1. DL manuals
  2. Rangemaster
  3. Oven
  4. Elan 90 Dual Fuel
  5. User Manual

Rangemaster Elan 90 Dual Fuel User Manual

Other manuals for Elan 90 Dual Fuel: User Manual
Manual is about: Range cooker

Summary of Elan 90 Dual Fuel

  • Page 1

    Elan 90 dual fuel britain’s no.1 range cooker user guide & installation instructions.

  • Page 2

    Rangemaster cookware our range cookers are well known for providing the best possible cooking performance and years of faithful service. However, a great cooker alone cannot guarantee perfect results every time. The other vital ingredients are of course enthusiasm and quality cookware. We offer cook...

  • Page 3: Contents

    I 1. Before you start... 3 important! 3 installation and maintenance 3 peculiar smells 3 if you smell gas 3 ventilation 3 personal safety 3 cooker care 4 cleaning 4 2. Cooker overview 5 hotplate burners 5 wok burner 6 the wok cradle 7 the griddle 7 the glide-out grill 8 the ovens 8 the clock 11 acce...

  • Page 4

    Ii.

  • Page 5: 1.  Before You Start...

    1 your cooker should give you many years of trouble-free cooking if installed and operated correctly. It is important that you read this section before you start, particularly if you have not used a dual fuel cooker before. Important! N n this appliance is designed for domestic cooking only. Using i...

  • Page 6

    2 always be certain that the controls are in the off position when the oven is not in use, and before attempting to clean the cooker. N n when the oven is on, do not leave the oven door open for longer than necessary, otherwise the control knobs may become very hot. N n when using the grill, make su...

  • Page 7: 2.  Cooker Overview

    3 2. Cooker overview the 90 dual fuel cooker (fig.2-1) has the following features: a. 5 hotplate burners including a wok burner b. A control panel c. A glide-out grill d. Main multi-function oven e. Tall fan oven hotplate burners the drawing by each of the central knobs indicates which burner that k...

  • Page 8

    4 artno.311-0002 pan with rim if, when you let go of the control knob, the burner goes out, then the fsd has not been bypassed. Turn the control knob to the off position and wait for one minute before you try again, this time making sure to hold in the control knob for slightly longer. Adjust the fl...

  • Page 9

    5 artno.215-0003 - elan griddle on hotplate artno.215-0006 - elan griddle - wrong artno.311-0006 correct wok sizes the wok cradle the wok cradle is designed to fit a 35 cm wok. If you use a different wok, make sure that it fits the cradle. Woks vary very widely in size and shape. It is important tha...

  • Page 10

    6 the glide-out grill open the door and pull the grill pan carriage forward using the handle (fig.2-15). The grill has two elements that allow either the whole area of the pan to be heated or just the right-hand half. Adjust the heat to suit by turning the control knob. To heat the whole grill, turn...

  • Page 11

    7 fan oven this function operates the fan and the heating element around it. An even heat is produced throughout the oven, allowing you to cook large amounts quickly. Fan oven cooking is particularly suitable for baking on several shelves at one time and is a good ‘all-round’ function. It may be nec...

  • Page 12

    8 half of the oven to cook. The oven temperature may also need to be lowered. Browning element this function uses the element in the top of the oven only. It is a useful function for the browning or finishing of pasta dishes, vegetables in sauce, shepherds pie and lasagne, the item to be browned bei...

  • Page 13

    9 the clock you can use the timer (fig.2-22) to turn the ovens on and off. The clock must be set to the time of day before the ovens will work. Note: when using the timer functions, first set the clock as required before setting the oven temperature and selecting the oven function (multi-function ov...

  • Page 14

    10 turn the timer knob to the [d] position (fig.2-27). Use the adjusting knob to set the ‘cook time’ you need (fig.2-28). Turn the timer knob to the [e] position. The display will show the current time of day plus the ‘cook time’ you just set. Use the adjusting knob to set the ‘stop time’ required (...

  • Page 15

    11 accessories oven shelves – left-hand (main) oven in addition to a flat shelf, your cooker is supplied with a drop shelf (fig.2-35). The drop shelf increases the possibilities for oven shelf spacing. The oven shelves can be easily removed and refitted. Pull the shelf forward until the back of the ...

  • Page 16: 3.  Cooking Tips

    3. Cooking tips tips on cooking with the timer if you want to cook more than one dish, choose dishes that require approximately the same cooking time. However, dishes can be ‘slowed down’ slightly by using small containers and covering them with aluminium foil, or ‘speeded up’ slightly by cooking sm...

  • Page 17: 4.  Cooking Table

    13 4. Cooking table artno.050-0007 oven shelf positions oven shelf positions top (t) centre (c) base (b) the oven control settings and cooking times given in the table below are intended to be used as a guide only. Individual tastes may require the temperature to be altered to provide a preferred re...

  • Page 18: 5.  Cleaning Your Cooker

    14 artno.311-0032 burner layout fsd a b c d e artno.311-0033 wok burner details fsd a b c d e artno.311-0016 fitting the burner inner head a b fig.5-1 fig.5-2 fig.5-3 fig.5-4 a – cap, b – head, c – notch, d – base, e – electrode a – inner burner cap, b – outer burner cap, c – inner burner head, d – ...

  • Page 19

    15 artno.331-0001grill pan pulled forwards artno.331-0003 grill frame out, no pan artno.331-0004 removing the grill frame artno.331-0005 removing the grill rail artno.331-0006 grill pan plan fig.5-5 fig.5-6 fig.5-7 fig.5-8 fig.5-9 the griddle always clean the griddle after use. Allow it to cool comp...

  • Page 20

    16 artno.320-0022 tall oven side support ovens ‘cook & clean’ panels the main oven has panels which have been coated with a special enamel that partly cleans itself. This does not stop all marks on the lining, but helps to reduce the amount of manual cleaning needed. The ‘cook & clean’ panels work b...

  • Page 21

    17 cleaning table cleaners listed (table 5-1) are available from supermarkets or electrical retailers as stated. For enamelled surfaces use a cleaner that is approved for use on vitreous enamel. Regular cleaning is recommended. For easier cleaning, wipe up any spillages immediately. Hotplate part fi...

  • Page 22: 6. Troubleshooting

    18 hotplate ignition or hotplate burners faulty is the power on? Is the clock illuminated? If not, there maybe something wrong with the power supply. Are the sparker (ignition electrode) or burner slots blocked by debris? Are the burner trim and caps correctly located? See the section on ‘cleaning’....

  • Page 23

    19 an oven light is not working the bulb has probably burnt out. You can buy a replacement bulb (which is not covered under the warranty) from a good electrical shop. Ask for a 15 w – 230 v lamp, for ovens. It must be a special bulb, heat resistant to 300 °c (fig.6-1). Turn off the power at the circ...

  • Page 24: 7.  Installation

    20 installation check the appliance is electrically safe and gas sound when you have finished. Dear installer before you start your installation, please complete the details below, so that, if your customer has a problem relating to your installation, they will be able to contact you easily. Safety ...

  • Page 25

    21 installation check the appliance is electrically safe and gas sound when you have finished. Checking the parts: location of cooker the cooker may be installed in a kitchen/kitchen diner but not in a room containing a bath or shower. This appliance is designed for domestic cooking only. Use for an...

  • Page 26

    22 installation check the appliance is electrically safe and gas sound when you have finished. Artno.090-0030 - 90 elan door clearances 130 mm min artno.090-0009 - 90 2bc cooker min spacings 75 mm min 75 mm min 650 mm min 900 mm min 925 mm max fig.7-1 fig.7-3 positioning the cooker fig.7-1 shows the...

  • Page 27

    23 installation check the appliance is electrically safe and gas sound when you have finished. Artno.010-0004 moving the cooker fig.7-6 fig.7-5 lowering the two rear rollers to adjust the height of the rear of the cooker, first fit a 13 mm spanner or socket wrench onto the hexagonal adjusting nut (f...

  • Page 28

    24 installation check the appliance is electrically safe and gas sound when you have finished. Conversion to another gas if the appliance is to be converted to another gas do the conversion at this point. See the conversion section of these instructions and see the instructions in the conversion kit...

  • Page 29

    25 installation check the appliance is electrically safe and gas sound when you have finished. Artno.090-0027 - 90 elan gas connections 300 100 240 a 100 all dimensions in millimetres gas inlet gas connection this must be in accordance with the relevant standards. The flexible hose (not supplied wit...

  • Page 30

    26 installation check the appliance is electrically safe and gas sound when you have finished. Artno.281-0026 - front plinth fig.7-16 electrical connection the cooker must be installed by a qualified electrician, in accordance with all relevant british standards/codes of practice (in particular bs 7...

  • Page 31: 8.  Conversion to Lp Gas

    Warning – servicing to be carried out only by an authorised person disconnect from electricity and gas before servicing. Check appliance is safe when you have finished. 27 a b c artno.311-0010 injectors fig.8-1 a – jet, b – internal injector, c – external injector fig.8-3 art no 215-0028 - handrail ...

  • Page 32

    Warning – servicing to be carried out only by an authorised person disconnect from electricity and gas before servicing. Check appliance is safe when you have finished. 28 stick on label stick the lp gas label over the natural gas part of the appliance data label. Pressure testing connect the applia...

  • Page 33: 9.  Circuit Diagram

    29 p028728 6 p6 5 p5 4 p4 7 p7 8 p8 2 p2 1 p1 3 p3 a b e f c d 1 2 p095199 1 2 p2 p1 e 1 2 1 2 w w w b b b b b b b b b b b b b b b or or or or gr w y y y v v v v v v r r r r br br r b r br br br br br br w v v b v w w w w b b b bk b br bk bk br b b w b br b br b b b br bk b v a1 a2 b1 b2 b3 b4 b5 b6...

  • Page 34: 10.  Technical Data

    30 10. Technical data the cooker is category: ii2h3+. It is supplied set for group h natural gas. A conversion kit from ng to lp is packed with the cooker. Installer: please leave these instructions with the user. Data badge location: cooker back, serial number repeater badge below oven door opening...

  • Page 35

    Consumer service if you have any product enquiries, or in the event of a problem with your appliance once it has been installed, please telephone 0870 789 5107. Consumer service lines open: monday to thursday 8am–6pm friday 8am–5pm saturday 9am–1pm warranty your manufacturer warranty covers goods of...

  • Page 36

    Britain’s no.1 range cooker clarence street royal leamington spa warwickshire cv31 2ad england tel: +44 (0) 1926 457400 fax: +44 (0)1926 450526 e-mail: consumers@rangemaster.Co.Uk consumer services tel: +44 (0) 870 7895107 www.Rangemaster.Co.Uk for roi enquiries tel: 1850 302 502 registered in engla...