Ravenheat CSI PRIMARY AAA User Manual

ESCAPE OF GAS

    Should a gas leak be suspected, contact your gas 

    supplier  without    delay.

    Do NOT search for gas leaks with a naked fl ame.

    WARNING: This appliance must be earthed.  Do not 

    touch or tamper with this sealed unit or its 

    components.

     1           INTRODUCTION 

1.1        Please carefully read information given in the 

                  booklet to help you again maximum control from 

                  your appliance with   minimum  trouble and cost.

     1.1.1Your Ravenheat Condensing   Boiler  has  been  

                  designed to supply your Central  Heating 

                  reqirements. 

                  PLEASE NOTE

Due to the high effi ciency and resulting low fl ue 

                  gas exhaust temperature a white plume of 

                  condensation vapour (cool steam) will be emitted 

                  from the fl ue outlet terminal, this is quite normal. 

                  It will be particularly evident during periods of low 

                  outdoor temparatureor when the  boiler is 

                  working at its optimum performance.

1.2          CLEARANCES AROUND THE BOILER       

                      Above 125 mm   ( 5  inches)

                      Below  150 mm   ( 6  inches)

                      Front    450 mm  (18  inches)

                      Sides        5 mm  (0.2 inches)

                      25mm (1inch) in front when installed in a

                      cupboard. 

    1.2.1        Minimum clearences are required for safety and 

                      maintenance. Do NOT obstruct any purpose 

made  ventilation opening if boiler has been 

fi tted in a compartment.

                      Never hang clothes,ect, over the appliance

     1.3           USER CONTROLS (Fig.1) 

1.3.1  This appliance is designed to operate with the 

minimum of attention by the User. All the controls 

are to be found on the control pannel.

     1.4            OPERATING SAFETY CHECKS TO PROTECT 

                      YOUR APPLIANCE

1.4.1         Before lighting the Appliance check that the 

Central Heating  system is charged with water 

within the system.

                       If it is a pressurised system, check that the bar 

gauge is not below 1. 

     1.4.2         A RED warning light on the control panel warns 

of a fl ame failure of the burner. This can be reset 

pressing on/ off switc.

    1.4.3          A RED warning intermittance light on the control 

panel warms of a high temperature lockout on 

the overheat thermostat. This could occur due to 

air or poor circulation in the boiler.

                       This can be reset manually by pressing on/ 

off switch. If lockout should persist leave the 

applliance shut down and consult your installer/ 

service engineer immediatly. 

     1.4.4.        The CSI Primary condensing boiler is fi tted with 

a condensate outlet whitch must be connected 

by the installer to a suitable discharge point 

as specifi ed in the installation manual. On no 

account should this discharge pipe be blocked or 

modifi ed.  

USER’S GUIDE

CSI PRIMARY  AAA

CONDENSING PRIMARY INNOVATION SUPER HIGH EFFICIENTY  AUTOMATIC

    MODULATING  BOILER FOR CENTRAL   HEATING AND DOMESTIC HOT WATER

 It is the law that all gas appliances are installed by 

 a competent person, in accordance with the gas 

 safety installation and use current regulations.

 To the current Gas Safety (Installation and Use) 

 Regulations B.S.5440:2-(2000).

All CORGI registered installers carry a CORGI ID card and 

have a registration number. Both should be recorded in your 

boiler Log book. You can check your installer by calling 

CORGI direct on 01256 732300.

  1