1. DL manuals
  2. Thelin
  3. Stove
  4. TIBURON PELLET STOVE
  5. Owner's Manual

Thelin TIBURON PELLET STOVE Owner's Manual

Manual is about: TIBURON PELLET STOVE

Summary of TIBURON PELLET STOVE

  • Page 1

    Thelin hearth products, inc. Tiburon pellet stove 1 of 39 tiburon pellet stove owner’s manual leave this manual with the owner. Please read this entire manual before installation and use of the pellet fuel-burning stove. Failure to follow these instructions could result in property damage, bodily in...

  • Page 2

    Thelin hearth products, inc. Tiburon pellet stove 2 of 39 table of contents introduction ............................................................................................................................................................................ 4 safety information ....................

  • Page 3

    Thelin hearth products, inc. Tiburon pellet stove 3 of 39 parts list ............................................................................................................................................................................... 35 figure 14 – replacement parts list ....................

  • Page 4: Introduction

    Thelin hearth products, inc. Tiburon pellet stove 4 of 39 congratulations on your purchase of thelin hearth products tiburon pellet stove! In this manual you will find information on stove specifications, installation instructions, operating guide, how to perform scheduled maintenance, a troubleshoo...

  • Page 5

    Thelin hearth products, inc. Tiburon pellet stove 5 of 39 do not overfire. If any external part starts to glow, you are over firing. Reduce feed rate. Overfiring or any such action that may cause a fire hazard including failure to perform regular maintenance as outlined in these instructions will vo...

  • Page 6

    Thelin hearth products, inc. Tiburon pellet stove 6 of 39 laboratory listing label.

  • Page 7

    Thelin hearth products, inc. Tiburon pellet stove 7 of 39 warnings hot surfaces! Hot glass will cause burns. Surfaces and glass are hot during operation and during cool-down period. Do not touch glass until it is cooled. Never allow children to touch glass. Alert children to hazards of high temperat...

  • Page 8

    Thelin hearth products, inc. Tiburon pellet stove 8 of 39 the stove may be installed as a free-standing unit mounted on a non-combustible protective floor pad or hearth. Non-combustible floor protection is required and must be used when placing the stove on any combustible material. Caution: do not ...

  • Page 9: Specifications

    Thelin hearth products, inc. Tiburon pellet stove 9 of 39 specifications figure 1 figure 2.

  • Page 10: Vent Information

    Thelin hearth products, inc. Tiburon pellet stove 10 of 39 vent information install vent clearances as specified in this owner’s manual. Use type l 3” or 4” pellet vent pipe depending on your installation. Secure pipe adapter to rear flange with 500 degree high-temp rtv silicone and using at least t...

  • Page 11

    Thelin hearth products, inc. Tiburon pellet stove 11 of 39 mobile home installation mobile home installation should be in accordance with the manufactured home and safety standard (hud), cfr 3280, part 24. 1. Outside combustion air is mandatory in mobile or modular home installations. An outside air...

  • Page 12: Installation

    Thelin hearth products, inc. Tiburon pellet stove 12 of 39 installation unpacking and inspecting your stove thelin hearth products packages your stove to ensure safe delivery. Each stove is surrounded by impact absorbent material as well as load shift indicators. However, damage can still occur whil...

  • Page 13

    Thelin hearth products, inc. Tiburon pellet stove 13 of 39 6. A non-combustible hearth pad must be used if installed on a carpet, wood floor, or other combustible material (see figure 3). Maintain 6” (152mm) beyond the front and beyond each side of the fuel loading and ash removal opening. 7. Keep f...

  • Page 14

    Thelin hearth products, inc. Tiburon pellet stove 14 of 39 figure 4.

  • Page 15

    Thelin hearth products, inc. Tiburon pellet stove 15 of 39 figure 5.

  • Page 16

    Thelin hearth products, inc. Tiburon pellet stove 16 of 39 figure 6.

  • Page 17

    Thelin hearth products, inc. Tiburon pellet stove 17 of 39 horizontal installation with vertical rise 1. Hook up the pipe adapter to the rear exhaust flange of the stove, and silicone with 500 degree high-temp rtv silicone. Screw together with at least three sheet metal screws. . 2. When exiting thr...

  • Page 18

    Thelin hearth products, inc. Tiburon pellet stove 18 of 39 figure 7 vertical installation a. All vertical runs require 4” type l pipe. (figure 4 and 5) b. Connect a vent tee with clean out cap and maintain a minimum 3” clearance to combustibles. C. When exiting through the roof, a minimum of at leas...

  • Page 19

    Thelin hearth products, inc. Tiburon pellet stove 19 of 39 3. Outside air hook-up: an aluminum flex pipe can be used to bring combustion air into the stove. See 2 ¼” round pipe with air shutter located on the rear of the stove. Use a stainless hose clamp to attach flex pipe to the stove air intake f...

  • Page 20: Operation

    Thelin hearth products, inc. Tiburon pellet stove 20 of 39 operation start-up and operation – control panel open hopper lid and remove all manuals and materials shipped with stove. Open front door and remove contents. Fill hopper with pellets. The tiburon stove will hold approximately 50 pounds of p...

  • Page 21

    Thelin hearth products, inc. Tiburon pellet stove 21 of 39 start up and operation - handheld remote and thermostat a wall thermostat or remote thermostat can be used to automatically control the tiburon stove. The thermostat or handheld remote provides the option of turning the stove on and off. Her...

  • Page 22

    Thelin hearth products, inc. Tiburon pellet stove 22 of 39 shortly thereafter, the automatic igniter will light the pellets in the firepot. Initially, the startup mode will take up to 10 – 20 minutes. The unit will then automatically go into your selected medium or high selection. After start-up mod...

  • Page 23

    Thelin hearth products, inc. Tiburon pellet stove 23 of 39 figure 8 figure 9.

  • Page 24

    Thelin hearth products, inc. Tiburon pellet stove 24 of 39 figure 10 figure 11.

  • Page 25

    Thelin hearth products, inc. Tiburon pellet stove 25 of 39 control functions the push-button control settings on the tiburon stove are as follows: off, fan, low, med, high, and clean (see figure 12). Figure 12 1. In the low position, the tiburon stove will feed approximately 2 pounds of pellets per ...

  • Page 26

    Thelin hearth products, inc. Tiburon pellet stove 26 of 39 high temperature / flue, trim, and battery indicators high temp/flue indicator there is a small red light to the top left of the fan button on the control panel. This indicator light will blink red if there is a blocked flue due to ash build...

  • Page 27

    Thelin hearth products, inc. Tiburon pellet stove 27 of 39 7. The battery switch should be set to internal battery to start and maintain the trickle charge. Note: it is not recommended to leave stove unplugged, as the battery will lose its’ charge. External battery backup operation 1. Place the exte...

  • Page 28

    Thelin hearth products, inc. Tiburon pellet stove 28 of 39 3. Run time on the battery will depend upon the amperage of the battery. See your local battery store for details. 4. If you wish to place the battery beyond 4 ft from the stove you will need to increase the wire size of the cable. Check wit...

  • Page 29: Maintenance

    Thelin hearth products, inc. Tiburon pellet stove 29 of 39 maintenance the tiburon pellet stove requires routine maintenance for maximum performance and prolonged life of parts and components. Maintenance is mandatory for warranty to remain in effect. Always disconnect power cord before servicing. R...

  • Page 30

    Thelin hearth products, inc. Tiburon pellet stove 30 of 39 3. While clean out covers are removed, vacuum and wire brush heat exchanger. Connect the supplied vinyl clean out tube to ash vacuum or shop vac (an adapter may be needed, which can be purchased at a home center) for a more thorough clean up...

  • Page 31

    Thelin hearth products, inc. Tiburon pellet stove 31 of 39 combustion blower fan 1. Make certain stove is unplugged from power outlet. 2. Stove may need to be removed from the exhaust vent and outside air intake to access rear compartment. 3. Remove 6 screws on the upper rear panel and remove air in...

  • Page 32

    Thelin hearth products, inc. Tiburon pellet stove 32 of 39 handheld remote (if applicable) battery replacement: thp recommends consideration be given to replacing all batteries at a minimum of every 6 months. There are batteries both in the handheld remote, and the black receiver located at the rear...

  • Page 33

    Thelin hearth products, inc. Tiburon pellet stove 33 of 39 figure 13.

  • Page 34: Troubleshooting Guide

    Thelin hearth products, inc. Tiburon pellet stove 34 of 39 troubleshooting guide.

  • Page 35: Parts List

    Thelin hearth products, inc. Tiburon pellet stove 35 of 39 parts list figure 14 – replacement parts list.

  • Page 36: Diagrams

    Thelin hearth products, inc. Tiburon pellet stove 36 of 39 diagrams figure 15 – circuit board diagram figure 18 - electrical schematic/wiring diagram figure 19 - igniter location.

  • Page 37

    Thelin hearth products, inc. Tiburon pellet stove 37 of 39 figure 16 - electrical schematic/wiring diagram.

  • Page 38

    Thelin hearth products, inc. Tiburon pellet stove 38 of 39 warranty thelin hearth products pellet stove warranty replacement program effective april 1, 2013 note: please read this warranty replacement program carefully before applying for warranty replacements or credit. Warranty coverage – this war...

  • Page 39

    Thelin hearth products, inc. Tiburon pellet stove 39 of 39 thelin hearth products 1312 striker avenue suite 101 sacramento, ca. 95834.