rangemaster 64000 series Installation Instructions Manual

Other manuals for 64000 series: Installation Instructions Manual

Summary of 64000 series

  • Page 1

    64000 series residential use only installer: leave this manual with homeowner. Homeowner: use and care information on page 10 broan mfg. Co., inc./a nortek company, hartford, wisconsin, 1-800-637-1453 in canada: broan limited, mississauga, ontario, 1-888-88-broan v03515 rev c installation instructio...

  • Page 2: Warning

    Warning warning - 2 - to reduce the risk of fire, electric shock or injury to persons, observe the following: 1. Use this unit only in the manner intended by the manufacturer. If you have questions, contact the manufacturer at the address or telephone number listed in the warranty. 2. Before servici...

  • Page 3: 64000 Series

    - 3 - backsplash (rp series) model p8 dual-blower (850 cfm) model 332 kr exterior blower rough-in kit model 410 (10” rd. Duct - 2 ft. Sections) 8” rd standard duct model 413 transition (3 1/4” x 10” to 8”) 7” rd standard duct model 412 transition (3 1/4” x 10” to 7”) model 421 (10” rd. Vert. In-line...

  • Page 4: 1.  Install Ductwork

    - 4 - 1. Install ductwork plan where and how the ductwork will be installed. Install proper-sized ductwork, elbows, and roof or wall cap for the type of blower you are installing. If using 7” or 8” round ducts, use the transition. Use 2” duct tape to seal duct joints. Hood 3 1/4" x 10" duct roof cap...

  • Page 5: 6.  Choose The Opening

    - 5 - 3. Prepare the installation make sure that the following items are included: - range hood - accessories: • filters • bag of parts including: (4) lock nuts, (1) wire clamp, (8) 1/2” double thread screws, (2) wire connectors, (2) 1/2” standard screws, (6) 3/8 screws. • adapter 3-1/4” x 10” • flo...

  • Page 6: 8.  Install The Adapter

    - 6 - 7. Install the rough-in plate and install the deviator secure the rough-in plate in the hood with 4 lock nuts. You must also install the deviator if you choose the vertical opening. (see picture below) note: the deviator will not slide entirely into the hood, you will notice 1/8” will remain. ...

  • Page 7: 9.  Install The Hood

    - 7 - 9. Install the hood run power cable to installation location. Place the hood to its location. Mark the position of the screws (smaller part of the key holes) with a pen. Remove the hood and install the (8) 1/2” double thread screws leaving a 1/8” gap (4 screws for 30” hood). Remove wiring cove...

  • Page 8

    - 8 - 11. Install the blower (internal) the blower must be installed to the rough-in plate using (4) 3/8” screws for the single blower unit and (6) 3/8” screws for the dual blower unit. Remove the cover from the blower assembly. Remove the impeller(s) by pulling them out gently (see picture below). ...

  • Page 9: 12.  Light Bulbs

    - 9 - plug the blower unit into the female receptacle and the power supply into the male connector inside the hood. 12. Light bulbs this range hood uses 50w halogen lamps. (120v, 50w, par 20) install the lights by rotating clockwise. 13. Heat lamps the heat lamps required are 120v, 175w max, infrare...

  • Page 10: Use and Care

    - 10 - use and care grease filters and impeller(s) the grease filters, impeller(s) and grease collection channel should be cleaned frequently. Use a warm detergent solution. Grease filters and impellers are dishwasher safe. Remove filters by pushing filters towards the back of hood and rotating filt...

  • Page 11: Technical Specifications

    - 11 - blower the blower is operated using two (2) controls. Use the red, lighted on/off switch to start and stop the blower. When turned on, the blower will operate at the previous setting of the speed control. Turn the speed control knob clockwise to decrease blower speed – counterclockwise to inc...

  • Page 12: Warranty

    - 12 - warranty broan one year limited warranty broan warrants to the original consumer purchaser of its products that such products will be free from defects in materials or workmanship for a period of one year from the date of original purchase. There are no other warranties, express or implied, i...

  • Page 13: Wiring Diagrams

    - 13 - wiring diagrams rangemaster 30” and 36” rangemaster 42” and 48” halogen lamp (50w par20) halogen lamp (50w par20) heat lamp 175w gang spst rocker switch spst rocker switch spst rocker switch spst rocker switch with neon thermal cutoff 206°f act smc1270pt solid state control motor socket (fem....

  • Page 14: Service Parts

    1 2 17 2 17 7 3 4 16 19 20 17 8 2 11 10 9 2 8 17 5 6 14 12 13 15 17 18 - 14 - service parts 64000 series key qty (hood width) # part number description 30” 36” 42” 48” 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 v03493 v02264 v02773 v02772 v03435 v03436 v03501 v03507 v03502 v03503 v03504 v035...

  • Page 15: Service Parts

    - 15 - service parts single blower/rough-in (model p5) key # part number description qty 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 v12997 v13230 v13233 v13235 v13240 v13296 v01766 v03400 v02160 v02001 v11705 v01857 v01810 v00871 v01831 v01927 v11614 v00606 v01869 v01582 v0061...

  • Page 16: Service Parts

    Key # part number description qty 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 v12997 v13230 v13234 v13236 v13240 v13296 v01766 v03457 v03400 v03399 v02160 v02001 v11705 v01857 v01810 v00871 v01831 v01927 v11614 v00606 v01869 v01582 v00613 v03494 v03495 v03496 v00660 v0357...