1. DL manuals
  2. Samsung
  3. Air Conditioner
  4. AC100KNPDEH
  5. Installation Manual

Samsung AC100KNPDEH Installation Manual

Other manuals for AC100KNPDEH: Service Manual
Manual is about: FLOOR STAND TYPE AIR CONDITIONER

Summary of AC100KNPDEH

  • Page 1

    Air conditgioner user manual/installation manual ar✴✴hvsd✴✴ • thank you for purchasing this samsung air conditioner. • before operating this unit, please read this user manual carefully and retain it for future reference. Air conditioner installation manual ac✴✴✴knpdeh/ac✴✴✴kxad✴h • thank you for pu...

  • Page 2

    2 contents english contents safety information safety information 3 general information installing the unit power supply line, fuse or circuit breaker installation procedure 6 step 1 choosing the installation location step 2 unpacking step 3 checking and preparing accessories step 4 drilling a hole ...

  • Page 3

    3 english saf ety inf ormation carefully follow the precautions listed as below because they are essential to guarantee the safety of samsung product. Warning ∙ always disconnect the air conditioner from the power supply before servicing it or accessing its internal components. ∙ verify that install...

  • Page 4

    4 safety information english saf ety inf ormation installing the unit important: when installing the unit, always remember to connect first the refrigerant tubes, then the electrical lines. Always disassemble the electric lines before the refrigerant tubes. ∙ upon receipt, inspect the product to ver...

  • Page 5

    5 english saf ety inf ormation ∙ do not install the air conditioner in following places. – place where there is mineral oil or arsenic acid. Resin parts flame and the accessories may drop or water may leak. The capacity of the heat exchanger may reduce or the air conditioner may be out of order. – t...

  • Page 6

    6 english ins tallation pr oc edur e installation procedure step 1 choosing the installation location determine the installation location considering the following conditions and obtain the user approval. Indoor unit ∙ install the unit where the pipes and cables can be easily connected to the outdoo...

  • Page 7

    7 english ins tallation pr oc edur e installation procedure ∙ construct a protection wall made of solid material such as concrete to block sea breeze. Make sure that its height and width are 1.5 times greater than the size of the outdoor unit. In addition, secure a space larger than 600 mm between t...

  • Page 8

    8 installation procedure english ins tallation pr oc edur e warning ∙ after installing the outdoor unit, apply rust inhibitor on the internal pipes and heat exchanger. – airborne corrosive gas such as sulfur compounds, hydrogen sulfide, and ammonia, or salty dust may cause pipe corrosion. This corro...

  • Page 9

    9 english ins tallation pr oc edur e step 2 unpacking unpacking the indoor unit 1 open the indoor unit package. 2 remove the top and middle cushions. 3 remove the bottom cushion. Unpacking the outdoor unit 1 pull out the outdoor unit from the package. 2 remove the top cushion. 3 remove the 4 screws ...

  • Page 10

    10 installation procedure english ins tallation pr oc edur e step 5 taping the pipes, cables, and drain hose 1 wrap the refrigerant pipes with the provided insulation. This wrapping minimises condensation. Insulation refrigerant pipes 2 wind the refrigerant pipes, power cable, communication cable, a...

  • Page 11

    11 english ins tallation pr oc edur e 1 connect each assembly pipe to the appropriate valves on the indoor and outdoor units and fasten the flare nuts. 2 as depicted in the illustration below, tighten the flare nut manually, and then apply the following torque with a torque wrench. Indoor unit liqui...

  • Page 12

    12 installation procedure english ins tallation pr oc edur e step 7 optional: cutting and flaring the pipes 1 make sure that you have the required tools; pipe cutter, reamer, flaring tool, and pipe holder. 2 if you want to shorten the pipes, cut it with a pipe cutter, making sure that the cut edge r...

  • Page 13

    13 english ins tallation pr oc edur e caution ∙ use rated cables or products only, with heat resistance over 105°c, as well as properly rated switches or fuses in the cabinet panel. ∙ make sure that the cables connected do not produce sparks around the auxiliary power switch or that they are not ins...

  • Page 14

    14 installation procedure english ins tallation pr oc edur e entire system diagram elb nfb single phase 220 to 240v, 50 hz outdoor-to-indoor power cable main power cable outdoor unit indoor unit electrical panel earthing ground wire communication cable power wiring diagram 1(l) 2(n) l n f1 f2 outdoo...

  • Page 15

    15 english ins tallation pr oc edur e main power cable specifications the power cable is not supplied with air conditioner. ∙ select the power supply cable in accordance with relevant local and national regulations. ∙ wire size must comply with the applicable local and national code. ∙ specification...

  • Page 16

    16 installation procedure english ins tallation pr oc edur e step 9 optional: extending the power cable 1 prepare the following tools. Tools spec shape crimping pliers mh-14 connection sleeve (mm) 20 x Ø6.5 (hxod) insulation tape width 19 mm contraction tube (mm) 70 x Ø8.0 (lxod) 2 as shown in the f...

  • Page 17

    17 english ins tallation pr oc edur e caution ∙ make sure that the connection parts are not exposed to outside. ∙ be sure to use insulation tape and a contraction tube made of approved reinforced insulating materials that have the same level of withstand voltage with the power cable. (comply with th...

  • Page 18

    18 installation procedure english ins tallation pr oc edur e 1 connect the charging hose of low pressure side of manifold gauge to the packed valve having a service port as shown at the figure. Note ∙ the designs and shape are subject to change according to the model. 2 open the valve of the low pre...

  • Page 19

    19 english ins tallation pr oc edur e 1 measure the quantity of refrigerant depending on the length of the liquid side pipe. Note ∙ when the pipe length exceeds the standard pipe length of 5 m, charge refrigerant according to the increased length. Do not charge refrigerant by assuming the quantity t...

  • Page 20

    20 installation procedure english ins tallation pr oc edur e pressure table for each temperature if extra refrigerant charging is required due to gas leakage or product relocation, see the following table. Cooling operation unit: [kpa, g] indoor temperature (°c) (dry bulb / wet bulb) outdoor tempera...

  • Page 21

    21 english ins tallation pr oc edur e step 15 installing and connecting the drain hose 1 wrap the drain hose with the provided insulation. This wrapping minimises condensation. Drain hose insulation 2 insert the end of the drain hose to the extension drain hose to make a connection. 3 tightly wrap t...

  • Page 22

    22 installation procedure english ins tallation pr oc edur e caution ∙ install the drain hose in a downward direction. ∙ water leakage may occur when the drain hose is not firmly fixed with a cable tie or tape. ∙ if there is any foreign substance in the drain pan, it may clog the drain hose. Be sure...

  • Page 23

    23 english ins tallation pr oc edur e 6 view mode: when the k4 switch is pressed, you can see information about our system state, as detailed below. K4 short push display contents seg1 seg2 seg3 seg4 unit 1 order frequency 1 hundreds digit tens digit units digit hz 2 current frequency 2 hundreds dig...

  • Page 24

    24 installation procedure english ins tallation pr oc edur e 7 dip switch option on 1 2 3 4 1 2 3 4 on ∙ dip switch (sw507) option on (default) off switch 1 auto address manual address switch 2 disable snow prevention control enable snow prevention control switch 3 silence mode option switch 4 – whe...

  • Page 25

    25 english appendix commission delegated regulation (eu) no 626/2011 i) product fiche (energy labelling of air conditioners) ii) a supplier's name - samsung electronics co., ltd. B model name (indoor/outdoor) - ac100knpdeh/ac100kxadeh c sound power level (indoor/outdoor) db(a) 60 / 70 d refrigerant ...

  • Page 26

    26 appendix english appendix [spanish-es] [french-fr] [italian-it] [portuguese-pt] reglamento delegado (ue) no 626/2011 de la comisiÓn rÈglement dÉlÉguÉ (ue) no 626/2011 de la commission regolamento delegato (ue) n. 626/2011 della commissione regulamento delegado (ue) n.O 626/2011 da comissÃo ficha ...

  • Page 27

    27 english appendix [german-de] [greek-el] [dutch-nl] [polish-pl] delegierte verordnung (eu) nr. 626/2011 der kommission ΚΑΤ’ ΕΞΟΥΣΙΟΔΌΤΗΣΗ ΚΑΝΟΝΙΣΜΌΣ (ΕΕ) αριθ. 626/2011 ΤΗΣ ΕΠΙΤΡΟΠΉΣ gedelegeerde verordening (eu) van de commissie nr. 626/2011 rozporzĄdzenie delegowane komisji (ue) nr 626/2011 prod...

  • Page 28

    28 appendix english appendix [hungarian-hu] [czech-cs] [slovak-sk] [romanian-ro] a bizottsÁg 626/2011/eu felhatalmazÁson alapulÓ rendelete naŘÍzenÍ komise v pŘenesenÉ pravomoci (eu) č. 626/2011 delegovanÉ nariadenie komisie (eÚ) č. 626/2011 regulament delegat (ue) nr. 626/2011 al comisiei termékisme...

  • Page 29

    29 english appendix [bulgarian-bg] [croatian-hr] [slovenian-sl] [danish-da] ДЕЛЕГИРАН РЕГЛАМЕНТ (ЕС) № 626/2011 НА КОМИСИЯТА delegirana uredba komisije (eu) br. 626/2011 delegirana uredba komisije (eu) št. 626/2011 kommissionens delegerede forordning (eu) nr. 626/2011 Продуктов фиш (енергийното етик...

  • Page 30

    30 appendix english appendix [swedish-sv] [finnish-fi] [estonian-et] [latvian-lv] kommissionens delegerade fÖrordning (eu) nr 626/2011 delegoitu komission asetus (eu) n:o 626/2011, komisjoni delegeeritud mÄÄrus (el) nr 626/2011, komisijas deleĢĒtĀ regula (es) nr. 626/2011 produktblad (energimärkning...

  • Page 31

    31 english appendix [lithuanian-lt] [serbian-sr] komisijos deleguotasis reglamentas (es) nr. 626/2011 КОМИСИЈА ДЕЛЕГАТЕД УРЕДБА (ЕС) № 626/2011 gaminio vardinių parametrų lentelė (oro kondicionierių energijos vartojimo efektyvumo ženklinimo reikalavimus) ПРОИЗВОДА ФИЦХЕ (енергетског означавања клима...

  • Page 32

    32 appendix english appendix [spanish-es] 1 las fugas de refrigerante contribuyen al cambio climático. Cuanto mayor sea el potencial de calentamiento global (gwp) de un refrigerante, más contribuirá a dicho calentamiento su vertido a la atmósfera. Este aparato contiene un líquido refrigerante con un...

  • Page 33

    33 english appendix [portuguese-pt] 1 a fuga de fluido refrigerante contribui para as alterações climáticas. Os fluidos refrigerantes com menor potencial de aquecimento global (pag) contribuem menos para o aquecimento global do que os fluidos refrigerantes com maior pag, em caso de fuga para a atmos...

  • Page 34

    34 appendix english appendix [dutch-nl] 1 lekkage van koelmiddel leidt tot klimaatverandering. Bij lekkage in de lucht draagt een koelmiddel met een laag aardopwarmingsvermogen (gwp) minder bij tot de opwarming van de aarde dan een koelmiddel met een hoog gwp. Dit apparaat bevat een koelmiddel met e...

  • Page 35

    35 english appendix [czech-cs] 1 Únik chladiva se podílí na změně klimatu. Chladivo s nižším potenciálem globálního oteplování (gwp) by se v případě úniku do ovzduší podílelo na globálním oteplování méně než chladivo s vyšším gwp. Toto zařízení obsahuje chladicí kapalinu s gwp ve výši [xxx]. To znam...

  • Page 36

    36 appendix english appendix [bulgarian-bg] 1 Изпускането на хладилен агент допринася за изменението на климата. Хладилен агент с по-нисък потенциал за глобално затопляне (ПГЗ) би допринесъл по-малко за глобалното затопляне, отколкото хладилен агент с по-висок ПГЗ при евентуално изпускане в атмосфер...

  • Page 37

    37 english appendix [swedish-sv] 1 läckage av köldmedium bidrar till klimatförändringen. Köldmedium med lägre global uppvärmningspotential (gwp) skulle vid läckare ge upphov till mindre global uppvärmning än ett köldmedium med högre gwp. Den här apparaten innehåller ett köldmedium med gwp motsvarand...

  • Page 38

    38 appendix english appendix [lithuanian-lt] 1 Šaldalo nuotėkis prisideda prie klimato kaitos. Jei šaldalo nutekėtų į atmosferą, mažesnį visuotinio atšilimo potencialą turintis šaldalas mažiau prisidėtų prie visuotinio atšilimo negu didesnį visuotinio atšilimo potencialą turintis šaldalas. Šiame pri...

  • Page 39

    39 english appendix troubleshooting the table below lists the self-diagnostic routines. For some of error codes, you must contact an authorized service centre. If an error occurs during the operation, it is displayed on the outdoor unit pcb led, both main pcb and inverter pcb. No. Error code meaning...

  • Page 40

    40 appendix english appendix no. Error code meaning remarks 24 e470 outdoor unit eeprom checksum error check outdoor eeprom data 25 e471 outdoor unit eeprom error check outdoor eeprom pba 26 e474 error on ipm (igbt module) or pfcm temperature sensor check outdoor inverter pba 27 e475 error on invert...

  • Page 41

    41 english appendix memo pac_im_eng.Indd 41 2016-06-23 오전 11:51:21.

  • Page 42

    42 memo english appendix pac_im_eng.Indd 42 2016-06-23 오전 11:51:22.

  • Page 43

    43 english appendix memo pac_im_eng.Indd 43 2016-06-23 오전 11:51:22.

  • Page 44

    Pac_im_eng.Indd 44 2016-06-23 오전 11:51:22.