1. DL manuals
  2. Sampo
  3. Monitor
  4. SME-27FDL5
  5. Service Manual

Sampo SME-27FDL5 Service Manual

Manual is about: 34“ MULTIMEDIA MONITOR

Summary of SME-27FDL5

  • Page 1

    34“ multimedia monitor service manual model ： ： ： ： sme-32dl5(p) mmm-0023 ver1.0

  • Page 2: Ver1.0

    If having any changes, do not do advanced advice. Ver1.0 contents 1. Important safety precautions......... 1-1 2. Block diagram........................................... 2-1 3. Factory & electronic adjustment... 3-1 4. Trouble shooting guides............. … .... 4-1 5. Specification...................

  • Page 3

    If having any changes, do not do advanced advice. 10.Defect bar code list … . ……………… 10-1 11.Packing of the set …………………… ..11-1.

  • Page 4

    Safety precautions ver 1.0 1-1 1. Before returning an instrument to the customer, always make a safety check of the entire instrument, including, but not limited to, the following items. A. Be sure that no built-in protective devices are defective and/or have been defeated during servicing. (1) prot...

  • Page 5

    Safety precautions ver 1.0 1-2 known earth ground. B. Some monitor chassis normally have 85v ac (rms.), between chassis and earth ground regardless of the ac plug polarity. These chassis can be safely serviced only with an isolation transformer inserted in the power line between the receiver and the...

  • Page 6

    Block diagram v e r 1 . 0 2-1 total block diagram l ◎ r ◎ v ◎ av1 l ◎ r ◎ v ◎ av2 l ◎ r ◎ v ◎ av out s i/p rgb i/p def. Block aux power power ○ ○ ○ ac line h v av block r l l v r phone tda2616 sound amp ta8184 sound control crt amp crt r b g ycbcr r ◎ l ◎ av3.

  • Page 7

    Block diagram v e r 1 . 0 2-2 monitor def. & crt amp block diagram main board signals output r b g h v pc87c380 ic001 tda4854 (def.Ic) ic691 iic bus h v rgb/tv dynamic focus:ic6c1 74hc221:ic631 amp/damp:q601,t601 sidepin:q6i1,6i2,l6i1 v0 v2 v1 sb sb1 h-size dc-converter:t604,q6d4 amp/damp:q6c9,c6d2 ...

  • Page 8

    Block diagram v e r 1 . 0 2-3 main power supply & aux. Power & sound amp block diagram ac input emi filter t702,t703 dega ic713 bridge & rectifier br701 low voltage protection q711,q712,q713 pwm ic ic711 dc switch ic716~d788 t781 rectifier & filter:ic781 rectifier & filter:d790 rectifier & filter:d7...

  • Page 9

    Block diagram v e r 1 . 0 2-4 av. Board av1 av2 rgb i/p s i/p av out av switch ic806 ic807 tc9090an v ic801 tb1276an sound block see page5 sound (r) sound (l) 5v 9v r/g/b/h/v (vga) r h to main board to cpu g b v r l v r l v r l c y video switch ic803 ycbcr yuv.

  • Page 10: Manual.

    Factory & electronic adjustment ver 1.0 3 -1 warning: before servicing this chassis, read the “x-ray radiation precaution”, “safety precaution” and “product safety notice” on page 1 and 2 of this manual. Set-up adjustment z the following adjustments should be made when a complete realignment is requ...

  • Page 11

    Factory & electronic adjustment ver 1.0 3 -2 purity adjustment note: before attempting any purity adjustments, the receiver should be operated for at least 30 minutes at white rasher. 1. Demagnetize the picture tube and cabinet using a degaussing coil. (east direction) 2. Slowly move the dy forward ...

  • Page 12

    Factory & electronic adjustment ver 1.0 3 -3 2. Xv misconvergence adjustment: adjust the xv coil (on the deflection yoke) to correct misconvergence at both sides on screen. (see the figure below.) use a hexagonal tip stick (plastic) to adjust the core of coil. 3. Center convergence adjustment 1) rec...

  • Page 13

    Factory & electronic adjustment ver 1.0 3 -4 4. Corner convergence adjustment: when the misconvergence is still evident on corners even though the above adjustment is done, use the ferrite sheet to correct misconvergence. Put ferrite sheets into the space under the yoke. Decide such position that mi...

  • Page 14

    Factory adjusted method and order ver 1.0 3 -5 a. The entry method for factory setting item. 1. Push the factory setting button on the r/c to go to factory setting mode. 2. When the monitor set is in “ on ” condition, pull the ac cord away. Then push the power sw continuously and insert the ac cord ...

  • Page 15

    Factory adjusted method and order ver 1.0 3 -6 geometry-adj. Item adj. Min. Max. H corner h corner adjustment menu+ ( std and chg ) h-pin-balance h pincushion balance adjustment v-linearity v linearity adjustment v-lin-balance v linearity balance adjustment pincushion pincushion size adjustment ( st...

  • Page 16

    Service mode adjustment ver1.0 3 -7 (1) rgb mode item adjustment procedure. 1. Adjustment (vr731) 1. Set to rgb mode. 2. Receive all white pattern (h:31.47k v:60hz 640x480 mode). 3. Connect dc volt-meter between cathode of d753 and ground. 4. Adjust vr731 for 210v ± ±± ± 0.5v output. 2. High voltage...

  • Page 17

    Service mode adjustment ver1.0 3 -8.

  • Page 18

    Service mode adjustment ver1.0 3 -9 item adjustment procedure. 8. V-size adjustment (rgb mode) (under factory adjustment mode) 1. Set to rgb mode. 2. Receive cross hatch pattern (we have nine main modes, please see the specification of chroma-2135 generator pattern). 3. Entry the factory adjustment ...

  • Page 19

    Service mode adjustment ver1.0 3 -10 (2) av mode item adjustment procedure 1 h-size adjustment (av mode) (under factory adjustment mode) 1. Set the av mode (av1). 2. Receive lion pattern. 54321 12345 digital test pattern → → → → lion pattern 3. The item 2 of factory setting is to adjust h-size. 4. A...

  • Page 20

    Service mode adjustment ver1.0 3 -11 5 sub color ( sub-color-av) (test point : b out ( q813 “ c ” ) 1. Set the av mode (av1) 2. Receive color bar pattern . 3. Go to the factory setting. Select the sub-color-av to adjust the sub-color to be as follow. (3) ycbcr mode item adjustment procedure 1. Sub-t...

  • Page 21: Stand-By Power

    Trouble shooting flow chart ver1.0 4 -1 stand-by power output voltage abnormal compare v c789=31v ± ±± ± 4v check output voltage at c789 replace abnormal parts check c792=12v ±±±± 1v ﹖ ﹖ ﹖ ﹖ check voltage at c709(+) check output stage yes abnormal no yes no check d789 check f701, ic716, zd781, br701...

  • Page 22: Main Power

    Trouble shooting flow chart ver1.0 4- 2 main power 1. No main power 2. Poor load regulation is the main power in power saving mode ﹖ ﹖ ﹖ ﹖ yes check the output stage 210v yes is the main power in over load condition ﹖ ﹖ ﹖ ﹖ yes is the main power in under voltage condition ﹖ ﹖ ﹖ ﹖ check ic713, ic712,...

  • Page 23

    Trouble shooting flow chart ver1.0 4- 3 3. Over voltage (1) 210v (2) 6.3v 4. The voltage of heater lower than 5.8v 5. The picture from r.G.B. Output is not clear adjust vr731, does the voltage of c757(+) can adjust to 210v ﹖ ﹖ ﹖ ﹖ adjust vr731 voltage of c757(+) to 210v check ic712, ic713 is the vol...

  • Page 24: Def.

    Trouble shooting flow chart ver1.0 4- 4 def. 1. No raster(no sound) 2. No raster(sound is normal) check +12v line on main pwb check/replace ic791, r791 check/replace ic711 check +13v output on main power supply heater element of crt are lighting or no check d757, r748, r758, c765, c756 check h.V. At...

  • Page 25

    Trouble shooting flow chart ver1.0 4- 5 3. One horizontal line raster (no vertical scan) 4. One vertical line raster (no horizontal scan) 5. Abnormal corner focus (abnormal dynamic focus) check/replace ic501 check/replace ic001 check vert. Yoke connector check +19v voltage check/replace ic691, q6c4,...

  • Page 26

    Trouble shooting flow chart ver1.0 4- 6 6. Raster distortion (side pin distortion) 7. Out of horizontal/vertical sync. Check/replace c6i1, r6i1, r6i2, l6i1 check/replace ic691 check/replace q6i1, q6i2, q6i3 check/replace d609, c623 check the cable check ic001 check/replace ic691 replace ic001 check ...

  • Page 27: Video

    Trouble shooting flow chart ver1.0 4- 7 video 1. No power 2. No osd (on screen display) is the stand-by 5v normal ﹖ ﹖ ﹖ ﹖ normal power o/p of ic001 pin20 or pin25 ？ ？ ？ ？ check stand-by 5v circuit does rl701 act normally ﹖ ﹖ ﹖ ﹖ check ic001 check rl701, br701 is the voltage of c709(+) normal ﹖ ﹖ ﹖ ﹖...

  • Page 28

    Trouble shooting flow chart ver1.0 4- 8 3. H-phase can not be adjusted. 4. Out of vert synchronization in rgb mode. Is the voltage of ic001 pin7 h-phase normal ﹖ ﹖ ﹖ ﹖ check ic001 does ic691 act normally ？ ？ ？ ？ check ic691 pin1 with or without the flyback pulse no yes check d-sub pin14 (v-sync in) ...

  • Page 29

    Trouble shooting flow chart ver1.0 4- 9 5. No rotation function 6. H-size can not be adjusted 7. No vertical scan is the rotation coil connector insert into ro check cpu and ic001 rotation circuit check q691, q692, q693 control circuit check ic001 pin42 h-size control voltage check ic631, ic632, ic6...

  • Page 30

    Trouble shooting flow chart ver1.0 4- 10 8. No picture 9. No video in av input mode check the voltage of heater, b+190v, b+210v and c765(+) 6.3v. Are they normal ﹖ ﹖ ﹖ ﹖ check q634, ic632, ic691 and q6c9 check q604, q665 and pwm circuit check r6f9, x-ray circuit yes no check ic101,ic102 check c861(+...

  • Page 31: D Io

    Trouble shooting flow chart ver1.0 4- 11 au d io 1. No audio output is audio d789(-) b+30v normal ﹖ ﹖ ﹖ ﹖ check ic311 audio amp circuit. Check f301 and audio 30v circuit check ic301 audio control circuit volume tone, balance is ic301 pin2,19 sound input normal check ic301,302,303 ic304,305,308 sound...

  • Page 32

    Specification ver1.0 5-1 1. Scope these specifications describe all the characteristics of the 34 inch color monitor. 2. Electrical requirements 2.1. Cathode ray tube a. Tube size 34 inch (4:3) b. Dot pitch h = 0.8 mm (center) c. Light transmission 35.5% typical d. Crt type name toshiba 2.2. Power a...

  • Page 33

    Specification ver1.0 5-2 2.3.6 preset timing chart ltem description : a total time b active display area including borders c active display area excluding borders d left / top border e right / bottom border f blanking time g front porch h sync width i back porch the table below is required timings a...

  • Page 34

    Specification ver1.0 5-3 2.4. Display performance requirements. The data of display performance are measured based on the following conditions unless otherwise specified. A. Ambient temperature 25 ± ±± ± 5 degree c b. Earth magnetic field : h : 0.00, v : 0.4 ± ±± ± 0.05 gauss c. Warm up period 30 mi...

  • Page 35

    Specification ver1.0 5-4 2.4.7 linearity (test with cross-hatch pattern. H: 17 line, v: 13 line) 2.4.8 distortions requirement a. Total geometric distortion (see fig. 1) top & bottom left & right ≦ ≦ ≦ ≦ 8 mm ≦ ≦ ≦ ≦ 8 mm b. Barrel (see fig. 2) top & bottom left & right ≦ ≦ ≦ ≦ 6 mm ≦ ≦ ≦ ≦ 6 mm 2.4...

  • Page 36

    Specification ver1.0 5-5 2.4.16 external user controls : (with osd control) rgb : brightness contrast v-size h-center h-width h-phase pincushion trapezoid parallelogram rotation r-gain g-gain b-gain av,ycbcr: brightness contrast color tint sharpness r-gain g-gain b-gain common : power mute degauss w...

  • Page 37

    Specification ver1.0 5-6 6.2. X radiation requirement. The unit shall conform to the following x-ray regulatory standards and must not emit more than 0.5 mr/h of ionizing radiation under normal operation or under a fault condition. A. Dhhs 21 cfr 1020.10 department of health and human services radia...

  • Page 38

    Specification ver1.0 5-7 av , ycbcr section: (according to ctv rules) video signal compatibility ： ： ： ： ntsc / pal 1. Picture quality 1.1. Resolution (center) contrast and brightness is adjusted so that the 25% gray bar is at cut off of crt 300 lines min. 2. Linearity # formula: (max. - min.) / max...

  • Page 39

    Specification ver1.0 5-8 465 m fig.5 misconvergence 465 mm bezel zone c 620 mm zone b top barrel right barrel bottom barrel left barrel fig. 2 barrel: top right bottom left fig. 1 total geometric distortion: fig. 4 pincushion: (av) a1 a b c1 d1 c b1 d top-bottom=2(a1+b1)/(ac+bd)x100% left-right =2(c...

  • Page 40

    Exploded view ver 1.0 6-1.

  • Page 51

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a represent the critical component. G r sync on green 1/10p p5 b p2 h-sync v-sync h-sync out v-sync out v h p2 p2 ic691 10p p4 sync on green 4/8p plag 1 9v aa1 aa2 aa3 aa 4 aa5 aa 6 aa4 aa5 aa6 p5 p2 p2 aa 1 aa2 aa 3 p6 p6 p2 b g r 0 sampo co. Electronic...

  • Page 52

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a xtal1 xtal2 vdd vss v-sync out p0.7 p0.6 p0.5 p0.4 p0.3 p0.2 p0.1 p0.0 reset dac1 dac2 dac3 vss vdd adc0 adc1 int1 dac0 __________ __________ ____ p2.7 p2.6 p2.5 p2.4 p2.3 p2.2 p2.1 p2.0 h-sync out p1.5 _____ tuner v0 v1 v2 cs0 cs1 cs2 cs3 degauss cs0 ...

  • Page 53

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a 2 4 6 8 4 3 1 2 1 2 3 4 p5 a k 16,13 17 r p6 p6 191v 6.3v p7 p2 p2 p2 p2 dc 150v p7 p6 p6 p4,5 191v ptc m l l s s c767 n c734 n c720 n 110uh 110uh ntc p10 p4 p1,2,4,5 c725 n p13 p2 p4,5 l d 12 page 3 sampo co. Electronic rd2 (power1.Sch) sme-32dl5(p) c...

  • Page 54

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a 1000:1 fv 16 h.V. Adj. X-ray dc signal(fbt pin 12) & v-blanking pulse clamp pulse p5 p5 p2 p2 p5 p3 p5 page 4 6000p/35kv h.V.R. 4.7k/1w h.V.C. D.F.C. 1000p/15kv bleeder 600m crt crt v-yoke v-yoke 1 2 5v p5 p5 p6 p5 p3 19v 19v 12v 19v 13v 5v 12v 208v p5...

  • Page 55

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a 7 6 5 vcc q1 a2 b2 a1 b1 q1 clr vcc vfb p3 p4 p2 page 5 h-yoke 1 2 3 1 4 6 p2 p3 p3 1 2 3 7 h-drv b+ 10 6 1 5 p4 p4 p4 p6 p4 p6 h-yoke 1 2 3 4 6 p2 p3 12v 5v 9v 12v 28v 208v 12v 28v v2 p2 p2 v2 12 v p2 p2 p2 p2 p2 y p1,4 p4 p4 p4 p4 p4 v2" 1 3 12v 2 p3...

  • Page 56

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a fbl r g b r g b sda scl r g b r g b nc. H-blk clamp nc. Abl 225v gnd3 g2 6.3v 5 7 4 9 10 11 8 6 r g b page 6 video mute 8v hv focus screen p4 p4 p4 p3 p3 p3 p3 p2 p4 p2 p2 sda' scl' p1 p1 p1 p1 p1 p1 p4 p2 p2 p2 p2 p2 p2 p2 h.V. P5 p2 osd b osd g osd r...

  • Page 57

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a page 7 1 2 3 4 1 3 7 9 10 11 12 5 4 k r a 5v .1a 30v +/-3v 1a 12v .25a fb786 primary gnd layout 0 sampo co.Electronic rd2 (power.Sch) sme-32dl5(p) b 7 14 monday, november 19, 2001 power size document number rev date: sheet of fb783 s-2 r786 4.7 .25w d7...

  • Page 58

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a treble bass gnd mute balance volume stby 5v woofer l gnd r 5 3 1 7 9 4 11 6 2 10 12 8 12v p9 p2 p9 p2 p9 p9 p2 stby 12v p2 p2 p2 p2 p2 p2 p7 ldu woofer r l r-back l-back 12v gnd vol-out vol-in h-vol-4 h-vol-2 1 2 3 4 5 6 7 8 9 10 11 12 12 4 3 1 11 7 9 ...

  • Page 59

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a g h-in v-in b+ clamp v-pol h-pol v-out h-out gnd afc blank 5v 5v 5v v2 left right 5v nc page 9 5v 0 sampo co.Electronic rd2 (s-m.Sch) sme-32dl5(p) c 9 14 monday, november 19, 2001 sync & mask size document number rev date: sheet of cm08 .1u rs07 n cm06...

  • Page 60

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a 1 2 208v p3 p5 p5 p5 p5 12v v pins y fbv01 fbv02 plag 10 0 sampo co. Electronic rd2 (vm.Sch) sme-32dl5(p) c 10 14 monday, november 19, 2001 vm size document number rev date: sheet of qv08 qv09 rv25 10 .5w cv15 100p rv26 82 rv27 82 cv17 100p cv14 4700p ...

  • Page 61

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a page 11 power power menu- vol+ vol- menu+ degauss i/p sel ro49 n stby r g b rgb sw sda scl h v 1 2 3 4 5 6 7 8 9 10 11 12 fr stby 5v suspend p2 p2 p2 p2 p2 p2 p2 p2 p1 p1 p1 p1 p1 p1 p1 p1 p1 p1 p1 p1 v gnd h rgb sw scl sda gnd b gnd g gnd r 1 2 3 r/c ...

  • Page 62

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a 9v 5v 5v 5v 9v 9v 9v 9v 9v v-sync v-s y n c tvd sd h-sync 5v 5v 5v v2' v0 v1 v2' v0 v1 9v f f f scl sda 9v 43 9v 9v 13v 5v mode 1 2 vm fbp y u v r g b 15k page 12 b g r blk b g r blk osd blk osd b osd g osd r 41 42 0n sampo co. Electronic rd2 (av1.Sch)...

  • Page 63

    8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 d d c c b b a a 5v 5v 9v ccd video ccd video tuner sda scl sda scl 9v 9v fsc 5v v1 l r 9v v1 9v 9v 9v 9v v1 v1 v1 v2' v2' control av2 video av2 l av2 r video out 9v tuner video tuner r tuner l v0 v0 v0 v0 av1 ypbpr v2 y0 y2 y y3 y1 x2 x1 x x0 x3 a b v1 v0 v3 0 1 0 1 1...

  • Page 64

    A a b b c c d d e e 4 4 3 3 2 2 1 1 rs232 scl sda +5v page 14 0 sampo co. Electronic rd2 (rs232.Sch) sme-32dl5(p) b 14 14 monday, november 19, 2001 rs232 size document number rev date: sheet of rd dtr dsr cts rts sd rxd txd c4 18p c13 0.1u rs 1 2 3 4 5 c10 47u/16v + c3 18p c7 n d1 1n4148 c6 n x1 11....

  • Page 65

    Sme-32dl5(p) electronic parts list ver1.0 9- 1 1. Main board ＊ ＊ ＊ ＊ - represent the critical component main pwb 81 qpwb51060-1g-b- main board ＊ ＊＊＊ br701 54 vsigbu6j------- ic gbu6j c001 21 vceacu1cg477m-p 470uf 16v ± ±± ± 20% aluminum elect. C002,044 20 vckbdu1hy103k-p .01uf 50v ± ±± ± 10% high di...

  • Page 66

    Sme-32dl5(p) electronic parts list ver1.0 9- 2 c623 71 vcpphf3cg272j-- 3300pf 1.6kv ± ±± ± 5% polypropylene film c624 64 vckbdu1hy332k-p 3300pf 50v ± ±± ± 10% high diel. Ceramic ＊ ＊＊＊ c625 32 vcpplu2ay102g-p 1000pf 100v ± ±± ± 2% polypropylene film c631 41 vckbdu1hy221k-p 220pf 50v ± ±± ± 10% high d...

  • Page 67

    Sme-32dl5(p) electronic parts list ver1.0 9- 3 c6i1 70 vcehcf1hg475m-- 4.7uf 50v ± ±± ± 20% aluminum elect. C6i2 47 vckbdu1hy562k-p 5600pf 50v ± ±± ± 10% high diel. Ceramic c6i3,6t2 82 vceacu1cg227m-p 220uf 16v ± ±± ± 20% aluminum elect. C6i4,6i6 73 vceacu1hg336m-p 33uf 50v ± ±± ± 20% aluminum elect...

  • Page 68

    Sme-32dl5(p) electronic parts list ver1.0 9- 4 d661,663,694 89 vsd1n4148-----u diode 1n4148 d664 37 vsdsf16-------u diode sf16 d6c1,6c2 03 vsdrgp02-16e--u diode rgp02-16e d6c5 09 vsdher305------ diode her305 d6c6,6i1,6k1 89 vsd1n4148-----u diode 1n4148 ＊ ＊＊＊ d6c7 32 vsdrgp10d-----u diode rgp10d d701...

  • Page 69

    Sme-32dl5(p) electronic parts list ver1.0 9- 5 l6i1 36 rcho-1129-1371- coil pincushion coil l751,752,757 47 rcho-1103-1111- choke l762 47 rcho-1103-1111- choke l831 28 vl-dh101k0000-u peaking coil 100uh q001~003 01 vst2sc1815y---p transistor 2sc1815y q010,012,034 82 vsidtc144es---p ic dtc144es q031,...

  • Page 70

    Sme-32dl5(p) electronic parts list ver1.0 9- 6 r007 26 vrcptv6--153j-u 15k ohm 1/6w 5% carbon film r008,019,6j4 73 vrcptv6--182j-u 1.8k ohm 1/6w 5% carbon film r010 61 vrcptv6--561j-u 560 ohm 1/6w 5% carbon film r011,012,071 78 vrcptv6--331j-u 330 ohm 1/6w 5% carbon film r014,028 34 vrcptv6--102j-u ...

  • Page 71

    Sme-32dl5(p) electronic parts list ver1.0 9- 7 r108,111 07 vrcptv6--222j-u 2.2k ohm 1/6w 5% carbon film r109,110 35 vrcptv6--472j-u 4.7k ohm 1/6w 5% carbon film r112,114,115 10 vrcptv6--750j-u 75 ohm 1/6w 5% carbon film r116 51 vrcptv6--273j-u 27k ohm 1/6w 5% carbon film r120,122,123 27 vrcptv6--122...

  • Page 72

    Sme-32dl5(p) electronic parts list ver1.0 9- 8 r646 60 vrmptv6-1502f-u 15k ohm 1/6w 1% metal film r647 13 vrcptv6--563j-u 56k ohm 1/6w 5% carbon film r652,673,689 35 vrcptv6--472j-u 4.7k ohm 1/6w 5% carbon film r653,658,685 11 vrcptv6--473j-u 47k ohm 1/6w 5% carbon film r654 02 vrcptv6--154j-u 150k ...

  • Page 73

    Sme-32dl5(p) electronic parts list ver1.0 9- 9 r6e4,6e5,6f1 58 vrcptv6--101j-u 100 ohm 1/6w 5% carbon film r6e6 87 vrcptv6--220j-u 22 ohm 1/6w 5% carbon film r6e9,6k9 54 vrcptv6--332j-u 3.3k ohm 1/6w 5% carbon film r6f3 38 vrmptv6-6811f-u 6.81k ohm 1/6w 1% metal film r6f6 63 vrcptv4--472j-u 4.7k ohm...

  • Page 74

    Sme-32dl5(p) electronic parts list ver1.0 9- 10 r730 37 qjum-1039-1540u jumper r731,7a5 87 vrmptv4-2673f-u 267k ohm 1/4w 1% metal film r732 54 vrcptv4--153j-u 15k ohm 1/4w 5% carbon film r733 38 vrcptv6--683j-u 68k ohm 1/6w 5% carbon film r734 78 vrcptv4--152j-u 1.5k ohm 1/4w 5% carbon film r735 63 ...

  • Page 75

    Sme-32dl5(p) electronic parts list ver1.0 9- 11 zd110 23 vszhz12a1-----u zener diode hz12a1 zd111~114 64 vszmtzj5.1b---u zener diode mtzj5.1b zd102,123,125 64 vszmtzj5.1b---u zener diode mtzj5.1b zd601,605,606 64 vszmtzj5.1b---u zener diode mtzj5.1b zd603,604 80 vszhz12c1-----u zener diode hz12c1 zd...

  • Page 76

    Sme-32dl5(p) electronic parts list ver1.0 9- 12 71 qfshc1017-1---p f701 use 71 qjakm1076-1---- rgb-audio jack 65 qpinr1069-1---- pin r503,507,603,609,6k3 use 08 qsoci1177-108-- ic socket ic002 use 76 qsoci1517-142-- ic socket ic001 use 46 xbpsd30p06000-- screw prdaa0171*3 use 39 xbpsd30p10000-- scre...

  • Page 77

    Sme-32dl5(p) electronic parts list ver1.0 9- 13 87 brc-229b------- r/c 52 dboxs0014-1fd-s spk box 26 dcaba0226-1fd-w cab-a assembly 19 gbox-0008-1fd-b dome spk guide 77 gboxs0014-1fd-b dome spk box 33 gcaba0226-1fd-f cab-a 34 gcabb0268-1fd-- rear cab 56 gcovs0008-1fd-b guide cover 67 gdorp0199-1f---...

  • Page 78

    Sme-32dl5(p) electronic parts list ver1.0 9- 14 14 tlabd1109-1b--- wating label (notice dan gers) 41 tlabm1142-1---- model label ＊ ＊＊＊ 87 vbm81ahm50x01-a crt 08 xetsd40p30000-- screw cab-ab*8 44 xetsd40p10000-- screw spk fix 64 xttsb40p16000-- screw qtmla*4, cab*2 42 tmapt1004-1---- install sketch 7...

  • Page 79

    Sme-32dl5(p) electronic parts list ver1.0 9- 15 2.Audio power board g pwb 16 qpwb51059-1b-3- power / sound amp board c301,308,312 78 vceacu1hg475m-p 4.7uf 50v ± ±± ± 20% aluminum elect. C302,307 15 vceacu1hg564m-p .56uf 50v ± ±± ± 20% aluminum elect. C303,306 50 vcpelu1hg822j-p 8200pf 50v ± ±± ± 5% ...

  • Page 80

    Sme-32dl5(p) electronic parts list ver1.0 9- 16 fb781 32 rcora1025-1---u core fb782 80 rcora1004-1---u core fb783~788 78 rcora1026-1---u core gnd2 67 qcnws0651-1067- connector with wire ic301 27 vsita8184p----- ic ta8184p ic302 52 vsimc14066bcp-- ic mc14066bcp ic303~309 20 vsinjm4558d---- ic njm4558...

  • Page 81

    Sme-32dl5(p) electronic parts list ver1.0 9- 17 r386,387 12 vrnmk02--r22j-- .22 ohm 2w 5% metal oxide film r388,389 73 vrcptv6--182j-u 1.8k ohm 1/6w 5% carbon film r393,394 26 vrcptv6--153j-u 15k ohm 1/6w 5% carbon film r397,398 75 vrcptv4--8r2j-u 8.2 ohm 1/4w 5% carbon film r399,3c8 75 vrcptv6--272...

  • Page 82

    Sme-32dl5(p) electronic parts list ver1.0 9- 18 3.Crt board crt pwb 12 qpwb51022-1b-3- crt board c901,903,904 12 vceacu1hg104m-p .01uf 50v ± ±± ± 20% aluminum elect. C902,908,910 20 vceacu1cg107m-p 100uf 16v ± ±± ± 20% aluminum elect. C905,907,915 20 vckbdu1hy103k-p .01uf 50v ± ±± ± 10% high diel. C...

  • Page 83

    Sme-32dl5(p) electronic parts list ver1.0 9- 19 r947,948 05 vrcptv4--270j-u 27 ohm 1/4w 5% carbon film r949,976,984 53 vrcptv4--100j-u 10 ohm 1/4w 5% carbon film r950~952 31 vrnmk02--153j-- 15k ohm 2w 5% metal oxide film r953,954,957 10 vrcptv6--103j-u 10k ohm 1/6w 5% carbon film r955 30 vrcptv6--33...

  • Page 84

    Sme-32dl5(p) electronic parts list ver1.0 9- 20 4. Vm board vm pwb 13 qpwb11275-1ba2- vm pwb cv1,v13 45 vceacu1cg476m-p 47uf 16v ± ±± ± 20% aluminum elect. Cv6 50 vcpelu1hg822j-p 8200pf 50v ± ±± ± 5% polypropylene film cv7 71 vckbdu1hy561k-p 560pf 50v ± ±± ± 10% high diel. Ceramic cv8 09 vckfdu1hy10...

  • Page 85

    Sme-32dl5(p) electronic parts list ver1.0 9- 21 5.Av & yuv board av & yuv 73 qpwb51087-1g--- av & yuv pwb c802,803,804 c802,803,804 c802,803,804 c802,803,804 53 53 53 53 vceacu1hg106m-p 1 0uf 1 0uf 1 0uf 1 0uf 50v 50v 50v 50v ± 20% 20% 20% 20% aluminum elect aluminum elect aluminum elect aluminum el...

  • Page 86

    Sme-32dl5(p) electronic parts list ver1.0 9- 22 c8m0,8m3 c8m0,8m3 c8m0,8m3 c8m0,8m3 45 45 45 45 vceacu1cg476m-p 47uf 47uf 47uf 47uf 1 6v 1 6v 1 6v 1 6v ± 20% 20% 20% 20% aluminum elect aluminum elect aluminum elect aluminum elect c8m2,8m4 c8m2,8m4 c8m2,8m4 c8m2,8m4 1 3 1 3 1 3 1 3 vceacu1hg474m-p 0....

  • Page 87

    Sme-32dl5(p) electronic parts list ver1.0 9- 23 r820,847,850 r820,847,850 r820,847,850 r820,847,850 8 1 8 1 8 1 8 1 vrmhnvg--101j-a 1 00 1 00 1 00 1 00 ohm ohm ohm ohm 1 /8w 1 /8w 1 /8w 1 /8w 5% 5% 5% 5% metal film metal film metal film metal film r82 1 ,823,855 r82 1 ,823,855 r82 1 ,823,855 r82 1 ,...

  • Page 88

    Sme-32dl5(p) electronic parts list ver1.0 9- 24 rj 1 ,j2,j3 rj 1 ,j2,j3 rj 1 ,j2,j3 rj 1 ,j2,j3 5 1 5 1 5 1 5 1 vrmhnvg--000j-a 0000 ohm ohm ohm ohm 1 /8w 1 /8w 1 /8w 1 /8w 5% 5% 5% 5% metal film metal film metal film metal film rj4 rj4 rj4 rj4 5 1 5 1 5 1 5 1 vrmhnvg--000j-a 0000 ohm ohm ohm ohm 1 ...

  • Page 89

    Sme-32dl5(p) electronic parts list ver1.0 9- 25 6. Sync on green board pwb pwb pwb pwb 7 1 7 1 7 1 7 1 qpwb51093-1b--- sync sync sync sync----on on on on---- green pwb green pwb green pwb green pwb c c c c----s0 1 ,s02 s0 1 ,s02 s0 1 ,s02 s0 1 ,s02 1 3 1 3 1 3 1 3 vceacu1eg476m-p 47uf 47uf 47uf 47uf...

  • Page 90

    Sme-32dl5(p) electronic parts list ver1.0 9- 26 7. Cs pwb cs pwb 01 qpwb51064-1b-3- cs pwb c383,384 29 vcenct1eg475m-p 4.7uf 25v ± ±± ± 20% aluminum elect. C608 12 vcmphf2gg274j-- .27uf 400v ± ±± ± 5% metal ploy. Film c609 52 vcmphf2gg155j-- 1.5uf 400v ± ±± ± 5% metal ploy. Film c610 15 vcmphf2gg224...

  • Page 91

    Sme-32dl5(p) electronic parts list ver1.0 9- 27 8. Rs232 board pwb 68 qpwb51089-1b-- rs232 pwb c1,10 45 vceacu1cg476m- 47uf 16v 20% aluminum elect c11,12,13 78 vclbhn1hy104k- 0.1uf 50v 10% high diel. Chip capacitir c14,15 11 vclbhn1hy181k- 180pf 50v 10% high diel. Chip capacitir c2 77 vceacu1hg105m-...

  • Page 92: Mmm Symptom Table

    Defect bar code list ver 1.0 10-1 mmm symptom table bar code sympton table description english description . M100 電源開機異常 no power . M200 外觀不良 poor cosmetic . M300 裝配不良 poor assembly !. M400 按鍵異常 press button abnormal ". M500 聲音異常 sound abnormal "#. M526 重低音不良 poor doom function #. M600 調整異常 poor adj...

  • Page 93: Mmm Root Cause Table

    Defect bar code list ver 1.0 10-2 mmm root cause table bar code cause table description english description '. *oa 未焊 solder-miss '. *ob 包焊 cold solderng '. *oc 流錫短路 solderingshort '. *ib 斷線 soldering open '. *2a 未配 missing part '. *2b 誤配 wrong part '. *2c 極性反 reversed polarity '. *2e 裝配不良 assembly ...

  • Page 94

    Packing of the set ver1.0 11-1 itme part no. Unit remarks 1. Spakc0623-1r-ao 1 2. Accessories 1 3. Spaka0579-1f--- crop 4. Ctv set 1 5. Spakc0623-1r-ao 1 6. Spaka0579-1f--- crop.

  • Page 95

    Packing of the set ver1.0 11-2 item part no. Unit remarks 1. Spakc0623-1r-ao 1 2. Jhndp0020-1---- 4.