1. DL manuals
  2. Triple E
  3. Motorhomes
  4. COMMANDER Series
  5. Owner's Manual

Triple E COMMANDER Series Owner's Manual

Other manuals for COMMANDER Series: Owner's manual
Manual is about: COMMANDER AND EMBASSY SERIES

Summary of COMMANDER Series

  • Page 1

    Commander & embassy motorhome owners manual experience the difference.

  • Page 3: Forward

    Forward a word to motorhome owners welcome to the growing number of discerning peo- ple who own and operate a triple e motorhome. Our company takes great pride in the quality and excellence that the triple e name represents. We have sought to anticipate your needs and desires with respect to safety,...

  • Page 4: Table of Contents

    Table of contents section description page section description 1 introduction .............................................. 1-1 1.1 operator's manuals ........................ 1-1 1.2 information kit ................................ 1-1 1.3 options and equipment ................. 1-1 1.4 keys ........

  • Page 5: Table of Contents

    Table of contents section description page section description 11 lp gas system ..................................... 11-1 11.1 safe use of lp gas ..................... 11-1 11.2 how lp gas works ...................... 11-1 11.3 selecting fuel types ................... 11-2 11.4 lp tank system ........

  • Page 6: Table of Contents

    Table of contents section description page section description 13.1.3 exterior refrigerator compartment ............................... 13-2 13.2 range and oven ......................... 13-2 13.2.1 lighting burners ........................... 13-2 13.2.2 safety tips ...................................

  • Page 7: 1     Introduction

    1-1 commander / embassy 1 introduction congratulations on your choice of a triple e built motorhome for your travelling and touring comfort and enjoyment. It utilizes the latest design features and manufacturing techniques to insure safe, effi cient and trouble-free operation at all times. 1.1 operat...

  • Page 8

    1-2 1.5 vehicle certification label this label contains vehicle identifi cation and other important reference information. The vehicle certifi ca- tion label is located on the sidewall to the left of the steering wheel, or on the driver's door. Never remove or destroy this label. Reference number code...

  • Page 9

    1-3 fig. 1-2 vehicle labels canadian u.S. Fig. 1-3 identification information (label location) commander / embassy.

  • Page 10

    1-4 1.6 identification information take a few minutes to fi ll in this information. It will be a handy reference for you. (some appliances may be optional). The label is located on the sidewall to the left of the steering wheel or on the driver's side door. Your name ______________________________ mo...

  • Page 11

    1-5 1.7 exterior feature identification - commander model composite model shown for illustration purposes only. Actual locations of features depends on coach model and options. *caution be careful. These features may become hot while water heater or furnace are in use. Note some equipment shown may ...

  • Page 12

    1-6 embassy model composite model shown for illustration purposes only. Actual locations of features depends on coach model and options. *caution be careful. These features may become hot while water heater or furnace are in use. Note some equipment shown may be optional. Fig. 1-6 exterior identific...

  • Page 13

    1-7 1.8 service assistance your dealer will be glad to provide any additional information you need and to answer any questions you may have about the operation of your mo- torhome. When it comes time for service, remem- ber that your dealer knows your vehicle best and is interested in your satisfact...

  • Page 14: 2     Safety

    2-1 the safety glyph identifi es an area that involves the personal safety of the operator, pas- sengers or a bystander. Always read, understand and follow the instructions and information in the safety sign or manual instruction. Do not take chances with safety. Most accidents can be pre- vented. In...

  • Page 15

    2-2 2.2 driving safety 1. Only trained and licensed drivers are allowed to drive this vehicle. 2. Observe all applicable road and driving regula- tions. Check with local transport authorities if you have any questions. 3. Inspect the vehicle before driving. Adjust, repair or replace components or sy...

  • Page 16: Warning

    2-3 2.4 minimizing asphyxiation risk 1. Do not use portable fuel-burning equipment including wood and charcoal grills and stoves in the vehicle. The use of this equipment can generate deadly carbon monoxide gas or cause fi res. 2. Provide proper ventilation when using the gas range or oven to prevent...

  • Page 17

    2-4 2.7 alarms 1. Each vehicle is equipped with a lp gas alarm: a. Sounds whenever there is an unsafe amount of gas in the vehicle. B. Follow instructions on safety sign and air out vehicle to silence alarm. C. Have a qualifi ed service personnel fi nd the leak and correct the problem before using uni...

  • Page 18

    2-5 2.9 loose components 2.10 maintenance 1. Do not attempt to start vehicle by hot wiring or shorting across starter terminals. 2. Do not remove radiator cap when radiator or engine is hot. Steam or hot fl uid can be released. Check coolant level using overfl ow reservoir. 3. Do not go under a vehicl...

  • Page 19: 3     Preparation

    3-1 3 preparation refer to information pack supplied with the mo- torhome prior to using or driving the unit. Read, understand and follow instructions in the chassis, motorhome, appliance and system manuals. Also follow the safety tips provided in section 2. Mo- torhomes can be used many ways and in...

  • Page 20: Warning

    3-2 3.1.3 trailer towing a trailer can affect the handling, durability, performance and economy of your mo- torhome. The factory installed towing hitch is rated for: a. 500 lb. - maximum hitch or tongue weight. B. 5000 lb. - maximum trailer weight. Fig. 3-1 trailer hitch the combined weight of the m...

  • Page 21: Warning

    3-3 3.1.5 parking, levelling and blocking try to pick a spot as level as possible on which to park your motorhome. You may choose to drive in or back in depending on your personal preference. Remember, however, that all your utility connec- tions (water, sewer, electrical, etc.) are all located on t...

  • Page 22: 4     Controls

    4-1 4 controls it is the responsibility of each owner, operator, driver or user to be familiar with the positions, functions and settings of all controls. Each new person should be trained in all aspects of motorhome operation prior to starting. Review this section as often as required to understand...

  • Page 23

    4-2 fig. 4-2 right side - upper commander / embassy 4.2 dash controls 1. Right side: a. Am/fm cd deck: this is a standard am/fm compact disc deck. Refer to the decks manufacturers manual in the information package for more details. An optional cas- sette deck is also available. B. Climate control: t...

  • Page 24

    4-3 commander / embassy d. Mirror adjustment - command- er only: this cluster of switches controls the position of the rear view mirrors on both sides. Use the center switch to select the left or right mirror. Depress and hold the four outer switches as re- quired to move the mirror to the desired p...

  • Page 25

    This rocker switch sets the position of the drivers door window. Depress and hold the foward portion of the switch to raise the window and back portion to lower. 4-4 4. Left side - under dash: a. Intruder alarm switch - (op- tional commander only): this push button switch con- trols the valet featur...

  • Page 26

    4-5 commander / embassy fig. 4-7 co-pilot seat control (typical) fig. 4-7 co-pilot seat control (typical) 4.4 drivers/co-pilot seat 1. Forward-back position: both the drivers and co- pilot seats are designed with a sliding base to allow the seat to be moved forward or backward for occupant com- fort...

  • Page 27

    4-6 commander / embassy fig. 4-9 lap/shoulder belt important all seat belt retractors are equipped with locks that engage when the belt moves too fast. Move the spade end slowly and steadily when fastening to prevent locking. If belt locks while fastening, release end and let it retract fully. Then ...

  • Page 28

    4-7 2. Lap belts: only seats equipped with seat belts are approved for use by occupants while the vehicle is moving. Never travel in a seat that is not equipped with a lap or shoulder belt. A. Sit in the seat and rotate the chair to its locked position. B. Pull the spade end of the seat belt across ...

  • Page 29

    4-8 4.7 front upper cabinets certain pieces of entertainment equipment are installed inside the front upper cabinets for conven- ience and looks. 1. Center: a. Vcr (optional): this is a standard vcr and is a part of the vehicle entertainment system. Refer to the instructions in the information packa...

  • Page 30

    4-9 4.8 bedroom tv - (optional, n/a embassy a-27) a motorhome can be equipped with a tv in the bedroom. Although it func- tions like a standard tv, it is recom- mended that the operator's manual in the information pack be reviewed prior to use. Use in conjunction with the input selector to select th...

  • Page 31

    4-10 commander / embassy 4.9 side entry the side entry doorway left wall is equipped with a switch panel that controls the following functions: 1. Porch light: this 2 position rocker switch controls the power to the outside porch light. Depress the upper portion of the switch to turn the porch light...

  • Page 32

    4-11 4.10 refrigerator the refrigerator control panel is located directly above the fridge and includes switches and several indica- tor lights. 1. Master on/off switch: this latching push button switch controls the power to the refrig- erator. Depress the switch and it will latch in the depressed p...

  • Page 33

    4-12 wall celing 4.11 light switches many rocker, slider or standard light switches are used throughout the motorhome to turn lights on and off. If there is any confusion as to which switch and light work together, try the switch. Commander / embassy fig. 4-16 light switches (typical).

  • Page 34

    4-13 4.12 comfort control center a comfort control center is located in the motorhome (living area or bedroom) to control the heating and cooling systems in the vehicle. The control center is customized to the speci- fi cations of your vehicle and will control one or more furnaces and air conditioner...

  • Page 35: Warning

    4-14 4.13 furnace each motorhome is equipped with one or two furnaces depending on the confi guration. They are controlled by the comfort control center. Review the operator's manuals for the furnace and comfort control centre in the information package for more detailed operating rear front do not t...

  • Page 36

    4-15 4.14 thermostatically controlled ceiling fan (optional on embassy) each motorhome is equipped with a roof vent with a reversible fan to pro- vide a controlled air fl ow through the vehicle. Use the vent fan in conjunc- tions with an open window to provide a fl ow of fresh air into the unit. Use t...

  • Page 37: Warning

    4-16 4.15 plumbing a motorhome plumbing system consists of fresh, grey and black water tanks plus a water heater and plumbing. Be sure to review, understand and follow all operating instructions for the sys- 4.15.1 water heater the water heater is located next to an outside wall and is only accessib...

  • Page 38

    4-17 4.15.2 water heater bypass the water heater is equipped with a valve that sets its plumbing circuit for normal or winterize. The valve is accessed from inside the mo- torhome by opening the bottom cab- inet next to the refrigerator. Howev- er, the location can vary depending on your specifi c co...

  • Page 39

    4-18 4.15.3 water pump the water system is equipped with a 12 volt pump that pressurizes the system and moves wa- ter to where it is required. A master switch is lo- cated above the coach doorway to turn the pump on or off as desired. In addition, the commander is equipped with optional auxiliary sw...

  • Page 40

    4-19 4.15.4 utility module (commander only) access the water system compartment through the door on the left side of the vehicle. Review the oper- ating instructions and control functions before trying to use the system. Fig. 4-24 water system access compartment 1. Exterior shower: a. Exterior hot w...

  • Page 41

    4-20 commander / embassy 5. Black water tank flush fitting: this fi tting directs water directly into the black water tank and can be used to rinse the tank when re- quired. Be sure the sewer valve (black water tank valve) is open before the water is turned on. 6. Water system winterizing valve: this...

  • Page 42

    4-21 commander / embassy 4.15.5 water system (embassy only) access the water system compartment through the door on the right side of the vehicle. Review the oper- ating instructions and control functions before trying to use the system. Fig. 4-27 exterior shower 1. Exterior shower (optional) (fig 4...

  • Page 43

    4-22 commander / embassy 3. Black and grey tank dis- charge valves: fig. 4-29 discharge valves a. Black water tank valve: this is the discharge valve for the black water tank. Pull out to open valve and push in to close. Always empty black water tank fi rst and use the gray water tank to fl ush out an...

  • Page 44: Warning

    4-23 4.16 tv antenna each motorhome is equipped with an extendable tv antenna on top of the unit to provide reception at remote locations. Always fully retract antenna whenever vehicle is moved or transported. 1. Extending retracting: this crank controls the position of the an- tenna assembly on top...

  • Page 45

    4-24 commander / embassy fig. 4-31 battery disconnect (commander) 4.17 battery disconnect 4.17.1 commander this switch disconnects the coach batteries from the electrical system when the motorhome is in storage to prevent battery discharge. Depress the upper portion of the switch to con- nect the ba...

  • Page 46: Warning

    4-25 commander / embassy left right fig. 4-34 room locks fig. 4-33 control panel 1. Control panel : this panel controls the operation of the slide-out room in the motorhome. Review the extend/retract procedure before operat- ing these controls. A. Key switch: this key switch controls the power to th...

  • Page 47

    4-26 4.19 system monitor a system monitor is located on the wall next to the doorway. Fig. 4-35 system monitor 1. Status led's: five led's are used to indicate the status of the tanks and bat- tery. The tank scale registers empty, 1/4, 1/2, 3/4 or full. The battery charge condition reg- isters poor,...

  • Page 48

    4-27 commander / embassy 4.20 energy management system (ems) option available - commander only control box 30 amp ems breaker panel fig. 4-36 optional 30 amp ems this system prioritizes and distributes the power from the shoreline or generator to the appliances or other 120 v users. This system disc...

  • Page 49: 5     Driving

    5-1 5 driving always review the chassis manual before starting or moving your motorhome. 5.1 pre-trip inspection 1. Be sure all equipment is serviced and ready for travel. 2. Inspect wheel lugs for tightness. Examine all tires for road damage. Ensure that all tires are infl ated to proper pressure. (...

  • Page 50

    5-2 5.2 emergency equipment check list use this list as a guide to identify the minimum amount of emergency or safety equipment. Take more as appropriate for your travel or personal needs. 1. First aid kit 2. Emergency flares 3. Tool box and tools 4. Plastic bucket 5. Tow rope or chain 6. Wheel bloc...

  • Page 51

    5-3 1. Controls: the motorhome driver controls are automotive type and the steering and braking controls are power assisted to help make driving as com- fortable as possible. However it must be re- membered that the motorhome is much higher, wider and heavier than a family automobile. 2. Handling: t...

  • Page 52

    5-4 5.7 travel tips as you travel with your motorhome you will learn much from your own experiences. Share with other mo- torhome owners and learn from them. Read rv, outdoor and camping magazines for camping and travel tips. Here are a few basic suggestions to make your travel and your camping easi...

  • Page 53

    5-5 5.8 quick loading check-list 1. Bedding: a. Sleeping bag b. Sheets c. Pillow cases and pillows d. Mattress pads e. Extra blankets f. Laundry bags 2. Cooking: a. Can opener b. Bottle opener c. Aluminium foil d. Matches e. Plastic bags f. Coffee pot g. Storage dishes 3. Cleaning: a. Scouring pads ...

  • Page 54

    5-6 5.9 severe weather information as a motorhome traveller you will fi nd the desire to explore new and out-of-the-way places irresistible. These recreational areas can be vulnerable to unusual and severe weather conditions that could endan- ger your safety. A few suggestions and safety precautions ...

  • Page 55

    6-1 6 safety equipment operation triple e has made every effort to design the vehicle to promote safe driving, use and occupancy. In addi- tion, it has several pieces of safety equipment that the drivers and users should be aware of and trained in their use. Review these instructions with all new pe...

  • Page 56

    6-2 6.1.2 fire extinguisher 1. Operation: a. Stay at least 6 feet away from the fi re and near an exit. The chemical from the fi re extinguisher will shoot at least 10 feet. Stay close to the fl oor to avoid heat and fumes. B. Break the seal; grasp the fi re extin- guisher fi rmly holding it in an uprigh...

  • Page 57

    6-3 6.2 emergency escape each motorhome is designed with an alternate emergency exit via a window in the sleeping area. 1. Emergency exit: release the red latches of the emergency egress window and push out the window. (the egress window has hinges on top). 2. Formulate a plan for escape from the ve...

  • Page 58: Warning

    6-4 6.3 alarms each motorhome is equipped with an lp gas, co and smoke alarm as standard safety equipment. An intruder alarm is available as optional equipment on some models. Refer to alarm manual(s) for more detailed instructions. Keep all alarms in good working order. 6.3.1 lp gas alarm this alar...

  • Page 59: Warning

    6-5 6.3.2 carbon monoxide this alarm is located in the up- per cabinets in the living area and sounds when there is an unsafe amount of carbon monoxide in the vehicle. Carbon monoxide gas is a odorless and colorless gas that is lethal to people. Do not breathe any exhaust, heating or cooking fumes t...

  • Page 60

    6-6 6.3.3 smoke alarm this alarm is located in the cabin and sounds whenever there is smoke in the cabin. Always use the exhaust fan, over the stove when cook- ing. Smoke from cooking may trigger the alarm. A. If alarm sounds, check for the presence of a fi re. If fi re is suspected, leave the vehicle...

  • Page 61

    6-7 6.3.4 intruder alarm (optional - commander only) the optional intruder alarm can be connected to the entry doors of your vehicle to protect it from theft or uninvited intrusion. Arm and disarm it using the remote transmitter supplied with the vehi- cle. If you need to turn off the alarm all toge...

  • Page 62

    6-8 6.4 rear view camera/ monitor system (optional) an optional rear view camera/monitor system is available to mount on the back of the unit to provide a view of the back of the unit. Commander / embassy 1. Camera: the camera is mounted to pick-up a view of the area behind the unit for backing up o...

  • Page 63: 7     Travelling

    7-1 7 travelling the motorhome has been designed to provide the driver and passengers maximum comfort and conven- ience while travelling safely from one place to another. It is the responsibility of the owner/operator/driver to review the safety section at the front of this manual and the chassis ma...

  • Page 64: Warning

    7-2 7.3 vehicle weight-loaded when loading the motorhome, make sure that the front or rear gross axle weight rating (gawr) or the gross vehicle weight rating (gvwr) and the gcwr (gross combined weight rating) are not exceeded. Check your vehicle certifi cation label for weights. If in doubt, take you...

  • Page 65: Warning

    7-3 7.6 seat belts 7.6.1 lap belts seats intended for passenger use when travelling are equipped with seat belts. Make sure lap belts are adjusted to a snug fi t and as low on the hips as possible for maximum safety and protection. 7.6.2 shoulder/lap belts the driver and co-pilot seats of your vehicl...

  • Page 66

    7-4 7.6.3 care and cleaning 1. Be careful not to damage the hardware or the webbing of your seat belt. Take care not to pinch them in the seat or doors. 2. Check belts and hardware from time to time. Replace any damaged parts. Do not modify or remove the belt system. 3. Keep belts clean and dry. If ...

  • Page 67: Warning

    7-5 7.8 free standing dinette (optional) your motorhome may be equipped with a free standing dinette. While travelling, these should always be secured with the harness provided to prevent the table and chairs from moving forward in case of sudden braking or a collision and to keep them from sliding ...

  • Page 68

    7-6 3. Fuel tank capacity: check in the chassis manual for capacities. 4. Fuel type: use only gasoline with this vehicle. The generator uses fuel from main tank but the fuel pick-up line is shorter than the engine pick-up tube, to prevent the vehicle fuel tank from be- ing completely emptied while o...

  • Page 69

    8-1 8 emergencies while driving the triple e motorhome is designed with features that allow the driver/occupants to resolve emergencies or failures when travelling. Review this section to be familiar with the recommended procedure to resolve these conditions or situations. Review this section with a...

  • Page 70: Warning

    8-2 8.4 overheating if the engine overheats while driving: 1. Pull off the side of the road and stop immedi- ately. 2. Shut engine off. 3. Check for proper coolant level in the recovery tank. The coolant level should be between the “full” and “add” marks on the tank. 4. If the coolant level is low: ...

  • Page 71

    8-3 8.5 jump starting when the vehicle batteries do not have suffi cient charge to start the engine, there are two ways to start the unit: 1. Coach batteries: depress and hold the switch on the left side of the dash to connect the coach batteries into the starter circuit to use all batteries for star...

  • Page 72: 9     Home Use

    9-1 9 home use the motorhome is designed to be your home on wheels while traveling in comfort. This section will cover the items that must be done or considered in order to obtain the maximum satisfaction from your unit. 9.1 parking 1. Parking: the motorhome can be stopped and parked just like an au...

  • Page 73: Warning

    9-2 c. Operate the joy stick controls to level the motorhome. D. Check that all jacks are down. Place pads under each jack if ground conditions require it. E. A yellow light indicates that the end or the side of the motorhome is low. Move the control lever to raise the corresponding end or side unti...

  • Page 74

    9-3 commander / embassy 9.3 slide out room a motorhome may be equipped with an optional slide out room to provide more living area for the oc- cupants. Triple e supplies a video explaining the operation of the slide out system with each slide out equipped model. Please use this video to familiarize ...

  • Page 75: Warning

    9-4 commander / embassy make very sure that everyone is standing clear of the interior and exterior path of the slide-out as you extend it, and just as important when you warning fig. 9-5 room extended make sure travel locks are removed be- fore extending the slide-out. Make sure travel locks are fa...

  • Page 76

    9-5 commander / embassy 9.3.2 slide out room emergency operation the slide out room and optional bedroom slide out can be manually retracted in case of sys- tem failure. Refer to the triple e supplied video and the hwh or power gear manual for further information. Fig. 9-6 winch anchors.

  • Page 77

    9-6 9.4 slide out room troubleshooting 1. Low battery voltage: a. The most common cause of malfunction is low battery voltage. To ensure adequate power, take the following steps: b. Run the motorhome engine while operat- ing the slide-out. This will ensure that the engine alternator is delivering ex...

  • Page 78: 10     Electrical Systems

    10-1 10 electrical systems your commander / embassy is equipped with two electrical systems operating on separate volt- ages - a 12 volt dc system and a 120 volt ac system. The 12 volt dc system draws its power either from the engine's charging system while driving or from the coach batteries when p...

  • Page 79

    10-2 commander / embassy 10.1.2 power control center - commander only (optional) fig. 10-2 power panel (open doors) this panel contains the fuses for the 12 volt sys- tem, circuit breakers for the 120 volt system. 120v power to 12v dc converter is mounted in compart- ment behind the panel. 10.1.3 12...

  • Page 80: Warning

    10-3 commander / embassy 10.1.4 ground fault circuit interrupter (gfci) various outlets in the motorhome, particularly those near sinks and water supplies, are con- nected to a gfci which is a very sensitive circuit breaker that will protect you from electrical shock if a severe ground fault develop...

  • Page 81: Warning

    10-4 10.2 auxiliary 120 volt generator (optional) refer to the generator owner operator's manual for more detailed instructions. Extreme care and caution should be exercised when handling the generator and its components. Carelessness can be dangerous and even fatal. Never touch any electrical leads...

  • Page 82

    10-5 10.2.2 generator operation 1. Controls: the generator switches are located: a. On the dash board, within easy reach from the driver's seat. B. Above the main entrance door, part of the main control panel. Commander / embassy the generator starter does not draw current from the engine batteries ...

  • Page 83: Warning

    10-6 10.2.3 automatic power transfer switch (commander only) this commander model is equipped with an automatic power transfer switch that transfers the electrical load between the shoreline or genera- tor power source. It automatically transfers all the load to shoreline whenever it is plugged in. ...

  • Page 84

    10-7 10.3 12 volt dc system the dc voltage system in your motorhome consists of two separate and yet connected battery systems: 1. The automotive batteries(or chassis battery) 2. The auxiliary or motorhome batteries (or coach battery) 10.3.1 automotive batteries (chassis) these are used to operate t...

  • Page 85: Warning

    10-8 10.3.3 12 volt coach fuses all 12-volt circuits are protected by either a circuit breaker or a fuse in the control panel. When a breaker trips or a fuse blows, shut off all applianc- es or lights on the affected circuit and reset the breaker or replace the fuse with a new one of the same ampera...

  • Page 86: Warning

    10-9 d. Keep the battery and terminals clean. Accumulations of acid fi lm and dirt may permit current to fl ow between the termi- nals and discharge the battery. E. To clean the battery, wash it with a di- luted solution of baking soda and water to neutralize any acid present, then fl ush with clean wa...

  • Page 87

    10-10 10.3.5 battery condition meter on your control panel you will fi nd a gauge which tells you the level of charge in your coach or auxiliary batteries. 10.4 trailer wiring connector your motorhome is ready for trailer or car towing. It has a wiring connector plug at the back for quick hook-up. Re...

  • Page 88

    10-11 10.5 electrical schematics commander / embassy.

  • Page 89

    10-12 commander / embassy.

  • Page 90

    10-13 10.6 vehicle fuse panels access panel fig. 10-18 vehicle fuse panel commander commander / embassy.

  • Page 91

    10-14 commander / embassy this page left intentionally blank.

  • Page 92: 11     Lp Gas System

    11-1 11 lp gas system lp (liquefi ed petroleum) gas is a colorless gas compressed into liquid form for easy transporta- tion and storage. It is the energy source for your range, oven, furnace, water heater, and an alter- nate source for your refrigerator. It is an excellent fuel source and both safe ...

  • Page 93

    11-2 11.3 selecting fuel types butane burns at a much higher temperature than propane but will not change from a liquid to a gas at temperatures below 32 degrees f or 0 degrees c. Propane, on the other hand, burns at a lower temperature and will continue to convert from a liq- uid to a gas at temper...

  • Page 94: Warning

    11-3 11.6 refilling lp tank a. Fill b. Overfl ow c. Outage d. Vapor simply open the baggage door, and fi ll the contain- er via the fi ll-in valve as indicated on the container. Filling should always be done by a qualifi ed service attendant. Do not smoke when refuelling. Keep fl ames, sparks and smoking...

  • Page 95: Warning

    11-4 after tank has been fi lled: 1. Check all container and line connections peri- odically to be sure they are tight. When testing for leaks, use soapy water (never a match). Lp gas has a distinct garlic odor. 2. If gasoline or lp gas fumes are noticed at any time, the cause should be determined an...

  • Page 96: Warning

    11-5 11.10 lp gas leaks if you ever smell lp gas in the vehicle or the detec- tor alarm sounds, follow the instructions carefully. If you smell gas 1. Extinguish any open fl ame, pilot lights and all smoking material. 2. Do not touch electrical switches. 3. Shut off the lp tank valve. 4. Open doors, ...

  • Page 97

    12-1 12 water/plumbing system your motorhome is designed with a fresh water, grey water, black water systems and associated plumbing to handle all of the water and waste requirements. Review this section carefully to understand each system and how they function together. 12.1 fresh water system ther...

  • Page 98

    12-2 12.1.1 fresh water tank filling procedure the water tank is not a pressure vessel. The fi lling procedure is done via a water pressure sys- tem and cannot be done without available water under pressure. Make sure the vent/overfl ow drain located underneath the tank area is open, free and clear of...

  • Page 99

    12-3 12.1.3 water pump switch the master switch for the water pump is located at the control panel above the entrance door. When this switch is in the on position, the pump will automati- cally activate when any faucet, shower or toilet is being used. On the com- mander, there are switches located a...

  • Page 100

    12-4 12.1.4 water pumps before water can enter the various out- lets in your motorhome it fl ow through a water fi lter. This fi lter is located on the water pump. Check the water fi lter periodically and clean or replace it at least annually to assure a clean supply of water. Commander / embassy fig. 1...

  • Page 101

    12-5 12.1.7 water pump troubleshooting 1. If pump will not prime: a. Make sure there is water in the tank. B. Make sure the battery is not run down. C. Make sure there are no kinks in the inlet hose. D. Make sure all inlet fi ttings and connections are air tight. E. Make sure water selector valve is ...

  • Page 102

    12-6 12.1.9 external water supply commander / embassy the external water source will supply your motorhome water system with water at city pres- sure and does not require the use of the water pump. 1. Connecting: a. Turn water pump switch to off. B. Attach garden hose to city water connection at wat...

  • Page 103

    12-7 12.2 waste systems 12.2.1 grey water - waste holding tank the drainage from the kitchen sinks, bathtub and shower pan is collected in a separate grey water holding tank. This tank has its own dump valve but ties into the same termination valve outlet as the waste holding tank. Drain grey water ...

  • Page 104

    12-8 12.2.3 dumping holding tanks when dumping holding tanks: 1. Remove drain hose from stor- age compartment. 2. Remove dust cap from drain outlet. Attach drain hose se- curely. 3. Place the other end of the hose in sewer opening. 4. Make sure hose is lying fl at. Open black water valve with a quick...

  • Page 105

    12-9 12.2.4 tank rinse (commander only) the motorhome is equipped with a built-in black water waste tank fl ush- ing system. To aid in draining the tank or to remove build-up or odors, attach a water hose to the fl ush con- nection in the utility compartment. Make sure the black tank drain valve is op...

  • Page 106

    12-10 12.2.7 holding tank level indicators fig. 12-13 water heater switch commander / embassy fig. 12-12 lpg to 120v selector switch 12.3 plumbing system operation 12.3.1 water heater your motorhome is equipped with a 6 gallon water heater. The water is heated in one of three ways: 1. With an lp gas...

  • Page 107

    12-11 2. 120-volt operation: open the water heater compartment door. Find the selector switch and set it to 120-volt electrical. Refer to the operating instructions included in the information package. 3. Motor aid water heater (commander only): your motorhome is equipped with a system whereby heat ...

  • Page 108

    12-12 12.3.4 exterior shower (standard on commander optional on embassy) your motorhome may be equipped with and exterior auxiliary shower to allow you to rinse off sand and dirt, to clean muddy footwear or to bathe pets before entering the vehicle. It is located in the utility system compartment on...

  • Page 109

    12-13 12.4.2 plumbing schematics drainage system commander / embassy.

  • Page 110

    13-1 13 appliances and interior features fig. 13-1 refrigerator 13.1.2 operating tips 1. The refrigerator should be cold before placing items in it. 2. Try not to put warm or hot items in the refrig- erator. Allow them to cool off fi rst. 3. Do not pack refrigerator too full. To operate ef- fi ciently...

  • Page 111: Warning

    13-2 13.1.3 exterior refrigerator compartment this compartment allows access to the refrigerator for cleaning, inspection, maintenance and service. It is a good practice to open the compartment door once in a while to make sure that the area is clean and free of any debris that might hinder air circ...

  • Page 112

    13-3 13.2.2 safety tips 1. Always wait 5 minutes before relighting range/ oven to allow gas to dissipate. 2. The range/oven is not designed for and should never be used as a space heater. 3. Do not operate range/oven while travelling or while refuelling your vehicle at a gasoline serv- ice station. ...

  • Page 113

    13-4 13.2.5 operating oven control to adjust the oven temperature, push in the knob and turn it counterclockwise to the desired temper- ature setting. There may be a delay of 45 seconds before the burner is ignited. This is normal. To keep the oven temperature at the set temperature, the burner will...

  • Page 114

    13-5 commander / embassy this page left intentionally blank.

  • Page 115

    13-6 13.4 lp gas furnace the furnace(s) should not be operated when the vehicle is underway, and the lp gas should be turned off at the lp container at any time the mo- torhome is operated on public roads. The furnace is controlled by the climate control center. This device located in the galley are...

  • Page 116: Warning

    13-7 13.5 roof air conditioners the roof air conditioner(s) are controlled by the climate control center. Adjust the control to cool- ing. Select the temperature and the fan speed to suit your needs. 1. Maintenance: we recommend that the fi lters by cleaned or changed at least every two weeks when th...

  • Page 117

    Dash 13-8 commander / embassy 3. Rotating the antenna: after antenna is in the up position, pull down the rotating knob until it disengages the ceiling plate. Rotate the antenna for best sound and picture. 4. Lowering the antenna: rotate the antenna until the pointer on the rotating knob and the cei...

  • Page 118

    13-9 13.10 video control center refer to manufacturer's manual for operating in- structions and maintenance information. This unit is powered by inverter and 120 v ac. 13.9 video cassette recorder(optional) refer to manufacturer's manual for operating in- structions and maintenance information. Fig....

  • Page 119: Warning

    13-10 commander / embassy 2-1. Sofa/bed conversion: the front sofa converts into a bed. To convert to bed: a. Lift the sofa seat up from the base. B. Pull forward until the back drops down to a bed position. To convert back to a sofa: a. Lift and push the sofa back against the wall. On the commander...

  • Page 120

    13-11 commander / embassy this page left intentionally blank.

  • Page 121

    13-12 commander / embassy 13.14 fresh water toilet the toilet in your motorhome is very much like the one on your home except that it uses a much smaller amount of water for fl ushing. When the levers are moved to the right for fl ushing, a high velocity stream of water produces a swirl effect that sh...

  • Page 122

    13-13 commander / embassy 13.15 electric step (op- tional on embassy) fig. 13-14 step 13.17 coffee maker (optional) see the instruction manual in your information packet. Fig. 13-16 coffee maker fig. 13-15 screen windows periodic maintenance including lubrication and cleaning are necessary to keep t...

  • Page 123

    13-14 commander / embassy 13.18 washer/dryer hook-ups - commander only (optional) your motorhome may be equipped with the wa- ter, drain and power requirements to allow the use of a washer and dryer. This feature works best when the unit is connected to city water, sewer and shoreline. The cabinet n...

  • Page 124

    14-1 14 care and maintenance 14.1 exterior 1. Roof: the roof is made of with an aluminium frame and constructed in a laminated 'sandwich' method. It is strong enough to support the weight of an average adult should it become necessary to repair the roof or any of the roof mounted components. It is n...

  • Page 125

    14-2 14.2 interior accumulations of dirt and dust not only detract from the appearance of the interior of your mo- torhome but will shorten the life of the carpets and fabrics. Weekly cleaning and vacuuming is recom- mended. 1. Carpets: see the manufacturer's carpet care guide on how to clean soil, ...

  • Page 126

    14-3 11. Refrigerator: the cabinet interior should be cleaned regu- larly. Remove shelves and wash the lining with lukewarm water to which a mild soap may be added. Dry thoroughly, especially around door frame and door gasket. Warm water only should be used to wash the cooling evapora- tor, ice tray...

  • Page 127

    14-4 15. Bathroom: a. General: as a general rule, use warm water and mild soap to clean walls and surfaces in your bathroom. On glass doors and mirrors a good quality glass cleaner may be used. Harsh cleaners, detergents or abrasives should never be used. B. Shower compartment: use a non-abrasive cl...

  • Page 128

    15-1 15 motorhome maintenance 15.1 chassis customer service commander / embassy chassis service is a concern for every vehicle owner. Ford and workhorse custom chassis have recognized this and have developed nationwide service centers. Each service center has the fa- cilities, technicians, equipment...

  • Page 129: 16     Storing Your Rv

    16-1 16 storing your rv all systems, components and appliances should be inspected and repaired prior to storage. Checklist: 1. Fill fuel tanks to reduce excessive build-up of moisture in the fuel tanks. 2. Check coolant level and add anti-freeze if required, to protect to the lowest expected tem- p...

  • Page 130: 17     Winterization

    17-1 17 winterization 17.1 cold temperature operation all motorhomes are built for year-round travel including: 1. Urethane installation undercoating. 2. Insulated and heated holding tank compart- ment. 3. All plumbing located in heated interior spaces. Although your motorhome is designed to withsta...

  • Page 131: Warning

    17-2 17.2 cold temperature storage 17.2.1 water system winterization 1. A.) commander: place the anti-freeze pick up line (located under rear bed) into a con- tainer of potable water anti-freeze. B.) embassy: remove the suction hose from the water pump (located under the rear bed). Attach a hose to ...

  • Page 132

    17-3 17.2.3 water purifier (optional commander only) to winterize: 1. Shut off in-line water valve located under the galley sink. 2. Unscrew the plastic water lines from the puri- fi er. 3. Remove and drain the unit. 4. Store water purifi er in an area where tempera- ture is above the freezing point. ...

  • Page 133: 18     Warranty Policy

    Triple e recreational vehicles warranty policy 1. Basic coverage a. Major component warranty: triple e recreational vehicles (here after known as triple e rv) has worked with our major component suppliers and is pleased to offer a two-year major component warranty from participating suppli- ers. Com...

  • Page 134

    1. What is not covered: this warranty will not apply where a motor home or trailer has been altered outside our factory in any way so as to, in our judgement, affect its stability or reliability, or which has been subject to misuse, negligence or accident. Any loss resulting from abuse or misuse, fa...

  • Page 135

    We shall not be responsible for commercial loss, special or consequential damages resulting from breach of these written warranties, or any implied warranty or condition. All correspondence should be directed to the dealer from whom the product was purchased and must specify the serial number and da...

  • Page 136

    Attachment a – major component listing for 2 year warranty attachment a – major component listing for 2 year warranty - refrigerator - furnace - water heater - roof air conditioners - tv antenna - range and oven - microwave - water pump - power converter - awning - television and vcr - generator - d...

  • Page 137: 19     Index

    Commander / embassy 19 index page page a appliances and interior features .........................................13-1 coffee maker (optional) .............................................13-13 dash television - 120 volt ...........................................13-8 ac/dc voltage inverter ..........

  • Page 138: 19     Index

    Commander / embassy 19 index page l lp propage gas system ......................................................11-1 air in the lp tank ......................................................... Air in the lp tank air in the lp tank 11-4 how lp gas works .................................................