1. DL manuals
  2. U-Line
  3. Refrigerator
  4. U-1115RB-00
  5. Service Manual

U-Line U-1115RB-00 Service Manual

Other manuals for U-1115RB-00: Installation Manual
Manual is about: 1100 & ADA ELECTRONIC CONTROL MODELS

Summary of U-1115RB-00

  • Page 1

    ® the built-in undercounter leader since 1962 u-line.Com service manual 1100 & ada electronic control models models covered wine captain ® models beverage center refrigerator ada height compliant refrigerator u-1115wcb-00 u-1175bevss-00 u-1115rb-00 u-ada24rb-13 u-1115wcb-02 u-1175bevss-02 u-1115rs-0...

  • Page 2

    U-line service product liability policy field service technicians are authorized to make an initial assessment. If in the servicer’s judgment the damage is the result of a product defect, the product would be removed and returned to u-line in an unaltered condition. The dealer would then be authoriz...

  • Page 3

    General information safety alert definitions .......................................................................................................................................1 general precautions .....................................................................................................

  • Page 4

    General information u-line service 1 general information notice • please read all instructions before installing, operating, or servicing the appliance. • proper installation procedures must be followed when completing an installation or relocation of a unit. An installation guide for the unit, prov...

  • Page 5

    U-line service 2 general information models covered this guide covers the following models: model voltage hinge configuration door configuration cabinet configuration reversible door u-1115rb-00 120v right hand hinge solid black glass shelves yes u-1115rs-00 120v right hand hinge solid black glass s...

  • Page 6

    U-line service 3 general information warranty claims procedure notice warranty claims must be filed within 60 days after the completion of the service call. When submitting claims for warranty payment, please follow these guidelines. You can use any form you would normally use to bill your customer ...

  • Page 7: 1214997-08-0005

    U-line service 4 general information serial number the serial number is divided into four segments. A typical serial number is 0914997-11-0005. 1214997-08-0005 year month factory use only factory use only the first two digits of the first segment, 09, represents the year the unit was made. The next ...

  • Page 8

    U-line service 5 general information checking product temperature to check the actual product temperature in the unit. 1. Partially fill a plastic (nonbreakable) bottle with water. 2. Insert an accurate thermometer. 3. Tighten the bottle cap securely. 4. Place the bottle in the desired area for 24 h...

  • Page 9

    U-line service 6 general information system default values model model code therm offset defrost length defrost interval differential set point u-1115rb-00 57 -5 60 240 1 38 u-1115rs-00 57 -5 60 240 1 38 u-1115rs-01 57 -5 60 240 1 38 u-1175rb-00 49 -3 45 360 1 38 u-1175rb-02 52 -3 45 360 1 38 u-1175...

  • Page 10

    7 u-line service general information interior lighting 5 4 3 2 1 ulin_0074_a normal operation. Opening the door will cause the interior of the cabinet to illuminate. Use the light button (1) on the control panel to change the lighting functions. Timed lighting. For wine captain models and beverage c...

  • Page 11

    U-line service 8 general information 1000 series electronic control 1000 series keypad options danger ! Electrocution can cause death or serious injury. Burns from hot or cold surfaces can cause serious injury. Take precautions when servicing this unit. • disconnect the power source. • do not stand ...

  • Page 12

    9 u-line service general information model number change 1000 series model selection: 1. Make sure board is not plugged in. 2. Hold down on/off key and plug in unit. 3. Release on/off key. 4. Press and release light icon. 5. Use warmer/colder to select the model number desired. 49-1175r/ada24r 120v ...

  • Page 13

    U-line service 10 general information error codes e1 thermistor 1 is open. E2 thermistor 1 is shorted. E3 main door or bottom drawer is open longer than 20 minutes. E4 compressor had 100% runtime between two defrost cycles. E5 thermistor 1 out of range + 10°f for more than 12 hours. E6 thermistor 1 ...

  • Page 14

    11 u-line service general information convection cooling models equipped with a convection cooling system use an evaporator fan to circulate cool air through the refrigerated zone and an evaporator plate to isolate the evaporator from the rest of the refrigeration zone. The evaporator cover is easil...

  • Page 15

    Standard doors 7 u-line service general information door alignment and adjustment align and adjust the door if it is not level, or is not sealing properly. If the door is not sealed the unit may not cool properly, or excessive frost may form in the interior. Notice properly aligned, the door’s gaske...

  • Page 16

    U-line service 8 general information install bottom hinge. 1. If you have a plate hinge, reorient the pivot screw so it protrudes the opposite direction from the hinge. Remove the pivot screw from the hinge. Turn the plate over and reinstall the screw. 2. Align hinge outer edge with cabinet. For mod...

  • Page 17

    Maintenance u-line service 14 maintenance lightbulb replacement to replace the lightbulb in your u-line unit: 1. Find the light located at the top of the unit. Grasp the edges of the light housing lens (1) opposite the exposed tab and gently push the lens toward the tab (2). 2. Pull the edge of the ...

  • Page 18

    15 u-line service maintenance notice • make sure the shelves are inserted fully into the unit. The edge strip toward the rear prevents cans and bottles from freezing against the cold evaporator. For models equipped with glass shelves having shelf supports, remove the shelves as follows: 1. Open door...

  • Page 19

    U-line service 16 maintenance removing and installing door shelves 1 2 for models equipped with door shelves: to remove the door shelf: 1. Grasp shelf in center, and lift until the shelf notches (1) clear the pins (2). 2. Carefully pull the shelf away from the door. To install the door shelf: 1. Hol...

  • Page 20

    11 u-line service troubleshooting customer call guide u-line’s warranty does not cover customer education calls. It has been reported that as high as 50% of all service calls performed are customer education calls. The following guide has been developed to help answer frequently asked questions. It ...

  • Page 21

    U-line service 18 troubleshooting compressor information cooling process refrigerant is pumped from the compressor to the condenser as a high pressure, high temperature vapor. As the refrigerant cools in the high pressure condenser, the vapor condenses to liquid. During this phase change, a great am...

  • Page 22

    System condition suction pressure suction line compressor discharge condenser capillary tube evaporator wattage normal normal slightly below room temperature very hot very hot warm cold normal overcharge higher than normal very cold - may frost heavily slightly warm to hot hot to warm cool cold high...

  • Page 23

    U-line service 20 troubleshooting thermistors type 2 thermistors are used for various temperature readings. Thermistors provide reliable temperature readings using a resistance which varies based on surrounding temperatures. If a faulty thermistor is suspected it may be tested using an accurate ohm ...

  • Page 24

    Service u-line service 22 service before calling for service if you think your u-line product is malfunctioning, read the operation section of this guide to understand clearly the function of the control. If the problem persists, read the normal operating sounds and troubleshooting guide section of ...

  • Page 25

    Cleaning 23 u-line service cleaning exterior cleaning vinyl clad (black or white) models: • clean surfaces with a mild detergent and warm water solution. Do not use solvent-based or abrasive cleaners. Use a soft sponge and rinse with clean water. Wipe with a soft, clean towel to prevent water spotti...

  • Page 26

    U-line service 24 cleaning condenser cleaning interval - every six months to maintain operational efficiency, keep the front grille free of dust and lint, and clean the condenser every three months. Depending on environmental conditions, more or less frequent cleaning may be necessary. Warning ! Dis...

  • Page 27: Service Manual

    ® building on three generations of innovation for nearly five decades and three generations, u-line continues to be the leader in innovation, quality and value in the premium built-in undercounter ice making, refrigeration and wine preservation market. U-line has captivated those with an appreciatio...