8 burners event grill model: st1017-012939 operator’s manual for outdoor use only thank you for purchasing this outdoor cooking appliance. Please read safety and precaution statements, grill maintenance, leak testing regulator / cylinder connection and lighting grill before using grill for first tim...
P 2 danger if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. Warning for your safety do not store or use gasoline or other flammable vapors or liquids in...
P 3 grill installation codes the installation and pressure regulator must conform with local codes, or in the absence of local codes, with the national fuel gas code, ansi z223.1/nfpa 54 , or the natural gas and propane installation code, csa b149.1 , as applicable, including: 1. The appliance and i...
P 4 product diagram.
P 5 parts list part number part description qty 1 dq08a-01-00 wind shield back panel 1 2 dq08a-03-46 cooking grid 3 3 dq08a-01-02 wind shield, right panel 1 4 dq08a-03-44 flame tamer 8 5 dq08a-03-04 grill body, back panel 1 6 dq08a-03-41 lead fire slot assy 7 7 dq08a-03-02 grill body, right panel 1 ...
P 6 component list a: grill cart 1 piece b: grill body 1 piece c: directional caster 2 pieces d: universal caster 2 pieces e: grease receptacle 1 piece f: towel rack 2 pieces g: side handle 2 pieces h: flame tamer 8 pieces j: grease tray 2 pieces k: cooking grid 3 pieces l: gas tank holder 2 pieces ...
P 7 2. Assemble cart with an assistant of some person again, turn the cart up-side-down. Unfold the cart legs and align the cart frame bracket to the legs. Then tighten the bracket with bolt #3. Caution: do not stand, lean or apply pressure to the cart frame bracket once assembly. 3. Install bottom ...
P 8 4. Assemble and install grease receptacle and grease tray position grease receptacles e to the holders on the left and right upper bar of cart. Slide the grease tray j to the slots underneath grease receptacle e. The grease tray is required to be present and centered for safety. 5. Install handl...
P 9 6. Install grill body with an assistant of other person, lift and position grill bowl body to the cart. Make sure that bottom four corners of grill body must be sitting on the seat on each leg. Then lock each leg by closing the latch of each buckle on legs and grill body. Warning: always keep th...
P 10 8. Install heat plates place the flame tamer on the grill and make sure that each tamer will be place over the burner. 9. Install cooking grid place the cooking grid inside the grill body..
P 11 10. Install hanger install towel rack to left and right side shelf and secure with bolt #4. 11. Install ignitor batteries unscrew ignitor cap from control panel place an aa battery into the igniter body with +ve outward and –ve inward. Position the cap and spring over the +ve end and tightly sc...
P 12 be sure all control knobs are set to “off” and open the grill lids have your assistant stand behind to the right of the grill and look toward the front of the grill bowl. Never put your face inside the grill head. Press the igniter cap, you should hear a “clicking” sound. Your assistant should ...
P 13 use and care instructions correct lp gas tank use lp gas grill models are designed for use with two standard 20 lb. Liquid propane gas (lp gas) tanks, not included with grill. Never connect your gas grill to an lp gas tank that exceeds this capacity. A tank of approximately 12 inches in diamete...
P 14 warning a. Do not store a spare lp-gas tank under or near this appliance. B. Never fill the tank beyond 80 percent full; and c. If the information in “(a)” and “(b)” is not followed exactly, a fire causing death or serious injury may occur. Warning use your grill at least 3 feet away from any w...
P 15 how to leak test your lp gas tank for your safety: all leak tests must be repeated each time your lp gas tank is exchanged of refilled. When checking for gas leaks do not smoke. Do not use an open flame to check for gas leaks your grill must be leak tested outdoors in a well-ventilated area, aw...
P 16 connect the regulator assembly to the tank valve and hand tighten nut clockwise to a full stop. Do not use a wrench to tighten because it could damage the quick coupling nut and result in a hazardous condition. Open the tank valve fully (counterclockwise) and use a soapy water solution to check...
P 17 caution always open both left and right lids as shown before lighting your grill. Lock the wheels to prevent movement while the appliance is in use wind shield must be properly installed while the appliance is in use grill lighting instructions note: this gas grill is designed to be used with t...
P 18 7. Set all control knobs to off and open the right-side tank valve slowly 1/4 of a turn. 8. To light the four right-side burners, push and turn the forth control knob from the right to high. This is considered the middle right control knob. 9. Immediately press the right-side electric igniter f...
P 19 warning failure to replace a faulty hose, secure gas supply connections or to open the lids before proceeding to the lighting procedures could result in a fire or explosion could result in a fire or explosion that could cause serious bodily injury, death, or property damage. Manually lighting y...
P 20 warning failure to comply with these instructions could result in a fire or explosion that could cause serious bodily injury, death or property damage. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids. Do not obstruct the flow of air for...
P 21 8. Check each spark electrode, adjusting as needed. The space between the spark electrode tip and spark receiver should be approximately 3/16”. 9. Replace the burners and adjust the gas collector box. The edge of the collector box should be overlapping the burner port. 10. Replace saver plates ...
P 22 method 1: bend a stiff wire or wire coat hanger into a small hook as shown and run the hook through the burner tube and inside the burner several times to remove debris. Method 2: use a bottle brush with a flexible handle and run the brush through the burner tube and inside the burner several t...
P 23.
P 24 limited warranty manufacturer warrants this event grill for replacement or repair of parts and/or workmanship for a period of 3 months. Paint is not warranted and may require touch-up. Items considered to be consumable such as batteries are not covered under these warranties. These limited warr...
