TATA Motors 2013 Nano Owner's Manual - Service Maintenance Schedule
99
99
Month
GENERAL
1 Wash the vehicle & clean condenser fins
Every Service
• • • • • • • • • • •
2 Check & top up fluids (if required) :
Every Service
• • • • • • • • • • •
Engine oil,Coolant,Brake fluid, Wind screen washer
fluid. Adjust wind screen washer nozzles if required.
3 Check fuel lines & transaxle housing for leakages
10000
• • • • • • • • • •
4 Check rubber boots & bushes for damage
20000
•
•
•
•
•
5 All standard checks as per job card (As applicable)
Every Service
• • • • • • • • • • •
ENGINE
1 Clean air filter element ( More frequent cleaning if
10000
• • • • • • • • • •
dust condition is severe)
2 Replace air filter element (More frequent replacement,
30000
•
•
•
if dust condition is severe)
3 Change Engine oil and Oil filter (10000 km OR
10000
• • • • • • • • • •
12 months whichever is earlier)
4 Change fuel filter
10000
• • • • • • • • • •
5 Check drive (Alternator & AC) belts for tension,
Every Service
• • • • • • • • • • •
adjust tension if required, replace if necessary
6 Replace Alternator belt (40000 km OR two years
40000
•
•
whichever is earlier )
7 Replace AC compressor belt, if required
100000
•
8 Check timing belt, replace if necessary
40000
•
•
9 Replace timing belt
100000
•
10 Change coolant ( 40000 km OR two years
40000
•
•
whichever is earlier )
11 Replace Spark Plug
30000
•
•
•
12 Check HT lead on engine for cracks or deformation
40000
•
•
(Only visual check. Do not remove), replace if
necessary.
13 Check the radiator core for dust, mud or mug
10000
• • • • • • • • • •
accumulation and clean core from outside if required
14 Check coolant lines for leakages (Only visual check)
10000
• • • • • • • • • •
TRANSAXLE
1 Change Transaxle oil and clean drain plug.
20000
•
•
•
•
•
2 Inspect Driveshaft for Boot cuts, etc
Every Service
• • • • • • • • • • •
3 Check & Adjust free play of Clutch release cable
Every Service
• • • • • • • • • • •
BRAKES
1 Check front and rear brake linings. Clean or
20000
•
•
•
•
•
Replace, if necessary.
2 Clean the brake drums with air
10000
• • • • • • • • • •
3 Replace brake fluid (40000 km OR 2 years which-
40000
•
•
ever is earlier) and check brake system
components for leakages
WHEELS & TYRES
1 Tyre Swapping with balancing ( Front with Front &
10000
• • • • • • • • • •
Rear with Rear)
1000-1500
FREQUENCY
10000-10500
20000-20500
30000-30500
40000-40500
50000-50500
60000-60500
70000-70500
80000-80500
90000-95500
100000-100500
OPERATION
SERVICE MAINTENANCE SCHEDULE
3
12
24
36
48
60
72
84
96
108
120