Samsung AJFCJ Installation Manual - Adding Refrigerant
20
A
Connecting up and purging the circuit
A
B
C
Vacuum
Pump
◆ RJ060F3HX**/RJ070F4HX**/RJ080F4HX**/AJ068FCJ3**/
AJ070FCJ4**/AJ080FCJ4**
1
Check the piping connections.
2
Connect the charging hose of low pressure side of manifold gauge to the
packed valve having a service port (5/8” Packed valve) as shown at the
figure (Value stem: 1/2” - 20UNF).
3
Open the valve of the low pressure side of manifold gauge
counter clockwise.
4
Purge the air from the system using vacuum pump for about 30 minutes.
- Close the valve of the low pressure side of manifold gauge clockwise.
- Make sure that pressure gauge show -0.1MPa(-76cmHg) after about
30 minutes. This procedure is very important in order to avoid gas leak.
- Turn off the vacuum pump.
- Remove the hose of the low pressure side of manifold gauge.
5
Set valve cork of both liquid side and gas side of packed valve to the
open position.
6
Mount the valve stem nuts and the service port cap to the valve, and
UJHIUFOUIFNBUUIFUPSRVFPGLHGtDNXJUIBUPSRVFXSFODI
7
Check for gas leakage.
- At this time, especially check for gas leakage from the 3-way valve’s
stem nuts, and from the service port cap.
Valve stem
Stem cap
Service port
◆Make the electrical connection and leave the system into “stand
by mode”. Do not turn on the system! This is necessary for better
vacuum operation (full OPEN position of Electronic Expansion
Valve - EEV -).
WARNING
Adding refrigerant
If you install the excessive length of pipe, add additional refrigerant as 10g(20g) per unit meter ;
refer to the table below.
Refer to the Service Manual for more details on this operation.
Model
Total connecting pipe length (L)
Adding refrigerant
RJ040F2HX**
AJ040FCJ2**
LT
d15m
Chargeless
LT>15m
(LT- 15m)x10g
RJ050F2HX**
AJ050FCJ2**
LT
d20m
Chargeless
LT>20m
(LT- 20m)x20g
RJ052/060F3HX**
AJ052/068FCJ3**
LT
d30m
Chargeless
LT>30m
(LT- 30m)x10g
RJ070/080F4HX**
AJ070/080FCJ4**
LT
d40m
Chargeless
LT>40m
(LT- 40m)x10g
3"JTBNJYFEUZQFPGSFGSJHFSBOU*UJTOFDFTTBSZGPSSFDIBSHJOHVOEFSDPOEJUJPOTPGMJRVJE8IFOSFDIBSHJOHSFGSJHFSBOUGSPN
UIFSFGSJHFSBOUDZMJOEFSUPUIFFRVJQNFOUGPMMPXUIFJOTUSVDUJPOTCFMPX
#FGPSFSFDIBSHJOHDIFDLXIFUIFSUIFDZMJOEFSIBTBTJQIPOPSOPU
5IFSFBSFUXPXBZTUPSFDIBSHFUIFSFGSJHFSBOU
$IBSHJOHUIFSFGSJHFSBOUVOEFSDPOEJUJPOTPGMJRVJECZVTJOHBMJRVJEQJQF
$ZMJOEFSXJUITJQIPO
TJQIPO
f
$IBSHFUIFSFGSJHFSBOUTUBOEJOHUIF
DZMJOEFSVQSJHIU
$ZMJOEFSXJUIPVUTJQIPO
f
$IBSHFUIFSFGSJHFSBOUUVSOJOHUIFDZMJOEFS
VQTJEFEPXO
t *G3"SFGSJHFSBOUJTDIBSHFEXJUIHBTUIFDPNQPTJUJPOPGUIFDIBSHFESFGSJHFSBOUDIBOHFTBOEUIF
DIBSBDUFSJTUJDTPGUIFFRVJQNFOUWBSZ
t %VSJOHUIFNFBTVSJOHPQFSBUJPOPGSFGSJHFSBOURVBOUJUZBEEFEVTFBOFMFDUSPOJDCBMBODF
*GDZMJOEFSEPFTOUIBWFTZQIPOVQTFUJU