1. DL manuals
  2. Thelin
  3. Pellet stove
  4. GNOME PELLET STOVE
  5. Owner's Manual

Thelin GNOME PELLET STOVE Owner's Manual

Manual is about: GNOME PELLET STOVE

Summary of GNOME PELLET STOVE

  • Page 1

    Thelin hearth products, inc. Gnome pellet stove 1 of 47 gnome pellet stove owner’s manual leave this manual with the owner. Please read this entire manual before installation and use of the pellet fuel-burning stove. Failure to follow these instructions could result in property damage, bodily injury...

  • Page 2

    Thelin hearth products, inc. Gnome pellet stove 2 of 47 table of contents introduction ................................................................................................................................................................................ 3 safety information ..................

  • Page 3: Introduction

    Thelin hearth products, inc. Gnome pellet stove 3 of 47 congratulations on your purchase of thelin hearth products gnome pellet stove! In this manual you will find information on stove specifications, installation instructions, operating guide, how to perform scheduled maintenance, a troubleshooting...

  • Page 4

    Thelin hearth products, inc. Gnome pellet stove 4 of 47 do not overfire. If any external part starts to glow, you are over firing. Reduce feed rate. Overfiring or any such action that may cause a fire hazard including failure to perform regular maintenance as outlined in these instructions will void...

  • Page 5

    Thelin hearth products, inc. Gnome pellet stove 5 of 47 6. The masonry chimney has been inspected by a professional and is clean, or the factory built (metal) fireplace is installed according to the manufacturer’s instructions. 7. A grounded power outlet with a surge protector is available nearby wi...

  • Page 6

    Thelin hearth products, inc. Gnome pellet stove 6 of 47 laboratory listing label.

  • Page 7

    Thelin hearth products, inc. Gnome pellet stove 7 of 47 warnings hot surfaces! Hot glass will cause burns. Surfaces and glass are hot during operation and during cool-down period. Do not touch glass until it is cooled. Never allow children to touch glass. Alert children to hazards of high temperatur...

  • Page 8

    Thelin hearth products, inc. Gnome pellet stove 8 of 47 provide adequate clearances around air openings into the combustion chamber and provide adequate accessibility clearance for servicing and proper operation. Never obstruct the front opening of the stove. The stove may be installed as a free-sta...

  • Page 9: Vent Information

    Thelin hearth products, inc. Gnome pellet stove 9 of 47 vent information install vent clearances as specified in this owner’s manual. Use type l 3” or 4” pellet vent pipe depending on your installation. Secure pipe adapter to rear flange with 500 degree high-temp rtv silicone and using at least thre...

  • Page 10

    Thelin hearth products, inc. Gnome pellet stove 10 of 47 mobile home installation mobile home installation should be in accordance with the manufactured home and safety standard (hud), cfr 3280, part 24. 1. Outside combustion air is mandatory in mobile or modular home installations. An outside air i...

  • Page 11: Installation

    Thelin hearth products, inc. Gnome pellet stove 11 of 47 installation unpacking and inspecting your stove thelin hearth products packages your stove to ensure safe delivery. Each stove is surrounded by impact absorbent material as well as load shift indicators. However, damage can still occur while ...

  • Page 12

    Thelin hearth products, inc. Gnome pellet stove 12 of 47 figure 2 figure 1 figure 3 check with local building code officials for specific requirements. Clearance to combustibles unit to sidewall ........................... 5" (125 mm) unit to back wall ......................... 1.5" (40 mm) unit to ...

  • Page 13

    Thelin hearth products, inc. Gnome pellet stove 13 of 47 figure 4.

  • Page 14

    Thelin hearth products, inc. Gnome pellet stove 14 of 47 horizontal installation with vertical rise 1. Hook up the pipe adapter to the rear exhaust flange of the stove, and silicone with 500 degree high-temp rtv silicone. Screw together with at least three sheet metal screws. 2. When exiting through...

  • Page 15

    Thelin hearth products, inc. Gnome pellet stove 15 of 47 figure 5.

  • Page 16

    Thelin hearth products, inc. Gnome pellet stove 16 of 47 figure 6.

  • Page 17

    Thelin hearth products, inc. Gnome pellet stove 17 of 47 vertical installation a. All vertical runs require 4” type l pipe (figure 7 and 8). B. Connect a vent tee with clean out cap and maintain a minimum 3” clearance to combustibles. C. When exiting through the roof, a minimum of at least 12” clear...

  • Page 18

    Thelin hearth products, inc. Gnome pellet stove 18 of 47 figure 7.

  • Page 19

    Thelin hearth products, inc. Gnome pellet stove 19 of 47 figure 8.

  • Page 20

    Thelin hearth products, inc. Gnome pellet stove 20 of 47 figure 9.

  • Page 21

    Thelin hearth products, inc. Gnome pellet stove 21 of 47 figure 10

  • Page 22

    Thelin hearth products, inc. Gnome pellet stove 22 of 47 figure 11 proper venting occasionally, the vent configuration can create a noisy, harmonic condition. This sound can be eliminated by closing the air damper located on the air intake tube on the rear of the stove..

  • Page 23

    Thelin hearth products, inc. Gnome pellet stove 23 of 47 the gnome pellet stove is equipped with a blocked flue/high temp safety sensor that will shut the stove off if there is a down draft, blocked flue, or high temperature condition. If you install the stove on the side of the house that is hit by...

  • Page 24

    Thelin hearth products, inc. Gnome pellet stove 24 of 47 figure 12.

  • Page 25

    Thelin hearth products, inc. Gnome pellet stove 25 of 47 figure 13.

  • Page 26: Operation

    Thelin hearth products, inc. Gnome pellet stove 26 of 47 figure 14 operation start-up and operation – control panel.

  • Page 27

    Thelin hearth products, inc. Gnome pellet stove 27 of 47 open hopper lid and remove all manuals and materials shipped with stove. Open front door and remove contents. Fill hopper with pellets. The gnome pellet stove will hold approximately 28 pounds of pellets. The hopper lid must be closed before o...

  • Page 28

    Thelin hearth products, inc. Gnome pellet stove 28 of 47 start up and operation - handheld remote and thermostat a wall thermostat or remote thermostat can be used to automatically control the gnome pellet stove. The thermostat or handheld remote provides the option of turning the stove on and off. ...

  • Page 29

    Thelin hearth products, inc. Gnome pellet stove 29 of 47 1. Unplug stove from power supply (both ac and dc). 2. Locate thermostat terminal at the bottom of the stove (see figure 9). 3. Remove metal shunt or known as “jumper”, and save for future use. Hook up thermostat wires to the two terminals. Fo...

  • Page 30

    Thelin hearth products, inc. Gnome pellet stove 30 of 47 4. When you wish to turn off your gnome pellet stove simply push the off button on the handheld remote or the wall thermostat and the feed will immediately cease. The fan will continue to run until the stove cools down and then it will shut of...

  • Page 31

    Thelin hearth products, inc. Gnome pellet stove 31 of 47 figure 12 1. In the low position, the gnome pellet stove will feed approximately 1 to 1.5 pounds of pellets per hour. Feed rate will depend upon size of the pellets, quality of pellets and the feed trim setting. 2. In the med position, the gno...

  • Page 32

    Thelin hearth products, inc. Gnome pellet stove 32 of 47 this indicator light will blink red if there is a blocked flue due to ash buildup or high wind conditions creating back draft. The indicator light will come on steady red if there is a hi-temp condition such as lint and dust build-up on the fa...

  • Page 33

    Thelin hearth products, inc. Gnome pellet stove 33 of 47 warning make sure the red cable goes to the red terminal and the black cable goes to the black terminal. If you hook these up correctly the batt light will glow green. If you hook them up backward the batt light will glow red and the backup wi...

  • Page 34: Maintenance

    Thelin hearth products, inc. Gnome pellet stove 34 of 47 maintenance the gnome pellet stove requires routine maintenance for maximum performance and prolonged life of parts and components. Maintenance is mandatory for warranty to remain in effect. Always disconnect power cord before servicing. Risk ...

  • Page 35

    Thelin hearth products, inc. Gnome pellet stove 35 of 47 weekly maintenance figure 13 the following is a step-by-step procedure to clean out and maintain your pellet stove. 1. Stove must be shut off and completely cold before performing this maintenance. 2. Open door; remove fire pot and clean-out c...

  • Page 36

    Thelin hearth products, inc. Gnome pellet stove 36 of 47 6. Replace clean-out covers and fire pot. The stove is now ready to use. Ash removal 1. Vacuum firebox and inside of door frame of ash build up and soot weekly or more often as needed. 2. Remove the two rear left and right clean out covers and...

  • Page 37

    Thelin hearth products, inc. Gnome pellet stove 37 of 47 yearly maintenance note: the following should only be performed by service and maintenance personnel familiar with both pellet stoves and in particular thelin’s product-line. We recommend you consult a thelin hearth product’s dealer for a prof...

  • Page 38

    Thelin hearth products, inc. Gnome pellet stove 38 of 47 12. Reinstall previously removed bottom plate making certain the air intake is aligned and tighten the 4 screws. 13. Reinstall stove to exhaust vent and outside air intake making certain to fully seal exhaust vent with high temperature silicon...

  • Page 39: Troubleshooting Guide

    Thelin hearth products, inc. Gnome pellet stove 39 of 47 troubleshooting guide.

  • Page 40: Parts List

    Thelin hearth products, inc. Gome pellet stove 40 of 47 figure 14 – replacement parts list figure 15 - replacement parts list parts list.

  • Page 41: Diagrams

    Thelin hearth products, inc. Gome pellet stove 41 of 47 diagrams circuit board diagram figure 18 - electrical schematic/wiring diagram figure 19 - igniter location figure 15 type 1 – thermostat on/off type 2 – thermostat hi/low.

  • Page 42

    Thelin hearth products, inc. Gome pellet stove 42 of 47 electrical schematic/wiring diagram figure 16.

  • Page 43

    Thelin hearth products, inc. Gome pellet stove 43 of 47 figure 17 air damper (butterfly valve) occasionally, the vent configuration can create a noisy, harmonic condition. This sound can be eliminated by closing the air damper located on the bottom front of the stove under the bottom ring. This pell...

  • Page 44

    Thelin hearth products, inc. Gome pellet stove 44 of 47 figure 18 e.I. Firepot assembly.

  • Page 45

    Thelin hearth products, inc. Gome pellet stove 45 of 47 figure 19 figure 19.

  • Page 46

    Thelin hearth products, inc. Gome pellet stove 46 of 47 warranty thelin hearth products pellet stove warranty replacement program effective april 1, 2013 note: please read this warranty replacement program carefully before applying for warranty replacements or credit. Warranty coverage – this warran...

  • Page 47

    Thelin hearth products, inc. Gome pellet stove 47 of 47 return product or defective part with proof of purchase and narrative description of defect together with your name and address, to: thelin hearth products, warranty division, 1312 striker avenue suite 101, sacramento, ca. 95834. Returned part ...