SAFARI Trek 2002 Owner's Manual

Manual is about: Safari Trek 2002 Motorhome owner's manual

Summary of Trek 2002

  • Page 1

    Trek owner’s manual 1 what the period of coverage is • 1 limitations of implied warranties • 2 what the warranty covers • 2 what we will do to correct the problems • 2 how to get service • 3 what the warranty does not cover • 3 events discharging warrantor from obligation under warranty • 4 disclaim...

  • Page 2

    Trek owner’s manual 2 limitations of implied warranties any implied warranties arising by way of state law, includ- ing any implied warranty of merchantability and any implied warranty of fitness for a particular purpose, are limited in duration to the term of this limited warranty and are limit- ed...

  • Page 3

    Trek owner’s manual 3 if two or more unsuccessful repair attempts have been made to correct any covered defect that you believe substantially impairs the value, use or safety of your motorhome, you must, to the extent permitted by law, notify warrantor directly in writing of the failure to successfu...

  • Page 4

    Trek owner’s manual 4 television(s), water heater, furnace, stereo, radio, compact disc player, washer, dryer, inverter and cellular phone; or flaking, peeling and chips or other defects or damage in or to the exterior or finish caused by rocks or other road hazards, the environment including airbor...

  • Page 5

    Trek owner’s manual 5 ~ n otes ~.

  • Page 6

    Trek owner’s manual 6 ~ n otes ~.

  • Page 7

    Revision date: july 15, 2001 the descriptions and specifications in this manual pertain to the 2002 model year and were in effect at the time of its approval for printing. Safari reserves the right to change specifications or designs without notice or without incurring obligation. This manual includ...

  • Page 9

    T able of c ontents safari motorhome limited warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 what the period of coverage is . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 limitations of implied warranties . . . . . . . . . . . . . . . . . . . . . . ....

  • Page 10

    Section 3 - heating & cooling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41 overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43 trek heating systems . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Page 11

    Section 5 - waste water systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65 overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67 holding tanks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

  • Page 12

    Water pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91 toilet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92 care & cleaning . . . . . . . . . . . . . . . . . . . . . . ...

  • Page 13

    Section 10 - storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .117 overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .119 storage preparation . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Page 15

    Chassis & dash - section 1 overview • 17 vehicle operation • 17 main dashboard • 18 switch panel detail • 19 instrument panel cluster (typical) • 23 side console • 26 other controls and accessories • 27 electric step • 27 inverter remote panel • 27 levelers • 28 coach monitor panel • 31.

  • Page 17

    Trek owner’s manual 1 ~ 17 c hassis & d ash o verview your safari trek is built on a p-series chassis by workhorse custom chassis. It is avail- able with your choice of either a 6.5 liter diesel or a 454 cid vortec or 8.1 liter vortec gasoline engine. Included in your warranty packet you will find a...

  • Page 18

    Trek owner’s manual 1 ~ 18 warning: if you have a diesel engine, you need to wait the appropriate amount of time after turning the ignition to the on position before actually starting your coach. (see chassis manual.) do not crank the starter for more than thirty seconds at a time. If the engine fai...

  • Page 19

    Trek owner’s manual 1 ~ 19 a. Switch panel this panel contains control switches for up to twelve different features available on your coach depending on model and floor plan. If you do not have one of these switches, it was not a feature included in your coach. The individual switch features are des...

  • Page 20

    Trek owner’s manual 1 ~ 20 1. Icc lights push this switch to activate exterior lights along the caps of the coach. This is useful to alert passing motorists when they have safe clearance to return into the lane when passing on two-lane highways. 2. Panel lights this switch allows the driver to illum...

  • Page 21

    Trek owner’s manual 1 ~ 21 power switch: the switch, when on (in) position, turns on the monitor for viewing. The green led indi- cator illuminates. When the switch is off (out), the monitor is in a standby mode of operation. The green led remains illuminated when the ignition is on. The moni- tor d...

  • Page 22

    Trek owner’s manual 1 ~ 22 7. Overhead defrost blowers this switch controls the cabin circulation fan located in the overhead cabinet. The switch has two speeds. The first stop is low and the second stop is high speed. 8. Mirror heaters the remote mirrors will be heated when this switch is activated...

  • Page 23

    Trek owner’s manual 1 ~ 23 instrument panel cluster (typical) located above the speedometer/tachometer instrument cluster are various warning lights. These warning lights will activate when the ignition is in the on position or under certain conditions to warn you of potential problems. These lights...

  • Page 24

    Trek owner’s manual 1 ~ 24 d. Engine fuel level gauge the fuel reading will vary when cornering, accelerating, braking, and climbing or descending hills. The fuel tank has a capacity of 60 gallons. E. Dc voltmeter gauge this gauge displays the performance of the chassis dc system, especially the bat...

  • Page 25

    Trek owner’s manual 1 ~ 25 warning: do not operate the engine at temperatures above 230º. If the tempera- ture reading exceeds this level, pull over promptly and allow the engine to cool. Extended or frequent operation at this temperature will void your engine warranty. I. Leveler controls these con...

  • Page 26

    Trek owner’s manual 1 ~ 26 n. Air vents these vents distribute air from the heating, air conditioning and fresh air systems. Controls allow you to choose whether air is vented from outside the coach or if it is to be recirculated from within the coach interior. Side console a. Remote mirror controls...

  • Page 27

    Trek owner’s manual 1 ~ 27 other controls and accessories electric step the electric step is controlled by two methods: the activation of the ignition switch and by an on/off switch near the doorway. The on/off switch controls the 12 vdc power to the step. If the switch is on, then the step will ext...

  • Page 28

    Trek owner’s manual 1 ~ 28 levelers note: please make sure the wheels are straight before extending the jacks or leveling the coach. Keep all persons away from the leveling system mechanism when operating the leveling system, driving the vehicle, and/or when the vehicle is parked. Before using the l...

  • Page 29

    Trek owner’s manual 1 ~ 29 extending the three-point leveling system step 1 park the coach in a level spot. Make sure the wheels are as close to straight as possible. Place transmission in park . Set the parking brake. Turn the ignition to the accessory position. Step 2 go outside the coach and chec...

  • Page 30

    Trek owner’s manual 1 ~ 30 to ensure the smooth operation, the leveling system should be operated at least once a month, or each trip, to keep the system in working condition. Check each hydraulic unit to prevent problems. This is especially true under the following conditions: if driving conditions...

  • Page 31

    Trek owner’s manual 1 ~ 31 coach monitor panel located in a compartment above the entry door in your safari trek is the coach monitor panel. This panel has a monitor switch for inverter power, battery levels, lp-gas, water and holding tank level. There are also switches to start the water pump and g...

  • Page 32

    Trek owner’s manual 1 ~ 32 c. Water pump switch remote power switch for the water pump. D. Generator stop/start switch use this switch to start and stop the generator. Simply press and hold it until the generator starts. To stop the generator, press the lower portion of the switch until the motor co...

  • Page 33

    Traveling - section 2 overview • 35 trip preparation • 35 your first trip • 35 leaving home • 35 coach preparation • 36 storing cargo • 37 at your destination • 38 conserving coach resources • 38 before leaving • 40

  • Page 35

    Trek owner’s manual 2 ~ 35 t raveling o verview to get the full enjoyment of traveling in your new trek, careful preparation is necessary. Good planning and preparation will lead to less potential trouble while traveling and when you reach your destination. This chapter gives some general guidelines...

  • Page 36

    Trek owner’s manual 2 ~ 36 the following checklist highlights many of the most important precautions. • arrange for deliveries, such as the newspaper, to be discontinued. • ask the post office to hold your mail. • arrange care for your animals and plants. • have the house periodically checked. • not...

  • Page 37

    Trek owner’s manual 2 ~ 37 • if you have a diesel engine, clean the fuel/water separator. • make sure that all scheduled maintenance for your chassis has been performed. • check that all lights, including the driving lights, are operational. • adjust the mirrors. • check the windshield washer fluid ...

  • Page 38

    Trek owner’s manual 2 ~ 38 helpful hint: • multi-purpose items, versatile clothing and periodic removal of unused cargo enables you to store more of what you usually use. Warning: avoid towing vehicles with a hitch weight in excess of 5000 lbs. It will place undue stress on components and cause unus...

  • Page 39

    Trek owner’s manual 2 ~ 39 lp-gas conservation your lp-gas tank holds 35 gallons of fuel. For maximum efficiency, follow these guidelines: • keep the refrigerator in automatic mode to take advantage of the 120 vac power. • use the micro/convection oven rather than the gas stove whenever you are able...

  • Page 40

    Trek owner’s manual 2 ~ 40 before leaving before leaving the camping area there are certain procedures that should be followed. These are summarized in this list: • make sure that all awnings are retracted and locked - both on the arms and on the roller. • make sure that all levelers are completely ...

  • Page 41

    Heating & cooling - section 3 overview • 43 trek heating systems • 43 40,000 btu lp gas furnace • 43 water heater • 44 trek cooling systems • 45 roof air conditioning • 46 attic fan • 46 dash air conditioning & heater • 47.

  • Page 43

    Trek owner’s manual 3 ~ 43 h eating & c ooling o verview your coach contains several systems to maintain a comfortable living temperature, including powerful furnace and air conditioning units. While these units will maintain your comfort in most climates, do not underestimate the importance of the ...

  • Page 44

    Trek owner’s manual 3 ~ 44 a thermostat located in the living room controls the furnace. Turn the furnace switch on the thermostat to the on position. Set the thermostat to the desired temperature. The fan will come on and the burner should light within thirty seconds. If the burner does not ignite,...

  • Page 45

    Trek owner’s manual 3 ~ 45 it also has a safety cutoff. If the heat in the unit exceeds 180º, it automatically shuts off, and will not start again until it has cooled down and the reset button is pressed. Warning: the water heater must never be started without a full tank of water. Make sure the wat...

  • Page 46

    Trek owner’s manual 3 ~ 46 roof air conditioning the 13,500 btu air conditioning system is 120 vac powered and thermostatically controlled. In addition to its cooling power, you can also use it as a forceful circulation fan. The airflow is ducted through registers on the ceiling. The system requires...

  • Page 47

    Trek owner’s manual 3 ~ 47 dash air conditioning & heater the dash of your motorhome contains an automobile-style heater and air conditioning unit. This is designed to keep the front cab area comfortable while driving, without using the main appliances. These units are intended to reduce the relianc...

  • Page 48

    Trek owner’s manual 3 ~ 48 ~ n otes ~.

  • Page 49

    Patio awning • 59 window awnings (optional) • 61 awning maintenance • 61 electromajic™ bed • 62 lowering the bed • 63 raising the bed • 63 appliances & equipment - section 4 overview • 51 galley features • 51 stove top • 51 refrigerator • 52 micro/convection oven • 53 sinks • 54 safety features • 55...

  • Page 51

    Trek owner’s manual 4 ~ 51 a ppliances & e quipment o verview your coach contains a variety of appliances and equipment, ranging from the awnings to the tv. The manufacturer's manuals for all of these items are included in the warranty package. This manual contains general information for quick refe...

  • Page 52

    Trek owner’s manual 4 ~ 52 warning: a gas stove top is not, nor should it ever be used, as a space heater. Warning: do not leave the burners or pilot lights lit while traveling or refueling your vehicle at a service station. To ignite the burners, push in the knob and turn counterclockwise to the ig...

  • Page 53

    Trek owner’s manual 4 ~ 53 three switches control the refrigerator. One switch controls the thermostat, another the humidity, and a third controls the mode of operation. To start the refrigerator, turn the thermostat to its coldest setting. Then push the mode switch to gas . The red x will appear. T...

  • Page 54

    Trek owner’s manual 4 ~ 54 an owner's manual is included in the warranty package. Be sure to read all of the instruc- tions and precautions supplied with the oven before using it. The manual also contains an excellent summary guide. The oven should only be adjusted or repaired by qualified service p...

  • Page 55

    Trek owner’s manual 4 ~ 55 s afety f eatures engines, generators, and water heaters all emit exhausts that could possibly enter your coach. While unlikely, these systems may also develop leaks of diesel or propane gas. For your safety, the following items are standard on every safari coach: smoke al...

  • Page 56

    Trek owner’s manual 4 ~ 56 carbon monoxide detector carbon monoxide (co) is an odorless, invisible gas that is an exhaust product from the engine, heaters, or furnace. It can be lethal. Your coach is designed to keep all exhausts from entering the interior. However, if co exhausts do enter your coac...

  • Page 57

    Trek owner’s manual 4 ~ 57 fire extinguisher each coach is equipped with a fire extinguisher located near the entry door. Be sure to learn correct operation of the fire extinguisher before an emergency arises. In order to keep the fire extinguisher in a safe and operable condition, inspect it regula...

  • Page 58

    Trek owner’s manual 4 ~ 58 note: if you are using the cable hookup, you must leave the antenna boost switch in the off position. Remember to lower the tv antenna before driving. This switch also controls whether the system is sending signals to the vcr from the antenna or a cable connection. When th...

  • Page 59

    Trek owner’s manual 4 ~ 59 the receiver can be pulled out of its location by hand without the use of tools. There is extra cable attached so the unit can be pulled out enough for access. When you have the card and numbers, call the number listed in the sony operating instructions. Video cassette rec...

  • Page 60

    Trek owner’s manual 4 ~ 60 note: it may be necessary in some installations to pull awning approximately halfway open, raise the main arms approximately halfway to the desired height and then finish unrolling the awning. This procedure should be reversed for closing the awning 5. Slide the pull strap...

  • Page 61

    Trek owner’s manual 4 ~ 61 window awnings (optional) window awnings are a very popular option on the safari trek. A manufacturer's manual with detailed installation and operation instructions has been provided in your warranty package. Please familiarize yourself with these instructions before opera...

  • Page 62

    Trek owner’s manual 4 ~ 62 note: your awning can be rolled up wet, if necessary, but be sure to open and dry it as soon as possible. This will help prevent mildew and rotting. The awnings have moving parts guiding the fabric. These parts should be periodically lubricated to resist corrosion and ensu...

  • Page 63

    Trek owner’s manual 4 ~ 63 use of the electromajic™ bed allows the full galley, bathroom and living area normally associated with a safari coach into trek's compact, economical size. Lowering the bed 1. Turn the lock out switch to the on position. It is a rocker switch located in the galley overhead...

  • Page 64

    Trek owner’s manual 4 ~ 64 ~ n otes ~.

  • Page 65

    Wastewater systems - section 5 overview • 67 holding tanks • 67 odor control • 68 sewer connection • 69 draining the tanks • 69 using a sewer line • 70

  • Page 67

    Trek owner’s manual 5 ~ 67 w aste w ater s ystems o verview the waste water holding system makes your coach a completely self-contained camping unit. You can use appliances and fixtures without a sewer hook-up while storing the waste until it is convenient to dispose of it. The system is designed to...

  • Page 68

    Trek owner’s manual 5 ~ 68 the "grey water" tank is used to hold waste water from the galley sink and shower. Those drains should not be used to dispose of solid waste, although small amounts of food or similar debris will not harm the system. You should not use the drains to dispose of any caustic ...

  • Page 69

    Trek owner’s manual 5 ~ 69 clean the tanks after every trip. The grey water tank generally requires only an occasional rinsing. Do this by running clean water from the shower or galley sink to fill and then drain the tank. If an odor develops in the grey water system, fill the tank with a solution o...

  • Page 70

    Trek owner’s manual 5 ~ 70 once the tanks have been cleaned, rinsed, and drained, the fluid levels should read empty at the monitor panel. If not, repeat the processes previously mentioned until both tanks read empty when drained. Note: always drain the black tank first and follow with the grey tank...

  • Page 71

    Electrical systems - section 6 overview • 73 electrical system operations • 73 120 vac system • 74 circuit breakers and gfci • 75 generator • 76 power transfer switch • 77 inverter • 78 12 vdc system • 79 chassis system • 79 solar panel • 79 isolator • 80 boost switch • 80 house system • 80 fuses • ...

  • Page 73

    Trek owner’s manual 6 ~ 73 e lectrical s ystems o verview the electrical system in your safari trek provides maximum power with a minimum amount of effort and maintenance from the owner. Any appliance you would use in your home can be used in your coach within the amperage limits of the system. Ther...

  • Page 74

    Trek owner’s manual 6 ~ 74 warning: do not connect the shore line to any source other than a rv approved outlet. Connecting your shore line to 30 amp outlets such as dryer or welder outlets in the home or well pumps on a farm will cause extreme damage to the electrical system of your coach and may c...

  • Page 75

    Trek owner’s manual 6 ~ 75 simplified electrical system circuit breakers and gfci the 120 vac system has two important safety mechanisms. First, a set of circuit breakers prevents any circuit from being overloaded. A breaker can be tripped as the result of a short circuit, a faulty appliance, or too...

  • Page 76

    Trek owner’s manual 6 ~ 76 warning: a circuit without a breaker presents a serious safety hazard. Never attempt to bypass the circuit breakers for any reason. Doing so will void the warranty both of your coach and any appliance on the circuit. The main breaker panel is labeled with the appliances an...

  • Page 77

    Trek owner’s manual 6 ~ 77 you can start your generator by using one of two generator switches. One is located on the coach monitor panel. The other switch is located on the generator itself. Press the start button and hold it until the generator starts. A delay of up to five seconds is normal. To s...

  • Page 78

    Trek owner’s manual 6 ~ 78 inverter warning: the coach batteries will drain much faster when not using external shore line or generator power. It is wise to conserve energy when your motor coach is using only inverter power. The inverter is located in the compartment in front of the driver's side re...

  • Page 79

    Trek owner’s manual 6 ~ 79 12 vdc s ystem note: if you experience an interruption in 12 vdc power, please check the 12 vdc disconnect switch located in the entry well. The 12 vdc coach system provides power for a variety of applications. Many coach lights, fans, the water pump, and other coach acces...

  • Page 80

    Trek owner’s manual 6 ~ 80 note: solar panel will not be immediately operational following extended periods of inside storage. After exposure to the sun, the trickle-charge process will begin. Isolator power from the alternator is channeled through an isolator. This device allows the alternator to s...

  • Page 81

    Trek owner’s manual 6 ~ 81 the house system is charged by several sources. The alternator charges the system through the isolator when the engine is running. As mentioned above, the isolator keeps the house system separate from the chassis system, preventing the chassis battery from being drained by...

  • Page 82

    Trek owner’s manual 6 ~ 82 fuses fuses offer a simple and effective method of protecting the 12 vdc lines from overloads. By burning out during an overload, they stop the current and end the hazard the over- loaded circuit might present to the appliances and to the coach. Fuses are an important safe...

  • Page 83

    Plumbing systems - section 7 overview • 85 operation • 85 using a connection • 85 using while disconnected • 86 filling the tank • 86 the water pump • 87 cold weather use • 88 toilet • 88 shower • 89 maintenance • 90 troubleshooting • 91 water pump • 91 toilet • 92 care & cleaning • 94.

  • Page 85

    Trek owner’s manual 7 ~ 85 p lumbing s ystems o verview your trek contains a full freshwater plumbing system capable of operating as a self- contained unit or for making use of a pressurized water source. For camping away from amenities, the system has a specially designed pump system that provides ...

  • Page 86

    Trek owner’s manual 7 ~ 86 note: in some rare instances, the water pressure of a locality may be very high. Inquire locally before using the connection. Pressure over 125 psi may damage the regulator and the plumbing system. Note: periodically check the city water tap plug for tightness. This plug p...

  • Page 87

    Trek owner’s manual 7 ~ 87 note: always use clean, potable water. The water system contains a pre-filter to prevent damage to the pump and heater; however, this filter cannot make potable drinking water from an inadequate source. This filter should be cleaned periodically. Note: using the external w...

  • Page 88

    Trek owner’s manual 7 ~ 88 turn off the pump if you are going to be away from your coach for an extended period of time remember to turn it on again when you return. You will not need to prime the pump or perform any other action to restart the system. Cold weather use the entire freshwater system, ...

  • Page 89

    Trek owner’s manual 7 ~ 89 when flushing liquids, the small amount of water released on flushing is generally enough to rinse the bowl. When flushing solid waste, raise the lever sufficiently to allow enough water to enter the bowl to carry the solids. After flushing, a small amount of water should ...

  • Page 90

    Trek owner’s manual 7 ~ 90 warning: after using the shower, always turn off the water at the faucet. Keep the shower drain plug locked when traveling. M aintenance the water system uses roto-molded plastic water tanks and vinyl tubing which deliver non-toxic, non-metallic, pleasant tasting drinking ...

  • Page 91

    Trek owner’s manual 7 ~ 91 note: periodically check the overflow pipe of the water tank to ensure it is not clogged with debris. Mud, road materials and even insects can close the vent and may over-pressurize the tank when it is filled. T roubleshooting occasional problems can occur to prevent the w...

  • Page 92

    Trek owner’s manual 7 ~ 92 problem: pump runs, but water sputters. Check the water level in the tank. Check for an air leak in the input lines to the pump. Check the in-line filter for evidence of leakage. Problem: pump "cycles" - turns rapidly on and off when a faucet is opened. Nothing is wrong. T...

  • Page 93

    Trek owner’s manual 7 ~ 93 check the ball valve and underside of the seal for dirt and foreign materials. If necessary, replace seals, flush ball, and half-clamps. Problem: water does not shut off after flushing. Toilet overflows. Disassemble and clean the water valve. If the valve is defective, rep...

  • Page 94

    Trek owner’s manual 7 ~ 94 care & cleaning the sinks, counter tops, and tub/shower fixtures are simple to care for. Use a mild soap/water combination to clean their surfaces. A commercial glass cleaner can be used on the glass shower door. The shower stall is constructed of a gel-coated fiberglass s...

  • Page 95

    Lp-gas - section 8 overview • 97 coach use • 97 safety precautions • 98 the lp-gas tank • 99 110 lp-gas tank • 100 filling procedure • 101 vapor valve • 101 regulator • 102 maintenance & troubleshooting • 102.

  • Page 97

    Trek owner’s manual 8 ~ 97 lp-g as o verview liquid propane gas, or "lp-gas", is an extremely clean and efficient fuel. It is safe, economical, and provides modern living conveniences no matter where you travel. It burns cleanly and packs a tremendous amount of energy in a small container. It is an ...

  • Page 98

    Trek owner’s manual 8 ~ 98 (p ictured above gasoline powered models ) not all lp-gas is the same. There are two main components of lp-gas, propane and butane, and they can be blended in any proportion. Butane is the less volatile, and cannot be used in temperatures below freezing. Propane can be use...

  • Page 99

    Trek owner’s manual 8 ~ 99 periodically have the lp-gas supplier check the system for possible gas leaks or miss- ing/damaged parts. Practice safety at all times. If you have questions about the operation of your appliances or lp-gas system, contact your local lp-gas dealer or rv service center. War...

  • Page 100

    Trek owner’s manual 8 ~ 100 (pictured: vortec gasoline powered) the fill and pressure-relief valves are used only when filling the tank, and should not be handled any other time. The vapor valve controls the supply of gas to the appliances. Warning: never store lp-gas tanks inside your coach or in s...

  • Page 101

    Trek owner’s manual 8 ~ 101 filling procedure before filling the tank, make sure that all pilot lights are off, and that the engine and gen- erator are not running. The vehicle should be level. The technician filling your tank should be trained in the full procedure. To allow for heat expansion, the...

  • Page 102

    Trek owner’s manual 8 ~ 102 warning: never use a wrench or pliers on any of the lp-gas tank valves. They are designed to close completely by hand. If tools are necessary to stop the flow, the valve needs to be repaired or replaced. Regulator the regulator controls the flow of gaseous fuel to the app...

  • Page 103

    Trek owner’s manual 8 ~ 103 the following procedures will help keep your system functioning properly: • inspect the lines and fittings regularly for signs of corrosion or dents. • periodically check for leaks. To check a fitting, apply very soapy water and look for bubbles. Make sure to do this befo...

  • Page 104

    Trek owner’s manual 8 ~ 104 the problem may require a trained technician. Moisture in the tank may have "frozen" the regulator, and requires purging. Take your coach to a service center. Problem: gas flow is inconsistent. Check for debris or corrosion on the regulators. If any is apparent, take the ...

  • Page 105

    Maintenance - section 9 overview • 107 exterior maintenance • 107 inspection • 108 interior maintenance • 109 cabinetry • 109 countertops • 109 bathroom fixtures • 110 dash & plastics • 110 walls & ceilings • 110 doors & hinges • 110 carpet • 111 wood floors (optional) • 111 chassis maintenance • 11...

  • Page 107

    Trek owner’s manual 9 ~ 107 m aintenance o verview every safari trek is designed to be the highest quality, most durable product of its kind on the market. Your coach will provide years of superior use with proper maintenance. Regular attention is essential to the enjoyment of your investment. In ad...

  • Page 108

    Trek owner’s manual 9 ~ 108 do not use chrome polish on any metal except chrome, and never use steam, caustic soap, or auto polish on the aluminum parts. On aluminum you may use a tire sidewall cleaner, but rinse thoroughly with clean water. Moisture enters locks, hinges and crank handles and then m...

  • Page 109

    Trek owner’s manual 9 ~ 109 i nterior m aintenance the interior of your coach will benefit from regular care. For the most part, maintaining the interior of your coach is much like maintaining a home. Most products needed for cleaning can be purchased at a grocery store. When using stain removers, a...

  • Page 110

    Trek owner’s manual 9 ~ 110 bathroom fixtures the shower, sink, and toilet in the bathroom have either a gel coat or a genovese finish. Countertops are made of either genovese or fountainhead. These can be cleaned with a liquid cleanser. Do not use scouring powder, it will scratch the surface. Brass...

  • Page 111

    Trek owner’s manual 9 ~ 111 carpet top-quality, residential, stain-resistant carpet is used in all safari coaches. Clean them as you would carpets in your own home. Normal vacuuming is sufficient day-to-day. Consult a professional carpet cleaner to shampoo the carpets. If stains occur, clean immedia...

  • Page 112

    Trek owner’s manual 9 ~ 112 weekly inspections: • check belts for proper tension. • check power steering fluid. • check engine fan. • check batteries. • check brake master cylinder fluid level. Every 6,000 miles: • check air intake system for damage. • check steering box for leakage. • check hydraul...

  • Page 113

    Trek owner’s manual 9 ~ 113 battery care batteries also require maintenance on a regular basis. Your coach has two sets of batteries - one set for the house 120 vac requirements, and one set for the engine. Remember to check both sets regularly. Identify each battery cable to be positive or negative...

  • Page 114

    Trek owner’s manual 9 ~ 114 if there is any damage to the tire, such as cuts, bulges, or peeling tread, replace the tire immediately. Remove any rocks lodged in the tread. Check for loose lug bolts. Even standing still, tires can age and wear. Tires have two major enemies: sunlight and unchanging we...

  • Page 115

    Trek owner’s manual 9 ~ 115 warning: do not add coolant through the fill on the radiator. Hot liquid or vapor can escape and cause severe burns or injury when opening the radia- tor. Always add coolant through the expansion tank above the engine..

  • Page 116

    Trek owner’s manual 9 ~ 116 ~ n otes ~.

  • Page 117

    Storage - section 10 overview • 119 storage preparation • 119 plumbing • 119 waste water system • 120 other systems • 120 moisture problems • 121.

  • Page 119

    Trek owner’s manual 10 ~ 119 s torage o verview to keep your coach in proper condition while it is stored, you must make preparations. The first thing to consider is the storage area itself. Obviously an inside area is preferable to outside storage. A heat source is also valuable since it will help ...

  • Page 120

    Trek owner’s manual 10 ~ 120 to drain your system, start with the water tank. Open the tank drain valve and leave it open. When empty, start the water pump and open several faucets. Run the pump until no more water comes out. Be sure to shut off the water heater. The switch is located above the entr...

  • Page 121

    Trek owner’s manual 10 ~ 121 your lp gas system requires virtually no maintenance. Simply turn the flow valves off. Do not attempt to drain the system. The generator requires the same type of attention as any engine. A full schedule of maintenance requirements is given in the generator manual. Your ...

  • Page 122

    Trek owner’s manual 10 ~ 122 temperature fluctuations increase the amount of condensation and make wood more vulnerable to damage. Below freezing temperatures are particularly hard on your coach. Therefore, strive to maintain a constant temperature in your coach. Do not attempt to use the coach furn...

  • Page 123

    Service - section 11 overview • 125 obtaining service • 125 service centers • 126 technical support • 126 road service • 126 appliances • 127 where to call • 128.

  • Page 125

    Trek owner’s manual 11 ~ 125 s ervice o verview we want to make sure you receive a quality unit that will serve you with a minimum of problems; however, your coach contains thousands of components, assembled by hun- dreds of technicians, with countless procedures. These components are subjected to c...

  • Page 126

    Trek owner’s manual 11 ~ 126 service centers we support three fully equipped factory service centers for both warranty and non-war- ranty service. One is located near corporate headquarters in harrisburg, oregon. There is another on the west coast in bend, oregon, and the east coast in brandon, flor...

  • Page 127

    Trek owner’s manual 11 ~ 127 warning: if your coach requires service somewhere other than at your dealer, call technical support before work commences. They will make arrangements with the service center for reimbursement of the cost and exchange of parts, if necessary. Work that is not prearranged ...

  • Page 128

    Trek owner’s manual 11 ~ 128 w here t o c all the following chart lists the service numbers of many of the companies with products in your coach. This is the best place to start for support on their products. Make sure that you call the correct manufacturer. Look for the manufacturer's label on the ...

  • Page 129

    Trek owner’s manual 11 ~ 129 manufacturers customer service numbers product manufacturer service numbers air conditioner - dash acme 800-552-2263 air conditioner - roof duo-therm 800-544-4881 antenna (tv) winegard 319-754-0600 or (800)288-8094 awnings carefree 800-621-2617 camera jensen 800-732-6866...

  • Page 130

    Trek owner’s manual 11 ~ 130 manufacturers customer service numbers product manufacturer service numbers satellite system datron sony receiver 800-287-5052 or 800-222-7669 solar panel photowatt 877-262-8749 (toll free) television rca 877-266-2728 tires michelin 800-847-3435 (m-f 8:30a.M. - 6:00 p.M....

  • Page 131

    Location reference guide - appendix a reference guides • 133 plumbing and waste • 133 appliances and connections • 134 electrical • 134 miscellaneous • 135 engine and chassis • 135.

  • Page 133

    Trek owner’s manual appendix a ~ 133 a ppendix a l ocation r eference g uide this appendix provides charts and tables giving reference information. This information was correct at the time of printing, but is subject to change without notice. The presence of certain options may also cause changes af...

  • Page 134

    Trek owner’s manual appendix a ~ 134 function location transfer switch ds; front of rear wheels (in basement) house batteries ps; behind rear wheels (under entry step) chassis batteries ds; behind front wheels coach 12 vdc power switch stepwell near entry door inverter remote switch galley corner (o...

  • Page 135

    Trek owner’s manual appendix a ~ 135 function location coach monitor panel above entry door front thermostat above sofa generator switch above entry door entry step switch above entry door water pump switch above entry door m iscellaneous function location fuel tank between rails, near rear fuel fil...

  • Page 136: Safari

    Safari 91320 coburg industrial way coburg, or 97408 fax: 541-335-8213 http://www.Safarimotorcoaches.Com.