1. DL manuals
  2. Tally
  3. Printer
  4. DT-210
  5. User Manual

Tally DT-210 User Manual

Manual is about: THERMAL RECEIPT PRINTER

Summary of DT-210

  • Page 3

    Tally dascom dt-210/230 i important safety instructions (english) read the following instructions thoroughly before starting up your printer. • never carry out maintenance or repair work yourself. Always contact a qualified service technician. • keep this operator’s manual in a place which is easily...

  • Page 4

    Tally dascom dt-210/230 ii wichtige sicherheitshinweise (german) lesen sie bitte diese sicherheitshinweise durch, bevor sie den drucker in betrieb nehmen. Führen sie wartungsarbeiten und reparaturen keinesfalls selbst aus, sondern verständigen sie immer einen qualifizierten servicetechniker. Bewahre...

  • Page 5

    Tally dascom dt-210/230 iii consignes importantes de sécurité (french) lire attentivement les instructions suivantes avant de mettre l’imprimante en service. Ne jamais effectuer soi-même les travaux d’entretien et de réparations. Contacter toujours un dépanneur qualifié. Placer l’imprimante sur un s...

  • Page 6

    Tally dascom dt-210/230 iv indicazioni di sicurezza importanti (italian) prima di mettere in funzione la stampante, leggere attentamente le seguenti indicazioni. Non eseguire mai da sé gli interventi di manutenzione e riparazione, ma rivolgersi sempre a un tecnico di assistenza qualificato. Conserva...

  • Page 7

    Tally dascom dt-210/230 v instrucciones de seguridad importantes (spanish) lea las siguientes instrucciones con esmero antes de poner la impresora en servicio. Nunca lleve a cabo trabajos de mantenimiento o reparación ud. Mismo, sino consulte a un técnico de servicio calificado. Guarde las presentes...

  • Page 8

    Tally dascom dt-210/230 vi Правила по технике безопасности. (russian) Прочитайте, пожалуйста, инструкцию по технике безопасности перед включением в работу принтера. Не выполняйте технические работы и ремонт техники самостоятельно, но сообщайте о неисправностях квалифицированным сервисным техникам. Д...

  • Page 9

    Tally dascom dt-210/230 vii instruções importantes sobre segurança (portuguese) leia as instruções de segurança antes de usar a impressora. Consulte sempre um técnico qualificado para executar uma reparação . Coloque a impressora sobre uma base sólida e nivelada, para que ela não sofra quedas. Jamai...

  • Page 10

    Tally dascom dt-210/230 viii Önemli güvenlik talimatları (turkish) lütfen, yazıcıyı işletime geçirmeden önce bu güvenlik talimatlarını bütünüyle dikkatle okuyun. Bakım ve tamir çalışmalarını kesinlikle ve hiçbir surette kendi başınıza yapmayın; her zaman kalifiye bir uzman servis-teknisyenine haber ...

  • Page 11

    Tally dascom dt-210/230 ix trademark acknowledgements “epson” is a trademark of epson america incorporated. “centronics” is a trademark of centronics data computer corporation. “dos” is a trademark of microsoft corporation. “windows”, “windows 7”, and “windows xp” are trademarks of microsoft corpora...

  • Page 12

    Tally dascom dt-210/230 x.

  • Page 13: Table Of Contents

    Tally dascom dt-210/230 i table of contents table of contents ............................................................................................................................ I 1 printer installation guide .....................................................................................

  • Page 14

    Tally dascom dt-210/230 ii.

  • Page 15

    Tally dascom dt-210/230 1 1 printer installation guide 1.1 unpacking the printer open the packaging, lift the printer out of the cardboard box and remove the remaining packaging material. Check the printer for any visible transport damage and missing items. If you find any transport damage or any ac...

  • Page 16

    Tally dascom dt-210/230 2 1.2 placing the printer place the printer on a solid, flat, stable surface; ensuring that the printer is positioned in such a way that it cannot move, and that there is easy access to the control panel and paper input devices. Also ensure that there is enough space for suff...

  • Page 17

    Tally dascom dt-210/230 3 1.3 printer components printer components and functions are shown as below: component function printer cover open the cover when loading or reloading roll paper. Control panel shows printer status for printer function setup. Power switch powers printer on or off. Cutter cov...

  • Page 18

    Tally dascom dt-210/230 4 1.4 connecting the interface cable the usb, cash drawer, serial/parallel/ethernet/wi-fi interface ports are located at the rear of the printer. Choose the interface which suits your system. Note: make sure the printer and the computer are switched off before connecting or d...

  • Page 19

    Tally dascom dt-210/230 5 1.5 connecting the mains power  checking the printer voltage make sure that the device has been set according to your country’s power supply voltage. To do this, check the rating plate at the rear of the printer. Contact your dealer if the setting is incorrect. Never switc...

  • Page 20

    Tally dascom dt-210/230 6 1.6 adjusting the near end sensor open the printer cover you will see a black lever inside as shown below. The dt-230 has a paper near-end sensor that provides notice that the paper roll is nearly exhausted. When the paper is running low, the paper led is lit red. If you fi...

  • Page 21

    Tally dascom dt-210/230 7 1.7 installing roll paper 1.7.1 installing 80mm roll paper 1. Press the cover open button to open the cover. 2. The correct installing direction of the roll paper. 3. Remove any used roll paper core, and load the new roll paper. 4. Pull out some paper over cutter cover as s...

  • Page 22

    Tally dascom dt-210/230 8 1.7.2 installing 58mm roll paper if you want to install 58mm roll paper, open the printer cover, you will see an inserter on the right side of the paper warehouse. Move this inserter to the specified position on the middle of the warehouse. Then you can install the 58 roll ...

  • Page 23

    Tally dascom dt-210/230 9 1.8 installing the interfaces  usb interface  cash drawer interface  parallel interface.

  • Page 24

    Tally dascom dt-210/230 10  serial interface  ethernet interface.

  • Page 25

    Tally dascom dt-210/230 11 1.9 installing the standard option and optional kits  interface cover (standard option) adjust the relative positions between interface cover and printer as shown below, and push the interface cover as arrow shown below.  splash cover (optional kit) slip the fixed hooks ...

  • Page 26

    Tally dascom dt-210/230 12 1.10 installing the printer driver installing the windows driver (compatible with windows xp/7) note: power off the printer before running the printer driver setup. Your printer cd-rom comes with windows drivers. Go to the drivers folder and run the installer “driversetup....

  • Page 27

    Tally dascom dt-210/230 13 3. Choose the desired port to use, after selecting the “port” option (usb001 for usb port, com1 for serial port and lpt1 for parallel port), click “next” to continue. 4. Click “finish” to finish the installation process successfully..

  • Page 28

    Tally dascom dt-210/230 14 installation guide for ethernet and wi-fi driver program 1. Install the printer driver as usb installation. 2. Click “start” → “control panel” → “hardware and sound” → “devices and printers”, right click on the dt-230 printer driver, and then click “printer properties”..

  • Page 29

    Tally dascom dt-210/230 15 3. Then you will see the screen as below. Click “ports” → “add port”..

  • Page 30

    Tally dascom dt-210/230 16 4. Select “standard tcp/ip port”, and click “new port”. 5. You will see the screen as below, cilck “next” to continue..

  • Page 31

    Tally dascom dt-210/230 17 6. Complete the “printer name or ip address” and “port name”. 7. Click “next” to access the screen as below..

  • Page 32

    Tally dascom dt-210/230 18 8. And then you will see the screen as below, click “next” to continue. 9. Click “finish” to complete the printer driver installation..

  • Page 33

    Tally dascom dt-210/230 19 10. Click “start” → “control panel” → “hardware and sound” → “devices and printers”, right click on the dt-230 printer driver, and then click “printer properties”. Then click “ports” → “configure port”, finish the setup parameter in the screen as below. Click “ok” to finis...

  • Page 34

    Tally dascom dt-210/230 20 2 control panel operation  led indicators and key feed key press feed key to feed paper. Power led power led turns on while printer is powering on. Error led error led turns on means error occurs. Paper led paper led turns on means paper near end or paper end.  self-test...

  • Page 35

    Tally dascom dt-210/230 21 3 setting dip switches you will see a metal plate on the bottom of the printer. Remove the metal plate with a screwdriver you will find two dip switches on the main control board as showm below. There are two dip switch banks on the main controller board (sw1 and sw2), eig...

  • Page 36

    Tally dascom dt-210/230 22  serial interface (rs-232c) · dip switches 1 sw function on off default 1-1 auto line feed enable disable off 1-2 handshaking xon/xoff dtr/dsr off 1-3 data length 7bits 8bits off 1-4 parity check yes no off 1-5 parity selection even odd off 1-6 baud rate selection (bps) r...

  • Page 37

    Tally dascom dt-210/230 23 · dip switches 2 sw function on off default 2-1 reserved - - off 2-2 internal bell control internal bell disable internal bell enable off 2-3 auto cutter disable enable off 2-4 busy condition receive buffer full * offline * receive buffer full off 2-5 print density refer t...

  • Page 38

    Tally dascom dt-210/230 24 4 troubleshooting your printer is extremely reliable, but occasionally problems may occur. This chapter provides information on some of the common problems you may encounter and how you may solve them. If you encounter problems that you can not resolve, contact your dealer...

  • Page 39

    Tally dascom dt-210/230 25  troubles occur during printing trouble potential problem solution coloured stripe in the paper paper near end reinstall the roll paper blurred printing or spot incorrect roll paper installation check if the roll paper is installed correctly unqualified roll paper use rec...

  • Page 40

    Tally dascom dt-210/230 26 4.3 cleaning thermal print head after printing, the thermal print head becomes very hot. Be careful not to touch it and to let it cool before you clean it. Do not damage the thermal print head by touching it with your fingers or any hard object. Turn off the printer, open ...

  • Page 41

    Tally dascom dt-210/230 27 5 specification 5.1 printer specification print parameter print method direct thermal line printing resolution 203dpi, 8dots/mm print speed dt-230: 260mm/s default; 240-270mm/s adjustable via eds. Dt-210: 220mm/s default; 210-230mm/s adjustable via eds. Print width 72mm (5...

  • Page 42

    Tally dascom dt-210/230 28 color black weight approx. 1.8kg optional kits splash cover and hanging plate standard option interface cable cover reliability tph lifetime 150km mtbf 360, 000 hours cutter lifetime 2,000,000 cuts mcbf 15,000,000 lines software function driver program 32bit: windows (win ...

  • Page 43

    Tally dascom dt-210/230 29 5.2 interfaces power supply interface, usb interface and cash drawer interface are standard interfaces for the printer. Serial interface, parallel interface, ethernet interface and wi-fi interface are optional interfaces for the printer. The interface pin assignment is lis...

  • Page 44

    Tally dascom dt-210/230 30 5.2.3 cash drawer interface cash drawer interface pin assignment cash drawer interface with dc24v, 1a, rj-11 6p type socket. Pin. No. Description direction 1 frame ground - 2 drawer kick-out drive signal 1 output 3 drawer open/close signal input 4 +24v - 5 drawer kick-out ...

  • Page 45

    Tally dascom dt-210/230 31 5.2.5 parallel interface parallel interface pin assignment parallel interface with 36 pin centronics socket. Pin no. Signal from description 1 h stb signal; data latch pulse, latch the data to the printer at the rising edge of the negative pulse. 2 h data 0 (the lowest bit...

  • Page 46

    Tally dascom dt-210/230 32 5.2.6 ethernet interface ethernet interface pin assignment pin. No. Name description 1 tx+ tranceive data+ 2 tx- tranceive data- 3 rx+ receive data+ 4 n/c not connected 5 n/c not connected 6 rx- receive data- 7 n/c not connected 8 n/c not connected ethernet interface conne...

  • Page 47

    Tally dascom dt-210/230 33 5.3 paper specification printable area the printable area of a paper with width of 79.5 ± 0.5 mm {3.13 ± 0.02"} is 72.2 ± 0.2 mm {2.84 ± 0.008"} (576 dots) and the space on the right and left sides are approximately 3.7 ± 2 mm {0.15 ± 0.079"}. Paper type specified thermal ...

  • Page 48

    Tally dascom dt-210/230 34 printing and cutting positions.

  • Page 49

    Tally dascom dt-210/230 35 6 character code pages  common to all pages (international character set: usa).

  • Page 50

    Tally dascom dt-210/230 36  page 0 [pc437: usa, standard europe].

  • Page 51

    Tally dascom dt-210/230 37  page 2 [pc850: multilingual].

  • Page 52

    Tally dascom dt-210/230 38  page 3 [pc860: portuguese].

  • Page 53

    Tally dascom dt-210/230 39  page 4 [pc863: canadian-french].

  • Page 54

    Tally dascom dt-210/230 40  page 5 [pc865: nordic].

  • Page 55

    Tally dascom dt-210/230 41  page 17 [pc866: cyrillic #2].

  • Page 56

    Tally dascom dt-210/230 42  page 18 [pc852: latin2].

  • Page 57

    Tally dascom dt-210/230 43  page 19 [pc858: euro].

  • Page 58

    Tally dascom dt-210/230 44  page 255 [user-defined page].

  • Page 59

    Tally dascom dt-210/230 45  international character sets.

  • Page 60

    Tally dascom dt-210/230 46  page 20 [ku42: thai].

  • Page 61

    Tally dascom dt-210/230 47  page 21 [tis11: thai].

  • Page 62

    Tally dascom dt-210/230 48  page 26 [tis18: thai].

  • Page 63

    Tally dascom dt-210/230 49  page 32 [pc720: arabic].

  • Page 64

    Tally dascom dt-210/230 50 7 printing control command sets · be compatible with epson tm-t88iv command sets; · support nv image and page mode printing. List of commands command name ht horizontal tab lf print and line feed ff print and return to standard mode (in page mode) cr print and carriage ret...

  • Page 65

    Tally dascom dt-210/230 51 command name esc a select justification esc c 3 select paper sensor(s) to output paper-end signals esc c 4 select paper sensor(s) to stop printing esc c 5 enable/disable panel buttons esc d print and feed n lines esc p generate pulse esc t select character code table esc {...

  • Page 66

    Tally dascom dt-210/230 52 command name gs ( k set up and print symbol pdf417: set the number of columns in the data region. Pdf417: set the number of rows. Pdf417: set the width of the module. Pdf417: set the row height. Pdf417: set the error correction level. Pdf417: select the options. Pdf417: st...

  • Page 67

    Tally dascom dt-210/230 53 the commands listed below in the first column are defined as “obsolete commands” in the esc/pos command system. This printer supports both upward-compatible commands and obsolete commands. However, the upward-compatible commands are recommended to use. Obsolete command upw...

  • Page 68

    Tally dascom dt-230 54 fcc statement 1. This device complies with part 15 of the fcc rules. Operation is subject to the following two conditions: 6 this device may not cause harmful interference. 7 this device must accept any interference received, including interference that may cause undesired ope...

  • Page 69

    Dascom representatives germany dascom europe gmbh heuweg 3 d-89079 ulm deutschland tel.: +49 (0) 731 2075 0 fax: +49 (0) 731 2075 100 www.Dascom.Com singapore (asia pacific) dascom ap pte ltd 21 bukit batok crescent #29-81, wcega tower singapore 658065 phone: +65 6760 8833 fax: +65 6760 1066 www.Das...