- DL manuals
- Rangemaster
- Oven
- Classic Deluxe 110 Dual Fuel
- User's Manual & Installation Instructions
Rangemaster Classic Deluxe 110 Dual Fuel User's Manual & Installation Instructions
Summary of Classic Deluxe 110 Dual Fuel
Page 1
Britain’s no.1 range cooker user guide & installation instructions classic deluxe 110 dual fuel.
Page 2
Rangemaster cookware our range cookers are well known for providing the best possible cooking performance and years of faithful service. However, a great cooker alone cannot guarantee perfect results every time. The other vital ingredients are of course enthusiasm and quality cookware. We offer cook...
Page 3: Contents
Iii classic deluxe 110 dual fuel u108820-15b contents 1. Before you start... 1 important! 1 installation and maintenance 1 peculiar smells 1 if you smell gas 1 ventilation 1 personal safety 1 ceramic warming zone 2 cooker care 3 cleaning 3 2. Cooker overview 4 hotplate burners 4 wok burner 5 the wok...
Page 4
Iv.
Page 5: 1. Before You Start...
1 your cooker should give you many years of trouble-free cooking if installed and operated correctly. It is important that you read this section before you start, particularly if you have not used a dual fuel cooker before. Important! N n this appliance is designed for domestic cooking only. Using i...
Page 6
2 n n accessible parts will become hot during use and will retain heat even after you have stopped cooking. Keep babies and children away from the cooker and never wear loose-fitting or hanging clothes when using the appliance. Always be certain that the controls are in the off position when the ove...
Page 7
3 artno.324-0001 steam burst n n take care not to place metallic objects such as knives, forks, spoons and lids on the hob surface since they can get hot. N n the appliance is not intended to be operated by means of external timer or separated remote-control system. N n avoid warming an empty pan. D...
Page 8: 2. Cooker Overview
4 artno.212-0019 - 110 df classic deluxe front view m 1 2 3 1 2 3 o a b c d e f 2. Cooker overview the 110 dual fuel cooker (fig.2.1) has the following features: a. Four hotplate burners with a wok burner and ceramic multi-zone hotplate b. A control panel c. A glide-out grill d. A multi-function ove...
Page 9
5 artno.311-0007 wok stand close-up artno.311-0006 correct wok sizes artno.311-0002 pan with rim the igniter should spark and light the gas. Keep holding the knob pressed in to let the gas through to the burner for about ten seconds. If, when you let go of the control knob, the burner goes out, then...
Page 10
6 the cradle will get very hot in use – allow plenty of time for it to cool before you pick it up. The ceramic hotplate the hotplate area on the left-hand side is dual purpose. It can be used either as a ceramic hob to heat a pan in the usual way (fig.2.11) or it can be used to heat the supplied gri...
Page 11
7 the griddle the griddle (fig.2.16) is designed to fit securely on the locating pins over the ceramic heating area (fig.2.17). Do not try to use it over one of the gas burners. It will not be securely held and you may damage the non-stick finish. There are two elements that allow either the whole o...
Page 12
8 the glide-out grill open the door and pull the grill pan carriage forward using the handle (fig.2.21). The grill has two elements that allow either the whole area of the pan to be heated or just the right-hand half. To heat the whole grill, turn the control knob clockwise (fig.2.22). To heat the r...
Page 13
9 the multi-function ovens have many varied uses. We suggest you keep a careful eye on your cooking until you are familiar with each function. Remember – not all functions will be suitable for all food types. Please remember that all cookers vary – temperatures in your new ovens may differ to those ...
Page 14
10 right-hand fan oven the right-hand oven is a fan oven that circulates hot air continuously, which means faster, more even cooking. The recommended cooking temperatures for a fan oven are generally lower than a conventional oven. Note: please remember that all cookers vary so temperatures in your ...
Page 15
11 the clock you can use the timer to turn the left-hand multi-function oven on and off. The clock must be set to the time of day before the ovens will work. Setting the time of day the 6-button lcd clock is shown in fig.2.28. When the clock is first connected the display flashes ( 0.00 ) and (g) al...
Page 16
12 auto is showing, but you want to reset to manual cooking to return to manual cooking from any automatic setting, the ‘cook period’ must be cancelled. Press and hold the [e] button and then press the [ –] button until the display reads ( 0.00 ). Press the [b] button to return to manual cooking. Ke...
Page 17
13 the handyrack (left-hand oven) the handyrack (fig.2.47) fits to the left-hand oven door only. Food cooking on it is easy to attend to, because it is accessible when the door is open. The maximum weight that can be held by the handyrack is 5.5 kg (12 lb). It should only be used with the supplied r...
Page 18: 3. Cooking Tips
14 3. Cooking tips tips on cooking with the timer if you want to cook more than one dish, choose dishes that require approximately the same cooking time. However, dishes can be ‘slowed down’ slightly by using small containers and covering them with aluminium foil, or ‘speeded up’ slightly by cooking...
Page 19: 4. Cooking Table
15 4. Cooking table artno.050-0007 oven shelf positions oven shelf positions top (t) centre (c) base (b) the oven control settings and cooking times given in the table below are intended to be used as a guide only. Individual tastes may require the temperature to be altered to provide a preferred re...
Page 20: 5. Cleaning Your Cooker
16 artno.311-0032 burner layout fsd a b c d e artno.311-0033 wok burner details fsd a b c d e artno.311-0016 fitting the burner inner head a b a – cap, b – head, c – notch, d – base, e – electrode a – inner burner cap, b – outer burner cap, c – inner burner head, d – outer burner head, e – wok burne...
Page 21
17 ceramic hotplate daily care first of all, be sure that the heat indicator light is off and that the cooking surface is cool. Apply a small dab of ceramic cleaning cream in the centre of the area to be cleaned. Dampen a clean paper towel and work the cream onto the cooking surface. As a final step...
Page 22
18 artno.331-0003 grill frame out, no pan artno.331-0004 removing the grill frame artno.331-0005 removing the grill rail glide-out grill™ the grill pan and trivet should be washed in hot soapy water. Alternatively, the grill pan can be washed in a dishwasher. After grilling meats or any foods that s...
Page 23
19 artno.320-0002a proplus oven door side screws control panel and doors avoid using any abrasive cleaners, including cream cleaners. For best results, use a liquid detergent. The same cleaner can be used on the doors, or alternatively, using a soft cloth wrung out in clean hot soapy water – but tak...
Page 24
20 table 5-1 cleaning table cleaners listed (table 5-1) are available from supermarkets or electrical retailers as stated. For enamelled surfaces use a cleaner that is approved for use on vitreous enamel. Regular cleaning is recommended. For easier cleaning, wipe up any spillages immediately. Hotpla...
Page 25: 6. Troubleshooting
21 hotplate ignition or hotplate burners faulty is the power on? Is the clock illuminated? If not, there maybe something wrong with the power supply. Are the sparker (ignition electrode) or burner slots blocked by debris? Are the burner trim and caps correctly located? See the section on ‘cleaning’....
Page 26
22 an oven light is not working the bulb has probably burnt out. You can buy a replacement bulb (which is not covered under the warranty) from a good electrical shop. Ask for a 15 w – 230 v lamp, for ovens. It must be a special bulb, heat resistant to 300 °c (fig.6.1). Turn off the power at the circ...
Page 27: 7. Installation
23 installation check the appliance is electrically safe and gas sound when you have finished. Dear installer before you start your installation, please complete the details below, so that, if your customer has a problem relating to your installation, they will be able to contact you easily. Safety ...
Page 28
24 installation check the appliance is electrically safe and gas sound when you have finished. 3 pan supports wok cradle artno.110-0002 110 pan supports artno.000-0009 wok ring, cast griddle grill pan and trivet artno.330-0001 - grill pan 3 flat shelves 1 drop shelf handyrack roasting tin artno.324-...
Page 29
25 installation check the appliance is electrically safe and gas sound when you have finished. Positioning the cooker fig.7.1 and fig.7.2 show the minimum recommended distance from the cooker to nearby surfaces. The cooker should not be placed on a base. The hotplate surround should be level with, o...
Page 30
26 installation check the appliance is electrically safe and gas sound when you have finished. Artno.010-0004 moving the cooker lowering the two rear rollers to adjust the height of the rear of the cooker, first fit a 13 mm spanner or socket wrench onto the hexagonal adjusting nut (fig.7.5). Rotate ...
Page 31
27 installation check the appliance is electrically safe and gas sound when you have finished. Artno.215-0026 - handle gaskets fixed artno.210-0006 - classic fitting the handles 2 fitting the handles and handrail remove the 4 mm allen screws from the doors (fig.7.10). Fit the door handles and secure...
Page 32
28 installation check the appliance is electrically safe and gas sound when you have finished. Artno.350-0010 - fitting the plinth 1 (kitchener) artno.350-0011 - fitting the plinth 2 (kitchener) outer plinth outer plinth fixing screw inner plinth turn off the burners. Make sure that you reassemble t...
Page 33: 8. Conversion to Lp Gas
A b c artno.311-0010 injectors fig.8.1 a – jet, b – internal injector, c – external injector art no 215-0028 - handrail fascia fixings 1 2 3 1 2 3 check the ‘technical data’ section at the back of the book that the hob is convertible to the gas you want to use. A suitably competent person must perfo...
Page 34
Pressure testing connect the appliance to the gas supply. Check the appliance is gas sound. The gas pressure can be measured at one of the hotplate injectors (not a wok burner). Lift off a burner head. Fit the pressure gauge to the jet. Turn on and light one of the other burners. Turn on and press i...
Page 35: 9. Circuit Diagram
31 6 5 4 7 8 2 1 3 p038434 p095199 1 2 p2 p1 1 2 a b e f c d 1 2 e p2 p1 p3 p4 p5 p6 p7 p8 1.1kw 1.1kw b b b b b b b b b b b b b b b b b br br br br br br br br br v v v v v v or or y y w w w y bk bk bk r r r bk bk r bk r v v br br br br b b b b b w w v v r v v r w r y y v r r r bk bk bk bk br w br ...
Page 36: 10. Technical Data
32 10. Technical data this cooker is category: catii2h3+. It is supplied set for group h natural gas. A conversion kit from ng to lp is available for the cooker. Installer: please leave these instructions with the user. Data badge location: cooker back, serial number repeater badge below oven door o...
Page 37
33 notes.
Page 38
34 notes.
Page 39
Consumer service if you have any product enquiries, or in the event of a problem with your appliance once it has been installed, please telephone: 0800 804 6261 or depending on your mobile network tariff you can call free on 0370 789 5107. Consumer service lines open: monday to thursday 8am–6pm frid...
Page 40
Britain’s no.1 range cooker clarence street royal leamington spa warwickshire cv31 2ad england tel: +44 (0) 1926 457400 fax: +44 (0)1926 450526 e-mail: consumers@rangemaster.Co.Uk consumer services tel: +44 (0) 800 804 6261 www.Rangemaster.Co.Uk for roi enquiries tel: 1850 302 502 registered in engl...