Rayburn Heatranger 355SFW User instructions

Other manuals for Heatranger 355SFW: Installation Instructions Manual

Manual is about: Solid Fuel and Wood Burning Cooker

Page of 12

Download

Print this page

Bookmark us

Consumer Protection Act 1987

As responsible manufacturers, we take care to make sure that our

products are designed and constructed to meet the required safety

standards when properly installed and used.

IMPORTANT NOTICE: PLEASE READ THE ACCOMPANYING

WARRANTY:

Any alteration that is not approved by Aga, could

invalidate the approval of the appliance, operation of the warranty

and could also affect your statutory rights. Use only authorised

replacement parts.

All local regulations including those referring to national and

European standards need to be complied with when installing

the appliance.

Control of Substances - Health and Safety

Important

This appliance may contain some of the materials that are indicated.

It is the Users/Installers responsibility to ensure that the necessary

personal protective clothing is worn when handling, where

applicable, the pertinent parts that contain any of the listed materials

that could be interpreted as being injurious to health and safety, see

below for information.

Firebricks, Fuel beds, Artificial Fuels

- when handling use

disposable gloves.

Fire Cement

- when handling use disposable gloves.

Glues and Sealants

- exercise caution - if these are still in liquid

form use face mask and disposable gloves.

Glass Yarn, Mineral Wool, Insulation Pads, Ceramic Fibre,

Kerosene Oil

- may be harmful if inhaled, may be irritating to skin,

eyes, nose and throat. When handling avoid inhaling and contact

with skin or eyes. Use disposable gloves, face-masks and eye

protection. After handling wash hands and other exposed parts.

When disposing of the product, reduce dust with water spray,

ensure that parts are securely wrapped.

The Rayburn 355SFW has been designed to burn a

variety of solid fuels and thereby provide heating facilities

for cooking, domestic hot water and central heating.

The thermostatically controlled hot water boiler can be

operated independently of the cooker and will provide hot

water for central heating and domestic use (normal

setting for winter usage), whilst manually operated

spinwheel control on the front of the ashpit door will

provide heat for cooking and domestic hot water (normal

setting for summer usage).

The cooker/boiler flueway damper knob on the centre

front of the cooker below the top plate requires to be set

in conjunction with the flue chamber damper to obtain the

appropriate service required from the appliance.

FIREBRICK POSITIONS

The Rayburn 355SFW is delivered complete including a

set of boiler removable firebricks where positional

location determines the amount of hot water supplied in

winter and summer seasons.

The oven side and firebox front firebricks are

permanently fixed with fire cement and should remain in

their positions at all times.

The two boiler face side bricks and boiler face rear brick

are so located for summer use when hot water, for

domestic use only, will be provided.

For winter use or central heating facilities the boiler face

rear brick is removed and the two boiler face side bricks

are transferred to locate on/over the oven side bricks.

Secondary Air Slide.

On opening the firedoor the secondary air slide is seen

on the base of the opening and should be set according

to the fuel being used as follows:-

Air Slide Open - wood logs

Air Slide Closed - manufactured smokeless fuels

This appliance has been tested using manufactured

briquetted smokeless fuel (Taybrite and Ancit) for closed

appliances sized between 20g and 140g. Other fuels are

commercially available and may give similar results.

WARNING: HOT SURFACES, use the tool supplied to

operate this appliance. It is recommended to use the

heatproof glove supplied when raising the dome lids to

use the hotplate. Replacement gloves can be obtained

from the Aga Shop.

Users Instructions.

Rayburn Heatranger 355SFW

Solid Fuel and

Wood Burning Cooker

INTRODUCTION

PREPARING COOKER FOR USE

04/07 EOPI 514409

WARNING

THE ASHPIT AND FIREBOX DOORS MUST BE LOCKED

CLOSED AT ALL TIMES DURING NORMAL USE, EXCEPT

WHEN LIGHTING OR RE-FUELLING.

Fig. 1

raywarranty@aga-web.co.uk

1 2 3 4 5 6 7 Next › »

Summary of Heatranger 355SFW

Page 1
Consumer protection act 1987 as responsible manufacturers, we take care to make sure that our products are designed and constructed to meet the required safety standards when properly installed and used. Important notice: please read the accompanying warranty: any alteration that is not approved by ...
Page 2
Manufactured - sunbrite singles, sunbrite doubles, coalite, phurnacite and supacite. Natural - anthracite large & small nuts, selected housecoal (trebles/large nuts and doubles/nuts), taybrite, coke. Petroleum coke must not be used. Oversize fuel lumps should be broken down to size. Stones and other...
Page 3
The cooker will satisfactorily burn wood logs, blocks or peat briquettes, but logs should be perfectly dry in order to obtain the best cooker performance and minimise the deposits of creosote. Wood logs may also provide overnight banking problems and the following hints are recommended:- a) burn dry...
Page 4
Set the cooker/boiler damper knob on the front of the cooker to ‘c’ and the boiler thermostat knob on the rear left hand corner of the top plate, to its minimum setting. D) thermostat set at no.1 as domestic hot water is obtained when cooking. Note: intermediate selective settings of the cooker/boil...
Page 5
The flue chamber damper to maximum and riddle the fire. When it is burning brightly, close the flue chamber damper, but do not refuel before use if the hotplate is required immediately. All fuels. Set the cooker/boiler damper knob ‘h’. Close spinwheel. To regulate burning, set the boiler thermostat ...
Page 6
When burning solid fuel and 2 hours burning wood when maintaining the maximum rated output of the boiler with intermittent cooking periods included. Note: when burning any wood fuels and sunbrite coke, the secondary air slide should be set in a fully open position. A deep bed of newly charged fuel o...
Page 7
It is not possible to control this oven, but during the course of roasting, sufficient heat input permits simmering of dishes that have been taken from the roasting oven. Oven temperatures:- idling 95ºc min. During cooking - 135ºc max. During the cooker idling periods, the oven is ideal for heating ...
Page 8
If it is not in use ashpit and flue chamber doors should be left open to ensure free passage of air through the appliance and avoid condensation problems. Sweep annually and inspect soot box at 3 monthly intervals and remove any deposits. Note: sweeps brushes must be of the type with wire centres an...
Page 9
9 properly installed and operated, this cooker will not emit fumes. Occasional fumes from de-ashing and re-fuelling may occur but persistent fume emission must not be tolerated. If fume emission does persist, then the following immediate action should be taken:- a) open doors and windows to ventilat...
Page 10
10
Page 11
11.
Page 12
12 for further advice or information contact your local distributor/stockist with aga’s policy of continuous product improvement, the company reserves the right to change specifications and make modifications to the appliance described at any time. Manufactured by aga station road ketley telford shr...