1. DL manuals
  2. Sailor
  3. Radio
  4. 6248 VHF
  5. Installation Manual

Sailor 6248 VHF Installation Manual

Other manuals for 6248 VHF: User Manual

Summary of 6248 VHF

  • Page 1

    Installation manual sailor 6248 vhf sailor 6222 vhf dsc.

  • Page 3

    Sailor 6222 vhf dsc installation manual document number: 98-132904-c release date: october 11, 2011.

  • Page 4

    Ii 98-132904-c disclaimer any responsibility or liability for loss or damage in connection with the use of this product and the accompanying documentation is disclaimed by thrane & thrane. The information in this manual is provided for information purposes only, is subject to change without notice a...

  • Page 5: Safety Warning

    Safety warning 1 the following general safety precautions must be observed during all phases of operation, service and repair of this equipment. Failure to comply with these precautions or with specific warnings elsewhere in this manual violates safety standards of design, manufacture and intended u...

  • Page 6: Record Of Revisions

    Iv 98-132904-c record of revisions preface 2 radio for occupational use the sailor 6222 vhf dsc fulfils the requirements of the marine equipment directive 96/98/ec and the amending directive 2002/75/ec and is intended for use in maritime environment. Sailor 6222 vhf dsc is designed for occupational ...

  • Page 7

    98-132904-c v regarding rf energy and electromagnetic energy levels including the recommended levels for human exposure: • fcc oet bulletin 65 supplement c, evaluating compliance with fcc guidelines for human exposure to radio frequency electromagnetic fields. • american national standards institute...

  • Page 8: Manual Overview

    Vi 98-132904-c manual overview 4 this manual has the following chapters and appendices: • introduction contains a description of the vhf radio. • installation explains how to mount the vhf radio and how to connect accessories and external equipment. • service & maintenance contains support informati...

  • Page 9: Table Of Contents

    98-132904-c vii table of contents chapter 1 introduction 1.1 vhf radio with dsc class a ................................................................ 1-1 1.2 accessories available ........................................................................ 1-4 chapter 2 installation 2.1 unpacking and...

  • Page 10

    Table of contents viii 98-132904-c index ................................................................................................................. Index-1.

  • Page 11: List Of Figures

    98-132904-c ix list of figures figure 1-1: controls on the front plate.................................................................................... 1-2 figure 1-2: system configuration, example............................................................................. 1-6 figure 2-1: deskto...

  • Page 12

    List of figures x 98-132904-c figure b-11: system configuration, can bus, sailor 6204 csm, close to the vhf radio......... B-13 figure b-12: system configuration, can bus, sailor 6204 csm, not close to the vhf radio... B-14 figure b-13: system configuration, can bus, sailor 6204 csm, far from the vh...

  • Page 13: List Of Tables

    98-132904-c xi list of tables table preface-1:related documents ...............................................................................................-vi table 1-1: accessories available............................................................................................ 1-4 table 2-...

  • Page 14

    List of tables xii 98-132904-c.

  • Page 15: Introduction

    98-132904-c 1-1 chapter 1 in tr oduc ti on introduction 1 1.1 vhf radio with dsc class a sailor 6222 vhf dsc, your new vhf radio with full dsc functionality, is approved to med, fcc and industry canada and is waterproof to the ipx8 and ipx6 standard. As part of the required safety equipment, use the...

  • Page 16: 1.1.1

    Vhf radio with dsc class a 1-2 chapter 1: introduction 98-132904-c 1.1.1 controls on the front plate 1. Loudspeaker. 2. Four soft keys with function title in the display. 3. Large display. 4. Keys 0 to 9 to enter numbers or text. 5. Dw button to toggle the watch function (dual or triple). 6. 16/c qu...

  • Page 17: 1.1.2

    Vhf radio with dsc class a 98-132904-c chapter 1: introduction 1-3 in tr oduc ti on 1.1.2 sailor 6222 vhf dsc display the picture shows the display after start-up. The display holds various fields of information, depending on the currently selected function. 1. Functions you can select with the soft...

  • Page 18: 1.2

    Accessories available 1-4 chapter 1: introduction 98-132904-c 1.2 accessories available accessory description sailor 6201 handset with cradle (additional) one sailor 6201 handset with cradle is included in the delivery of the sailor 6222 vhf dsc. You can connect another 2 sailor 6201 handsets. Sailo...

  • Page 19

    Accessories available 98-132904-c chapter 1: introduction 1-5 in tr oduc ti on connection cables 5m connection cable for bulkhead mount: use this cable in installations where the sailor 6201 or 6203 handset is not connected directly to the sailor 6222 vhf dsc, but located in a different position (pa...

  • Page 20: 1.2.1

    Accessories available 1-6 chapter 1: introduction 98-132904-c 1.2.1 system configuration — example the sailor 6222 vhf dsc can be customized to suit your installation. The following illustration is one example of a system. For further configuration examples see appendix b, system configurations. Fig...

  • Page 21: Installation

    98-132904-c 2-1 chapter 2 in st a ll a ti on installation 2 in this chapter you find information and guidelines for: • unpacking and initial inspection • installing the vhf radio • connectors • vhf and dsc antenna installation • accessories 2.1 unpacking and initial inspection the following items ar...

  • Page 22: 2.1.1

    Installing the vhf radio 2-2 chapter 2: installation 98-132904-c 2.1.1 initial inspection inspect the shipping carton immediately upon receipt for evidence of damage during transport. If the shipping carton is severely damaged or water stained, request that the carrier's agent be present when openin...

  • Page 23: 2.2.1

    Installing the vhf radio 98-132904-c chapter 2: installation 2-3 in st a ll a ti on for the safe distance after magnetization between the nearest point of the device and the centre of the compass at which it will produce a deviation of 0.3°. 2.2.1 sailor 6222 vhf dsc with u mounting bracket the moun...

  • Page 24

    Installing the vhf radio 2-4 chapter 2: installation 98-132904-c overhead mounting mounting with u mounting bracket to mount the vhf radio as tabletop, do as follows: 1. Find a suitable location for the vhf radio. Check that the space is wide/deep enough to accommodate the vhf radio. 2. Fasten the b...

  • Page 25

    Installing the vhf radio 98-132904-c chapter 2: installation 2-5 in st a ll a ti on 4. The display of the vhf radio should be at an angle of approximately 90° to your line of sight when operating it. Figure 2-3: mounting with the mounting bracket figure 2-4: drilling plan for the mounting bracket 99...

  • Page 26: 2.2.2

    Installing the vhf radio 2-6 chapter 2: installation 98-132904-c 2.2.2 sailor 6222 vhf dsc for flush mount you can mount the vhf radio to a flat surface, e.G. An instrument panel. The flush mount installation kit is included in the delivery. 1. Find a suitable location for the vhf radio. Check that ...

  • Page 27

    Installing the vhf radio 98-132904-c chapter 2: installation 2-7 in st a ll a ti on 5. Ensure that the flush mount gasket is placed correctly on the vhf radio. 6. Before mounting the vhf radio be aware that the surface is plane and rigid. If the surface is not plane and/or rigid (stiff) remove the g...

  • Page 28: 2.2.3

    Installing the vhf radio 2-8 chapter 2: installation 98-132904-c 2.2.3 sailor 6090 power converter figure 2-8: sailor 6090 power converter, dimensions figure 2-9: connecting the sailor 6090 power converter 99-132778 +vin ................ -vin ................. Screen/ground +vout (red) .... -vout (b...

  • Page 29: 2.2.4

    Installing the vhf radio 98-132904-c chapter 2: installation 2-9 in st a ll a ti on 2.2.4 sailor 6201 handset with cradle figure 2-10: sailor 6201 handset with cradle this handset has a hook-on/off function, which is activated by a small magnet embedded in the cradle. The cradle must be installed as...

  • Page 30: 2.3

    Connectors 2-10 chapter 2: installation 98-132904-c 2.3 connectors 2.3.1 connector at the front panel for handset or handmicrophone use the connector at the front of the sailor 6222 vhf dsc to connect a sailor 6201 handset. You may also connect a waterproof sailor 6203 handset or sailor 6202 handmic...

  • Page 31: 2.3.2

    Connectors 98-132904-c chapter 2: installation 2-11 in st a ll a ti on 2.3.2 connectors at the rear panel l 1. Acc connector for accessories 2. Aux connector for vdr, external speaker, alarm panels, gps input 3. Power connector pwr fuse with fuse 10 a mini ato 4. Dsc ant connector for dsc antenna 5....

  • Page 32: 2.3.3

    Connectors 2-12 chapter 2: installation 98-132904-c 2.3.3 acc connector use the connector marked acc to connect gps and a sailor 6201 handset. You may also connect a waterproof sailor 6203 handset or sailor 6202 handmicrophone. Connector type: circular connector, 10pin, male. Connection cable with p...

  • Page 33

    Connectors 98-132904-c chapter 2: installation 2-13 in st a ll a ti on nmea interface description nmea input: impedance: 600 ohm. Max. 2ma at min. Level of 2v the nmea interface supports nmea 0183 v2.0, v2.1 and v2.3. The following sentences are supported: • gga: utc, "position", "quality indicator"...

  • Page 34: 2.3.4

    Connectors 2-14 chapter 2: installation 98-132904-c 2.3.4 aux connector this connector is used to connect vdr, external speaker, dsc alarms and gps input. Connector type: circular connector, 12pin. Connection cable with plug, part number 406208-941. Pin assignment: connector front view on the vhf ra...

  • Page 35: 2.3.5

    Connectors 98-132904-c chapter 2: installation 2-15 in st a ll a ti on 2.3.5 ctrl connector this connector is used to connect a sailor 6204 control speaker microphone or sailor 6208 connection box. Connector type: circular connector, 12pin. Connection cable with plug, part number 406208-941. Pin ass...

  • Page 36: 2.3.6

    Connectors 2-16 chapter 2: installation 98-132904-c 2.3.6 ethernet connector: lan there is one ethernet (10/100 mb) connector on the rear panel, it is marked lan. Connector type: rj-45 female, shielded 2.3.7 power connector pwr fuse the dc power input connects to a dc supply with 12 dc nominal (10.8...

  • Page 37: 2.3.8

    Connectors 98-132904-c chapter 2: installation 2-17 in st a ll a ti on connecting dc power • connect dc+ (red wire) to dc out + from your dc supply. • connect dc- (blue wire) to dc out - from your dc supply. Connect the yellow wire in the power cable to use the remote on/off function. 2.3.8 dsc ant ...

  • Page 38: 2.4

    Vhf and dsc antenna installation 2-18 chapter 2: installation 98-132904-c 2.4 vhf and dsc antenna installation the sailor 6222 vhf dsc must be installed with one antenna for vhf rx/tx communication and one antenna for dsc communication. You can install all commonly available 50 ohm antennas covering...

  • Page 39: 2.4.3

    Vhf and dsc antenna installation 98-132904-c chapter 2: installation 2-19 in st a ll a ti on antennas as far away as possible from antenna main beam of any radar and satellite equipment. 2.4.3 dsc antenna the positioning of the dsc antennas is less critical in terms of the imposed vswr and due to th...

  • Page 40: 2.5

    Accessories 2-20 chapter 2: installation 98-132904-c 2.5 accessories 2.5.1 part numbers for accessories the following accessories are available for the sailor 6222 vhf dsc: you can connect a lan printer to the radio for printing dsc messages, see also setup of a lan printer to work with sailor 6222 ...

  • Page 41: 2.5.2

    Accessories 98-132904-c chapter 2: installation 2-21 in st a ll a ti on 2.5.2 connection box sailor 6207 the sailor 6207 connection box is used to connect gps (nmea), gps/ais dsc modem and further sailor 6201 handsets. For wiring and cabling details see system configuration examples on page b-1 and ...

  • Page 42

    Accessories 2-22 chapter 2: installation 98-132904-c figure 2-17: sailor 6207 connection box for parallel handsets, diagram -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat -vbat ! " ! " # $ # $ ) ) *+% *+% #* $ #* $ % % , -. , -. # $ # $ % % , -. , -. ...

  • Page 43: 2.5.3

    Accessories 98-132904-c chapter 2: installation 2-23 in st a ll a ti on 2.5.3 connection box sailor 6208 the sailor 6208 connection box is used to connect sailor 6204 control speaker microphones and other auxiliary equipment. For wiring and cabling details see system configuration examples on page b...

  • Page 44

    Accessories 2-24 chapter 2: installation 98-132904-c terminate the last sailor 6208 on the can bus (furthest away from the transceiver). Figure 2-20: sailor 6208 control unit connection box, diagram.

  • Page 45: 2.5.4

    Accessories 98-132904-c chapter 2: installation 2-25 in st a ll a ti on 2.5.4 setup of a lan printer to work with sailor 6222 vhf dsc for connection and cabling see the system configuration drawings at how to install a printer on page b-26 and how to install an additional printer on page b-27. If a ...

  • Page 46

    Accessories 2-26 chapter 2: installation 98-132904-c.

  • Page 47: First-Time Power Up

    98-132904-c 3-1 chapter 3 fir st -time power up first-time power up 3 3.1 general use and navigation the tasks needed to be performed during installation are described below. See the sailor 6222 vhf dsc user manual for instructions how to operate and set up the vhf radio. 3.1.1 power on and volume i...

  • Page 48: 3.2

    Entering the mmsi number 3-2 chapter 3: first-time power up 98-132904-c 3.2 entering the mmsi number when the vhf radio is powered on for the first time, you must enter the vessel’s mmsi number. Hereafter the mmsi number is briefly displayed after power up. The mmsi is a unique, 9-digit identifier a...

  • Page 49: Service & Maintenance

    98-132904-c 4-1 chapter 4 ser vic e & m a int en a nc e service & maintenance 4 4.1 contact for support contact your authorized dealer for technical service and support of the vhf radio. Before contacting your authorized dealer you can go through the troubleshooting guide to solve some of the most c...

  • Page 50

    Maintenance 4-2 chapter 4: service & maintenance 98-132904-c without enabling the transmitter power amplifier. In parallel the radio decodes and compares the received call to be the same as the transmitted. The display shows the result of the test. 4. Press the soft key ok to acknowledge the test re...

  • Page 51: 4.3

    Troubleshooting guide 98-132904-c chapter 4: service & maintenance 4-3 ser vic e & m a int en a nc e 4.3 troubleshooting guide action symptom remedy the radio will not turn on the display is empty. Check if power is present. Check fuse which is placed in the power connector. Check performance of pow...

  • Page 52

    Troubleshooting guide 4-4 chapter 4: service & maintenance 98-132904-c dsc routine testing check the dsc function regularly. Verify the complete dsc installation, with antennas, by transmitting a safety test call to another station (coast or ship). The test call is generated using the dsc call flow ...

  • Page 53

    Troubleshooting guide 98-132904-c chapter 4: service & maintenance 4-5 ser vic e & m a int en a nc e radio time dsc logs are sorted with wrong time stamp or radio time is incorrect a wrong radio time indication should occur only if gps position source is not connected or providing correct time data....

  • Page 54: 4.3.1

    Troubleshooting guide 4-6 chapter 4: service & maintenance 98-132904-c 4.3.1 replacing the fuse in the power connector one fuse is installed in the power connector. If the fuse is blown, do as follows: 1. Track down why the fuse was blown and solve the problem. 2. Take out the old fuse. 3. Insert th...

  • Page 55: 4.3.2

    Troubleshooting guide 98-132904-c chapter 4: service & maintenance 4-7 ser vic e & m a int en a nc e 4.3.2 replacing the fuse in the sailor 6090 power converter one fuse is installed in the sailor 6090 power converter. If the fuse is blown, do as follows: 1. Track down why the fuse was blown and sol...

  • Page 56: 4.4

    Warranty and returning units for repair 4-8 chapter 4: service & maintenance 98-132904-c 4.4 warranty and returning units for repair should your thrane & thrane product fail, please contact your dealer or installer, or the nearest thrane & thrane partner. You will find the partner details on thrane....

  • Page 57: Technical Specifications

    98-132904-c a-1 appendix a te ch ni ca l spec if ic a tion s technical specifications a a.1 transceiver unit sailor 6222 vhf dsc item specification weight sailor 6222 vhf dsc box weight sailor 6222 vhf dsc 3.8 kg (8.4 lbs) approximately, including sailor 6201 handset and wall mount cradle, sailor 60...

  • Page 58

    Transceiver unit sailor 6222 vhf dsc a-2 appendix a: technical specifications 98-132904-c item specification frequency range tx: 156,000 mhz — 157,425 mhz, rx: 156,000 mhz — 163.425 mhz channel spacing 12.5 khz and 25 khz, all international maritime channels number of p channels the radio may be pro...

  • Page 59: A.2

    General dsc specifications 98-132904-c appendix a: technical specifications a-3 te ch ni ca l spec if ic a tion s a.2 general dsc specifications lf power built-in loudspeaker: 6 w (at 5 khz dev./1 khz tone) external loudspeaker: 6 w / 8 ohm distortion below 5% s/n ratio better than 43 db spurious em...

  • Page 60: A.3

    Nmea data rates and formats a-4 appendix a: technical specifications 98-132904-c a.3 nmea data rates and formats a.4 sailor 6090 power converter 24—12 v item value 61162-1 4800,8,n,1 61162-2 38400,8,n,1 table a-4: nmea data rates and formats item description weight 300 g dimensions height: 33 mm wid...

  • Page 61: System Configurations

    98-132904-c b-1 appendix b sy st em c o nf ig ur at io ns system configurations b this appendix lists selected examples of system configurations. For an overview and specifications of the cables needed see cable requirements on page b-28. B.1 system configuration examples the following list shows sy...

  • Page 62

    System configuration examples b-2 chapter b: system configurations 98-132904-c 19. How to install a can bus with 4 sailor 6204 csms 20.How to install a can bus with 4 csms in bridge wings 21. How to install a can bus with 3 sailor 6204 csms 22.How to install a can bus with 4 sailor 6204 csms 23. How...

  • Page 63: B.1.1

    System configuration examples 98-132904-c appendix b: system configurations b-3 sy st em c o nf ig ur at io ns b.1.1 how to connect a sailor 6090 power converter figure b-1: system configuration, sailor 6090 power converter sailor 6201 /03 rx/tx 12vdc 24vdc dsc/rx 1 2 3 remove jumper for remote on/o...

  • Page 64: B.1.2

    System configuration examples b-4 appendix b: system configurations 98-132904-c b.1.2 how to connect a sailor n163s ac power supply figure b-2: system configuration, sailor n163s power supply sailor 6201 /03 rx/tx 12vdc dsc/rx 1 2 3 3 110vac/230 vac sailor n163s power supply 24vdc 24vdc line neutral...

  • Page 65: B.1.3

    System configuration examples 98-132904-c appendix b: system configurations b-5 sy st em c o nf ig ur at io ns b.1.3 how to connect an n420 dc power supply figure b-3: system configuration, sailor 6201 handset and n420 dc power supply sailor 6201/03 rx/tx 12vdc 24vdc dsc/rx 1 2 3 on/off 12vdc output...

  • Page 66: B.1.4

    System configuration examples b-6 appendix b: system configurations 98-132904-c b.1.4 how to install an extra sailor 6201, gps, ext. Loudspeaker and alarms figure b-4: system configuration, sailor 6201, gps, ext. Loudspeaker and alarms sailor 6201 /03 acc rx/tx 12vdc sailor 6201 /03 dsc/rx connectio...

  • Page 67: B.1.5

    System configuration examples 98-132904-c appendix b: system configurations b-7 sy st em c o nf ig ur at io ns b.1.5 how to install a gps and sailor 6270 external loudspeaker figure b-5: system configuration, gps and sailor 6270 external loudspeaker sailor 6201 /03 rx/tx 12vdc 24vdc dsc/rx connectio...

  • Page 68: B.1.6

    System configuration examples b-8 appendix b: system configurations 98-132904-c b.1.6 how to install 2 extra sailor 6201 handsets and a gps figure b-6: system configurations, 2 sailor 6201 handsets and a gps sailor 6201 /03 acc rx/tx 12vdc sailor 6201 /03 dsc/rx sailor 6207 connection box 1/17/ 2011...

  • Page 69: B.1.7

    System configuration examples 98-132904-c appendix b: system configurations b-9 sy st em c o nf ig ur at io ns b.1.7 how to install an extra handset sailor 6201 in sailor 6207 figure b-7: system configurations, extra handset sailor 6201 in sailor 6207 sailor 6201 /03 acc rx/tx 12vdc sailor 6201 /03 ...

  • Page 70: B.1.8

    System configuration examples b-10 appendix b: system configurations 98-132904-c b.1.8 how to install a sailor 6202 handmicrophone, an extra sailor 6201 and a gps figure b-8: system configuration, sailor 6202 handmic., sailor 6201 handset, gps sailor 6202 acc rx/tx 12vdc sailor 6201/03 dsc/rx 3/25/2...

  • Page 71: B.1.9

    System configuration examples 98-132904-c appendix b: system configurations b-11 sy st em c o nf ig ur at io ns b.1.9 how to install a gps to the acc port with a sailor 6208 connection box figure b-9: system configuration, gps and sailor 6208 connection box sailor 6201 /03 acc rx/tx 12vdc dsc/rx sai...

  • Page 72: B.1.10

    System configuration examples b-12 appendix b: system configurations 98-132904-c b.1.10 how to install a gps to the acc port using a sailor 6207 connection box figure b-10: system configuration, gps and sailor 6207 connection box sailor 6201/03 rx/tx 12vdc 24vdc dsc/rx remove jumper for remote on/of...

  • Page 73: B.1.11

    System configuration examples 98-132904-c appendix b: system configurations b-13 sy st em c o nf ig ur at io ns b.1.11 how to install a can bus with a sailor 6204 csm close to the vhf radio figure b-11: system configuration, can bus, sailor 6204 csm, close to the vhf radio sailor 6201 /03 ctrl rx/tx...

  • Page 74: B.1.12

    System configuration examples b-14 appendix b: system configurations 98-132904-c b.1.12 how to install a can bus with a sailor 6204 csm not close to the vhf radio figure b-12: system configuration, can bus, sailor 6204 csm, not close to the vhf radio sailor 6201 /03 ctrl rx/tx 12vdc dsc/rx sailor 62...

  • Page 75: B.1.13

    System configuration examples 98-132904-c appendix b: system configurations b-15 sy st em c o nf ig ur at io ns b.1.13 how to install a can bus with a sailor 6204 csm far from the vhf radio figure b-13: system configuration, can bus, sailor 6204 csm, far from the vhf radio sailor 6201 /03 ctrl rx/tx...

  • Page 76: B.1.14

    System configuration examples b-16 appendix b: system configurations 98-132904-c b.1.14 how to install a can bus with 2 sailor 6204 csms close to the vhf radio figure b-14: system configuration, can bus, 2 sailor 6204 csms, close to vhf radio sailor 6201 /03 ctrl rx/tx 12vdc dsc/rx sailor 6208 conne...

  • Page 77: B.1.15

    System configuration examples 98-132904-c appendix b: system configurations b-17 sy st em c o nf ig ur at io ns b.1.15 how to install a can bus with 2 sailor 6204 csms far from the vhf radio figure b-15: system configuration: can bus, 2 sailor 6204 csms, far from vhf radio sailor 6201 ctrl rx/tx 12v...

  • Page 78: B.1.16

    System configuration examples b-18 appendix b: system configurations 98-132904-c b.1.16 how to install a can bus with 2 sailor 6204 csms close to each other figure b-16: system configuration: can bus, 2 sailor 6204 csms, close to each other sailor 6201/03 ctrl rx/tx 12vdc dsc/rx sailor 6208 connecti...

  • Page 79: B.1.17

    System configuration examples 98-132904-c appendix b: system configurations b-19 sy st em c o nf ig ur at io ns b.1.17 how to install a can bus with 2 sailor 6204 csms close to vhf on a small bridge figure b-17: system configuration: can bus, 2 sailor 6204 csms, close vhf, small bridge sailor 6201 /...

  • Page 80: B.1.18

    System configuration examples b-20 appendix b: system configurations 98-132904-c b.1.18 how to install a can bus with 2 csms in bridge wings figure b-18: system configuration: can bus, 2 sailor 6204 csms, in bridge wings sailor 6201/03 ctrl 12vdc 2 3 8 shield/gnd -battery yellow black red pink grey ...

  • Page 81: B.1.19

    System configuration examples 98-132904-c appendix b: system configurations b-21 sy st em c o nf ig ur at io ns b.1.19 how to install a can bus with 3 csms in bridge wings figure b-19: system configuration: can bus, 3 sailor 6204 csms, in bridge wings sailor 6201/03 ctrl 2 shield/gnd -battery yellow...

  • Page 82: B.1.20

    System configuration examples b-22 appendix b: system configurations 98-132904-c b.1.20 how to install a can bus with 4 csms in bridge wings figure b-20: system configuration: can bus, 4 sailor 6204 csms, in bridge wings sailor 6201/03 ctrl 2 shield/gnd -battery yellow black red pink grey brown/drai...

  • Page 83: B.1.21

    System configuration examples 98-132904-c appendix b: system configurations b-23 sy st em c o nf ig ur at io ns b.1.21 how to install a can bus with 3 sailor 6204 csms figure b-21: system configuration: can bus, 3 sailor 6204 csms sailor 6201 /03 ctrl 12vdc 2 3 8 shield/gnd -battery yellow black red...

  • Page 84: B.1.22

    System configuration examples b-24 appendix b: system configurations 98-132904-c b.1.22 how to install a can bus with 4 sailor 6204 csms figure b-22: system configuration: can bus, 4 sailor 6204 csms sailor 6201 /03 ctrl 12vdc 2 3 8 shield/gnd -battery yellow black red pink grey brown/drain blue can...

  • Page 85: B.1.23

    System configuration examples 98-132904-c appendix b: system configurations b-25 sy st em c o nf ig ur at io ns b.1.23 how to install lan figure b-23: system configuration: installation of lan sailor 6201 /03 acc rx/tx 12vdc sailor 6201 /03 dsc/rx sailor 6207 connection box 3/30/ 2011 gps receiver n...

  • Page 86: B.1.24

    System configuration examples b-26 appendix b: system configurations 98-132904-c b.1.24 how to install a printer figure b-24: system configuration: installation of a printer sailor 6201 /03 lan rx/tx 12vdc dsc/rx 9/27/2011 printer 1 2 3 110vac/230vac sailor n163s power supply 24vdc 24vdc sailor 6222...

  • Page 87: B.1.25

    System configuration examples 98-132904-c appendix b: system configurations b-27 sy st em c o nf ig ur at io ns b.1.25 how to install an additional printer figure b-25: system configuration: installation of an additional printer sailor 6201 /03 lan rx/tx 12vdc dsc/rx 9/27/2011 printer 1 2 3 110vac/2...

  • Page 88: B.2

    Cable requirements b-28 appendix b: system configurations 98-132904-c b.2 cable requirements the following cable information relates to the cable numbers in the system configuration drawings on the previous pages. Cable part number description specification remarks 1 antenna cable rg214 or better 2 ...

  • Page 89

    Cable requirements 98-132904-c appendix b: system configurations b-29 sy st em c o nf ig ur at io ns cable 1 cable type: coax cable rg 214 or better. 16 cable for can screened with twisted pairs, length and size see cable description for cable 16 on page b- 35. Extension cable for can bus, see also ...

  • Page 90

    Cable requirements b-30 appendix b: system configurations 98-132904-c cable 2 (handset, cable included) cable 3 (power cable, included in 406222a) cable type: 3-wire cable. Sailor 6222 vhf dsc front connector ltw 10-pin, circular male signal designation signal description pin 1 nc pin 2 nc pin 3 nc ...

  • Page 91

    Cable requirements 98-132904-c appendix b: system configurations b-31 sy st em c o nf ig ur at io ns cable 4 (power cable) cable type: 3-wire screened cable. Dimensions depend on the cable length. Cable 5 (cable for sailor 6207 connection box) cable type: 10-wire screened cable. Part number: 406209-...

  • Page 92

    Cable requirements b-32 appendix b: system configurations 98-132904-c cable 6 connection cable for bulkhead mount, 5 m. Part number: 406209-940 same pin configuration as cable 5. Cable 7 2-wire screened cable for nmea (gps connection). Cable 8 (aux) part number: 406208-941 sailor 6222 vhf dsc aux co...

  • Page 93

    Cable requirements 98-132904-c appendix b: system configurations b-33 sy st em c o nf ig ur at io ns pin 9 ext. Speaker+ black j1-9 j2-9 j3-9 vhf radio external speaker output, nom. 6 w into 8 ohm paired with no. 10 pin 10 ext. Speaker+ orange j1-10 j2-10 j3-10 paired with no. 9 pin 11 vdr+ purple j...

  • Page 94

    Cable requirements b-34 appendix b: system configurations 98-132904-c can cable (cable 8 - ctrl) part number: 406208-941 sailor 6222 vhf dsc ctrl connector ltw 12-pin, circular male signal designation cable pin 406208- 941 (5 m) sailor 6208 conn. Box in from vhf sailor 6208 conn. Box out of box sail...

  • Page 95

    Cable requirements 98-132904-c appendix b: system configurations b-35 sy st em c o nf ig ur at io ns cable 11 lan connection. Ethernet cable with screen and rj45 shielded plugs. Cable 16 the can bus cable must be of a paired and twisted type designed for the purpose. The can bus cable can handle sig...

  • Page 96

    Cable requirements b-36 appendix b: system configurations 98-132904-c cable 17: can cable for bulk head installation. Same cable as cable 12, but the plug is removed and the wires are connected to the connection box. Same pin configuration as cable 8. See cable specifications for cable 8 (ctrl) on p...

  • Page 97: Glossary

    98-132904-c glossary-1 gl os sa ry glossary glossary c a acc accessories c can controller-area network. A message based protocol designed to allow microcontrollers and devices to communicate with each other within a vehicle without a host computer. Csm control speaker microphone ctrl control d dsc d...

  • Page 98

    Glossary glossary-2 98-132904-c n nmea national marine electronics association, specification for communication between marine electronic devices r rmc nmea sentence, version of essential gps position, velocity, time data. U usb universal serial bus. A specification to establish communication betwee...

  • Page 99: Index

    98-132904-c index-1 inde x index index d a ac power supply connect, b-4 acc connector, 2-13 action line, display, 1-3 adjust speaker volume, 3-1 ant connector, 2-18 b backlight, 1-1 browse channels, 3-1 c cable can, b-34 cable for vhf antenna, 2-18 cable overview, b-28 cable requirements, b-28 can c...

  • Page 100

    Index index-2 98-132904-c handset cradle installation, 1-4 how to replace, 4-8 i input gps, 2-22 handset, 2-22 installation cradle for 6201, 1-4 desktop, 2-3 flush mount, 2-6 handset cradle, 1-4 mounting bracket, 2-4 overhead, 2-4 ip rating, a-2 k keys on front plate, 1-2 knob selector, 1-2 volume, ...

  • Page 101

    Index 98-132904-c index-3 inde x specifications, a-1 squelch control, 1-2 support, 4-1 system configuration example, 1-6 t technical data, a-1 temperature operational, a-1, a-4 storage, a-1, a-4 u utc time, 1-3 v vhf antenna cable, 2-18 antenna connector, 2-18 frequency range, a-2 volume louder, 3-1...

  • Page 102

    Index index-4 98-132904-c.

  • Page 104

    Info@thrane.Com • thrane.Com 98-132904-c.