1. DL manuals
  2. Rangertugs
  3. Boat
  4. R-25
  5. Owner's Manual

Rangertugs R-25 Owner's Manual

Manual is about: Boats

Summary of R-25

  • Page 1

    R-25 owner’s manual 25802 pacific highway south kent, washington 98032 all rights reserved. Reproduction or translation by any means in whole or in part is not permitted without written authorization from ranger tugs. The information contained herein is correct to the best of ranger tugs knowledge a...

  • Page 2: Table Of Contents

    2 table of contents table of contents ................................................................................................................................................ 2 about this manual………………………………………………………………………………………………………………………………………………3 symbol glossary .............................

  • Page 3: Congratulations

    3 congratulations the ranger tug family has a passion for boating. We are committed to continuous process improvement in all areas that affect our customer’s satisfaction with our products and providing great customer service. Safety safety is always a concern at ranger tugs. Please read all manuals...

  • Page 4: Symbol Glossary

    4 symbol glossary attention! – important operating or maintenance instructions attention! – electrical shock hazard fresh water black water fuel std standard equipment opt optional equipment hints.

  • Page 5

    5 specifications (subject to change without notice) boat & anchor roller & swim step 28’ 5” length with swim platform on trailer 32’ length overall (loa) 24’ 7” (7m) beam 8’ 6” (2.6m) draft 26” (.66m) displacement 5,750 lbs (2,608kg) fuel capacity 75 us gal (284l) fresh water capacity 30 us gal (113...

  • Page 6

    6 optional equipment (subject to change without notice) air conditioning w/ rev cycle heat dometic environment 16,000 btu bruce style anchor 16.5lb/200’ line/50’ chain generator 2.5 kw macerator discharge w/ y-valve 12v johnson macerator waste pump navigation package garmin 5212, 4kw radar dome, gps...

  • Page 7: Equipment Location

    7 equipment location starboard fittings std 1235678, shore power opt 4, bow thruster keep all vents, drains and exhausts clear of any obstructions to ensure proper performance of each system. Keel drain.

  • Page 8: Port Fittings

    8 port fittings std anchor locker drain, engine exhaust opt ac, generator, bow thruster, & macerator keep all vents, drains and exhausts clear of any obstructions to ensure proper performance of each system..

  • Page 9

    9 main cabin top deck components std mast take down support rod, horn, navigation lights opt gps, radar, searchlight, mast.

  • Page 10: Stern Components

    10 stern components std waste pump out cap, waste pump out vent, diesel fuel cap, diesel fuel vent, swim platform, swim platform retracting ladder, aft bilge pump out, swim platform supports, scupper drains, stern eyes, rudder, trim tabs, propeller opt stern thruster, depth finder transducer 1 2 3 4...

  • Page 11: Stern Lights

    11 stern lights std.

  • Page 12: Available Storage

    12 available storage std.

  • Page 13: Fuse Location & Values

    13 fuse location & values std the dc fuse panel is located behind a hinged access panel on the starboard side in the v-berth next to the cabin light. Fuses are automotive blade type and all values shown below are in amps. 12 volt dc outlets 12 volt dc outlets wipers 30 30 20 20 15 15 5 7.5 sub panel...

  • Page 14

    14 main cabin and cockpit lights std on light fixture dc distribution panel helm or main cabin door switch helm or transom door switch helm switch panel v-berth cabin lights chart lights cabin lights walkway lights galley light bathroom light mid cabin light dining area lights.

  • Page 15: Battery Compartment

    15 battery compartment std house batteries, engine battery opt thruster battery, thruster fuses, diesel stove fuse diesel stove fuse (15a) thruster fuses thruster/windlass isolation switch house/ engine emergency dc parallel switch 1 3 2 2 1 3 2 2 house engine thrusters 1 2 3 batteries house breaker...

  • Page 16

    16 house / engine emergency dc parallel switch std this switch panel is located in the mid-cabin storage/extra sleeping area just to the port side of the main cabin entrance door, on the side of the entrance step. The switch is shown in the normal operational configuration. Once the emergency parall...

  • Page 17: Dc Distribution Panel

    17 dc distribution panel std the bilge pumps operate automatically with electronic float switches when all switches and breakers are in the off position. However, the bilge pump and bilge pump2 will run continuously once their switches are placed in the on position. Monitor the outflow accordingly. ...

  • Page 18: Heater Control

    18 ac distribution panel, dc battery bank meter, helm heater control std.

  • Page 19: Wallas Stove

    19 wallas stove opt wallas 85du stove, dual burner, heater, diesel, 2.5 gallon tank (refer to wallas owners manual for proper priming and reset functions.) stove has a separate diesel fuel tank as shown below. Remove tank from vessel for adding fuel. Do not overfill. Allow for fuel expansion. Stove ...

  • Page 20: Engine Fuel System

    20 engine fuel system std opt mase 2.5 kw diesel generator engine fuel return racor fuel filter fuel shut off valve fuel fill hose fuel vent hose fuel pick up fuel fill fuel vent m a s e 2 .5 k w fuel pick up there is a secondary on engine fuel filter that is not shown on this drawing. You will be a...

  • Page 21

    21 closed engine cooling system std provides alternate heating system for the fresh water heater and provides primary heating source for the forced air cabin heater. The system uses a johnson 12 volt centrifugal circulation pump (yanmar only) fed by the coolant outlet of the engine and pumps it to t...

  • Page 22: Sea Strainer System

    22 sea strainer system std multi port sea strainer for engine, marine toilet std raw water washdown.

  • Page 23: Raw Water Wash Down

    23 raw water wash down std johnson aqua jet 5.2 gpm.

  • Page 24

    24 fresh water plumbing system std.

  • Page 25: Shower Sump

    25 shower sump std 12v, 500 gph (this should be inspected for debris on a regular basis if shower is used frequently.).

  • Page 26: Bilge Pump System

    26 bilge pump system std 12v 750gph the bilge pumps operate automatically with electronic float switches when all switches and breakers are in the off position. However, the bilge pump and bilge pump2 will run continuously once their switches are placed in the on position. Monitor the outflow accord...

  • Page 27: Waste System

    27 waste system std 30 gallon tank with pump out and vent waste tank fill level can be checked by lifting the engine access hatch and viewing the translucent waste tank. Waste tank pump out stations are widely available. Please follow the directions carefully for the pump out equipment you are using...

  • Page 28

    28 waste system with macerator pump opt 30 gallon tank with macerator pump out, standard pump out, and vent waste tank fill level can be checked by lifting the engine access hatch and viewing the translucent waste tank. Pump out can be done with the macerator or standard pump out. The y-valve that s...

  • Page 29: Mast Set Up And Takedown

    29 mast set up and takedown mast set up procedure 1. Remove the two black plastic wing nuts from the mast base. 2. Remove the two mast tie down cables from their storage positions in the roof clips. 3. With the mast tie down cables still loose, raise the mast off of the stainless steel support bar. ...

  • Page 30: Working Decks

    30 working decks.

  • Page 31: Care And Maintenance

    31 care and maintenance the following checklists are examples and are not all inclusive and are provided only as a guide. Please customize to your personal needs. Consult your engine and trailer user manuals for additional information. Example of a preparation for the road checklist tow vehicle – pr...

  • Page 32

    32 example of a spring pre-launch checklist cleaning: o remove debris from scuppers and scupper drains. O clean hull using a mild biodegradable detergent and then wax. O clean topsides and decks using a mild biodegradable detergent and then wax. O clean and polish all bright work. O clean and oil te...

  • Page 33

    33 example of winter storage checklist general maintenance: o fill fuel tank and add a fuel stabilizer. O empty and clean black water tank. O empty fresh water tank use a non-toxic antifreeze per manufacturer’s directions. O winterize black and fresh water tanks as necessary based on weather. O chec...

  • Page 34: Reference Material

    34 reference material the following table contains a list of reference materials provided by ranger tugs that are contained under separate manuals. Equipment original manufacturer navigation system raymarine engine yanmar / cummins stove, diesel wallas trim tabs bennett thrusters side power search l...

  • Page 35: Contacts

    35 contacts customer service – andrew custis customer service manager phone 253-839-5213 andrewcustis@rangertugs.Com web site – www.Rangertugs.Com.