1. DL manuals
  2. Thelin
  3. Gas Heater
  4. GNOME
  5. Installation And Operating Instructions Manual

Thelin GNOME Installation And Operating Instructions Manual

Manual is about: DIRECT VENT GAS HEATER

Summary of GNOME

  • Page 1

    Gnome direct vent gas heater installation and operating instructions th-ref-sls-231 rev. A made in the usa by: installer: please leave this manual with the customer! Customer: please keep instructions for future reference please read this entire manual before installation. Save these instructions..

  • Page 2

    Gnome 3000 direct vent gas heater 2 safety notices for your safety do not store or use gasoline or any other flammable vapors or liquids in the vicinity of this or any other appliance what to do if you smell gas  do not try to light any appliance.  open windows.  do not touch electrical switches....

  • Page 3

    Gnome 3000 direct vent gas heater 3 safety notices if this appliance is not properly installed, a house fire, or explosion may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and installation requirements in your area. Please r...

  • Page 4

    Gnome 3000 direct vent gas heater 4 installation this appliance is suitable for installation in a bedroom or bed sitting room. This appliance may be installed in an aftermarket permanently located, manufactured (mobile) home, where not prohibited by local codes. This appliance is only for use with t...

  • Page 5

    Gnome direct vent gas heater 5 index of contents airflow, 9 alcove installation, 17 appendix a, 35 appendix b, 36 bedroom installation, 14 burner inspection, 25 burner on/off switch, 22 chrome polishing, 27 cleaning fan, 25 glass, 32 gold-plated parts, 27 clearance to combustibles, 11, 14 control co...

  • Page 6

    Gnome direct vent gas heater 6 figures figure 1– diagram of dimensions ........................................................................................................................ 10 figure 2 – clearance to combustibles .......................................................................

  • Page 7

    Gnome direct vent gas heater 7 warning failure to follow the information in this manual exactly could result in a fire, explosion resulting in property damage, personal injury, and loss of life. Do not store or use gasoline or other flammable liquids in the vicinity of this or any other appliance. W...

  • Page 8

    Gnome direct vent gas heater 8 laboratory listing label.

  • Page 9

    Gnome direct vent gas heater 9 introduction and safety information thelin hearth products would like to thank you for choosing our gnome direct vent gas appliance. Whether using a natural gas or liquid propane gas, please read the following safety information thoroughly before installing or lighting...

  • Page 10

    Gnome direct vent gas heater 10 figure 1– diagram of dimensions.

  • Page 11

    Gnome direct vent gas heater 11 figure 2 – clearance to combustibles use these diagrams to locate stove in the room. Note “cornerwall” means from the back of the stove to the corner..

  • Page 12

    Gnome direct vent gas heater 12 water or any corrosion occurs. Do not operate if you suspect any improper operation. Call your dealer. Door and logs always allow the heater to cool before carrying out any maintenance or cleaning. The viewing door should be opened for service only (see maintenance se...

  • Page 13

    Gnome direct vent gas heater 13 figure 3 – bottom view showing air shutter and location for pressure gauge insertion (burner must be removed to access air shutter) orifice information factory installed orifices are as follows: natural gas = #43 (up to 4,500’ elevation) lp gas = #55 (up to 4,500’ ele...

  • Page 14

    Gnome direct vent gas heater 14 orifice size the orifices are factory installed for altitudes up to 4,500 feet. If installing in a higher altitude check the orifice information (see figure 3). Electrical rating room fan electrical rating is 115 v, 1.3 a, 60 hz. Dimensions see figure 1 for heater dim...

  • Page 15

    Gnome direct vent gas heater 15 figure 4 – vent termination locations.

  • Page 16

    Gnome direct vent gas heater 16 b. Clearance to window or door that may be opened: canadian installation: 6” minimum (15 cm) for appliances 10,000 btuh (3 kw); 12” (30 cm) for appliances > 10,000 btuh (3 kw) and 100,000 btuh (30 kw), 36” (91 cm) for appliances > 100,000 btuh (30 kw) u.S. Installatio...

  • Page 17

    Gnome direct vent gas heater 17 mobile home installation direct vent appliances installed in mobile homes must be secured to the floor in a minimum of two locations. Drill holes through the two back legs and counter sink and secure with lag screws. Fill counter sink holes with putty or furnace cemen...

  • Page 18

    Gnome direct vent gas heater 18 figure 5 – diagram of venting requirements.

  • Page 19

    Gnome direct vent gas heater 19 vertical installation vertical installation is acceptable: be aware of the following conditions: vertical rises can sometimes create turbulence which will put out the pilot light. In this event the air intake restrictor disks (see appendix a) will have to be adjusted ...

  • Page 20

    Gnome direct vent gas heater 20 figure 6 – pipe configurations.

  • Page 21

    Gnome direct vent gas heater 21 figure 7 – vent termination wind flow over roof structures can often cause localized pressure disturbances. Vent termination must take into account these disturbances and minimize them by using the following table to maintain the correct legal height of the vent. Note...

  • Page 22

    Gnome direct vent gas heater 22 operation location of controls see figure 9 for location of controls. Control functions are outlined below. Gas control knob this knob is used for starting the pilot and has three (3) positions: on, off, and pilot. The pointer directly above the knob indicates the pos...

  • Page 23

    Gnome direct vent gas heater 23 figure 8- location of pilot, burners, and logs burner and pilot checks a periodic check of the pilot and burner lames should be made. Check after the fire has been on for at least 30 minutes. The pilot flame must cover the tip of the thermocouple and thermopile probes...

  • Page 24

    Gnome direct vent gas heater 24 figure 9 – diagram of control components.

  • Page 25

    Gnome direct vent gas heater 25 lighting the pilot stop! Read the following safety information before lighting. This heater is equipped with an ignition device which must be lighted by hand. When lighting the pilot, follow these instructions exactly. Before lighting, smell all around the appliance a...

  • Page 26

    Gnome direct vent gas heater 26 lighting instructions for your safety, read before lighting warning: if you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. 1. Stop! Read the safety information above. 2. Set the thermo...

  • Page 27

    Gnome direct vent gas heater 27 glass replacement warning: do not operate this appliance with the glass removed, cracked, or broken. Replacement of glass should be done by a licensed or qualified service technician. Glass replacement can be done by lifting the door off the stove and removing the fac...

  • Page 28

    Gnome direct vent gas heater 28 troubleshooting warning: all servicing and troubleshooting of gas controls and high voltage circuits should be done by a qualified service technician. As a guide to help you understand the functioning and potential problem areas in your heater, use the following chart...

  • Page 29

    Gnome direct vent gas heater 29 replacement parts list replacement parts are available at your dealer. The parts listed below are the only parts that the consumer may replace. All other parts must be replaced by a qualified gas service person. Part description door gasket white 3/8” dia. Fiberglass ...

  • Page 30

    Gnome direct vent gas heater 30 figure 10 – wiring diagram.

  • Page 31

    Gnome direct vent gas heater 31 thelin hearth products limited warranty thelin hearth products warrants the gnome direct vent gas heater against defects in material and workmanship for a period of five (5) years from the date of purchase with the exception of the electrical components, gaskets, logs...

  • Page 32

    Gnome direct vent gas heater 32 figure 11 – directions for enabling door – opening & securing door cleaning glass 1. Turn off stove and let cool down. 2. Open door and clean glass with glass cleaner (i.E., windex or similar product) and wipe with soft cloth. 3. Fasten door securely before relighting...

  • Page 33

    Gnome direct vent gas heater 33 figure 12 – delayed ignition safety door this unit is equipped with a safety door system that will prevent damage if the stove ignites with delayed combustion. If this happens, have a qualified service person determine the cause of the delayed ignition..

  • Page 34

    Gnome direct vent gas heater 34 figure 13– gas valve and pilot assembly.

  • Page 35

    Gnome direct vent gas heater 35 appendix a– vertical pipe installation air intake restrictor disks.

  • Page 36

    Gnome direct vent gas heater 36 appendix b – gnome stove with burner.

  • Page 37

    Gnome direct vent gas heater.