Summary of Solaire
Page 2
We at rasmussen iron works, inc., would like to offer our sincere thanks for purchasing a solaire infrared grill. We believe that you are now in possession of one of the finest out- door cooking appliances ever produced. By carefully following the instructions outlined in this care & use manual you ...
Page 3
Table of contents page 1 safety precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 & 2 locating the grill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 assembly instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . ...
Page 4
Safety precautions page 2 safety practices to avoid personal injury when properly cared for, your solaire infrared grill will give safe, reliable service for many years. However, extreme care must be used since the grill produces intense heat, which can increase accident potential. When using this a...
Page 5
Locating & assembling the grill page 3 when determining a suitable location, take into account concerns such as exposure to wind, proximity to traffic paths and keeping any gas supply lines as short as possible. Locate the grill only in a well-ventilated area. Never locate the grill in a building, g...
Page 6
L.P. (propane) gas hookup page 4 never connect the grill to an unregulated gas supply. Never connect an unregulated gas line to the appliance. Total gas consumption (per hour) with all burners on "hi": 27" grill 27,000 btu the installation of this appliance must conform with local codes or, in the a...
Page 7
Natural gas hookup page 5 never connect the grill to an unregulated gas supply. Never connect an unregulated gas line to the appliance. Total gas consumption (per hour) with all burners on "hi": 30" grill 55,000 btu 42" grill 82,500 btu 56" grill w/ side burners 117,500 btu dual side burners 35,000 ...
Page 8
Leak testing page 6 general although all gas connections on your solaire infrared grill are leak test- ed at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in ship- ment, or excessive pressure unknowingly being app...
Page 9
Final checklist page 7 1. Specified clearances maintained to combustibles. 2. All internal packaging removed. 3. Knobs turn freely. 4. Pressure regulator connected and set for l.P. Or natural gas operation. 5. Unit is tested and free of leaks. 6. User informed of gas supply shut off valve location. ...
Page 10: Warning
Operating the grill page 8 each grill burner is rated at 27,500 btu. The grill burners encompass the entire cooking area and are protected with a wire mesh to minimize block- age from falling grease and debris. Each grill burner has its own igniter. The igniter push button is located on the front co...
Page 11
Page 9 warning: important - l.P. Models. Before lighting... Inspect the gas supply piping or hose prior to turning the gas "on". If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. Do not use the grill if the odor of gas is pre- sent. The pressure regulator and hose as...
Page 12: Warning
Page 10 rotisserie installation: if you purchased the optional rotisserie for your solaire grill, it is necessary to mount the bracket and motor to the grill by following these instructions: 1. Attach bracket to either side of grill as shown in fig. 6 using bolts and nuts provided in the rotisserie ...
Page 13
Page 11 optional accessories bbq tray: this optional accessory serves a dual purpose. First, it will catch drippings and help prevent flare-ups when cooking particularly juicy foods, either on the grill or the rotisserie. Second, it will serve as a heat diffuser when grilling delicate foods such as ...
Page 14: Warning
Page 12 optional accessories steamer/fryer: this optional accessory brings a new level of versatility to outdoor cooking, allowing you to deep fry, steam or boil foods on one side of your solaire while grilling on the other. To ensure safe operation and quality results, follow these instructions: to...
Page 15
Troubleshooting page 13 spider and insect warning spiders and insects can nest in the burners of this or any other grill, and cause the gas to flow from the front of the burner. This is a very dangerous condition, which can cause a fire to occur behind the valve panel, thereby damaging the grill and...
Page 16
Care & maintenance page 14 grilling grids routine cleaning of the grill grids is best accomplished by scrubbing the grids with a brass or stainless steel brush immediately before and after cooking, while the grill is hot. Wear a barbeque mitt to protect your hand from the heat while cleaning. When n...
Page 17
Care of stainless steel stainless steel is widely used for catering and residential kitchen equipment because of its strength, its ability to resist corrosion and its ease of cleaning. In fact, stainless steel ranks alongside glass and new china in terms of "ease of cleaning" and in percentage remov...
Page 18
Gas conversion - grills - natural gas to l.P. Page 16 gas conversion requires a conversion kit, available from your solaire dealer for 30" models, kit includes for 42" model & 56*” models, kit includes • two (2) # 155 main burner orifices. • three (3) # 155 main burner orifices. • lp regulator / hos...
Page 19
Gas conversion - grills - l.P. To natural gas page 17 gas conversion requires a conversion kit, available from your solaire dealer for 30" models, kit includes for 42" model & 56*” models, kit includes • two (2) # 250 main burner orifices. • three (3) # 250 main burner orifices. *56” model also requ...
Page 20
Gas conversion - side burners - natural gas to l.P. Page 18 gas conversion requires a conversion kit, available from your solaire dealer conversion kit for 56” grill side burners or sb-2 and sb-2c side burners includes: • two (2) # 121 main burner orifice. • two (2) # 24 simmer burner orifice • tool...
Page 21
Gas conversion - side burners - l.P. To natural gas page 19 gas conversion requires a conversion kit, available from your solaire dealer conversion kit for 56” grill side burners or sb-2 and sb-2c side burners includes: • two (2) # 182 main burner orifice. • two (2) # 32 simmer burner orifice • tool...
Page 22
C 36 11 1 / 4 2 min. 2 7 / 8 24 1 / 2 insulated jacket cutout dimension c model irij-30 35” model irij-42 47” model irij-56 61” combustible enclosure built-in cutout details page 20 a 23 36 10 1 / 4 18 1 / 4 b 3 5 / 8 3 7 / 8 (see note) grill cutout dimension a model irbq-30 28 1/2” model irbq-42 40...
Page 23
Solaire infrared grills limited warranty page 21 this warranty covers the following: solaire infrared grills (all models) duration of warranty rasmussen iron works, inc. Warrants all grill components to the original purchaser to be free of factory defects in material and workmanship for a period of ...
Page 24
Parts list page 22 item no. Part no. Description model no. Qty. 1 8030r rear hood 42" irbq-42 1 1a 8029r rear hood 30" irbq-30 1 2 8026r front hood 42" irbq-42 1 2a 8025r front hood 30" irbq-30 1 3 6001r stander bracket & phenolic base all models 2 4 6018r 42" hood handle (12" embossing) 1.3mm irbq-...
Page 25
Parts list drawing page 23 1 2 3 4 5 5 6 7 8 9 10 11 12 13 14 15 16 17 18.
Page 26
Notes page 24.
Page 27
Also available for built-in installations only is this compact, functional 24” unit. Part# sol-irdt-24 solaire bartending centers wood chip smoker add great wood smoke flavor to all your grilled foods with this all 304 stainless steel smoke drawer. Fits under grilling grate. Part# sol-irws-bq solair...
Page 28
Tm l iste d ® c us solaire, a division of rasmussen iron works, inc. 12028 e. Philadelphia street, whittier, ca 90601 phone: (562) 696-8718 • fax: (562) 698-3510 www.Riwinc.Com • email: info@riwinc.Com also from rasmussen solaire grills are brought to you by rasmussen iron works, inc., a family busi...