Model fm 1000 electronic & media air cleaner installation operation service please read these instructions carefully for trouble free operation and to get the most out of your purchase. For further information concerning this project, contact your local trion representative 101 mcneill road • sanfor...
2 specifications fm 1000 electrostatic input voltage: 120 v, 60 hz, 1 ph amp draw: 3.1 max. Unit weight: 108 lbs. Air output: 600, 800 and 1100 cfm (nominal) options: 1. Charcoal after filter 2. Remote discharge fm 1000 media input voltage: 120 v, 60 hz, 1 ph amp draw: 4.0 max unit weight: 88 lbs. A...
3 3. Open filter access door and remove it. Also remove both collector cells or media filter and set aside being careful not to damage either. 4. Install eyebolts provided with unit as shown in sketch a. 5. Select mounting location as near to the center of the area to be cleaned or at the point reco...
4 will notice a light film, then a very definite collection will be evident at a later examination. When there is a noticeable build-up of dirt, it is time to wash. In most areas the collecting cell should be washed every 12 weeks. Note: dirt build-up on the ionizing–collecting cell should not be co...
5 troubleshooting problem solution unit does not operate light not on 1. Check 120 vac input power 2. Broken lead in power cord 3. Bad speed controller light on blower does not run 1. Broken wire between the speed controller and the motor 2. Bad motor capacitor 3. Bad motor.
6.
7 fm 1000 e & m unit assembly parts list item part number description 1 440549-001 discharge grill (2 req.) 2 227833-006 charcoal afterfilter (2 req.) 3 228276-001 switch, 3 speed rotary 4 139999-001 knob, switch 4a 244223-001 label, control switch esp (not shown) 4b 244224-001 label, control switch...
8 6a 244225-004 retainer (2 req.) 6b 120456-001 nylon washer (2 req.) (not shown) 7 440541-001 access door 8 422086-504 ionizer/collector cell (electrostatic) 9 340553-001 pleated media filter (media) 10 140551-001 4 blade fan (electrostatic) 10a 140552-001 5 blade fan (media) 11 240537-001 collecto...
9.
10
11.
12 fm 1000e wiring diagram.
13.
14 fm 1000m wiring diagram.
Warranty all trion air cleaners are warranted for component failure and workmanship for a period of three years after purchase. Do not return defective parts without prior permission from the factory. Contact your local trion distributor or trion customer service department at 1-800-884-002 of fax 1...
