Raypak 1005-2005 Specification Sheet

Catalog No.:  6000.37 

Effective:  9-15-08  

Replaces:  NEW

Job: 

Engineer: 

Contractor: 

Prepared By: 

 Date:

Model:  

 Indoor/Outdoor:   

97% Thermal Efficiency at Full Rate; Up to 99% at Part Load 

100% Factory Fire Tested  

Maximum Outlet Water Temperature: 160°F 

Minimum Acceptable Inlet Water Temperature: 50°F 

Full Safety Diagnostics with History 

Footprint: Less Than 10.8 ft

2

Limited Twenty-Five-Year Thermal Shock Warranty 

Limited Ten-Year Primary Heat Exchanger Warranty 

Limited Five-Year Secondary Heat Exchanger Warranty 

Full Electronic Modulation, Constant Ratio 4:1 Turndown 

Digital Controller with LCD Display 

Status Display Lights 

Heat Exchanger 

ƒ Bronze Headers 

ƒ  ASME HLW Stamped; 160 PSIG 

MAWP  

ƒ  National Board Listed 

ƒ  Cupro Nickel Fin Tubing 

ƒ  ASME Powder-Coated Tube Sheet 

ƒ  Silicone High Temp O-Rings 

ƒ  ASME Pressure Relief Valve 

125 PSIG – Standard (Loose) 

ƒ  150 PSI Air Vent, Auto 

ƒ  T&P Gauge (Loose) 

ƒ  Stainless Steel Secondary Heat 

Exchanger 

ƒ  Stainless Steel Evaporator Plate 

ƒ  Boiler Pump: Bronze,            HP, 

120V, 1

∅, 60Hz 

Control 

ƒ  120V, 60Hz, 1Ø, Power Supply 

ƒ  120/24V 60Hz Transformer 

ƒ Ignition Module 

 3-Try – Standard 

 Single-Try – Option C-6 

ƒ  Hot Surface Ignition (HSI) 

ƒ  Remote Flame Sensor 

ƒ  High Limit Control, Auto Reset 

ƒ  On/Off Power Switch 

ƒ Flow Switch 

ƒ  Blocked Vent Pressure Switch 

ƒ  Combustion Air Proving Switch 

ƒ Freeze Protection 

ƒ Pump Switch 

ƒ  Pump Time Delay 

ƒ  Blocked Condensate Switch 

Control (cont.) 

ƒ  Diagnostics Panel with LCD Display,  

2 lines, 20 characters 

ƒ  Digital Temperature Control 

ƒ  Water Temperature Sensors (3) 

ƒ  Cold Water Protection 

Burner 

ƒ  Ultra-Low NOx: Less than 20 PPM 

(Natural Gas Only) 

Gas Train  

ƒ Fuel 

 Natural Gas 

 Propane 

ƒ Zero Governor Regulator 

ƒ  Dual-Seat Combination Valve 

ƒ  Electronic Firing Mode (WHP)  

Construction 

ƒ Indoor/Outdoor Construction 

ƒ Front Controls Enclosed 

ƒ  PolyTuf Powder Coat Finish 

ƒ  Rear Connections (Water, Gas, Vent, 

Electrical, Comb. Air, Cond. Drain) 

ƒ  Combustion Air Filter 

ƒ  Design Certified ANSI Z21.10.3/CSA 4.3 

Venting 

ƒ Vent Termination 

 Outdoor or Indoor, Vertical –  

Option D-11 

 Indoor, Horizontal – Option D-15 

ƒ  Extractor - Optional 

 By others 

 Not required 

Multi-Boiler Digital Temp Controllers 

 B-36  TempTracker Mod+,  

2-4 Water Heaters 

 B-37  TempTracker Mod+,  

5-10 Water Heaters 

 B-38   TempTracker Mod+,  

11-16 Water Heaters 

Options 

 F-10  Low Water Cut-Off, Remote 

Probe 

 I-5 

High Limit, Manual Reset, 

Adj., 100-200

°F 

 S-1 

Low Gas Pressure Switch,  

Manual Reset 

 S-2 

High Gas Pressure Switch, 

Manual Reset 

 Z-12  Condensate Neutralizer Kit 

Regulatory Agency Requirements 

XTherm

™

- Type WHP

    Water Heaters

Models 1005-2005