- DL manuals
- U-Line
- Refrigerator
- WINE CAPTAIN 1175BEV
- Service Manual
U-Line WINE CAPTAIN 1175BEV Service Manual - page 22
Summary of WINE CAPTAIN 1175BEV
Page 1
Entertain with u-line elegance service manual 2010 www.U-line.Com 2115r 2115wc 2115wcol 2175/2275dwrr 2175r 2175rf 2175wc 2175wcol clr2160 clrco2175 co2175/co2275dwr co2175f 2175bev 2275dwrws 2275dwrwol 2275zwc 2275zwcol 1115r 1115wc 1175bev 1175r 1175wc ada24r.
Page 2
1-1 section 1 - general information introduction three generations of pride and quality manufacturing and design improvements are built into all u-line products. The result: u-line leads the market with innovative technology and superior craftsmanship. This manual contains specific instructions for ...
Page 3
1-2 section 1 - general information table of contents section 1 - general information introduction ..................................................................................................................................................................1-1 potential problems with hfc-134a......
Page 4
1-3 section 1 - general information 2175r ............................................................................................................................................................................4-14 2115r ..............................................................................
Page 5
1-4 section 1 - general information safety precautions important important please read all instructions completely before attempting to service the unit. • proper installation procedures must be followed if this unit is being initially installed, or is moved to a new location after being in service....
Page 6
1-5 section 1 - general information u-line corporation limited warranty u-line corporation warrants each u-line product to be free from defects in materials and workmanship for a period of one year from the date of purchase; and warrants the sealed system (consisting of the compressor, the condenser...
Page 7
1-6 section 1 - general information product liability policy field service technicians are authorized to make an initial assessment. If in the servicer’s judgment the damage is the result of a product defect, the product would be removed and returned to u-line in an unaltered condition. The dealer w...
Page 8: 914997-11-Xxxx
1-7 section 1 - general information serial number format important important starting october 2009 u-line corporation went to a 13 digit serial number. Anything before that date will have 12 digits. The serial number is divided into four segments. A typical serial number is 0914997-11-0005. The firs...
Page 9
1-8 section 1 - general information parts listing how to order replacement parts 1. Refer to service parts and locate the illustration(s) for the model you are servicing. 2. Locate the desired part to be serviced and note the item number assigned to it. 3. Locate the item number within the parts lis...
Page 10
2-1 section 2 - troubleshooting customer call guide the following guide has been developed to help answer frequently asked questions. It can be used by persons scheduling service calls. Things to consider before scheduling a service call: concern response the unit is not cold enough. • are you famil...
Page 11
2-2 section 2 - troubleshooting clr2160 model only: drawer models only: 2175dwrr model only: concern response the cubes are wet. • the storage bin that holds the ice is not refrigerated. The cubes in the bin are slowly melting down. The bin will maintain a temperature of 32°f to 34°f. The floor is v...
Page 12
2-3 section 2 - troubleshooting refrigeration system diagnosis guide thermistor types type 1 (black) resistance at 77°f = 10,000 ohms ± 5%. Operating range is 185,000 to 650 ohms. Resistance goes down as temperature increases. Type 1 does not need to be calibrated and can be changed without changing...
Page 13
2-4 section 2 - troubleshooting troubleshooting danger never attempt to repair or perform maintenance on the unit until the main electrical power has been disconnected from the unit. Cause remedy will not eject ice (water frozen). 1. Control setting too cold. 2. Control inoperable. 3. Bin switch ino...
Page 14
2-5 section 2 - troubleshooting low ice production. 1. Control set too cold. 2. Fan motor stalled. 3. Ice cubes too large. 4. Dirty condenser. 5. Bypass valve stuck open (frost free units only). 1. Adjust control warmer. 2. Replace fan motor. 3. Lower water fill adjustment. 4. Clean condenser. 5. Re...
Page 15
2-6 section 2 - troubleshooting water leak (under unit). 1. Water supply line leaking at solenoid valve inlet. 2. Water line leaking at solenoid valve outlet. 3. Water line leaking at fill tube. 4. Defrost drain line not in drain pan. 5. Crack in water line. 1. Tighten or replace fitting. 2. Replace...
Page 16
3-1 section 3 - service and repair operation clr2160 general upon initial startup, this unit will enter mode number 5 which is a three-minute water fill regardless of the thermistor temperatures. This only occurs when the initial startup is caused by a power-up of the main board. Following the three...
Page 17
3-2 section 3 - service and repair . Figure 1. Clr2160 high pressure lowpressure transitional pressure in capillary tube h l c l l c c c c c l l h h c l icemaker evaporator 2276 r4: water supply r5: water circulation pump r4: hot gas bypass valve r1: condenser fan condenser r3: compressor relay r1 r...
Page 18
3-3 section 3 - service and repair troubleshooting (continued) no ice check the ice bin temperature. If the temperature is in the 34- 35°f range, the unit is shut down due to low temperature inside. This could be caused by low ambient temperatures or running the unit without a water supply attached....
Page 19
3-4 section 3 - service and repair clrco2175 general the u-line model clrco2175 combines the best of Échelon refrigeration and clear ice-making capabilities into a single unit. A state-of-the-art microprocessor-based controller simplifies operation and troubleshooting. There are four primary modes o...
Page 20
3-5 section 3 - service and repair figure 2. Clrco2175 mode 1: ice making and refrigeration ulin_0328_a.
Page 21
3-6 section 3 - service and repair figure 3. Clrco2175 mode 2: ice making and no refrigeration (or ref defrost) ulin_0329_a.
Page 22
3-7 section 3 - service and repair figure 4. Clrco2175 mode 3: refrigeration and no ice making ulin_0330_a.
Page 23
3-8 section 3 - service and repair figure 5. Clrco2175 mode 4: ice harvest (no refrigeration possible) ulin_0331_a.
Page 24
3-9 section 3 - service and repair figure 6. Clrco2175 mode 5: off ulin_0332_a.
Page 25
3-10 section 3 - service and repair figure 7. Clrco2175 mode 6: water fill - no refrigeration possible (normal start-up).
Page 26
3-11 section 3 - service and repair figure 8. Clrco2175 mode 7: cleaning (no refrigeration possible).
Page 27
3-12 section 3 - service and repair thermistor outage in the event that the condenser thermistor (t4) fails, the unit will stop all functions and display “er” on the user interface. The exact error can be accessed via the service mode. If the refrigerator thermistor (t1) fails, the refrigerator will...
Page 28
3-13 section 3 - service and repair too much ice ensure there is permagum around the thermistor hole. If there is, proceed to the next step. The control board is equipped with adjustment to adjust the level of ice in the bin for customer preference or when used in abnormal installations. With ice st...
Page 29
3-14 section 3 - service and repair 2175r/2115r 2175wc/2115wc 2175bev 2175dwrr/2275dwrws 2275zwc (includes overlay models) general refrigerant is pumped from the compressor to the condenser as a high pressure, high temperature vapor. As the refrigerant cools in the high pressure condenser, the vapor...
Page 30
3-15 section 3 - service and repair figure 10. 2275dwrws/2275zwc review the following notes for general information. • the unit is equipped with a four-minute compressor-off cycle. • the mullion heater is energized on the 2175dwrr whenever the t3 temperature falls below 90°f. Normal defrosting is ba...
Page 31
3-16 section 3 - service and repair suspected of not operating correctly, you can run through this sequence to ensure each component is turning on and off through the board correctly. Go into service mode and choose option #22. This will cycle every relay on and off showing 10 11 20 21 …. If a compo...
Page 32
3-17 section 3 - service and repair co2175f/2175rf/co2175dwr general u-line frost free refrigeration system cooling mode: • bypass solenoid valve closed • evaporator fan operating • refrigerant flows through capillary tube • normal vapor/compression cycle refrigeration • drain heater off (co2175f/21...
Page 33
3-18 section 3 - service and repair figure 12. Co2175r & 2175rf only: typical frost free airflow configuration thermistors three or four thermistors are employed. All are of the type 2. These measure the refrigerator, freezer, ice maker, or evaporator drain pan. Reed switch a reed switch is mounted ...
Page 34
3-19 section 3 - service and repair ice maker warning do not cycle ice maker by hand. This will cause damage to the ice maker. Freeze cycle • neither ice maker relay is energized. • unit is cooling down to 15°f set-point. • the unit may cycle on and off as the ice maker is pulling down to maintain t...
Page 35
3-20 section 3 - service and repair figure 13. Co2175f harvest-1 cycle (first 30 seconds figure 14. Co2175f harvest-2 cycle (after 30 seconds) ulin_0348a_a.
Page 36
3-21 section 3 - service and repair figure 15. Co2175f harvest-3 cycle (post harvest) figure 16. Co2175f water fill cycle.
Page 37
3-22 section 3 - service and repair figure 17. Co2175f freeze cycle figure 18. Co2175/2275dwr harvest-1 cycle (first 30 seconds) ulin_0350a_a.
Page 38
3-23 section 3 - service and repair figure 19. Co2175/2275dwr harvest-2 cycle (after 30 seconds) figure 20. Co2175/2275dwr harvest-3 cycle (post harvest) ulin_0345_a.
Page 39
3-24 section 3 - service and repair figure 21. Co2175/2275dwr water fill cycle figure 22. Co2175/2275dwr freeze fill cycle ulin_0346_a ulin_0347_a.
Page 40
3-25 section 3 - service and repair thermistor outage if the refrigerator thermistor (t1) fails, the unit will continue to operate based on the freezer temperature. Cycle lengths and temperatures may not be exact; however, this will prevent the loss of perishables. The display will show “er.” the ex...
Page 41
3-26 section 3 - service and repair too much ice ensure the bin arm is correctly moving during an ice production cycle and that it can touch the top of the ice. If not, the arm may have been bent. Excessive frost on evaporator force a defrost cycle via the keypad input. If the evaporator clears it w...
Page 42
3-27 section 3 - service and repair 1175r/1115r 1175wc/1115wc 1175bev/ada24r general refrigerant is pumped from the compressor to the condenser as a high pressure, high temperature vapor. As the refrigerant cools in the high pressure condenser, the vapor condenses to liquid. During this phase change...
Page 43
3-28 section 3 - service and repair thermistor outage if the refrigerator thermistor (t1) fails, the unit will continue to operate based on a preset time interval of 10 minutes on and 30 minutes off. The display will show “e1.” troubleshooting error code e1, e2 bad thermistor errors. Replace thermis...
Page 44
3-29 section 3 - service and repair operating environmental/ climate control requirements for all - except wc, ada, dwrws, bev center, codwr & dual zone(z) many u-line models are designed to operate in harsh outdoor/ marine environments. Special considerations include the following: • the units are ...
Page 45
3-30 section 3 - service and repair adjusting the set-point - 2275dwrws only 1. Press and release the warmer icon. The top of the f in °f of the top drawer will begin to flash. This will allow you to adjust the temperature of the top drawer. In 10 seconds of inactivity, the bottom bar of the f in °f...
Page 46
3-31 section 3 - service and repair viewing actual temperature - 2275dwrws only to view the temperature in the top and bottom drawer (t1 and t2), hold the warmer key for five seconds until “°f” flashes. Release and the display will show the corrected temperatures of both zones on their respective di...
Page 47
3-32 section 3 - service and repair forced defrost this will allow the unit to defrost quickly. For r and wc units, this is just an off cycle. For units with hot gas defrost the unit will enter a hot gas defrost per the specification. Hold the light key and press on/off three times. The unit will be...
Page 48
3-33 section 3 - service and repair this allows calibration of the sensor to cabinet for abnormal operations. By adjusting this number colder you can change the average cabinet temperature to a colder value. Not available on clr2160. 11. Data download along with the separate espy software you can do...
Page 49
3-34 section 3 - service and repair e2 thermistor 1 is shorted. Not available on clr2160. E3 main door or bottom drawer is open longer than 20 minutes. Not available on clr2160. E4 compressor had 100% runtime between two defrost cycles. Does not show on display—only in error log. E5 thermistor 1 out...
Page 50
3-35 section 3 - service and repair model thermistor 1 thermistor 2 thermistor 3 thermistor 4 door switch 1 door switch 2 2175r ref evap n/a n/a yes n/a 2115r ref evap n/a n/a yes n/a 2175wc ref evap n/a n/a yes n/a 2115wc ref evap n/a n/a yes n/a 2175dwrr ref evap ambient n/a bottom drawer top draw...
Page 51
3-36 section 3 - service and repair Échelon service quick reference card model part number pin 7 c_f a n pin 6 lights pin 5 pin 4 h_h20 pin 3 c_pump pin 2 r_v al ve pin 7 bp_v a l v e relay 1 relay 2 r elay 3 r elay 4 r elay 5 r elay 6 r elay 7 2175r 61/75 light compressor/ fan 21 15r 71/73 light co...
Page 52
3-37 section 3 - service and repair Échelon electronic control quick reference guide t ask t ouch t ouch display comments 1 on/of f hold 10 seconds release when unit beeps or the clr2160 will show ic e 2 t oggle lights glass door/drawer models only light normally goes on/of f with door opening. Pres...
Page 53
3-38 section 3 - service and repair origins electronic control origins keypad options danger danger electrocution can cause death or serious injury. Burns from hot or cold surfaces can cause serious injury. Take precautions when servicing this unit. • disconnect the power source. • do not stand in s...
Page 54
3-39 section 3 - service and repair turn back on. If desired, you can manually cancel this mode by touching the light button. Release and the unit will automatically start normal operation. Model number change origins model selection: origins service menu enter service menu by holding warmer and pre...
Page 55
3-40 section 3 - service and repair error codes e1 thermistor 1 is open. E2 thermistor 1 is shorted. E3 main door or bottom drawer is open longer than 20 minutes. E4 compressor had 100% runtime between two defrost cycles. E5 thermistor 1 out of range + 10°f for more than 12 hours. E6 thermistor 1 ou...
Page 56
3-41 section 3 - service and repair refrigeration system diagnosis guide defrost information - all models system condition suction pressure suction line compressor discharge condenser capillary tube evaporator wattage normal normal slightly below room temperature very hot very hot warm cold normal o...
Page 57
3-42 section 3 - service and repair caution if frost is heavy, divert water from drain to prevent water from overflowing on the floor. Specifications clr2160 compressor/coil specifications danger danger electrocution can cause death or serious injury. Burns from hot or cold surfaces can cause seriou...
Page 58
3-43 section 3 - service and repair clrco2175 compressor/coil specifications danger danger electrocution can cause death or serious injury. Burns from hot or cold surfaces can cause serious injury. Take precautions when servicing this unit. • disconnect the power source. • do not stand in standing w...
Page 59
3-44 section 3 - service and repair 2175r/2115r 2175wc/2115wc 2175bev 2175dwrr/2275dwrr 2275dwrws/2275zwc compressor/coil specifications danger danger electrocution can cause death or serious injury. Burns from hot or cold surfaces can cause serious injury. Take precautions when servicing this unit....
Page 60
3-45 section 3 - service and repair co2175f/2175rf/co2175dwr compressor/coil specifications danger danger electrocution can cause death or serious injury. Burns from hot or cold surfaces can cause serious injury. Take precautions when servicing this unit. • disconnect the power source. • do not stan...
Page 61
3-46 section 3 - service and repair 1175r/1115r 1175wc/1115wc 1175bev/ada24r compressor/coil specifications danger danger electrocution can cause death or serious injury. Burns from hot or cold surfaces can cause serious injury. Take precautions when servicing this unit. • disconnect the power sourc...
Page 62
3-47 section 3 - service and repair adjustments and repair leveling important important it is extremely important that the unit is level for maximum production. If it is not: doors or drawers will not work properly. In ice maker units, uneven sized cubes will be formed. Ice production will reduce an...
Page 63
3-48 section 3 - service and repair note: if door is adjusted correctly, but panel is not square with the adjacent cabinets, slight adjustments can be made by drilling the holes in the vinyl-coated steel panel slightly oversized (figure 37). Figure 37 adjusting door alignment 1. Remove top hinge scr...
Page 64
3-49 section 3 - service and repair figure 41 8. Mount the door, install top hinge pivot pin. Door alignment - origins models the unit’s door is aligned at the factory before shipment. However, its alignment could have been disturbed during shipment or during door panel installation. Important impor...
Page 65
3-50 section 3 - service and repair checking drawer alignment the unit’s drawers are aligned at the factory before shipment. However, their alignment could have been disturbed during shipment or during overlay panel installation. Figure 44 see figure 44. Check each drawer to confirm that it is align...
Page 66
3-51 section 3 - service and repair side-to-side adjustment see figure 46. The drawer will need a side-to-side adjustment if, when viewed from the top, the drawer front is not square with the sides of the cabinet. This is caused by one of the slides being mounted too far forward on the unit’s liner....
Page 67
3-52 section 3 - service and repair figure 50 4. Repeat the procedure for the other slide. Severe adjustment note: the slides have extra mounting holes that may be used. 1. Loosen one slide’s rear mounting screws. 2. Remove the slide’s front mounting screws. 3. Reposition the slide so it is level. 4...
Page 68
3-53 section 3 - service and repair figure 54 note: front location holes are shown. Corresponding rear holes will also need to be marked. 4. Drill all the new holes with a #30 drill bit. 5. Remount the slide. Re-installation of drawer caution use care when handling the drawer. Drawer edges, drawer r...
Page 69
3-54 section 3 - service and repair ice cube thickness adjustment interval - as required ice thickness adjustments are made using the control panel as follows: 1. To enter the thickness adjustment mode: a. Touch and hold the up arrow button. B. Touch and release the down arrow button three times, th...
Page 70
3-55 section 3 - service and repair parts replacement note: echelon models do not require removal of the ice maker or freezer housing to access the fan motor, drain or evaporator. Replacing evaporator fan motor - co2175f/2175rf 1. Disconnect unit from power source. 2. Remove two screws (figure 58) f...
Page 71
3-56 section 3 - service and repair replacing evaporator fan motor - co2175dwr 1. Disconnect unit from power source. 2. Remove two screws (figure 58) holding evaporator fan cover to evaporator cover. 3. Unplug fan connection. 4. Remove two nutsand two washers holding the fan to the fan bracket. 5. R...
Page 72
3-57 section 3 - service and repair replacing ice maker 1. Unplug unit. 2. Disconnect ice maker wire harness at plug (figure 60). 3. Disconnect thermistor plug. 4. Remove water inlet tube. 5. Remove front cover. 6. Advance ejector blade to the 3 o’clock position by turning the 5/ 16" hex head on the...
Page 73
3-58 section 3 - service and repair replacing mold and heater - co2175f/co2175dwr 1. Remove ice maker assembly. Refer to replacing ice maker assembly. 2. Remove one stripper screw (figure 61) and stripper. 3. Remove three face plate screwsand face plate. 4. Remove one screw and detach limit switch f...
Page 74
3-59 section 3 - service and repair plumbing - clr2160 and clrco2175 caution plumbing installation must observe all state and local codes. All water and drain connections must be made by a licensed/qualified plumbing contractor. Failure to follow recommendations and instructions may result in damage...
Page 75
3-60 section 3 - service and repair figure 65 figure 66 important important before installing your u-line unit with factory- installed u- line p60 pump, it is extremely important to check and test all hose connections at the drain pump. There is a possibility that hose connections may have loosened ...
Page 76
3-61 section 3 - service and repair 9. Unplug unit power cord from electrical outlet. 10. Reinstall back panel. To connect to drain: 1. Attach the 5/8" id drain connection on the back of the unit to a 5/8" od rigid tube, using a worm clamp. 2. Attach the other end of the rigid tube to your 5/8" id d...
Page 77
3-62 section 3 - service and repair figure 70 3. Your u-line icemaker requires a drain connection. This unit can be purchased with or without a factory-installed drain pump. If a pump is not installed in the appliance you must use the gravity drain style installation or install a pump per the instal...
Page 78
3-63 section 3 - service and repair 10. Once pushed completely into the opening finish routing the drain tubing to the desired location. Common installations use a floor drain, standpipe, garbage disposal, or y-branch tailpiece-type drain connection (figure 73 - 76). After the installation is comple...
Page 79
3-64 section 3 - service and repair water supply connection when connecting the water supply, follow these guidelines: • review the local plumbing codes before you install the unit. • connect to the cold water supply. • the water pressure should be between 20 and 120 psi. • the water line must have ...
Page 80
4-1 section 4 - parts parts listing how to order replacement parts 1. Refer to service parts and locate the illustration(s) for the model you are servicing. 2. Locate the desired part to be serviced and note the item number assigned to it. 3. Locate the item number within the parts list. Note the fu...
Page 81
4-2 section 4 - parts clr2160 (1 of 2).
Page 82
4-3 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 80-17071-01 80-17071-02 80-17071-03 door assembly, rh n/a n/a 80-17071-13 door assembly, lh 2 23025 23025 23025 nameplate 3 26071-01-s 26071-02-s n/a handle assembly 4 42173-blk 42173-nat n/a hole plug (i...
Page 83
4-4 section 4 - parts clr2160 (2 of 2).
Page 84
4-5 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 68092 68092 68092 thermistor, white 2 68072-s 68072-s 68072-s circuit board assembly 3 68080 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 41992 support, circuit board (included with 680...
Page 85
4-6 section 4 - parts clrco2175 (1 of 4).
Page 86
4-7 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 80-17072-01 80-17072-02 80-17072-03 door assembly, rh n/a n/a 80-17072-13 door assembly, lh 2 23025 23025 23025 nameplate 3 26070-01-s 26070-02-s n/a handle assembly 4 42173-blk 42173-nat n/a hole plug (i...
Page 87
4-8 section 4 - parts clrco2175 (2 of 4).
Page 88
4-9 section 4 - parts clrco2175 (2 of 4) item part no. Part no. Part no. Description black white stainless steel 32 5300 5300 5300 fan motor, condenser 33 5303 5303 5303 fan blade, condenser 34 41826 41826 41826 fitting, water line, 90° 35 42114 42114 42114 screw, water valve 36 2716 2716 2716 water...
Page 89
4-10 section 4 - parts clrco2175 (3 of 4).
Page 90
4-11 section 4 - parts clrco2175 (3 of 4) item part no. Part no. Part no. Description black white stainless steel 1 68092 68092 68092 thermistor, white 2 68072-s 68072-s 68072-s circuit board assembly 3 68080 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 41992 support, circuit boar...
Page 91
4-12 section 4 - parts clrco2175 (4 of 4).
Page 92
4-13 section 4 - parts clrco2175 (4 of 4) item part no. Part no. Part no. Description black white stainless steel 1 80-37005-00-s 80-37005-00-s 80-37005-00-s valve manifold assembly (includes dryer and process tube) 2 73004 73004 73004 bypass valve (included with 80-37005-00-s) 3 2819 2819 2819 proc...
Page 93
4-14 section 4 - parts 2175r (1 of 2).
Page 94
4-15 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 80-17060-01 80-17060-02 80-17075-01 door assembly, rh 2 n/a n/a 80-17075-02 door assembly, lh 3 23025 23025 23025 nameplate 4 26070-01-s 26070-02-s n/a handle assembly 5 42173-blk 42173-nat n/a hole plug...
Page 95
4-16 section 4 - parts 1 2 3 4 5 6 7 8 9 10 11 12 18 17 16 15 14 13 19 20 21 22 23 24 25 26 27 2175r (2 of 2).
Page 96
4-17 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 2303-s 2303-s 2303-s condenser assembly** 2 2800 2800 2800 process tube 3 2694 2694 2694 dryer 4 31434-1 31434-1 31434-1 rivet, thermistor cover 5 26091 26091 26091 cover, thermistor 6 41855 41855 41855 ...
Page 97
4-18 section 4 - parts 2115r (1 of 2).
Page 98
4-19 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 80-17064-01 80-17064-02 80-17080-01 door assembly, rh 2 n/a n/a 80-17080-02 door assembly, lh 3 23025 23025 23025 nameplate 4 26071-01-s 26071-02-s n/a handle assembly 5 42173-blk 42173-nat n/a hole plug...
Page 99
4-20 section 4 - parts 2115r (2 of 2).
Page 100
4-21 section 4 - parts 2115r (2 of 2) item part no. Part no. Part no. Description black white stainless steel 1 68092 68092 68092 thermistor, quick connect white 2 68072-s 68072-s 68072-s circuit board assembly 3 68080 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 41992 support, ci...
Page 101
4-22 section 4 - parts 2175wc/2175wcol/2175wcol2 (1 of 2) 23 24 31 30 29 25 27 26 34 32 33 33 28 7 8 13 12 11 10 35 36 41 40 22 20 21 13 9 12 1, 2 6 5 4 19 39 38 37 7 8 6 7 8 37 38 3 18 17 16 15.
Page 102
4-23 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 80-17057-01 80-17057-03 door assembly, rh 2 n/a 80-17057-13 door assembly, lh 3 80-17081-02 n/a overlay door (model u-2175wcol-00) 80-17104-11 n/a overlay door (model u-2175wcol2-00) 4 26088-4-blk n/a ha...
Page 103
4-24 section 4 - parts 2175wc/2175wcol /2175wcol2(2 of 2).
Page 104
4-25 section 4 - parts item part no. Part no. Description black stainless steel 1 68092 68092 thermistor, quick connect white 2 68072-s 68072-s circuit board assembly 3 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 support, circuit board (included with 68072-s) 5 41993 41993 suppor...
Page 105
4-26 section 4 - parts 2115wc/2115wcol/2115wcol2 (1of2).
Page 106
4-27 section 4 - parts 2115wc/2115wcol/2115wcol2 (1 of 2) item part no. Part no. Description black stainless steel 1 80-17065-01 80-17065-03 door assembly, rh 2 n/a 80-17065-13 door assembly, lh 3 80-17081-01 n/a overlay door (model u-2115wcol-00) 80-17104-12 n/a overlay door (model u-2115wcol2-00) ...
Page 107
4-28 section 4 - parts 2115wc/2115wcol/2115wcol2 (2 of 2).
Page 108
4-29 section 4 - parts item part no. Part no. Description black stainless steel 1 68092 68092 thermistor, quick connect white 2 68072-s 68072-s circuit board assembly 3 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 support, circuit board (included with 68072-s) 5 41993 41993 suppor...
Page 109
4-30 section 4 - parts 43 4816 4816 screw (included with 23027-03) 2175bev/2175bevol/2175bevol2 (1 of 2).
Page 110
4-31 section 4 - parts item part no. Part no. Description overlay door stainless steel 1 n/a 80-17094-03 door assembly, rh 2 n/a 80-17094-13 door assembly, lh 3 80-17094-01 n/a overlay door (model u-2175bevol-00) 80-17104-11 n/a overlay door (model u-2175bevol2-00) 4 41319 41319 foot, leveler 5 2891...
Page 111
4-32 section 4 - parts 2175bev/2175bevol/2175bevol2 (2 of 2).
Page 112
4-33 section 4 - parts item part no. Part no. Description black stainless steel 1 68092 68092 thermistor, quick connect white 2 68072-s 68072-s circuit board assembly 3 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 support, circuit board (included with 68072-s) 5 41993 41993 suppor...
Page 113
4-34 section 4 - parts 2175dwrr/2275dwrr (1 of 2).
Page 114
4-35 section 4 - parts item part no. Part no. Description black stainless steel 1 2175dwr-top-blk n/a drawer front assembly 2 41604 n/a screw, handle 3 26070-05-s n/a handle, overlay 4 12094-07 12094-08 gasket, door 5 26094 26094 housing, display 6 14138-02 14138-02 drawer, no front, top 7 23025 230...
Page 115
4-36 section 4 - parts 2175dwrr/2275dwrr (2 of 2).
Page 116
4-37 section 4 - parts 2175dwrr/2275dwrr (2 of 2) item part no. Part no. Description black stainless steel 1 68092 68092 thermistor, quick connect white 2 68072-s 68072-s circuit board assembly 3 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 support, circuit board (included with 68...
Page 117
4-38 section 4 - parts 2275dwrws/2275dwrwol (1 of 2).
Page 118
4-39 section 4 - parts item part no. Description 1 18066-vinyl wine rack assembly 2 12094-08-grey gasket, drawer, grey 12094-07-blk gasket, drawer, black 3 14016 front, top drawer 4 39004-03 wood front, top drawer 5 41729 pop rivet, stainless steel 6 42106 screw, wood 7 42175 pop rivet 8 26018-02 gl...
Page 119
4-40 section 4 - parts 2275dwrws/2275dwrwol (2 of 2).
Page 120
4-41 section 4 - parts item part no. Description 1 2953 main harness to plug 2 2959 dual harness 3 41992 support, circuit board (included with 68064) 4 41993 support, center, circuit (included with 68064) 5 42122 screw, wood 6 68092 thermistor assembly 7 68084 main board 8 68085 display assembly, to...
Page 121
4-42 section 4 - parts co2175f (1 of 4).
Page 122
4-43 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 80-17060-01 80-17060-02 80-17075-01 door assembly, rh 2 80-17060-01 80-17060-02 80-17075-02 door assembly, lh 3 23025 23025 23025 nameplate 4 26070-01-s 26070-02-s n/a handle assembly 5 42173-blk 42173-n...
Page 123
4-44 section 4 - parts co2175f (2 0f 4) 15 16 43 43 44 44 31 31 30 30 29 29 25 25 27 27 26 26 34 34 32 32 33 33 28 28 7 8 13 13 12 11 10 10 41 40 13 9 12 35 36 42 20 21 1, 2 23 22 24 14 3 2 19 6 7 8 39 37 38 18 5 4 46 51 50 47 49 48 17 45 26 27.
Page 124
4-45 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 31 5408-cap 5408-cap 5408-cap cover 32 5263-s 5263-s 5263-s fan motor, condenser 33 5188 5188 5188 fan blade, condenser 34 41787 41787 41787 nut (included with 5263-s) 35 31550-1-s 31550-1-s 31550-1-s drai...
Page 125
4-46 section 4 - parts co2175f (3 of 4).
Page 126
4-47 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 68092 68092 68092 thermistor, quick connect white 2 68072-s 68072-s 68072-s circuit board assembly 3 68080 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 41992 support, circuit board (in...
Page 127
4-48 section 4 - parts co2175f (4 of 4).
Page 128
4-49 section 4 - parts item part no. Description 80-39010-00 ice maker assembly 150-co2175f faceplate assembly 1 627000 cover 2 628210*† gear 3 80-39015-00* motor 4 627163*† spring 5 625836*† valve switch plate 6 31403* switch spacer 7 627302*† cam 8 627680* insulator 9 2506* hold switch 10 2918 wir...
Page 129
4-50 section 4 - parts 2175rf (1 of 3).
Page 130
4-51 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 80-17060-01 80-17060-02 80-17075-01 door assembly, rh 2 80-17060-01 80-17060-02 80-17075-02 door assembly, lh 3 23025 23025 23025 nameplate 4 26070-01-s 26070-02-s n/a handle assembly 5 42173-blk 42173-n...
Page 131
4-52 section 4 - parts 2175rf (2 of 3).
Page 132
4-53 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 31 5408-cap 5408-cap 5408-cap cover 32 5263-s 5263-s 5263-s fan motor, condenser 33 5188 5188 5188 fan blade, condenser 34 41787 41787 41787 nut (included with 5263-s) 35 31550-1-s 31550-1-s 31550-1-s drai...
Page 133
4-54 section 4 - parts 2175rf (3 of 3).
Page 134
4-55 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 68092 68092 68092 thermistor, quick connect white 2 68072-s 68072-s 68072-s circuit board assembly 3 68080 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 41992 support, circuit board (in...
Page 135
4-56 section 4 - parts co2175dwr/co2275dwr (1 of 4).
Page 136
4-57 section 4 - parts item part no. Part no. Description black stainless steel 1 80-29010-01 80-29010-03 grille 2 20033-blk 20033-zp screw (included with grille) 3 11969 11969 back panel 4 41342 41342 screw, back panel 5 26014 26014 ice bucket 6 80-48001-00 80-48001-00 drawer organizer assembly 7 2...
Page 137
4-58 section 4 - parts co2175dwr/co2275dwr (2 of 4).
Page 138
4-59 section 4 - parts item part no. Part no. Description black stainless steel 1 2175dwr-top-blk n/a drawer front assembly, top 2 41604 n/a screw, handle 3 26070-05-s n/a overlay handle 4 12094-07 12094-08 gasket, drawer 5 26094 26094 display housing 6 14138-02 14138-02 drawer, no front, top 7 2302...
Page 139
4-60 section 4 - parts 29 30 co2175dwr/co2275dwr (3 of 4).
Page 140
4-61 section 4 - parts item part no. Part no. Description black stainless steel 1 68092 68092 thermistor, quick connect white 2 68072-s 68072-s circuit board assembly 3 68080 68080 switch jumper (included with 68072-s) 4 41992 41992 support, circuit board (included with 68072-s) 5 41993 41993 suppor...
Page 141
4-62 section 4 - parts co2275dwr (4 of 4).
Page 142
4-63 section 4 - parts item part no. Description 80-39011-00 ice maker assembly 150-dwrco faceplate assembly 1 2506* hold switch 2 2506* bin switch 3 2506* valve switch 4 2917 limit switch 5 2918 wire harness 7 11641*† face plate 8 18031 bin arm 9 20044 screw 13 31400 stripper 14 41375 screw, plate ...
Page 143
4-64 section 4 - parts 2275zwc/2275zwcol (1 of 3).
Page 144
4-65 section 4 - parts item part no. Part no. Description overlay stainless steel 1 80-17104-01 80-17100-13 door, lh 80-17104-01 80-17100-03 door, rh 2 42173-blk n/a hole plug (included with handle assembly) 3 12094-01 12094-01 gasket, door 4 12095-10 12095-10 gasket, door, center 5 11994-blk-s 1199...
Page 145
4-66 section 4 - parts 2275zwc/2275zwcol (2 of 3).
Page 146
4-67 section 4 - parts item part no. Part no. Description overlay stainless steel 39 41319 41319 foot, leveler, 1/4-20 40 2948 2948 power cord 41 70077-s 70077-s compressor 42 2800 2800 process tube (included with compressor) 43 2694 2694 dryer (included with compressor) 44 31021 31021 grommet (incl...
Page 147
4-68 section 4 - parts 2275zwc/2275zwcol (3 of 3).
Page 148
4-69 section 4 - parts item part no. Part no. Description overlay stainless steel 1 26100 26100 display housing 2 41992 41992 support, circuit board (included with 68084-s) 3 41993 41993 support, circuit board (included with 68084-s) 4 42106 42106 screw, #6-32 x .38 5 68084-s 68084-s main circuit bo...
Page 149
4-70 section 4 - parts 1175r (1 of 2).
Page 150
4-71 section 4 - parts item part no. Part no. Part no. Description black white stainless steel 1 80-17051-01 80-17051-02 80-17067-03-e door assembly, right-hand n/a n/a 80-17067-13-b door assembly, left-hand 2 23051-01 23051-01 23051-01 nameplate 3 26078-01 26078-02 n/a handle assembly 4 41604 41725...
Page 151
4-72 section 4 - parts 2 3 4 5 6 7 10 9 11 12 13 14 15 16 17 1 8 1175r (2 of 2).
Page 152
4-73 section 4 - parts item part no. Description 1 1951-s condenser assembly ** 2 2800 process tube 3 2694 dryer 4 41855 screw, evaporator 5 31434-1 rivet, thermostat cover 6 26091 cover, thermistor 7 68073 thermistor, quick connect white 8 26059-02 control display assembly 9 66010 reed switch 10 20...
Page 153
4-74 section 4 - parts 1115r (1 of 2).
Page 154
4-75 section 4 - parts item part no. Part no. Description black stainless steel 1 80-17062-01 80-17066-03-c door assembly, rh n/a 80-17066-13-c door assembly, lh 2 31493-6-blk 31493-6-blk gasket, door 3 41604 n/a screw, handle 4 31447-blk 31447-blk hole plug 5 23051-01 23051-01 nameplate 6 26077-01 ...
Page 155
4-76 section 4 - parts 1115r (2 of 2).
Page 156
4-77 section 4 - parts item part no. Description 1 26059-02 control display assembly 2 31434-1 rivet, thermostat cover 3 26091 cover, thermistor 4 66010 reed switch 5 68073 thermistor, quick connect white 6 41863 rivet, reed switch 7 2878-01-s evaporator, roll-bond 8 31154 insulation, .38 id x .88 o...
Page 157
4-78 section 4 - parts 1175wc (1 of 2).
Page 158
4-79 section 4 - parts item part no. Part no. Description black stainless steel 1 80-17070-01 80-17069-03-g door assembly, ss door is field reversable 2 23051-01 23051-01 nameplate 3 26078-01 n/a handle assembly 4 31493-4-blk 31493-4-blk gasket, door 5 31447-blk 31447-blk hole plug 6 41604 n/a screw...
Page 159
4-80 section 4 - parts 2 3 4 5 6 7 10 9 11 12 13 14 15 16 17 1 8 1175wc (2 of 2).
Page 160
4-81 section 4 - parts item part no. Description 1 1951-s condenser assembly ** 2 2800 process tube 3 2694 dryer 4 41855 screw, evaporator ss 41855-02 screw, evaporator black 5 31434-1 rivet, thermostat cover white 31434-2 rivet, thermostat cover black 6 26091 cover, thermistor white 26091-03 cover,...
Page 161
4-82 section 4 - parts 1115wc (1 of 2).
Page 162
4-83 section 4 - parts item part no. Part no. Description black stainless steel 1 80-17063-01-d 80-17068-03-g door assembly, ss door is field reversable 2 23051-01 23051-01 nameplate 3 26077-01 n/a handle assembly 4 31447-blk 31447-blk hole plug 5 41604 n/a screw, handle 6 31493-6-blk 31493-6-blk ga...
Page 163
4-84 section 4 - parts 1115wc (2 of 2) 2 3 4 5 6 7 10 9 11 12 13 14 16 8 1 15 17 18.
Page 164
4-85 section 4 - parts item part no. Part no. Description black stainless steel 1 2223-s 2223-s condenser assembly** 2 2800 2800 process tube 3 2694 2694 dryer, r-134a 4 31434-1 31434-1 rivet, thermistor cover white 31434-2 31434-2 rivet, thermistor cover black 5 26091 26091 cover, thermistor white ...
Page 165
4-86 section 4 - parts 1175bev (1 of 2).
Page 166
4-87 section 4 - parts item part no. Description 1 80-17069-03-g door assembly, fieldreversable 2 23051-01 nameplate (included with #1) 3 31493-4-blk gasket (included with #1) 4 31447-blk hole plug (included with #1) 5 20031 screw (included with #1) 6 66016 magnet (included with #1) 7 20042-blk scre...
Page 167
4-88 section 4 - parts 2 3 4 5 6 9 8 11 12 1 7 10 1175bev (2 of 2).
Page 168
4-89 section 4 - parts item part no. Description 1 1951-s condenser assembly ** 2 2800 process tube 3 2694 dryer 4 31434-1 rivet, thermostat cover white 31434-2 rivet, thermostat cover black 5 26091 cover, thermistor white 26091-03 cover, thermistor black 6 68073 thermistor, quick connect white 7 26...
Page 169
4-90 section 4 - parts 2 3 4 5 6 1 7 8 9 10 11 12 13 ada24r (1 0f 2).
Page 170
4-91 section 4 - parts ada24r (1 0f 2) 14 15 16 17 18 19 20 21 22 23 24 25 27 26 item part no. Description 1 70077-s compressor** 2 68103 transformer 3 2819 process tube* 4 2694 drier* 5 41319 leveling leg 6 31021 grommet* 7 74021-s condenser** 8 67009 dc condenser fan (includes fan blade) 9 2938-2 ...
Page 171
4-92 section 4 - parts ada24r (2 0f 2) 2 4 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 11 21 20 22.
Page 172
4-93 section 4 - parts item part no. Part no. Description black stainless steel 1 80-17119-01 80-17121-01 glass door right hand hinge n/a 80-17121-02 glass door left hand hinge 80-17118-01 80-17120-01 solid door right hand hinge n/a 80-17120-02 solid door leftt hand hinge 2 23051-01 23051-01 namepla...
Page 173
4-94 section 4 - parts this page intentionally left blank..
Page 174
5-1 section 5 - wiring diagrams water pump lawrence bin cond 12 6 fuse 42247 d green black (hot) white (neutral) 1 10 control board model plug 7 1 thermister reed jumper (ground) to display waste water pump jumper plug without p60 waste pump green (ground) black white pink pink pink pink fan hot gas...
Page 175
5-2 section 5 - wiring diagrams wiring diagram 42248 rev. E top lamp bottom lamp power cord assembly green ground black-hot (smooth) black-neutral (ribbed) embraco white compressor overload brown blue purple cond fan relay black capacitor black white white white btm valve top valve yellow red white ...
Page 176
5-3 section 5 - wiring diagrams 2175dwrr, 2275dwrr 2175rf.
Page 177
5-4 section 5 - wiring diagrams co2175f co2175dwr, co2275dwr.
Page 178
5-5 section 5 - wiring diagrams 1175r, 1115r, 1175wc, 1115wc, 1175bev ada24r.
Page 179
5-6 section 5 - wiring diagrams this page intentionally left blank..
Page 180
For every room there is a u-line ® about u-line building on 45 years, u-line has captivated those with an appreciation for the finer things with exceptional design, inspired innovations and attention to even the smallest details. U-line is synonymous with premium built-in undercounter ice making, re...